I have this exact set up but in OHV 16HP. It has run like a champ, besides carb, solenoid replacement, since I bought it almost 24 years ago. I finally replaced the muffler since I thought it would be worn out after all this time and it had the "quiet package," but it didn't get one decibel quieter.
@stacybrooks57584 күн бұрын
Do you have a video where you don’t struggle the whole way through?😆
@JonasBluntson4 күн бұрын
How much does a job like this charge
@trillonmccormick160412 күн бұрын
I hear more complaining and spitting then I see working
@mattdiesel2294Ай бұрын
I have a 96 SW2 that doesn't throw sparks, it cranks but never starts. On jumpers it once in a while acts like it throws one weak spark but then always goes back to just no spark cranking. Starter is good. ICM replaced. Plugs and plug wires replaced. Crankshaft position was the first replacement. New coils. Still no spark. A field test made me and a friend point to the pcm as the source. Had no trouble codes and showed signs that it didn't even know the engine was turning over. Replaced, still cranks with no spark. The wires all aren't broken. Even other connections like grounds aren't broken. Nss is fine. Just, any ideas on what the deal could be? Everyone I talk to or have help me is stumped just like me.
@phyllismoynihan8183Ай бұрын
It would be helpful to see you actually undoing the nuts, bolts, etc. so we actually see how easy or difficult this job really is. Do appreciate what has been shown.
@BluedupK8182 ай бұрын
I thought the water pumps were bulletproof in these
@PRStremonti972 ай бұрын
If i put a regular aftermarket cat like this one on my malibu which is carb compliant, will it still run better?
@SickCustoms.com.6 ай бұрын
Still for sale?? ❤
@mauricewilliams28057 ай бұрын
My cat is integrated with my manifold...seems way different than what is shown here
@hitmanm8189 ай бұрын
Just so everyone knows atleast here in CA the Malibu has a catalytic converter warranty that covers either 150,000 miles or ten years what ever comes first I’m sharing this to help people I just saved 3000 dollars on it and I hope It can save you guys money
@EricBentleyEB5minus211 ай бұрын
A tripod or someone else holding the camera to film you doing the work would make this video much more informative
@XX-fr1wu Жыл бұрын
How much does something like this cost?
@hitmanm8189 ай бұрын
Dude I just saved 3000 the Malibu atleast in CA HAS WARRANTY FOR 10 years or 150000 miles
@robertfullone9032 Жыл бұрын
My '09 has a lot of differences.
@JeremyProctor93 Жыл бұрын
You may have a engine with smog pump if so there will be 2 plac boxes above the exhaust manifold that will complicate things a bit or better known as California emissions this video is for federal emissions
@Ricky-eo5ym Жыл бұрын
Thanks 👍
@ancientgains4154 Жыл бұрын
They never thought about replacing parts when they built these engines/engine bay.
@Euphoria589 Жыл бұрын
What codes were you receiving
@JeremyProctor93 Жыл бұрын
P0420
@itsteddyp1262 Жыл бұрын
Does it cause the car to sound loud ?
@jefftrotter8152 Жыл бұрын
Yes
@matthewmartinez5907 Жыл бұрын
Did the vehicle smell like gas in the cabin before this change
@Lilsportshady3 ай бұрын
I have to replace my catalytic converter and it smelled like gas at times inside my car.
@damonwilliamson186 Жыл бұрын
appreciate you
@zig62872 жыл бұрын
How many converters does it need
@JeremyProctor932 жыл бұрын
Typically just the one upper cat
@zig6287 Жыл бұрын
@@JeremyProctor93 changed mine with ebay converter code came back any suggestions
@kevinwoods77792 жыл бұрын
Lmao.... your gonna wanna make sure it's hot!!! No doubt
@jackson51162 жыл бұрын
9:47 maybe on the highway, but it's still a V6, it won't get great mileage in the city.
@anthonybostwick1632 жыл бұрын
What size socket for bolts on converter
@daronmccartney17338 ай бұрын
15 mm
@anthonybostwick1632 жыл бұрын
Do have a video for the manifold to??
@mikhailouranga41552 жыл бұрын
whats the part number for the cat plz and thank you
@wheinz5742 жыл бұрын
Just sold mine for parts. It was a good mower that served me for 13 years until it no longer ran.
@brayannexon46132 жыл бұрын
Why did you pull the entire crossover pipe? A water pump only requires removing a couple lines, the housing and the pump the rest is only needed if you are going to fix the heater pipe fitting that always leaks.
@JeremyProctor932 жыл бұрын
It's not like the old ones the whole cross over needs to come off to get the clearance to get it out
@sahrarogers20302 жыл бұрын
Wow !!! Thank you so much for this !!!!!!
@JeremyProctor932 жыл бұрын
No problem thanks for watching
@snyp3rseth2 жыл бұрын
I couldn't watch this. You did great pointing out the parts and saying what needs to be done but I am here to see it get done not before and after
@JeremyProctor932 жыл бұрын
That's actually a comment I have gotten more then once I will try and do better in future videos thanks
@frankierodriguez56202 жыл бұрын
Completed the job but I got a p0420 code. Checked and I have a leak at the flange. I used the new gasket that came with the manifold. Can I use a thicker gasket or is it possible I installed it incorrectly?
@JeremyProctor932 жыл бұрын
Possibly sounds like the round gasket came out of the groove if not go grab a new one and try again sometimes the aftermarket ones are to small and don't seal correctly
@frankierodriguez56202 жыл бұрын
@@JeremyProctor93 Thanks - will try that.
@cbriggsmkx14362 жыл бұрын
@@JeremyProctor93 hey I got a 2012 ltz I went to e-check and it saying my car is not ready. My check engine light is not on either. The paper they gave me says my o2 sensor has not read yet should I change that or drive for another week and try again. Thanks
@mikhailouranga41552 жыл бұрын
@@cbriggsmkx1436 drive another week to reset the computer it takes about 70 miles on mine
@jefftrotter8152 Жыл бұрын
What size are the nuts that hold the cat
@nunyabuziness84212 жыл бұрын
Dont show how to take things off
@DavidGurrney75892 жыл бұрын
Holy 💩💩💩 just to change a water pump you have to tear half the engine apart. Those GM engineers should be sent to Puketin. LET'S GO BRANDON 😷 😷 😷 😷 😷
@tonyploma23302 жыл бұрын
Just had mine done and yes it's a pain in the ass . The mechanic really made it harder on himself by not pulling the water pump housing out. He did it with the housing all in the water which made it nearly impossible
@JeremyProctor932 жыл бұрын
The older ones the water pump comes out nee ones don't unfortunately
@keithlawlor99932 жыл бұрын
Good job, I am sure that the engineers that designed this never knew the nightmare they created.
@JeremyProctor932 жыл бұрын
It was a mess ha
@sterlingwitherspoon57092 жыл бұрын
I bet they did
@tylerlewis5072 жыл бұрын
I keep getting p0420 every couple hundred miles. Changed the manifold already.changed both 02 sensors. Car doesn’t have any bad car symptoms. Do you the the front cat converter is causing me issues?
@JeremyProctor932 жыл бұрын
Absolutely classic issue with them
@gerarivera48822 жыл бұрын
Donde puedo conseguir piezas de este vehículo?
@cheyannestanley43862 жыл бұрын
I own a 1995 sable mercury right now. And I need help
@marquettehoward15092 жыл бұрын
Give me the link where u got the converter from
@JeremyProctor932 жыл бұрын
Got this one from www.rockauto.com
@GoofTRICK2 жыл бұрын
@@JeremyProctor93 hey After doing that was the car quiet???
@JeremyProctor932 жыл бұрын
@@GoofTRICK yes this one was if yours is loud there are a few things that are commonly wrong with them check and make sure your manifold is not cracked and make sure the flex pipe at the bottom isn't wrecked
@GoofTRICK2 жыл бұрын
@@JeremyProctor93 the flex pipes been replaced like two times
@GoofTRICK2 жыл бұрын
And yes in the mornings when I start it is sound like shittt soon it warms up it’ll be quiet but when I give gas it sound like the muffler is in the floor like in the bottom or middle we’re the catalytic goes
@GABAGOOLLL2 жыл бұрын
Shit engine so happy I got rid of mine!
@kylethomas43952 жыл бұрын
Just take the rail off. Makes the whole job a lot easier get stuff out of the way so you can reach things. And you don't have to worry about breaking the fuel rail. I can't tell if this guy is ASE certified or not. He's definitely ASS certified. Good morning Charlie. This video would have sucked without Charlie's nipples. Lol. This is definitely a poorly designed engine but they are good engines and with proper maintenance will go 200,000 mi no problem.
@ironinquisitor36562 жыл бұрын
My aunt gave me her 92 LS wagon at the start of the year. Has the keypad, digital dash, and electronic climate control. Sky blue in color too.
@justinbearinger19892 жыл бұрын
I have the same car my dule fans don’t work trying to figure out what to replace on mine
@CarnivorousApe3 жыл бұрын
Okay I've got a 2002 sc2 that dies after it warms up and won't restart until it cools back down. the code it's throwing is the P0341 camshaft position sensor which has caused me to replace everything from the ignition module all the way to the spark plugs and I'm still having the same issues. Would the crankshaft position sensor be worth replacing or do I just need to take it to the mechanic finally?
@JeremyProctor933 жыл бұрын
I would suggest that you take it to a shop and have them scope the cam and crank signals and make sure they look good could be a broken wire bad connection the possibilitys are endless better to get nip it in the but then try to chase your tail . Good luck !!
@CarnivorousApe3 жыл бұрын
@@JeremyProctor93 Got the part before you responded but it looks like it did the trick. Even managed to get the new crankshaft sensor in without having to remove the starter. Thanks though. If that hadn't worked I would have gotten it to the shop.
@mrdunkin833 жыл бұрын
What are the name of those gaskets called? What ALL would I need to replace the water pump as far as parts?
@JeremyProctor933 жыл бұрын
Crossover pipe gaskets
@mrdunkin833 жыл бұрын
@@JeremyProctor93 ok. And you think I should replace the thermostat as well?
@JeremyProctor933 жыл бұрын
@@mrdunkin83 yes you should key to a happy northstar is a happy coolant system!
@mrdunkin833 жыл бұрын
@@JeremyProctor93 say no more boss man I'm definitely going too. Thank you so much
@No-eo2fc3 жыл бұрын
Man did all that work for nothing . There's Special waterpump tool, that unlocks it from the housing.. no need in removing the whole assembly .. maybe 30min job
@JeremyProctor933 жыл бұрын
Only on the older cars i forget the year that ended but on these you have to remove the whole thing i have the tool
@mr.juicethebeetle33733 жыл бұрын
We had two of these growing up and one taurous, now i want one
@JeremyProctor933 жыл бұрын
That ome was a nice car getting hard to find good examples
@johnpowell81883 жыл бұрын
I just did a starter that wasn’t fun shit that water pump looks miserable. Gotta be an easier way I have an 06 dts id like too meet the idiot who thought of this engine.
@davidcoleman48653 жыл бұрын
How in the hell did you get the new gaskets installed? Yeah the bolts are a pain in the ass, (13mm ratchet wrench is gold) but I think the hardest part of this job is reinstalling the crossover while keeping the 4 new gaskets aligned and inserted properly. Sigh!