I have 2022 XLT Hybrid and facing same issue. Driver side 🤷🏻‍♂️

I have the exact same issue right now on my 2019 Raptor. Dealer said it was the rear window, replaced that last week, and after more rain today it's still leaking. It wasn't the rear window. Water is in that channel and just like your driver footwell. No water detected from the sunroof at all that I can tell. What did they do to finally fix it?

From rear window

2021 Tremor soaking wet under driver’s side floor. Been at the dealership for a week and they still haven’t found the leak. SMH !!!

Ford sucks...and this is a pick up

The air vent behind the back seat. Like down the space between the bed and the cab may be leaking

i have a 2018 f150 and it was the vapor barrier in the door was not sealed. butyl tape to reseal

These trucks are complete garbage. It’s the first and only Ford I’ve ever bought. Pathetic engineering and piss poor quality.

I’m having the same problem. I ran a garden hose at different spots on the windshield. After trial and error and flooding my truck, I believe l found it. The lower drivers corner of the windshield dumps inside the wheel well, and behind the panel of the parking break. I noticed 2 holes in the metal wall that are plugged with rubber grommets. One of my grommets was missing. I plugged it up and will monitor, but l watched water pour in and stop after the repair. Good luck

I am having the same problem 2019 lariat Heritage ford just butcherer my carpet buy striping the under pad off the carpet and replacing part of the wet under pad and left 1 third of the pan bare at the accelerator , and i complained to service manager , and he said that a pro did the job and thats how they repair by ford recommendation , what a shit show .

My 2016 f150 had water dripping from passenger side handle , then from ceiling panel. I took off inside liner and found the hose to the top right drain was completely off. Once I pushed the rubber hose back on, problem solved.

I had this same issue in my 2016. Took me forever to figure it out. It ended up being the 3rd brake light gasket. It would come in, hit the headliner, and proceeded to run down the pillars to the channels and it ends up everywhere. Look at the headliner near the back window for water stains and take 3rd break light off and inspect foam gasket.

Having the same issue on the passenger side of my 2005 Explorer

Found the same problems with my 2011 F-150....it was running down and into crumple zone punch out and running into the A-pilar, and into the harness valley on both sides. Have pics to show it...horrible. I can see why Ford can't find it, had to pull the dash and mimic rain falling with garden hose.

Working thru this same issue on a 2016 f150 crewcab, no sunroof nor back sliding window. We've had small drips of water at the brake pedal for a bit now (over a year?) but nothing major at all, even thru a PNW winter. This year though that changed as I started to see more and more water on the brake pedal and drivers side floor was getting wet, no puddles but definitely wet. No water anywhere else ... or so I thought. We had our windshield replaced this summer (for other reasons) so understandably I went back to them first. Windshield was fine so he directed me to the rear headliner ... water stains along the whole rear right above headrests. Crap. He said the 3rd brake light is likely the culprit, indicating they've seen it many times. First I caulk around the 3rd brake. This appears to have helped a little as I'm not seeing any clear signs of new water in the headliner, but still getting a bit of water at the brake pedal. Next day (we've had a lot of rain this month) floor is clearly wet, but I also notice the caulking has completely shrunk, basically making it worthless. I order a new 3rd brake light and put that on. Next day it rains (again, hard) ... no water in the headliner at all, but brake pedal has drips and a small amount of water still on the carpet. So ... either the 3rd brake light design is clearly faulty or there's more going on here. Next up is sealing the rear windshield, which I'm doing today. Hopefully that fixes it.

I own a 2017 f150 limited. Same problem. F@cked On Rainy Days

Same issue with my 2016 F150. Took it in in Feb 2018 and they said they couldn’t find the issue. Fast forward, moved to the east coast recently and the rain on this coast has flooded my truck and it’s not covered by the extended Warranty. Such bullshit.

I have a 2018 F-150 and my passenger side is leaking. Ford is not covering it and my warranty is not covering it. It is going to cost me 1,000 to have ford replace my ac box and seal. 👎 I’m calling Ford tomorrow to see if they will fix it my truck only has 39,000 miles. If they don’t fix it. I’ll fix it and I think I’ll trade it for a Toyato or a GMC truck

JUST watched this guy track down the culprit on youtube... here is the vid... kzbin.info/www/bejne/nXKUY4V3hat1btU. Unbelievable!

Well I have a 2005 F150… Good to see they have it fix the problem in 15 fucking years.

Ford hasn't even figured this out. A real bummer my friend. My 2019 SorryassDuty has the same problem. I'm shooting for the lemon law.

I have the same issue in a 2019 f-150 XLT. I just bought this truck almost new and now the passenger side floormat is soaked. It seems like a common issue I will contact Ford and see if they fix it.

I read something about the roof track seems in top of the cab. The 2 channels that run down each side. Possibly small cracks located in the aluminum 👎 welded together up there. My thinking is aluminum fatigue due to flexing of the truck. I have a 2019 f350 longbed with dual sunroof and I'm having this issue, and buyer remorse right now. I'll be at the dealer first thing in the morning. 😤

Same issue its your windshield seal or that 3rd break light

I’m having the same issue with my f250 2017

I have a 04 model doing the same thing on the right side

well it's still leaking on the 2019 F250...my brother just purchased one new..ford thought they fixed it the first time...they need to take another look because it's still leaking...

I have this issue. The two main culprits are the back windshield and the third brake light. Apparently Ford uses very subpar, cheap seals that don't last long. The water recently shorted out the fuse box underneath the glove box on the right side. It cost me $1100 to fix. I'll never buy another Ford if I can help it.

***UPDATE: Okay, update on my 2016 F150 (no moonroof), soaking passenger floorboard and a pond under the sill plate as shown in this video. Took my truck to Ricart Ford, Columbus OH. Apparently this is such a common problem that there’s a specialist that comes in every Friday to fix these water leak issues. So, I had to wait 3 weeks for scheduling but they fit me in. Work order states that leak is confirmed and body seams resealed. $200. I can’t confirm yet, as it was just repaired on Friday; but I can absolutely hear less road/wind noise. The cab of my truck is so much quieter now. Crazy stuff. I expect a class action suite at some point...chalking it up to Ford learning how to build with aluminum.

i have the same problem with my 2005 F150Xlt. Have it in shop, my mechanic said he believes it is the rubber door seals. Crossing my fingers. will update later.

I have the same problem with my 2007 king ranch and it was caused by the sealing of the brake mount on the back top of the car ... changed the brake mount and problem solved

Drain hose from the water rail on top of the roof have come off midway before the water is carried to the ground. The tubes are not clamped and only friction fit. They are located in the side front pillars.

Had the same problem on two trucks 2011 and I just found out it’s coming from a seal behind the control module. There’s one on each side on the a pilar. Took everything apart and took it thru an automated car wash and that’s how I saw it

I had the same issue but on both sides of my 2016 King Ranch. Turned out to be cracks above the windshield, defective sunroof, and the rear window were all leaking. Interior of my truck has been wet for months. Lots of rust, mold, and other issues... Now the truck won't start or even turn on.

Did you find where leak was coming from

Did you ever find the source? Mine was on the passenger side. Found out it was leaking at the place where the fat bundle of wires go from the door into the body..there's a plug where they go thru. I used some black putty (plumbers?) around 3 sides on the plug (not the bottom) and that solved the leak.

Looks like my Jeep Wrangler 😂. glad you got it fixed!!

Ok, I think I know how to fix it. I had the same thing going on, but on the passenger side. carpet was soaked and standing water in the foot well where the wires are. First you want to remove the foot well housing and vacuum out all the water with a shop vac. Also pull back the soaked carpet. I used Vic grips and a bungie to keep the carpet lifting exposing the floor board so it can dry. Get a some trimmer wire and open your sunroof. There are two drain holes in the front to corners of the sunroof. Place the wire down the holes so you can unclog the sunroof drain spouts. It took me a good 2 mins to unclog the drain on the passenger side sunroof. Then test out the drain by pour water in the drain holes while your sunroof is open. You should hear the water pouring down the A pillar of you vehicle. You should also see and hear the water pouring out underneath you vehicle. I poured approx. 64oz of water in the drains to make sure all the debris came out. Hopefully this was the fix in your vehicles too. I'll come back in a few days and give you an update if that was the fix for my vehicle. I'm pretty sure this will be the fix.

I have the same thing going on in my 2006 f150. Please help!

BEHIND THE REAR SEAT THERE IS TO VENT FLAP.....WE FOUND 3 TRUCK THAT WERE LEAKING FROM THERE

My leak came from the sun roof not being sealed properly. Not my door is full of water. Does Ford suck? It's my first one.

I took my 16 into the dealership today. I'm having the same issue as the guy in this video. I soaked up the water with a few towels and placed some damprid in the truck to hopefully eliminate mold forming. I will find out in a few days hopefully what the issue is. I'm hoping that the drain tube was not in the correct position. I will post an up-date and keep the thread going as needed.

My 52 quart cooler leaked in the back floor of my 2018 work truck , has water near the wiring harness just like the video , how do I drain it ?

Cars have been declared total loss with flooding cause of damage because of the leaky sunroof's

I have a 2013 F150 extended cab. I resealed the 3rd brake light. It is still leaking -- most certainly at the corners of the rear of the roof where there is a channel, a rivet, and black plastic channel inserts (drip molding). Both sides of the headliner right under these corners are currently wet and dripping water. The water then soaks the rear carpet, drops in the wiring channel on the floor, and soaks the front carpet too. Have not fixed it yet, but a forum person did (though not sure how). www.f150forum.com/f12/water-leak-top-rear-corners-crew-cab-216995/#post2816094

I have a 2017 F-150 XLT 4WD super crew with very similar problem.... for the past 2 1/2 months it has spent more time at the Ford dealer service garage than it has at my house.. Their body shop has found nothing... I've had to do most of the successful investigating myself. It is actually leaking from the bottom of the door then onto the 'scuff panel' (plastic threshold cover) and running into that channel that you mentioned. It then fills up then channel which then overflows and then is 'wicked' into the carpet padding. After the weather warmed up in the springtime it began to mold and began to stink very bad, giving me a terrible head ache. Now that I have figured out how the carpet got saturated you would think the dealer could figure out how it gets into the door to begin with,,, not so... Still trying to figure that part out. will update as I find out.

16 also leaking after having my windshield replaced im on my 3rd windshield leaking driver side handle area . seem they can't fixed i took ther to have my windshield replaced due to a crack. it was not leaking before. who know the fix? if it ford epoxy is the windshield shop . or ford to fix this

I have same issue with my 2009. Today I'm going to take the 3rd brake light off and replace the bulbs. Then apply rtv silicone as a gasket. While I'm up there I'll put some on the corner rivets that look suspicious.

my 2017 f150 crew cab is having same issue waiting for dealer to call me back.

Just discovered the exact same issue with my 2015 F150. Trying to dry the carpet out to prevent mold. Not sure how the water is getting in. Anyone else have this issue and have it resolved?