Changing the gear oil in my Volvo penta 290dp outdrive
Пікірлер: 27
@Aaaaaagggghhhhhh11 жыл бұрын
It's guys like you taking the time out to make videos like this that make the internet such a valuable resource, cheers.
@Castoors12 жыл бұрын
Thanks for making this video. Made the oilchange very easy for me!
@dberlier7110 жыл бұрын
The reason you fill from the bottom up is that you fill every part up with oil. If you fill from the top some of the oil dosent fill some spots because of air bubbles and you get a false reading on the dip stick. Then you wind up with not enough oil in the unit. Always fill from the bottom like he did in the video but when your on your last quart go slow to make sure bubbles have a chance to disipate and check with dipstick. It is alright to top off from the stick at this time.
@tedberry14767 жыл бұрын
I buy the gear oil in 5gal buckets and per-measure for the correct amount into gallon jugs. I then use a turkey baster to fill from the top. After I get most of the oil in I let it settle for a few hours, measure with the dip stick and generally after 2 or 3 trys it is topped off. I've found an electric impact hammer to be fantastic in getting frozen drain plugs lose.
@mikeadkins939611 жыл бұрын
your a good dude gary with an informative video. Thanks!
@jean-paulbout67677 жыл бұрын
Great vid ! Tip : i like to flush iT before filling iT with new oil.
@EN-ks1vt11 жыл бұрын
V/P dealer stated that the old school SP drives used the same 10/40 as the engine because the quality of the drive unit was superior and didn't require heavy gear lube. However, he recommended using 80/90 conventional in anything over 15 years old that had not been rebuilt yet. He hasn't steered me wrong yet...
@matsparhammar396710 жыл бұрын
Great initiative. Might I ask why you didn't fill the new oil through the hole intended for that? There's a plug under the "hood". Just remove the hood, two screws, and you find a plug that you remove, and fill the new oil through that hole. No pump is necessary.
@tazzace6 жыл бұрын
Yes check the drive diagram. www.marinepartseurope.com/en/volvo-penta-explodedview-7744030-44-18080.aspx Don't feel silly I also had a blister from pumping until i found the hollow screw. So you open the dipstick and the oil just runs down freely. I have DP280.
@marcharris27348 жыл бұрын
manual says to fill behind back cover. tilt drive up and add 2 u.s quarts.
@Flyhigh28111 жыл бұрын
thanks for the vid, overlapping music was draining your voice out though, my 275 outboard says to use 10w-30 motor oil
@kierakingfisher824610 жыл бұрын
good on you mate
@steve869910 жыл бұрын
Looks like your oil hasn't been changed for 20 years by the color of it!! Recommended oil for 290dp is 80w90 btw! Volvo is the only manufacturer to recommend using engine oil in the out drive because of convenience but then finally realized that gear oil was a better product, especially in sx drives which have more stress on critical parts. Never fill drive with oil through dipstick plug! Use the filling plug behind cover otherwise you will overfill causing oil to blow past uj seal and into bellows thinning grease on uj leading to much expense! Simples!
@arlenefontaine-torres853211 жыл бұрын
Thank you great info
@TeacherBrunoOneil10 жыл бұрын
I am sorry for the stupid question, but english is not my first language and i am not sure if \i understood what you said properly.. did you say ~ this drain plug was seized to the hole, which apparently happens a lot ? if you said it so, I am wondering how you took the torq of it before using your screwdrive on it. mine is pretty tight and the bolt is worn.. so I am worried about using a screwdrive and hammer to loose it. hope you could help me somehow.
@zandemen4 жыл бұрын
That oil seemed to come out pretty fast when you switched from pump to plug; did you close the vent/dipstick?
@asor1611608 жыл бұрын
It is wrong not have a pump to fill oil There is a screw the top right open the oil Hmmdid open to let in air And oil enters the scene
@Hotakish12 жыл бұрын
thanks
@baclieustud10 жыл бұрын
Where did you buy the AMS Marine Oil at? Nice video by the way.
@scottwein4579 Жыл бұрын
Do not listen to this guy 290s have fill plugs. drain it, put the plug in with a new o-ring, tilt it all the way up, take out the fill plug and fill it with the right amount, replace plug with new oring, put it back down and check the dip stick
@TeacherBrunoOneil10 жыл бұрын
did you read the manual for the right oil for this outdrive ? because mine says 10w30 or 20w40, which is much thiner in the viscosity than the oil you are using. I am really shocked with the oil you are using.however, mine is a 270 volvo penta.
@tazzace6 жыл бұрын
In my Drives EP 90 works best!
@sprchrgr6912 жыл бұрын
Yeah, my 280 calls for 30w motor oil..
@rnyoungusa12 жыл бұрын
Doesn't the Volvo Outdrives take 30W motor oil? Not the 75W gear oil that he put in.
@strandtiger309 жыл бұрын
No way... it is not a Mercruiser! Volvo has an oil screw behind the gearbox
@MegaLuckydog18 жыл бұрын
I hate rookies that talk like they know what they're doing! SOOO many mistakes. No disrespect just being honest.