Engine Cranking But Not Start ??? Engine Starting Problem Causes and Solution in Urdu / Hindi.

Watch More Informative Videos by ASAD ELECTRICAL:
DG Problems (Diesel Genset)
Unbalance Voltage Problems
• Unbalance Voltage in 3...
Engine Speed Problems
• Engine Overspeed and U...
Generator Voltage Problems
• Generator Voltage Prob...

[@hemantpatel3126]

Sir aapka Video Dekhar Aaj Hamne DG ka Trouble Shooting Kiya .aur DG Chalu Hogaya. Thanks For Informative video Sharing.

[@sajidsajid2847]

Khosh rahooo bohut knowlege milta hay aap k videos say

[@Info-Tech-]

So good video asad bhi.

[@haqnawazsial2405]

There is so much to learn thanks brother

[@mehmoodurrehman9322]

Sir, you are great 👍

[@ABDULSALAM-tv6ni]

JazakAllah

[@rajusagar9343]

Nice explained Sir,

[@mwengineeringworkswaseem9748]

Jazak Allah

[@bilalkhan-rx4nf]

good explain brother

[@ashiqali2954]

Thank you dear sir ❤

[@aamirmahmood7725]

Very well Done Asad..... You explain everything in a very effective way.... Impressed.

[@AsadElectrical]

Thanks sir

[@vikalpjoshi4845]

Thanks Sir .

[@muddassirhanif]

Thanks.

[@muhammadarif-haider]

Great video. Asad bhai can you please make video on sensors and how to test them

[@AsadElectrical]

Thanks, already made it please check link below: kzbin.info/www/bejne/jKC4iH-omNl4rZo

[@lifestyleindesert]

Good Video

[@rahmatkhan1421]

Nice video ❤️❤️❤️❤️

[@wajiatariq8778]

Nice

[@BulbulAhmed79]

Dear Asad Sir, Please make a video about valve lashing/Tappet adjustment detail & why we rotate flywheel at this time.Pls take it seriously. #Caterpiller G3515A

[@prakashzion1059]

To identify top dead center of corresponding piston

[@thegreatmycountryindiasanj8033]

Good

[@user-qg4de9ne3f]

Good Vedio bro but CAT M/C Emergency Engaged also a Major issues

[@AsadElectrical]

yes you right

[@praneshrai834]

Inspected one engine...CAT 3512 Manual engine...Engine cranking but not starting...RPM maximum reaching 148 RPM...Fuel is there

[@kabirrafiqu3142]

Asad bahi 3406e eingen d8r dozer per laga ha start ne ho rah

[@imran3055]

Bro please Caterpillar engine k sub sensors pey video bnaye... r agr koi b sensor khrab ho jye to engine pey kiya farq parhta hy

[@AsadElectrical]

Well noted

[@indian5142]

Bhai jcb cat ka engine hai parkins ka 4cylendar strat ing problem ho rhi engine full runnning hota hai diesel pump se injector me diesel bhi aa rha but start nhi ho rha

[@MuhammadShani-w6b]

When cracking but not start if patrol gums inter in the air duct engine started what is cause

[@ishtiaqahmed4986]

Bhai Catterpillar Generator 3410 mai Air lock howa hai kesy release kry

[@hemantpatel3126]

Sir Hamara DG Cutterpiller ka Hai ,1000kva ka hai aur DG Crannk Nahi hota hai , battery Voltage 26.8 V hai , manually start Karne pe Battery 25.8 V Tak Hota hai But DG Crannk aur Start nahi hota hai. please Reply

[@mangesh7277]

Sir I'm facing same problem in 3512 engine 168 02 code logged while cranking I checked according sis power supply ..J1 P1 point between 5,6 /11,4 and 11,23 I found battery voltage is it right or its should be 24 .4+- as per standard sis.?

[@AsadElectrical]

Yes voltage is ok maybe some loosing in connections

[@alamtechnical6074]

Sir 1500 kva ka gen set me speed nhi ho rha hai

[@richieuntaran8530]

Sir asad in cat 3408 genset i start manual the engine running but i switch off the negative terminal of fuel solenoid still running, the fuel solenoid 2 terminal, hows these working. Thanks

[@AsadElectrical]

There are 2 types of solenoid, Energize to Run and Energize to Shut. Please make sure which one is using in this engine,

[@richieuntaran8530]

@@AsadElectrical ok thanks sir asad, the one terminal is hold then the other terminal is pull,

[@bilalmwm5]

Cummins generator cranking but not start engine Inline pump speed controler cranking time highprusser pipe removed but diesel not comming

[@vishaldeepsaini5291]

Dear Asad sir, 2000 kVA cater DG engine oil mai pani jane kay kaya kaya karn ho sakate hai?? Lub oil cooler + Air after cooler ko be check kiya they both are ok

[@AsadElectrical]

Inspect Head cracked, liner cracked etc..

[@mohammadaurangzeb3518]

Check manifold

[@kewalsingh9934]

Sir ji cat engin ke filter ke no. Kaise pata karein i means naye isshu karne hain but hamare pass inke model no. Nahi hai ji all filter fuel, lub oil air filter kaya engine ke model ke hisaab se manga sakte hain ji pls reply🙏🙏🙏🙏

[@AsadElectrical]

Engine model k hisab se manga sktay hen

[@kapilchaudhari4869]

air start arrangement hai... governor fuel off position me jaa rha h

[@shahid91261]

Generator long cranking k baad start leta ha 57 hz pe ponchta ha fr down ho jata fr cranking kerta ha aur 57 ya 58 hz pr jata aur yaha pe 30 second leta ha 60 hz tak ponchney ma aur normal condition ma running kerta ha. Again generator off kerta ho fr b yehi process hota ha please guide me

[@hamadahassan8996]

Hello, how can make over-speed from 2301 A speed controller?

[@AsadElectrical]

Increase the rated speed setpoint

[@arifindubaidubai6378]

Over speed not start what's porblem

[@monojkumar7369]

Generator deasal nozzle not reach reason

[@kapilchaudhari4869]

solenoid ko external 24vdc dekar operate Kiya.. solenoid kaam Kar Raha hai

[@nbajalwa741]

Bhai mere paas 1 generator me yahi problem h usme battery stater sahi h deasel ka bhi problem nhi h or na hi Air filter ka deasel pump me kabhi currant aata h to start ho jata h or achha chalta h or kabhi currant nhi aata h to start nhi hota h kya dikkat ho sakta h

[@AsadElectrical]

Control relay or solenoid ka msla hosakta he

[@muhammadehsaq4152]

diesel pump air lock how is solved

[@muhammadehsaq4152]

diesel pump air lock how is solved and parts told me

[@AsadElectrical]

Loose lines and purge air

[@nehaljamal2357]

main power fail hone per ATS me trip start fail ka alarm araha ha or genset nahi chal raha ...kya cause hosakta hai sir ...genset display per kuchh seconds k liye running dikha raha hai

[@AsadElectrical]

Generator starting problem Lagra he .

[@kaustavchakraborty6249]

My generator 15 kva kirloskar.. Not starting.... Cranking slowly...In display showing " High Cilynder temp"...

[@AsadElectrical]

Cranking slow means battery dead and high cylinder temp means sensor or wiring fault

[@asadawan1072]

@@AsadElectrical sir kia generator mn mpu fuel open krata ha by actuator off laod se full load tk . Ager mpu fuality ho jae to fuel open nhi hoga

[@syedawais7640]

Aslam o alikom 2500 serise 500kva ka genratr ha start ni ho rha

[@AsadElectrical]

Wsalam, Fuel system (electrical , mechanical) dono check karain.

[@FAHADHUSSAINKHAN]

Yar oil are petrol Engine main mix ho gaya ha

[@abdulrahmankhan3515]

salamm bahi Cummins engine satat ni ho raha karink ho raha hy

[@AsadElectrical]

same steps check krain

[@salmanmapari8455]

Assalam alaikum Perkins 2200 engine crank ho rha h mger start nhi ho rha h.kya problem ho skti h

[@salmanmapari8455]

Fuel line sb check ki air remove ki sensor check kiye.mgr start nhi ho rha h

[@pandit0997]

Sir air stutoff pe video

[@AsadElectrical]

kzbin.info/www/bejne/eXmlg6yEo9l-p6M

[@pandit0997]

Thank you sir

[@computerworld4641]

Sir 50kva caterpiller engine start but off after 10 sec what's the reason?

[@AsadElectrical]

Check fault alarm

[@allaboutelectrical5776]

Brother Generator Diode blast kr Deta ha har 8/10 din bad Kya reason ho skte ha.?

[@AsadElectrical]

Winding check krain megger se

[@saifali6083]

Hii sir mera sat bhi same problem hua hai parkins 2800 engine carnk hota hai but on nhi hota ECM laga hua hai uska undar

[@AsadElectrical]

ECM ki supply check krain

[@Shorts_km]

Sir I'm facing problem on display..MCB h trip kr raha h....

[@AsadElectrical]

Internally short circuit hoga ya phir breaker kharab hoga

[@CK-eu9qm]

Caterpiller c2.2 engine Genset alaram( 10 sec start engine but shutoff engine) alaram list 1 Sd star fail ...in display showing what's the problem sir

[@AsadElectrical]

Control panel name ?

[@mohammadaurangzeb3518]

It's having EMCP 4.1 OR 4.2

[@zarmuradmurad9377]

Sir Generator volvo not start alarm (*sd card fail)

[@AsadElectrical]

plz change card

[@sultanateofoman8918]

Asslam walekum

[@AsadElectrical]

Walykum assalam

[@faizykhanjannat6509]

Bhai I'm in saudi Arabia ek 8 celender Ganerator haii uska screen khrab haii jiski wajha se fault show nhii ho rha haii... Or fault ye haii k wo wo Generator 10 15 secend baad auto matic shut down ho Jaya haii... Fir Bina reset liye wo start nhii hota... reset karne k baad 10 15 secend k liye start hota haii bas... electricity usko full mil rhi haii har jaGha pr...

[@AsadElectrical]

screen kharab he to change krna parega takay fault pata chal sakay

[@allaboutelectrical5776]

1 Diesel Generators ha wo Diods blast kr Deta ha bar bar Kya wja ho skti ha

[@mohammadaurangzeb3518]

@@allaboutelectrical5776 Chek main rotor winding + stator winding it's getting ground or unbalanced

[@danikhan7439]

Yar ya jo practical kr k agr bta do

[@vaibhav500264]

Engine starting progress showning in air conditioning unit mack company, but engine is not starting what will be cause? Sir

[@AsadElectrical]

Check wiring

[@vaibhav500264]

Wiring checked every thing done, diffect still persisting

[@AsadElectrical]

@@vaibhav500264 please tell me in more detail what kind of problem you are facing

[@mohammadaurangzeb3518]

I think your message are not clear to understand

[@rameezrameez]

Minidor engine not starting but cranks

[@sureshsinghpanwar8794]

Sir good evening..Mera eicher kav15kva DG set load dene par current unbalanced show Karke trip ho Raha h or overheat ho Raha h

[@AsadElectrical]

Load 3 phases pe equal hona chahye

[@sureshsinghpanwar8794]

Lekin sir pehle bhi to DG set thik chal Raha tha current thoda bhut unbalance hone se band nhi hota tha

[@AsadElectrical]

@@sureshsinghpanwar8794 phir diagnose krna prega fault

[@sureshsinghpanwar8794]

Wahi na sir Aisa kisliye ho Raha h

[@sureshsinghpanwar8794]

Reason???

[@akramulhaquehaque7706]

Asslam alaikum crenk bar bar ho rha tha ab avr nhi ghumta hai ab crenk v nhi hota hai please jaldi reply dena mehrbani

[@AsadElectrical]

fuel system check karain

[@adudkhan8449]

Sir aap apna phone bhejo

[@Wiseman7755]

MTU 1.2MW diesel engine crank ho raha but 150 rpm sy oper nai ja raha plzz WHAT should I do?

[@AsadElectrical]

Please check fuel system may be not open

[@Wiseman7755]

@@AsadElectrical fuel system open but still same problem sir

[@AsadElectrical]

@@Wiseman7755 Maybe Air in fuel

[@ahmadsagheer3564]

Sir Event logs ka error a Raha he,

[@AsadElectrical]

kzbin.info/www/bejne/aJe7mIeCg8mCrLM

[@ramashankar1181]

Dg me Fuel line ke Air ko kaise remove karte bataye

[@zarmuradmurad9377]

Sir parkin generetor crank. But not start what. Reason. Sir.

[@AsadElectrical]

Model ?

[@zarmuradmurad9377]

@@AsadElectrical 2017

[@usamajadoon352]

Bro 3406 is not starting from remote panel

[@AsadElectrical]

Jump 30 and 57 number wires and put on auto mode

[@Skallvideos-hp4ww]

Engine crank direct ho gaya hai sir Keya problem ho sakta hai

[@AsadElectrical]

Starting relay ko check krain

[@kapilchaudhari4869]

hamara 3408 crank ho Raha but start Nahi ho raha

[@extremeBNCRider]

Starting problem me v signal ata hai..!

[@user-jb1to3wz7e]

Volvo gen is cranking but not start

[@AsadElectrical]

Apply same process

[@viswamurthykonthanur4692]

No msg kateye sarji

[@ishtiaqahmed4986]

Diesel level low hogaya ta abi refill kiya hai lekin abi crank ho raha hai but start ni horaha

[@AsadElectrical]

Fuel line loose kr k pump krna parega one by one all injectors ki

[@ishtiaqahmed4986]

All Injector ki feul line loose krna hai ya one by one

[@AsadElectrical]

@@ishtiaqahmed4986 All ki loose kr k priming pump karain phir jis me fuel ata jaaye usko tight krdain one by one aur return fuel line close kr k start krain jab start hony lagay to return line open krdain

[@ishtiaqahmed4986]

Return feul line kaha s bnd hoga

[@AsadElectrical]

@@ishtiaqahmed4986 Fuel Valve

[@adudkhan8449]

Sir aap phone no bheje please

[@ZuberKhan-ge6ln]

3.1 red light aa rhii h start nahi ho raha or rest bhi nh ho raha

[@AsadElectrical]

Event logs me fault check karain konsa arha he. jb tk fault reset nhi hoga start nhi hoga

[@ZuberKhan-ge6ln]

@@AsadElectrical bhai open circuit aa raha hai event me

[@AsadElectrical]

@@ZuberKhan-ge6ln konsay sensor ka? any code? name

[@ZuberKhan-ge6ln]

@@AsadElectrical engine speed sensor 1/20

[@ZuberKhan-ge6ln]

Subha better ki wayr nikali thi fr dubra lagai toh red light aa gai