Why Does Ford Transit Still Have Blocked DPF After 4 Mechanic Visits & Various Parts Replaced?

  Рет қаралды 159,807

O'Rileys Autos

O'Rileys Autos

Күн бұрын

Launchtech.co.uk
look at why this vehicle was looked at various times but failed to fix the issue and also explain other common causes of constant diesel particulate filter blockages
fault codes
P244C:00-28 Exhaust Temperature Too Low For Particulate Filter Regeneration
P2463:00-AF Particulate Filter Restriction Soot Accumulation
P246C:00-AF Particulate Filter Restriction Forced Power Limit

Пікірлер: 375
@TheUnapologeticallyMimi
@TheUnapologeticallyMimi Жыл бұрын
I’ve had a DPF problem since Jan and I watched sooooo many of your videos and managed to do it myself and reduced the soot levels from 169% to nearly all clear, no more limp mode, engine light off and driving like a new car! Been 2 weeks now 👍🏼 Thank you 😊
@ORileysAutos
@ORileysAutos Жыл бұрын
Yes! Well done student 😉👍🏻
@akbychoice
@akbychoice Жыл бұрын
The fact that it can say 169% is a clue to DPF being a garbage mandate.
@TheInvisibleMan1001
@TheInvisibleMan1001 6 ай бұрын
has it blocked again?
@Markdmarque
@Markdmarque Жыл бұрын
DPF was the worst invention ever for the diesel. They are always prone to falling and mechanics ,as you say, seem clueless as to how to fix the issues. Thanks for your excellent video
@TheElderOne2003
@TheElderOne2003 Жыл бұрын
Spot on!
@prawny12009
@prawny12009 Жыл бұрын
Emissions control device, great Now measure it's emissions under its worse case operating conditions IE whilst under a heavy regeneration cycle. No point collecting soot to burn later if the additional fuel required to burn it causes worse emissions. Same goes for stupidness like secondary air pumps etc, fooling emissions measurements by pumping air into the exhaust doesn't mean your emissions are actually cleaner.
@hallsey5405
@hallsey5405 Жыл бұрын
Some mechanic accidentally took my dpf out no problems now 😉
@Markdmarque
@Markdmarque Жыл бұрын
@@hallsey5405 I did the same on my car but it needed a dpf delete and tune on engine management because the engine management needs to know it isn't there
@hallsey5405
@hallsey5405 Жыл бұрын
@@Markdmarque Yeah my van did need a bypass 😁
@coffeeguy6673
@coffeeguy6673 Жыл бұрын
Can't get enough of Jimmy's videos, keep up the great work Jimmy !! You'd make a great instructor, logical thinking and step by step detailing, just fab !
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks, will do!
@briancurran2988
@briancurran2988 Жыл бұрын
I've a Nissan xtrail, 1st car I've owned with a dpf, the car was doing a regen nearly everyday, even the day after doing a long motorway drive. I got a fuel card through the blue light card, but it's only for Esso fuel, I save enough for it to be cheaper than supermarket fuel. Since going over to Esso fuel, my cars not done a regen in over 4 months Not saying changing fuel supplier would work for everyone, but it definitely worked for me.
@BeerGuy2345
@BeerGuy2345 8 ай бұрын
Eh I think a regen is actually good for it every once in a while
@jamiebendall6913
@jamiebendall6913 Жыл бұрын
Just want to say a thank you for all your videos on transit customs and DPF's after spending a few evenings watching your videos I tackled my van this weekend and found a blocked fuel vaporizer. Sadly I couldnt get it out with the dpf attached so had to pull dpf out, you make it look easy getting it out. However a clean up with a blow torch reassemble and some dpf cleaner and 5 minutes of forced regen and now 0.5kpa on idle was between 3kpa and 5kpa before. Out for a test drive and no lights or limp mode! Thanks for taking the time to make your videos they are a great help!
@ORileysAutos
@ORileysAutos Жыл бұрын
Cheers 👍🏻
@dejavoue88
@dejavoue88 Жыл бұрын
been in the trade for 36 years and I'm still on a learning curve. you never stop learning in this trade
@thehouseholder5468
@thehouseholder5468 Жыл бұрын
I’ve learned more off two of your videos than a months worth of other ones. Thank you 🙏
@leecav214
@leecav214 Жыл бұрын
a guy that knows what he's doing...bravo..knowledge is worth every penny and what you pay for.
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks
@F4AUST
@F4AUST Жыл бұрын
Hi jimmy just come across your channel. As a mechanic my self for 40 years + in the trade working in a dealership ford being one of them . And I agree with your comment on the heater plugs can you do a video on removing them 😅 . Keep up the good work and the videos coming 👍
@ORileysAutos
@ORileysAutos Жыл бұрын
I've got maybe 4 videos removing them on my channel
@keltecshooter
@keltecshooter Жыл бұрын
Cheers from the New England colonys ! Awesome video, unfortunately I don't get a lot of diesel cars and trucks at my shop however it's important to stay on top of things because someday I'll run across this and I will be prepared!
@derekmillar318
@derekmillar318 Жыл бұрын
Great vid...educational and no annoying music thanks
@sheldonmcclaflin8904
@sheldonmcclaflin8904 Жыл бұрын
Sorry I forgot the 3.2 Ford diesel is an American model Transit, 350 HD, 2017. The van is in America and I'm in Thailand trying to trouble shoot its many problem's. Not a lot of people know the engine very well. The glow plug problem hasn't even come up. Again thank you very much for what you do to help people.
@johnnyskratch40
@johnnyskratch40 Жыл бұрын
On transits during regen the engine glow plugs come on when the engine is in over-run. When putting throttle on, the vapouriser pump hz will increase proportionately up to a max of around 4hz pulses as the increased combustion heat allows more vapouriser fuel to be injected without visible white smoke appearing from the tailpipe. Conversely, when in over-run the pump hz will ramp down to zero (stop flow to the vapouriser) and the glow plugs will come on. At this time during over-run the throttle body will close more to gag the air flow to try maintain DPF heat until load conditions mean heat can be restored. As soon as you ease your foot back onto the accelerator the glow plugs will go back off and the pump hz will ramp back up again. The vapourizer glow plug stays energised throughout. Debatable how much influence the cylinder glow plugs heat has on the combustion or regen heat process during this small operating window or whether it is mainly to load the engine up via load on the alternator in the same way as the heated screen comes on (60A load) during regen.
@johnnyskratch40
@johnnyskratch40 Жыл бұрын
I think what most likely happens is on-over-run, as the combustion fuel is decreased then post-combustion fuel is increased and the glow plugs are energised to help burn this post injection fuel to maintain heat. I've noticed on my 2014 van it happens more i.e. the glow plugs kick in more frequently on over-run during regens when the weather is colder. No doubt manufacturers will have ECU's calibrated to pull more and more tricks out of the bag as ambient temps drop to help generate heat during regens..
@mohammadkhan8567
@mohammadkhan8567 Жыл бұрын
@@johnnyskratch40 good information thanks!
@timmychippy3903
@timmychippy3903 Жыл бұрын
Dont forgot the glow plugs help start the engine when cold so unburnt fuel doesn't get into the dpf which will start to clog the system most likely the very beginning of all problems with dpf systems, dont ignore a bad glow plug
@trevorwhalley7466
@trevorwhalley7466 4 ай бұрын
Sir, it is knowing how to access the info, what is needed to rectify the fault, then using correct parts to complete that, Your videos highlight this brilliantly
@bazjones8075
@bazjones8075 Жыл бұрын
Great video mate. What is critical for dpf systems is when vehicle gets an oil change you must reset the oil data and service reminders as the systems only know if you tell them. Otherwise the system thinks it hasn't had an oil change and thinks the oil is diluted and will not complete regenerations.
@matthewwakeham2206
@matthewwakeham2206 Жыл бұрын
Interesting. Glad I always did that for an oil dilution warning light service.
@paulcook3089
@paulcook3089 Жыл бұрын
Wish I knew good mechanics as good as you fantastic job and video
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks 👍
@johnbullough6431
@johnbullough6431 8 ай бұрын
@@ORileysAutos hi great video where are you based cheers
@ORileysAutos
@ORileysAutos 8 ай бұрын
@@johnbullough6431 Biggleswade UK
@davidwright1752
@davidwright1752 Жыл бұрын
Life of a motor mechanic a lot of learning every year.
@G4RY1159
@G4RY1159 Жыл бұрын
If only garages had reliable knowledgeable people like you fella Nice one Thanks
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks. Hopefully enough people will learn from the videos
@Jonodrew1286
@Jonodrew1286 Жыл бұрын
Never likes forced regens - seen an exhaust go so hot the fuel tank melted 😮 your a master of your trade 🙏🙏
@ORileysAutos
@ORileysAutos Жыл бұрын
Thank you
@raymondrobertson3869
@raymondrobertson3869 Жыл бұрын
Just found your channel I am in my late sixties and not up to speed with all this new stuff. But still find it very interesting. Thank you so much for making these videos. You tell it as it is. Regards Raymond 🏴󠁧󠁢󠁳󠁣󠁴󠁿
@ORileysAutos
@ORileysAutos Жыл бұрын
Welcome aboard!
@BeerGuy2345
@BeerGuy2345 8 ай бұрын
I agree this is helping so much
@RideBikes_Walkplaces
@RideBikes_Walkplaces 3 ай бұрын
I've had to saw the vaporiser off the nut many a time to get a socket on and crack it off. You've got some nads replacing them on the street, bro! Fair play.
@t0m541
@t0m541 19 күн бұрын
Such an informative guy with a wealth of knowledge and not keeping it to himself like a lot would. +O'Rileys Autos, have you considered an induction heater rather than the old blow torch method. They are cheap these days and my one has well and truly paid for itself multiple times over and is so much faster and safer than having that blue flame warming the whole area as well as that stuck in fitting.
@herridge819
@herridge819 Жыл бұрын
Very interesting video, thanks for taking the time and trouble to load it!
@ORileysAutos
@ORileysAutos Жыл бұрын
No worries!
@xxbambamxx7261
@xxbambamxx7261 9 ай бұрын
I run everything that puts a load to the engine, like the ac on full blast, heated seats, heated windows etc so the exhaust Temps rise more... It actually helps out alot!
@BeerGuy2345
@BeerGuy2345 8 ай бұрын
Yes the AC trick helped me fix my dpf plus diesel additives plus check your oil level and a good run on the motorway
@markholian3506
@markholian3506 Жыл бұрын
Jimmy keep them coming - every day is a school day as far as I’m concerned - I can see a 2017 plate Vivaro coming down to you on a trailer soon 😂 I’m on my third attempt here just waiting on the launch gun to give me the FOAM action which you shared the other night 👍🏻👍🏻👍🏻👍🏻👍🏻👍🏻
@RWL2012
@RWL2012 Жыл бұрын
no such thing as a 2017 plate, it's 66 (January/February), 17 (March-August) or 67 (September-December)
@davidelliott5843
@davidelliott5843 Жыл бұрын
Oh dear another fussy so and so.
@jackrussel853
@jackrussel853 Жыл бұрын
Interesting stuff, not sure how similar a 2012 Subaru Outback diesel system is but my mate bought one a while back with 50k miles, not long after purchase the money light came on and it went into limp mode so he took it to the local garage, something like £1200 later with some new parts and a dpf clean he got it back, there were signs the dpf had previously been cleaned and the garage said chemical cleaning doesn't work (which my friend now takes as gospel) so it was sent away to be burnt out? or something, anyway the garage said it possibly wouldn't work, later on the eml came back and it went into limp mode again so he took it to Subaru, a new dpf and parts for something like £2500 and it was meant to be fixed but by then he was paranoid it was going to go again so recently part ex'd it on a Hyundai.
@BIBIWCICC
@BIBIWCICC Жыл бұрын
Diesel particle filter - designed to stop diesel particles from entering the environment. So you pump a load of Nast chemicals into the DPF and squirt it out over the road and back into the environment! Guess you put profit over health!
@SIMONB1
@SIMONB1 Жыл бұрын
Hey up Jimmy, just found your channel, someone who knows something, as nowadays everybody thinks they do 🤔, great technical details and the truth, really like this sort of stuff, thanks for sharing, ride safe, Simon B 👍
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks 👍
@TheDarvec1
@TheDarvec1 4 ай бұрын
I used some Launch Flow restored and after the second tank full popped the vaporizer off and it looked almost completely clean. Think I'm going to use that every 3 months or so as preventative maintenance.
@jimmydickson8854
@jimmydickson8854 Жыл бұрын
These DPF filters are a scourge of vehicles today
@larrysimon1
@larrysimon1 Жыл бұрын
Great advice as always Jimmy. Top Man.
@ORileysAutos
@ORileysAutos Жыл бұрын
Glad you enjoyed it
@kahernebally
@kahernebally Жыл бұрын
I was having DPF problems for a few years with a 2012 Transit , the van is sold now but its just a pity I didn't find out about you sooner I'd still have the van .
@SlimTortoise
@SlimTortoise Жыл бұрын
It's seems to me that most of the large garages seem to plug in thier diagnostic tool cancel the fault then take your money and do nothing else.
@sheldonmcclaflin8904
@sheldonmcclaflin8904 Жыл бұрын
At what millage should the glow plugs be changed as a maintenance item, doing 100,000 miles per year? Just found your cannel. WE have a 3.2 ford. Thank you very much.
@Gearhead90
@Gearhead90 Жыл бұрын
Coming from an hgv perspective where scr systems and dpf etc are far more complicated than on any modern car or van I’m absolutely flabbergasted as to how garages can’t seem to fathom these systems out 😅 I’ve even come across a Peugeot Citroen expert who didn’t even know what the fap fluid was actually doing in the system thought it was being injected into the exhaust by the adblu injector i mean Jesus come on fella lolll
@prawny12009
@prawny12009 Жыл бұрын
Seen mechanics fill the fap/Eloy's fluid reservoir with diesel.
@Gearhead90
@Gearhead90 Жыл бұрын
@@prawny12009 Pmsl great inject diesel into a diesel fuel tank I’m sure that’ll help loll nuggets
@MT_T991
@MT_T991 Жыл бұрын
I was just thinking this, heavy diesel mechs this is nothing new
@prawny12009
@prawny12009 Жыл бұрын
@@Gearhead90 they don't put it in pump fuel because the additive is extremely carcinogenic hence injecting into the fuel tank. The thing is it injectors every time the fuel nozzle goes in so if you are a cheapskate that only puts a few less of fuel in at a time the additive estimate counter will trigger earlier.
@G4RY1159
@G4RY1159 Жыл бұрын
Poor training David, simple as that fella
@scoobydoodandy4296
@scoobydoodandy4296 Жыл бұрын
It's not just mechanics, it's everyone. I had a Mercedes E220d Convertible with a soot content of 400%. The key thing is what does the vehicle manufacturer count as red lines and what do they consider grey lines in terms of DPF regeneration cycles running naturally. Using Autel 806 I was able to let the car know the DPF had definitely been replaced, no, honestly. Then making sure that the red line of the EML not being illuminated does not prevent DPF regeneration drive the vehicle whilst keeping the measured PIDs as close to the perfect conditions as possible. In my particular case the engine speed was specified as between 725 and 925 RPM. This is in no way keeping the car in a lower gear and higher road speed to keep the revs high. This does nothing. On a vehicle that has a functioning DPF regeneration system you will see the optimal differential pressure value fluctuate between +1 to +16 and two negative values which can not be returned by the sensors. When the value is in the possible range you will see the exhaust temps rise from 300's to 600's as the system works and these will drop back when the range switches to the nonsense values. This is how the system is set up on '13 Mercedes 180, 200, 220, 250 diesel engines. I got this vehicle to return soot content of 72.5% and 77% the last two times I checked over the last 3000 miles of normal mostly urban driving. It took 3.5 trips on the A34 between Oxford and Newbury to get the DPF to stabilise at a normal fill level. No physical work was done on the vehicle except the Differential pressure sensor was replaced at owners request as the last "Parts Grenadier" told him it was necessary. I also used one tank of fuel with a non specific additive to run this process. The key TLDR message is get a live data scanner which gives you the PIDs you need to monitor for the DPF system to optimise the conditions needed for your manufacturers system. Plus EML illuminated is a red line for every manufacturer. Also don't believe everything you read on Google... Thanks for coming to my TED talk!
@BeerGuy2345
@BeerGuy2345 8 ай бұрын
I enjoyed it
@mike-ology22
@mike-ology22 Жыл бұрын
You're really good at teaching mate, I enjoyed watching this. Thanks for sharing
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks 🍻
@steptoeandson3554
@steptoeandson3554 Жыл бұрын
Glow plugs fault can on some vehicles put ecu into a un noticeable "safe" mode where dynamic regeneration won't ever happen hence why the dpf eventually clogs up. They are also utilised as a load on the engine during regeneration
@ORileysAutos
@ORileysAutos Жыл бұрын
Correct 👍🏻
@andrewthomas2406
@andrewthomas2406 Жыл бұрын
Getting a 2005 van ,older than what i have now but no dpf fitted.simples
@josephtaylor6346
@josephtaylor6346 Жыл бұрын
Hi Jimmy! Love the videos Wondering if you could help a welsh lad currently stranded in Canada. It’s a Ducato 115 multijet, 2l, 2014 I’ve located the dpf which sits vertically behind the radiator. Just wondering if you know which is the 02 sensor or which bolt I should undo to start the process.
@stevexb12ss
@stevexb12ss Жыл бұрын
When I worked at Ford. We were changing vaporisers on transits every day
@ORileysAutos
@ORileysAutos Жыл бұрын
Sounds like I work at ford 😅 Done 3 today 1 tomorrow and 2 Wednesday
@jted93
@jted93 Жыл бұрын
I know with manitou forks if you go too easy on them you have dpf filter issues, but you need to keep the revs up to keep the filter right
@bigbigtom001me7
@bigbigtom001me7 4 ай бұрын
Good man, keep up the good work with the videos. I am thinking of coming up to you for some work on my Touareg, but what is your preferred / normal working area.
@ORileysAutos
@ORileysAutos 4 ай бұрын
Biggleswade
@davidsharrock5704
@davidsharrock5704 Жыл бұрын
No need to replace the vaporiser. Drill a hole in the flat end, clean the carbon out and put a spot of weld over hole you have drilled. It’s a 10 minute job with the vaporiser on the bench.
@ORileysAutos
@ORileysAutos Жыл бұрын
This customer came 150 miles or so to have it repaired. Not worth risking as new part not expensive. I have lots of videos repairing a vaporizer
@barrymair2623
@barrymair2623 9 күн бұрын
Hi mate unsure if u can help Jimmy my 2014 64 plate front wheel drive transit has engine management light on and vehicle is in limp mode I have just sprayed a cleaner into the dpf and ran it but light is still on what could you advise ?
@Altair885
@Altair885 Жыл бұрын
Do transits really run that dirty that they block the DPF within a matter of a couple of hundred miles or so after the DPF has been supposedly cleaned? I understand that the vaporiser system wasn't functioning but I'm still surprised it clogged it up so fast! Is it possible the van has some other issue causing excessive soot to be produced. In my experience a blocked DPF is usually a symptom of another underlying fault. The only other explanation I can think of is that it hasn't been cleaned properly! 😏
@mrblonde2013
@mrblonde2013 Жыл бұрын
Worn injectors, egr issues, crankcase breathing issues, oil leaks from the turbo into the exhaust, lazy or non functional thermostat, cooler issues, etc,etc the list goes on and on...many causes of dpf problems.
@Altair885
@Altair885 Жыл бұрын
@@mrblonde2013 Well that's kind of point I was making. Unless you find the underlying issue then even with a working vaporiser there's still going to be a problem with the DPF clogging up prematurely, and during that period the vehicle is going to be trying to regenerate almost constantly which will have an effect of fuel consumption at the very least.
@alouisschafer7212
@alouisschafer7212 Жыл бұрын
No diesel should plug their DPF that quickly really. First question I ask myself with these cases is: Why is the engine producing all that soot in the first place?
@jasoneldridge4738
@jasoneldridge4738 Жыл бұрын
Modern diesels run rich,to reduce NOX ,which occurs if an excess of oxygen is present in exhaust gas from running lean mixtures which also run hotter.EGR coolers also are also more prone to clogging than older engines.
@Altair885
@Altair885 Жыл бұрын
@@jasoneldridge4738 Not so rich that it should clog the DPF a hundred or so miles after it's just been cleaned though, right? 😁
@barryscott8263
@barryscott8263 3 ай бұрын
I'm getting a knoc sensor fault and the ad blue tank isn't tracking the level in the tank. It's ful but only says no engine restarts in 250 miles . Ad blue dosing malfunction
@prawny12009
@prawny12009 Жыл бұрын
Catch 22 other faults cause regen cycle to fail to prevent the dpf burning out/melting but it then blocks the dpf and refuses to regen at all even after the first fault is fixed. Clogged adblue injectors cause nox emissions faults (selective nox efficiency below fresh hold) which prevent regeneration, leaking as blue can also completely block the exhaust with urea salts showing as a clogged dpf.
@markharris8929
@markharris8929 Жыл бұрын
DPF. One of the major problems is understanding why it fills! Less foot on the pedal stops generating the soot in the first place. DPF systems rely on the temperature sensors to regen.
@whitacrebespoke
@whitacrebespoke Жыл бұрын
I’ve got a sprinter that is showing many of the same symptoms as this it’s been to various Mercedes specialists, merc main agent and a local garage and it’s no better. DPF was taken off when it was having a clutch two months ago and acid bathed light back on with less than 1000 miles since.
@huwrichards9016
@huwrichards9016 Жыл бұрын
Best thing to do is get all the emissions crap removed. DPf filters and EGR valves kill engines. When emissions things are removed the MOT test results are better than before, also engines produce more power and better MPG.
@liamcinq
@liamcinq Жыл бұрын
Does this model have the 2 air filters? Worth replacing them at the same time?
@emirlekusic2192
@emirlekusic2192 Ай бұрын
Thank you very much for your videos. I have Talisman 1.6 dci 96kw and many mechanics dont know this . When i was told thay say that it will not br good I need to block Dpf and Egr . I clean pipe of exhaust pressure sensor like you said and do regen and now car is very good. Thx again. Only one question do I need to change oil after regeneracion dpf??
@davidrobertson5700
@davidrobertson5700 Жыл бұрын
Launch is the best, I only recommend Launch.
@ORileysAutos
@ORileysAutos Жыл бұрын
Launch UK are an amazing company
@davidrobertson5700
@davidrobertson5700 Жыл бұрын
@@ORileysAutos I know matey, I'm a Vehicle Electrician. I trust my life to Launch
@anthonywilson4873
@anthonywilson4873 Жыл бұрын
Glow plugs are used to help start with low emissions and also in many cases they are used during warmup. If a glow plug has failed that cylinder is less efficient and the engine will have a different performance from that cylinder during warmup. This torsional shock on the crankshaft will damage a dual mass flywheel with all of that cost! I had that conversation with a LUK Dual Mass Flywheel Technical rep. Also crankshaft dampers on the front of the engine if they fail the Dual Mass Flywheel takes all the Torsional vibration and fails early. False economy do the glow plugs.
@davidelliott5843
@davidelliott5843 Жыл бұрын
Engine manufacturers fit DPF and FAP systems. Why do they need an EGR as well? These are notorious for footing up the engine internally and creating even more soot that messes up the after treatments
@supernoodle48
@supernoodle48 Жыл бұрын
EGR reduces NOx. If you reduce NOx you increase soot, so you need the DPF to capture those soot particulates.
@kitcht
@kitcht Жыл бұрын
Great video. Thanks for the insights
@ORileysAutos
@ORileysAutos Жыл бұрын
My pleasure!
@eatsinabeat
@eatsinabeat Жыл бұрын
Hi, Jimmy, my wife has a 2.0 tdci kuga she's had from new, its on 117k miles, it regens as it should & I change the oil 4 times a year, do you think I should give the DPF a clean as a preventative measure given the miles or wait until it starts being an issue? I have always serviced it myself from new and it's never missed a beat, what's your thoughts, cheers. Billy.
@ORileysAutos
@ORileysAutos Жыл бұрын
If it ain't broke dont fix it 👍🏻
@eatsinabeat
@eatsinabeat Жыл бұрын
@@ORileysAutos thanks Jimmy.
@wellybobs4403
@wellybobs4403 Жыл бұрын
It helps if you put premium diesel and keep it full. Not heating oil...😅
@scottstrails9369
@scottstrails9369 Жыл бұрын
Another top video from the top techs,thanks for sharing
@ORileysAutos
@ORileysAutos Жыл бұрын
Glad you enjoyed it
@ghollidge
@ghollidge Жыл бұрын
My Relay was starting to smoke rather bad but after doing 400 miles in a few days it seemed to have cleaned itself out. That's one thing my van didn't fail it's mot on ha
@georgelekkos2766
@georgelekkos2766 Жыл бұрын
why your diagnostic has 2 differential pressure values? top says 0 and bottom says 49.... is this front and back of dpf?
@user-gw5qi9tw1t
@user-gw5qi9tw1t Жыл бұрын
Hi jimmy , I have a 2015 Ford transit 350 2.2 tdci mk8 euro 5 Blowing white smoke out of exhaust no loss of power no engine lights etc driving 100% Do you think a cable tied injector would cause the issue randomly smoking
@TheOriginalDaveJ
@TheOriginalDaveJ Жыл бұрын
Hey Jimmy, now you've had your new launch scanner a while, how about another quick vid on its ins and outs. . Assuming you're a bit more familiar with it. Cheers bud.
@ORileysAutos
@ORileysAutos Жыл бұрын
If I can think of anything extra to add yes
@vincemarshall8550
@vincemarshall8550 5 ай бұрын
bit late to the party ,how would you do a dpf that was pre vapouriser ,would you just do the dpf clean? cheers ,my transit doesnt have one thankfully but i had a mk4 mondeo 2.2 that went into limp due to dpf shame because it were a great car up to that issue
@tonyrice3348
@tonyrice3348 Жыл бұрын
New subscriber here, you definitely know your stuff. Great to watch, good work!!
@ORileysAutos
@ORileysAutos Жыл бұрын
Welcome aboard!
@veelside200sx
@veelside200sx Жыл бұрын
Did you buy the extended prope for the launch dpf cleaner, i mainly do volkswagen cars, and would have thought i could use the standard prob, if that was the one you were using in the video via the pressure difference sensor pipework.
@fabmukaj1615
@fabmukaj1615 Жыл бұрын
Please, maybe you can help me, I changed the Dpf filter 3 weeks ago on my Ford custom, and now the problem is back again. Do you have any idea what the problem can be ?
@betatester2560
@betatester2560 Жыл бұрын
dpf light came on my Mk4 caddy and just ran the the Vag Group DPF regen as per the instructions never heard from it again and sold the vehicle with a clean histrory.
@brendonelton
@brendonelton 9 ай бұрын
I believe that the mechanics that attempted to resolve this DPF issue were old school, and mainly guessing at what could be causing the issue, possibly not having the correct OBD2 canbus equipment either.
@rabhaw2327
@rabhaw2327 Жыл бұрын
I had the same problem with my transit. It failed on a blocked DPF filter so they took it off for me and I got 2 gallons of chemical cleaner and blocked one end and all the connection holes and put in over a gallon of the cleaner and left it overnight then drained it and put in the rest and gave it a good shake and drained it, they refitted and no engine management light and it passed no bother. Cost £45.
@luc-alaindehaes3512
@luc-alaindehaes3512 8 ай бұрын
is it possible to manipulate the DPF into regeneration mode by maintaining a certain engine speed at a certain RPM , gear ? and do these extra additional regenration modes prevent these problems.
@syncrosimon
@syncrosimon Жыл бұрын
Great information. Thanks for sharing. We have a 2014 460 minibus adblue. Should we be looking at getting a dpf service as a preventative measure?
@nigelbiscombe9199
@nigelbiscombe9199 Жыл бұрын
Saab do the same. Failed regen because the thermostat is stuck open. Can't reach system requirements. Can the vaporiser be stripped and cleaned?
@garryrichardson4572
@garryrichardson4572 Жыл бұрын
A couple of years ago a car guy in stralia called John cadogan was talking about the Toyota hilux dpf issues and one of his theories was a air leak in between the air flow sensor and the engine.
@rbeamish6492
@rbeamish6492 Жыл бұрын
This can absolutely cause DPF blockage. I had a cracked intercooler hose on my Volvo V50 cause the DPF to block. Apparently the air leak messes with the sensor readings which throws up error codes on the ECU. While those error codes are there the DPF regen cycle won't run. When my mechanic replaced the hose the regen cycle kicked in as soon as he started the car.
@GRUSSNewton
@GRUSSNewton Жыл бұрын
Hi mate, was there a code for the exhaust pressure sensor or did you just go off live data readings? Thermostat replaced? Great vids, keep up the good work
@ORileysAutos
@ORileysAutos Жыл бұрын
Thermostat getting replaced part on order. I ain't replacing the Thermostat. I was called to figure out the injection fault as no clear indication of what was causing it. It's common for this pipe to block so I checked it. Very difficult to unblock it
@arbit3r
@arbit3r 8 ай бұрын
I heard somewhere that the new Peugeot boxers with the 2.0HDI using these ford engines? Or is that only the 2.2? Thanks for your work.
@MattFaz-y8t
@MattFaz-y8t Жыл бұрын
glow plugs on transits are only used for starting.
@luke-so9hs
@luke-so9hs 7 ай бұрын
Great video and very good explanation on how to fix the issue, i'm looking at buying a 2014 Transit custom which the seller has stated there is a exhaust filter issue hence price! I'm assuming its the dpf also and has same issue , where can i source the same part make you use as there are so many chinese ones online and i need a decent trusted part. Thanks :) Luke
@michaeljohnson1006
@michaeljohnson1006 Жыл бұрын
The custom has got a dangerous safety problem. The design of the air intake for the heater it lets fumes from under the engine bay though the windscreen wiper arm holes and some small grills the fumes the get sucked into the cabin. The exhaust needed to exit at the rear not half way down trapping the fumes
@MrCountryhead
@MrCountryhead Жыл бұрын
Great video I have to say you no your stuff about the workings of these dreaded dpf’s
@ORileysAutos
@ORileysAutos Жыл бұрын
Thank you
@autoelectric3519
@autoelectric3519 Жыл бұрын
You are great man You are boss for all dpf story thanks man
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks and welcome
@RS.8184
@RS.8184 Жыл бұрын
Tbh the part name itself is pretty cool: A Vaporiser!
@mysurlytrucker7510
@mysurlytrucker7510 Ай бұрын
Do your glow plugs work all the time on a Citroen relay.
@NiktheEnglishGreekCypriot
@NiktheEnglishGreekCypriot Жыл бұрын
Hello mate. I’ve got a 2013 mark 7 transit. Had Dpf problems for months, had the vaporiser and bank 1 sensor 3 changed, engine light still would come back on after. Now the engine light has stayed off but the powertrain light is on permanently, would occasionally come on when I would drive at high rpm to try and force a regen but now it’s on constantly. Never has gone into limp mode the whole time I’ve had the issues with it. I’ve spent nearly £1500 in 6 months on it. Bar going to Ford and bring raped with their prices I’m at a complete loss. Any advice please mate?
@MrGrtx
@MrGrtx 7 ай бұрын
Been watching most of your videos now, you,re dam good at your job .:-}
@khoshalee99
@khoshalee99 6 ай бұрын
Hi love your videos how to clean dpf on peugeot 5008 2.0 hdi from 2012 .
@KKTR3
@KKTR3 3 ай бұрын
Have you had ford DPF blow back past the turbo?
@mechanicallymindedmike9677
@mechanicallymindedmike9677 10 ай бұрын
What model launch you using please pal? Can't seem to find the name of it. I currently use autel mk808- but thinking of upgrading to this
@ORileysAutos
@ORileysAutos 10 ай бұрын
Euro Tab 3 from www.launchtech.co.uk
@egghed1000
@egghed1000 5 ай бұрын
I currently have a transit in with blocked dpf that a mobile cleaning company couldn't unblock so I'm removing it to be cleaned properly. I've also found the vapouriser blocked and have codes for 2 glow plugs . Will the glow plugs stop a regen in the future as don't really want to do them lol
@liambyrne591
@liambyrne591 Ай бұрын
Do the dam things
@colinmaguire-nt4vl
@colinmaguire-nt4vl Жыл бұрын
Like any part on a car they don't last forever I had problems with dpf on BMW 318d I had it regenerated all faults on dianostic disappeared I eventually replaced dpf had no further issues
@peterr7437
@peterr7437 Жыл бұрын
hi jimmy surely half a bottle of the launch isnt going to clean that dpf fully,local dpf place wants silly money to clean it off the van plus he wont remove it so thats another bill to get it off ,plus he recons any mobile unit doing an on the van clean are ripping customers off ,any thoughts jimmy
@ORileysAutos
@ORileysAutos Жыл бұрын
Who is the guy saying this?
@properlymaintained1376
@properlymaintained1376 Жыл бұрын
Can I do away with the dpf have remapped and if I do will it put the dpf vaporizer light off
@skycanecorsa100percentpure5
@skycanecorsa100percentpure5 Жыл бұрын
a lot of them havent got a clue i had 2 mobiles 160 later light still on my mate took to his man and just plug in and sorted it out 30 pounds for his time dpf been good no for 6 months
@robertmobileman8304
@robertmobileman8304 Жыл бұрын
great video , great content and Jimmy fixed it again ......
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks again!
@careyautorepairs
@careyautorepairs Жыл бұрын
Amazes me why people won't pay for a clean after a new part is fitted.
@cypeman8037
@cypeman8037 5 ай бұрын
Glowplugs work other than to start a cold engine? Are you sure?
@ianrodger8927
@ianrodger8927 Жыл бұрын
Jimmy come up to Glasgow please sort my merc, love your videos and work.
@marklilley9079
@marklilley9079 Жыл бұрын
Still good videos for the community, to your knowledge does a autel 808 do DPF resets for vauxall vivaro I know you had one years back ??
@ORileysAutos
@ORileysAutos Жыл бұрын
Sorry u can't remember. Definitely not the newer PSA Vivaro
@marklilley9079
@marklilley9079 Жыл бұрын
2013 vivaro so hopefully it'll be good, cheers
@notmanynamesleft
@notmanynamesleft Жыл бұрын
Why are people still running Diesel Particle Filters? Just remove and delete them ffs.
@steveng5503
@steveng5503 Жыл бұрын
Well done mate! ✌️👍🇬🇧
@ORileysAutos
@ORileysAutos Жыл бұрын
Thanks 👍
Bag Of Parts Changed But No Mechanic Could Solve This Fault
17:14
O'Rileys Autos
Рет қаралды 38 М.
🍉😋 #shorts
00:24
Денис Кукояка
Рет қаралды 3 МЛН
Electric Flying Bird with Hanging Wire Automatic for Ceiling Parrot
00:15
МАИНКРАФТ В РЕАЛЬНОЙ ЖИЗНИ!🌍 @Mikecrab
00:31
⚡️КАН АНДРЕЙ⚡️
Рет қаралды 42 МЛН
New Ford Custom 2024 Break in - Tradesman Nick explains - Can we repair the hole in the door?
14:18
Sussex Installations - The Van Security Specialist
Рет қаралды 128 М.
My Customer Bought This Cheap Mercedes C250 CDI With A Blocked DPF
15:17
🍉😋 #shorts
00:24
Денис Кукояка
Рет қаралды 3 МЛН