SPORTSMAN 570 GETS NEW EXHAUST AND WATERPROOFED!

[@oscarazuara4441]

Video is short,simple and to the point.. love it

[@SequoyahJordan-l6o]

What did you use to waterproof it all

[@JayThompson25]

Silicone, but I believe OMC now offers gaskets for them, that’s the route I’d go if I had to do it again

[@jarrettford7090]

So this exhaust fixed the under water cut off problem? Mine runs like a turd under water

[@JayThompson25]

Yes, it idles with no issues. I’ve had the back rack completely submerged (check out the video on my channel) and it never cut off on me!

[@canamxmr4760]

Same issue with the water and back pressure. It fix the issue? As in long term in various situations like a soupy hole etc.

[@JayThompson25]

Yes, I have been rack deep in water, and some thick mud as well, as long as it’s not completely clogged (which could hurt any fourwheeler) the bike idles and runs perfect!

[@canamxmr4760]

07F150Kingrancher that’s what I needed to know. Thanks!

[@rswany16]

Did you relocate the battery? If so where would be the best spot?

[@JayThompson25]

I haven’t yet, but I would like to relocate to under the seat as some previous Polaris ATVs have been to keep it out of the water! Relocation kits are around $80-100 dollars and most of them move the existing battery to under the seat!

[@mudpuppy318]

I’m going to get a AGM Battery for mine when this original one craps out. Being so low and exposed I’m sure it won’t take long..

[@JayThompson25]

@@mudpuppy318 I agree, the placement on these machines is poor from factory.

[@J_TRAIN]

Damn she sounds good, can’t wait to get my pipe Friday. Under warranty for the next 3 years on my new 2021 so I’m not able to tune it. Figured this would be the perfect pipe. Make a little difference without a tuner at first?

[@JayThompson25]

Little more low end. tune helps with the top end a lot

[@J_TRAIN]

@@JayThompson25 thanks man. When my warranty runs out I’ll tune it. Appreciated brotha.

[@JayThompson25]

Anytime my guy

[@primer3458]

@@J_TRAIN this pipe fits a 2021 sportsman 570?

[@J_TRAIN]

@@primer3458 yes it’s on mine

[@RIDERSSOUL24]

I have a Polaris Hawkeye 300. The standard muffler went under the water a little, stalls, installed a Chinese muffler from Aliexpress. With it, when the muffler is hidden under water, the engine does not stall.

[@shawnsweat1906]

Did u have to get it tuned after adding the exhaust

[@JayThompson25]

Shawn Sweat I did not, gse markets the exhaust as a slip on that requires no optimization

[@shawnsweat1906]

So not running lean tht u can tell

[@JayThompson25]

I’ve rode it for 2-3 days so far everything is going great with the bike. No lean or rich issues that I have noticed!

[@jonreynolds2574]

Does that pipe and filter need a tuner to get it to its full potential? Any noticable power increase with the set up? Always thought you needed a fuel tuner when piping a quad. Thinking it would run to lean without one?. Good video! Thanks.

[@JayThompson25]

I noticed a increase In throttle response and possibly a slight increase in the low end! Gse markets the exhaust as not needing a tuner, the quad ran fine before the custom tune and I noticed no issues, I am now running a custom tune to get the full potential out of it and am pleased with the power it’s putting down now!

[@jonreynolds2574]

@@JayThompson25 thank you for the info. Appreciate it!

[@jonreynolds2574]

@@JayThompson25 thanks for the reply. I didn't want to dump another $289 into a tuner if I didn't have to. If a tuner would only possibly give me a couple of HP it's not worth the money. I'll just try the pipe and filter for now. I just wanted to be sure before I took a chance of damaging my brand new machine. I am just really looking for a little more power out of the hole and a little mid range power if I hit the throttle from a 30ish mph roll. Not expecting race quad results here. Just a small improvement from stock. Thanks again!

[@JayThompson25]

No problem!

[@JayThompson25]

If you didn’t want/trust a tuner, a custom tune would be a good option as it changes multiple things on the machine rather than just afr’s! Just a thought for later down the road for your bike! It cost me $300 out the door which is what you’d most likely pay for the handheld optimizers, hope this helps!

[@D_Carrillo08]

Does it need a tuner? For it to run properly

[@JayThompson25]

GSE markets the exhaust as not needing a tuner and the bike ran fine without one!

[@D_Carrillo08]

07F150Kingrancher alright thanks man those were the exact words for me to get it