Vauxhall Zafira how to remove radio & refit DAB double din + part numbers needed

As title this video is a step by step easy to follow guide on how to remove the factory fitted radio and fit an aftermarket double din radio with bluetooth & dab.
I keep the video as short as possible but do cover every single step while also showing the part numbers needed for the extras that you will need to do the job.
I am in no way held responsible for any Injury, damage of faults that arise from following this video. If unsure seek professional advice.

[@mumihp]

Guys, I finally got this to work 100% right now, I was so happy that my stereo turned on. This is what I did, instructions: You can do this method 2 ways, go through the fuse box or spice into the cigrette lighter. I went through the fuse box as I had experience due to hardwiring my dash cam to the fuse box. 1. Since this is a corsa, you need a mini add on fuse, brought one from ebay, £1 2. You also need to buy fuses. I picked up a collection from 5 to 30. You get like 40 fuses in a nice small box, it cost me £4 (I brought this because I wasn't sure which fuse size I need so It gives me option). 3. What you need to do, is decide which fuse you need to take out. You must take out the fuse which does nothing when the key is off otherwise there will be contant power to you stereo and you WILL KILL YOUR CAR Battery. I first used a 10 fuse but the stereo was on when I exited my car, to test it. 4. I finally found a 7.5 fuse that only works when the key is in the ignition. I then got the stereo red ingition wire, stripped about 1 cm or wire so the copper shows. I twisted the copper wire so the wire doesn't fray. 5. I then got the add on fuse, put the red ignition wire inside the add on fuse, then got a crimper and pushed down on the blue butt connector. So the copper wire is now essentially joined to the add on fuse. If you pull on the ingition wire, it should not come out, it should be secured tightly. 6. I then put an 10 fuse in my add on fuse, added the car fuse of 7.5 then I put it back into the car. The stereo SHOULD NOT TURN ON. 7. I then put my car keys in the ingition, turned on my car and the stereo came on. I tested it a few times, taking out my keys, putting it back in to make sure it's off when the keys were out. 8. Success. I then followed the instruction of this video. Makes sure you pull the ingition fuse wire from the back of the stereo cage to the fuse box, there are spaces in the back to wire you ingition wire to the fuse box. 9. After that, I got some cable ties, tied up the cables and finish. I used the fuse method because I did not want to splice into the cigrette lighter and fiddle around with that. The fuse method was the cheapest and easiest. Brought the add on fuse and a box of multiple size fuses for £5. No my stereo on turns on when my keys are in the ignition. Thank you PJs Projects, I watched your dash cam video and used this video to install my dash cam and my new car stereo in my corsa d.

[@wanhliu552]

Brilliant video, thanks for sharing !

[@MultiRetroMan]

How did you connect the red power cable to the fusebox? I daren't do any wiring or anything but your video made it look quite straightforward to do :D

[@jamiecook798]

Where is the 12v ignition switch wire in the fuse box to wire the red from the stereo ???

[@mumihp]

Really nice video. I tried installing my new car stereo in my 2009 Corsa D. It didn't work. I forgot about the ignition wire. Now...I thought about splicing into cigarette lighter but decided against it. Today...I brought a add on fuse. Question: which amp did you piggy of? Was it the lights, window ect...what was the amp size...10amp, 15amp, ect. This is what I plan to do....strip the wire a bit of the ignition wire. Put the red wire in the but connector of the add on fuse...crimp it. Then find a correct amp in the fuse box and piggy of it. So it would mean, when I put the key in the ignition, the stereo will turn on and off with the key out. Meaning my battery won't drain as there will be no power to stereo.

[@muff3m]

Will this be the same for a vectra? I currently have a cdc40 and want to change it for a bt/dab/USB 2din unit. Very informative video, not over complicated at all!

[@SaucyBegger25]

I want a new stereo in my Zafira so I can use my subwoofer from my other car but I’ve seen replacements even single headunits but they look awful.might get a full screen headunit to fill the gap one day

[@aaranokvlad8140]

i want to fit a sony XAV AX100 head unit in, but i wanted to know first if that would mean losing the BC functions? also as far as i can tell the adaptors are for ISO, is that correct?

[@robertabernard7946]

Thanks great info

[@sahajankhan1436]

My copper metal peice doesnt fit flush and clipped in on the stereo like your did, will that be a problem?.

[@csraln6748]

How deep from the tip do you have to insert the removal keys? Then you have to pull outwards or inwards to unlock it?

[@bader8544]

Hi One I clean this box from water and open the colored cables and clean it and returned everything in its place the car did not start up Only from light, horn and radio are working .. Any idea what could be the problem? Do I need to do reprogramming ? Thanks

[@mumihp]

Also, just in case the piggy fuse does not work for me, other than buying a steering wheel controler unit, the last method would be the cigrette method. Splicing into the ignition wire in the cigrette lighter, then connecting the red ignition wire to that, either use butt connectors, heat shrink or electrical tape. Can I ask, why you think this is a bad method, is there any risk to the cigrette method. I mean, catch on fire, screw up the electronics, ect...

[@WEREWOLF.FRANCE]

hello can you help me how to connect the power cable

[@edwardthomas9671]

Did the little screen work with the new radio?

[@wwillems88]

What will happend with the display if you put a new radio in a safira? I will know the info of the radio will not work anymore, but the other info like the time and datum and something like that. Will that also lost?

[@vanhelsing3432]

Hi can u help me to connect to the main ignition switch the red cable I don't have a clue where the main switch ignition located

[@gezrhys806]

Will this kit connect the steering wheel controls as well

[@shanegreenwood5408]

Hello we have a Astra mk5 van,cd30mp3 radio. The problem we have is screen above works perfect CD works,the whole radio powers up but no sound on tuner,changed all fuses that I can find listed in guide??? Is there a fuse for amp?

[@mattmattman1984]

How much would all this cost including the radio? Really needing to sort mine out

[@martinnewman2955]

Do lose the steering wheel controls?

[@robertibbotson409]

If i wire my stereo to my cigarette lighter and then turn my stereo off would it still use power from my battery because power still goes to my cigarette lighter even when the key isn't inserted. Thanks

[@markcurran7708]

how do you add the red power cable to the fuse box

[@paullawrence1726]

What's best way to wire red wire upto fuse box

[@Charlie-603]

Where do I put the other end of my red wire? One video I watched it ran into fuse box behind glove box and I have no idea how to do it.. everything else I can do I just cannot get my red wire connected

[@HiTubex]

Hi PJ, Thanks for this useful video. I have a question. How should I remove the newly installed double din stereo, if needed.

[@PJsprojects]

It will come with two release keys that you slide into slots each side and then pull to release the radio.

[@HiTubex]

Thanks

[@bradjames3555]

When you remove the original stereo you will lose the settings button so i guess you will no longer be able to use the driver info centre at the top centre because there will be no way to to through the menu's

[@waynewatson5437]

Hello, great video , would u happen to know the wiring diagram for the radio plug from the Astra H??

[@PJsprojects]

Currently still not working so don't have access to my diagrams.

[@rickysmith7516]

Hi great video , what fuse did you plug into for the ignition live ?

[@PJsprojects]

10amp

[@SaucyBegger25]

Was thinking of going from my lighter socket at the back of centre console in my 2011 zafira b but I’ve fitted lighter sockets in there and the back and they don’t seem to be ignition switched. We use monitors for the kids in the back and even with the ignition off they still charge if plugged in 🤔

[@computertechy]

All the lighter sockets are permanent live but there is a unused connector taped the the front cigarette lighter loom that is switched live.

[@SaucyBegger25]

@@computertechy thanks buddy. Yeah I found that wire upon stripping the centre console. It’s all good 👍🏻. Stereo is crap though lol gotta get a better one although it is usb

[@peterbennetts]

Will it suit a 2010 zafira

[@ssslgn]

Great and informative video, good job... Couple of questions though: I suppose the settings button will be lost? What happens with the info in the center display? How can you set the clock if you loose battery power?

[@PJsprojects]

The part of the car info centre that displays the radio station will be blank but the all the other bits will still light up.Sadly without a VERY expensive adaptor your can't set the clock,most modern radios have a clock function built in so it's not really a big loss.

[@ssslgn]

Maybe it is easier to cut power to the display, is that easily done?

[@angu31a]

To connect the red wire to an ignition switched power supply, did you just use a piggy back fuse connector attached to an already there ignition switched circuit? I'm going to be installing a radio into my 08 Vauxhall Vivaro.

[@PJsprojects]

Yes thats correct.

[@angu31a]

Do you know if I will require the orange cable for my van?

[@angu31a]

Thanks for your reply.

[@RobertSmith-ti6cx]

Hi, is this job more complicated on a Vauzhall Zafira Tourer 2.o sri 2017. We would like a more functional touchscreen stereo fitted to the car.Regards and thanks.

[@PJsprojects]

Yes the newer shape Zafira is a little more complex and as such I will be doing a video on one when I get one booked in with enough time to allow for recording. I do around thirty cars/vans/trucks a week so shouldn't be to long.

[@daleclatworthy1407]

We’re in the fuse box do the red wire go and what fuse to put it to please .

[@PJsprojects]

You will need a ignition switched fuse circuit such as the heater blower, make 100% sure you test the fuses before pulling them.

[@benjones443]

On the ariel converter what do you do with the blue cable?

[@PJsprojects]

The blue cable connects to the blue one coming from your new head unit. It has a very low power going in the converter. The blue wire from head unit can also be used to power electric aerials.

[@neilwatkins7494]

The red wire can it be connected to the 12 volt lighter

[@PJsprojects]

With the Zafira people tend to use a couple of short cut methods instead of going to the fuse box. I have seen either the red wire going to the heater control panel power cable(thick red wire) as this panel is very simple to pop out or if your Zafira has a ignition switched lighter socket then yes that is also an option.

[@canaluluandrei1424]

Make for vauxhall meriva pleaseeee

[@inulovesonu]

hii i am fit stereo in my vaxhall zafira 2007 model and its work nicely i am using adapter with cable and i want to just know about red wire thats ignition wire i am fit that wire also but problem only when i turn the start key then its working how can i use without start the engine use the stereo pla reply me and advice me about that thank u have a great time

[@PJsprojects]

To use the stereo without the ignition you need to put both power cables (the red and yellow) to a constant live such as the one that currently goes to your radio via the quadlock plug in the back of the radio.

[@inulovesonu]

PJs projects mate I don’t understand what i have to do with red and yellow wire where i have to connect both so its work when I normally key on and no need to start the engine pls mate give me normal idea thank u for your giving time to me

[@lisaosborne-adams5492]

Hi. Do you have any ideas on how to install an audioline radio into a Vauxhall Zafira when the wires to the original radio are different colours to the new radio please? Any help much appreciated

[@PJsprojects]

Hi. The Audioline radio should have a double black plug on the end of it's wiring loom,this should plug in to the plug that has come out of the back of the original radio.

[@lisaosborne-adams5492]

PJs projects yes we tried that at first but it doesn't fit I'm afraid as they are different connectors. So now we're stuck 😕 and the Mr thought it was a good idea to take the connection off and connect the wires together but the new radio wires are a different colour to the ones connected to the car so we're trying to work out which wires need to be joined together.

[@geordiegamer8323]

Hey pj I have a blue/yellow wire coming from the stereo it says steering wheel remote wire but I'm not sure where to connect it into my pc2-85-4 harness. On the harness box it says yellow is steering wheel control but the yellow wire is already connected to the stereo can u help me plz

[@PJsprojects]

That wire connects to a steering control interface such as this one - www.ebay.co.uk/itm/CTSVX002-2-Steering-Wheel-Stalk-Control-Adaptor-For-Vauxhall-Tigra-Vectra-Zafira/400435146944?epid=1722981206&hash=item5d3bcb70c0:g:DEYAAOSwySlZ6cSu

[@geordiegamer8323]

@@PJsprojects ok I see thanx mate

[@davidedwards633]

Do you have a video of wiring into fuse box?

[@PJsprojects]

Afraid not but if you run a wire from the red power cable at the new radio end and then use the mini blade fuse spur listed below it should work fine. www.ebay.co.uk/itm/Standard-Mini-Maxi-Blade-Fuses-Holders-Removal-Insertion-Tool-Fuse-Boxes-F/251928540375?hash=item3aa81c74d7:m:mmgwtFa_CShp7JW6OpqaZGg

[@arturkochan4649]

how do i know which radio modesl will fit zafira? same as in video

[@PJsprojects]

All aftermarket single or double din size radios will fit the Zafira.

[@adriansteward4779]

Hi great vid thanks 1 question,after installing my kenwood the info display is completely blank.any idea what I have done wrong? Thanks

[@PJsprojects]

Your info display should still show outside temp and time,the rest should go blank because the radio station is now displayed on your Kenwood radio.

[@Flokilegend]

please let me see where you connected the red, and orange cables, i have the car like yours, i'm in trouble, i don't have money to pay a professional

[@webbie104]

How do you change the washer bottle on a Vauxhall zafira and pump

[@stephenmcmahon2217]

webbie104 join a site called zafira b owners on fb or griffin owners they all zafira owners and plenty of help on them groups

[@PJsprojects]

Take wheel off and then remove inner arch liner,this gives clear access to the bottle. The bottle is held on with a handful of small bolts.

[@jj-iu3ni]

Is the quad adaptor color coded coz I need to wire mine up?

[@PJsprojects]

Not colour coded to the cars original wiring no,but the colours will match the cable that came with your new radio.

[@jj-iu3ni]

@@PJsprojects the problem I have is the female adaptor is not attached to anywires. Just bought the car. Di I need a mechanic or electrician? Thanks for replying

[@blairfleming825]

My car radio is turning on but no sound is coming out the speakers. Any ideas how to fix this?

[@PJsprojects]

Well if you had sound to start with then you can rule out speakers/wiring to the speakers,if on the other hand you have just bought the car and have never had them working then you need to check that firstly the car actually has speakers and they work. Other than that it could be the amp has packed up in the original radio or if you have fitted another radio in place of one that worked you may of not plugged the connector in fully.

[@dylanburkinshaw2177]

Central lock-in not workin propyl Vauxhall’s Astra

[@jonesyboy6933]

Where did you run the microphone cable?

[@PJsprojects]

Depends on the mic design,if a normal single mic then top right corner of the windowscreen hooked under the edge of the headliner and the cable run down the screen pillar. If a double stereo mic then above the interior mirror. On either run the cable down from the radio slot to the drivers footwell and then back up the side of the dashboard making sure the cable is well tucked up above the lower cowling to stop it dropping down on to the pedals.

[@rb1826]

how do you wire in the red wire please

[@PJsprojects]

You need a circuit that goes on and off with the ignition so get a test probe or multi meter and check which fuse in the fuse box reads no power when the ignition is off. If your unsure how to use a multi meter I do show in some of my other radio install vids how to use a multi meter to test for a ignition switched fuse,if that help.

[@user-dl9ck1hx7l]

Hi unfortunately i can not find an ACC in the engine bay how else can i get a ACC feed and were from please in have a zarifa b 2009 auto

[@PJsprojects]

Heater switch power feed is a switched live, normally it's the thick red cable in the switch connector but make sure to check with a meter before tapping power from it.

[@user-dl9ck1hx7l]

@@PJsprojects OK thank you if i am right did you say that this is not the best way as you took your feed to the engine bay how would i do that and what would i tap into please

[@nawafal3nezi720]

Where is the fuse for the CD player I couldn’t find it...? Please check out

[@PJsprojects]

Fuse box is in the boot at the side,check your owners manual for which one it is on your model.

[@nawafal3nezi720]

PJs projects thanks a lot I got it

[@cookalou7157]

How did you wire the power to the fuse box?

[@roartex4249]

Wish this had been included also

[@cookalou7157]

Instead of wiring it to the fuse box ive wired it to cigarrete lighter ignition wire

[@gmagill8611]

Any video or how to instructions

[@brianwaterfield3072]

How do i find the ign acc wire on an astra h

[@PJsprojects]

The correct way would be from the cars internal fusebox but I've seen a lot of people wanting a quick fix run a power from the large red wire at the back of the heater control panel(I do not advise this).

[@daveclixby8918]

Hi Ihave a CD stuck in the CD player how donI remove it it won’t eject when I press the CD play button it shows CD error

[@PJsprojects]

This would be one I would strip down to remove the disk as sadly no easy way to remove a jammed disk.

[@daveclixby8918]

Thank you

[@CJDJSDiscos]

Does this still show stuff to the top screen?

[@PJsprojects]

Your top screen will still show time and temp but the area for anything radio related will be blank.

[@CJDJSDiscos]

@@PJsprojects okay thank you!

[@sahajankhan1436]

If its a DAB why would you need both ariel to go at the back?.

[@PJsprojects]

If you only use the dab antenna you will not get any FM reception.

[@sahajankhan1436]

@@PJsprojects thanks for that.

[@sahajankhan1436]

@@PJsprojects i bought a Pioneer AVH-Z5100DAB, will i that kit?, it came with cage.

[@joepearson6644]

I can't remove mine at all power wire is to short and I can't get my hands in at all I am truly fucked 😭

[@akasteveps5805]

People pay a fortune for a new car so why are they always fitted with a crap stereo no one wants nad everyone changes I just bought a used car year 2008 and the stereo is straight off off the ark. I want USB ports and Bluetooth who uses or even buys CDs these days?