Volkswagen Audi Seat Belt Wire Repair / 00591 Fault Code Air Bag Light

Try at your own risk!I am not responsible if you damage your car or set your airbags off.That shouldn't happen but I can never know your situation. This is pretty easy on my car.
2008 Volkswagen Golf MKV R32 US edition #3900. This is how I diagnosed and fixed my airbag light.
If you would like to contribute to my channel and help with future videos
www.paypal.com...
Hood hinge wire repair
• 18 Faults 8 Malfunctio...
034 Motorsport dogbone insert
• 034 Motorsports Dogbon...

[@seanrobinson1780]

Thanks for the tip on the liquid tape. My wires were crimped so close to the buckle, it was a huge help. Got it done in one try.

[@kirk7547]

Thank you !!!! , I just sorted out my VW Crafter motorhome 's SRS light , bit of tape to tidy up wires and glue the two halves back together tomorrow and one major head ache gone BIG CHEERS ,

[@spuddoright1970]

Good video on a common VW problem. I just repaired mine this weekend. Both seatbelts had broken wires. Just to add to your tips, I took my seats all the way out and worked on them on a bench... made it a lot easier. Once you have the seat out, you have access to the other end of the harness that attaches to the main harness. With that access, you can check for continuity using a multi-meter to make sure your repair was sufficient. Also, I soldered all of mine. I did not have to clear any codes as they just went away when the system no longer detected the fault. FWIW, mine was on a 2003 GTI. Good video!

[@fordinlinestraight]

Was it the air bag code as well?

[@leodano2947]

Awesome video man. The weird thing is that the same 2 color wires were broken on mine too. Blue was obvious but the yellow I had to split open the housing. No more Airbag light. You rule! FYI, mine has 4 wires.

[@Justin-op8gg]

In my case, there was just leaves and debris in the buckle. Helpful video anyway.

[@3kkk514]

My audi a4 b7 intermitent airbag on, it kerp comming bavk after i deleted using vag obd, any suggestions?

[@joshcb7]

Could check the wires, I found mine by accident wiggling the seat belt

[@Celsian]

Thanks a lot!

[@MrMar4o]

I got the same problem with my belt except only the locking part. While I am driving with my seat belt on it still is beeping and the light that my belt is off comes on. I am guessing that one of those wires got disconnected, cause as you do when I wiggle the belt it goes off and on again... So I need to fix it, but how did you open the thing? Just brake the plastic?

[@joshcb7]

Slowly pry at the bottom up the sides.But yea you will need a little glue putting it back because its a part thats melted shut when they made it

[@Montery12]

Message left on 12/30/18: Check airbag icon came on after car sat idle with on engine for a few hours without knowing. Any ideas what happened or why icon came on right after car had run out of gas? Happy New Year everyone.

[@heavenlyhatch6219]

I'm going to cheek my pass on to see if there's any brakes the air bag fault has been on for few months somone moved the seat and it come on

[@fordinlinestraight]

Any luck with your airbag fault? Mines on to

[@nydrell1969]

Ill check mine also,changed the clockspring and the darn warning is still there

[@robertgreenfield9051]

Or just go to the junkyard and get a used one for like $10

[@JB-ro3sz]

and it will be bad or go bad in like a week.

[@mazpr2025]

@@JB-ro3sz not really, many car parts.

[@AliA-jr3iv]

I have 4 wires lol 😂 mk4 gti