Will the tile plow hold up to both 850 dozers pulling on it installing over 3,000 feet of mainline?!

shop Dirt Perfect
www.dirtperfect1.com/shop
Facebook
dirtperfect/...
Instagram
pCNzzDGKFL...
Ariat links
• Save 10% off your first order - ariat.dkkdet.net/c/2316545/69...
• Dirt Perfect's Favorites - ariat.dkkdet.net/c/2316545/85...
The tile plow is tested again, hoping all the equipment is up to perform!!
#850dozer
#drainage
#dozeratwork
#tileplow
#fieldtile

[@tommussington8330]

You should paint the fire extinguisher bracket blue and buy the 2 liter bottles of pespi for it.

[@billbarnes1043]

There is what we always called “The Dead Zone “ anytime you are pulling. It doesn’t matter if you are using chain, cable or rope. I have pulled feeder cables for 45 years, certified in rigging and lifting, off-road recovery and was an equipment operator. Pulling cable, I have seen a 7/8” Kevlar rope break and punch an 8” block out of a wall. The length of the line from point to point should determine the area (dead zone) that nobody should be in. That area is determined by the length x the radius from both ends.

[@toddincabo]

A couple of soaked towels draped over the cable helps drop it in a failure event.

[@erikcourtney1834]

@@toddincabo if using chains just hang some short chains along the length of it. Or whatever you have to weight it down.

[@kenore4003]

Just a question, is this the first time being doubled up with the 850's?

[@wdwerker]

@@kenore4003 we have seen it a few times already.

[@zzirSnipzz1]

Hate chains tho. Idiots online using a long one to pull a tractor that was stuck it snapped and went in the front window at him i think he was okay and hopefully learned a lesson

[@billbyrnes9505]

WARNING: I worked for a man, who lost his leg from the knee down, doing just what your doing! They where pulling a loaded rail car on a set of tracks so they could load the next one. That cable, just like you just proved, when stretched too far, snaps like a rubber band and didn't care what's in it's way. Note, how close where your kids? Your lucky my friend. Just a warning. That cable wrapped around my ex bosses leg and did NOT stop there. Please use more caution!

[@waynehoch3009]

I was thinking the same thing. Those kids don't need to be that close. Could have been bad.

[@paulprigge1209]

I was thinking that Cable was going to break before It did. Hopefully he will listen. Take care of that burden around would be horrible. Especially with a kid.

[@toddincabo]

Those kids were well enough away to be safe. Maybe DP could build a titanium cage to put any onlookers in next time to keep you naggy nannies happy. I'm sure the parent was right there as well and applaud him for having his kids outside witnessing true work.

[@k1n2g4]

@@toddincabo i totally agree... dp most certainly took plenty of care.. we all could hear him instructing the kids. And when the cable snapped the kids where even behind the golfcart. Even with the fact that cameras don't show angles very well they where at least 3 times the dozer with away.

[@splatterize]

I was told a story about a guy core drilling through pre-stressed concrete. Cut through the cable and it cut him, the floor, and the wall in half.

[@mharry860]

The little dozer pulling the big one is the perfect description of my life, my daughters and my Christas 2 daughters keep me going. Love seeing the little ones.

[@DirtPerfect]

Interesting both dozers or the same size

[@willb3018]

That plow is amazing. Every time I see it I am amazed at the amount of pipe you can lay so relatively quickly.

[@tomswindler64]

All I can say it’s impressive,lotta planning,lotta scratching heads,but y’all accomplished the final goal with minimal glitches.job well done guys.especially you Matt ,I can imagine how hard it is to have to keep D.P.in line.Lol.great video,great content,just keep doing what your doing.😎😎😎👍👍👍

[@ronpeacock9939]

Well, I can say that from looking at your outflow... that's way more than a gallon/min.. more like 3+ gal/min... that means, A. That field clearly needed it.. and B. you guys and your toys did it right. Looks like that tileplow is getting a ton of use and it's doing the job well. I agree with many about that cable.. seeing the kids that close made me cringe. Looking forward to more.

[@roycepruett5862]

I was thinking about if the cable had broken at the pulling dozer with the proximity of the children, the cable could whip back several feet..

[@glennspreeman1634]

Wow, just wow!! second the motion on the cable and safety. keep everybody away especially precious kids.

[@NathanCEnyart]

You letting those kids ride on there reminds me of when I was about his age. A guy my Dad knew took me for a ride on the dozer he operated. I forgot all about it till I seen this video. You sir are a great Man.

[@jeffreykbevins7116]

It is amazing how well that the dozer and the tile plow is working together . That tile plow is the greatest idea and thing that you have ever made Mike . You all had to made back up and make a few changes, but I believe that you all have worked all the bugs out, and it is just amazing how that everything is working now . You will become known as the "Plow Man" and stay covered up in jobs, people wanting you to lay drain pipe . I have found that when using steel cable to pull stuff, old fire hoses are great to run the cable through and make it a lot safer if the cable breaks . 10,000 feet of pipe in 2 days is a good accomplishment and really didn't have any problems at all on this job . This was a super great video of you all doing a super great pipe laying job, and the dozer and tile plow could not of been asked to do any better, really, they both just worked amazing . I will see you all later so take care and stay safe and keep on laying pipe and digging and pushing dirt . As always, Jeffrey !!! 🤗👍💖💫

[@KarenL-qt7dy]

What an amazing property owner! He's not just "supervising", he's hands on, and very helpful! The three of you worked so well together. I wish him great success on whatever he will be planting in those fields, and more success to you, DP, on future tile plowing jobs.

[@anthonysutherland9487]

When using wire cable you must put a dampener or weight at the half way point to slow the whip effect if the cable breaks.

[@jester-gq9jq]

The best way is to keep everybody out of the way

[@tommymitchell3055]

I was just thinking "get the kids further away" when the cable broke.

[@calvinjutila8270]

@@tommymitchell3055 Same here...a good time to start teaching the kids.

[@FishFind3000]

@@calvinjutila8270 it looks like the adult needs a teaching to keep the kids safe

[@DirtPerfect]

Man it amazing to me how much you guys know from what little you see lol

[@patrickcolahan7499]

That plow is working amazingly well. So nice when a project comes out so well and you can reap the benefits. Thanks for sharing.

[@micheal49]

The kids and dog playing in the scoop is what makes this video!

[@randallsmerna384]

I would like to suggest that you put a parabolic curve on the tile entry point up top kind of like a tuba cone but with a rolled edge. You can see that there's unnecessary friction because of the edge of that current entry cone due to the clicking of every rib. Perhaps even a six or eight foot arc with a separate feed motor on top That engages every time you move forward to eliminate all drag and friction from having to lift and pull the tile along. It's probably not an extraordinary amount but every bit counts especially when you need to get pulled to buy a second dozer.

[@nothing2loud]

Awesome seeing something come together and work so perfect! Great job men!

[@donaldtrabeaux5235]

That was awesome and letting me young man ride along with you is priceless, you are awesome DP and Matt.

[@josephdriscoll8527]

working great as expected ,as you pull and turn I think you are so fortunate to have MBTS in your life for all the excellent welds and craftsmanship. Matt is a great hard working team player geetar done

[@terryrogers1025]

True, good testament to design and build of the plow especially with 2 dozers pulling thru mud on a curve, I can’t even imagine the pressure on it. Again congrats, it’s been a long haul to this point, thanks for the ride along sir.

[@okiemale1589]

A little dirt in my coffee this morning is always a good thing... The pipe plow is really kicking butt!! Great job guys!! Another great video... 😎👍

[@chazco]

Thanks for showing the outlet. It is great to see that all the work is paying off.

[@paulmccormick5042]

Loved all the design and build work vids you've posted, but you definitely now need a proper A frame towing attachment for those slippy moments; and a twin bladed trench closer attachment on the following dozer would complete the picture.

[@wildtimbrown]

"proper" Can you show us?

[@dansbrown1313]

Thanks for a very thought provoking video Mike. All the early testing of the plow was done on your families property but this just might be your first paying customer and he must be very happy! With regard to the tow cable snapping, We use two heavy duty snatch blocks, one end attached to your equipment and the other to the tow vehicle. One side of the snatch block opens so you can put the rope or cable through quickly and doing this will mitigate safety concerns. The kinetic energy build up will be lowered at the snatch blocks. We use them on all our marine ways to pull large steel vessels out of the ocean. Cheers from Canada.

[@donniemccaffery3961]

Your plow is working amazing, great job on the build. Keep the videos coming.

[@rebano2341]

Around 07:30 DP asks the children some questions ... no answers. DP: "Who wants to go first?" Immediate reply. 🤣

[@robertellard]

Great work guys. I agree, its best to roll out the tile 1st. It frees up Matt to pull you if needed. Your franken-tile plough has really paid off. 🙂👍🇮🇪

[@williammeiklejohn2850]

The system you guys have in place is absolutely fantastic awesome work and video

[@Jameson4327]

That plow has worked fantastically!

[@retrodad6864]

Great teamwork Mike. Enjoyable to watch the progress. Thanks for posting. 🇬🇧👍👍👍

[@DirtPerfect]

Thanks

[@scrotiemcboogerballs1981]

I was told by a old man to put a blanket or rubber mat on the cable even say something like floor mats out of a car on top of the cable in the middle so if it breaks it will most likely drop down when it whips back just saying glad the plow is working so well congratulations on a job well done thanks for sharing buddy

[@frag0mat1c]

Nice to see your idea put into practice and work so well.

[@slowlydimming4320]

Impressive construction of that plow, watched the build it's working fantatastic!

[@richardthomas1743]

WOW! That was a huge job! Well done!

[@joeberanek6653]

You make my DAY'S with what you do. It's too HOT in AZ. to do much . We need the Rain you get there. Stay safe and thank you for posting your video's.

[@SullivansTrails]

You guys are fun to watch! Interesting stuff with good commentary!

[@DirtPerfect]

Thanks

[@thomasdesmond2248]

DP you get the best film crews. God bless

[@lindaleslie5634]

Great plan executed to completion!

[@kopenhagenkid]

Great video Mr Dirt Perfect and Matt

[@TheGingerGenius78]

Awesome to see both 850s pulling nice work and the speed that tile drys the ground up is amazing ! Was funny when Matt got the tractor stuck :)

[@SteveQ270]

Nice work. Glad no one got hit by that 1st cable that broke

[@brianmoreau8386]

yup I GOT a bad story about cables you don't to hear it plenty on the feed already

[@danielelwell2571]

All that hard work is paying off, what a team.

[@gayle4804]

Awesome job guys you accomplished quite a bit watching the tile laying 😀 👍

[@prinzeugenvansovoyen732]

get some army surplus tank pulling cables, they are good for a dozer, they are also wrist thick , this flimsy cable probably had a capacity between 16 and 20 tonns , you expected 50 tonns of pulling power from it

[@charlesfreed7834]

That plow is working great good job on the building of it 2 850 s pulling on it that's impressive

[@genegoodman5233]

I liked 👍 Matt’s idea, it kept the pipe off the ground most of the time so it doesn’t get “dirty “ before installing. Yelp it looks good 👍 keep trucking.

[@dlyn3583]

The two wee lads helping are adorable... And put a time lapse camera on the next mainline as you instal it to show the flow as it happens... Well done guys

[@marksaunders2500]

Hi from uk Mike and crews👋👍 good job getting a good start on this job! But I really to wish you could get 20 ft of anchor chain or summit to double pull with and 2 big shackles as I think starting to push your luck with cables and tensile strengths or weaknesses or put cables in a old fire hose to slow it down 👍 good job tho guys 👌 thanks for your time and be safe see you soon👍👋

[@cs-gi8me]

Great job we definitely need all the farmland we can get

[@drewzavasky2562]

these are the money shots I've been waiting for!!!

[@Bman2020]

I had said in the past that whole set up is so impressive fantastic u. Think a guy might get bored watching this but nope great content 👍👋🇨🇦

[@leol1682]

Thanks for the video love it Mike and guy's .

[@everestyeti]

That is a brilliant bit of kit, especially with the laser level, that pipe was flat and straight. Makes pipe laying so much easier.

[@TheBlueberry606]

Working like a charm. That cable breaking with those kids around scarred me to death, I almost 💩 my pants.

[@johneken2056]

Would a three point tow bar be safer that cable/chains that can snap and recoil?

[@joejohnson7097]

The plow working perfectly it's amazing how much water drains to the pipe for run off thanks for the video

[@kopenhagenkid]

Great job driving the cat Mr Dirt Perfect

[@michaelmullins1290]

That's alot of pipe and alot of water going to a better place. Great job DP and Matt. All the little help was good to.

[@kevinkenyon7045]

Mike and Matt awesome video! Thanks for sharing ! Kevin

[@SpeedSmith]

Coming along very nicely.

[@thomasdesmond2248]

And the MVP goes to the 850J. With 850D getting the assist. God bless

[@trumpingtonfanhurst694]

That plow and laser is just awesome. Nice work, a/c boy :)

[@machinemoverman4614]

Seems like the tile plow build videos is ancient history now. You done good!

[@morgansword]

Super happy for you Mike... might just consider making a second plow system for back up if its going to be as steady as I think your going to be... after all, its only money. Like you, I never ever had too much of that green stuff. That farmer looked real happy.... are all those water outlets doing a gallon or more?? I am just guessing but if that was only a gallon a minute, why after seeing the water running that well, I had to drain some of my own... funny how water affects us that way but at seventy two, nothing should surprise me much

[@SwedishCook1]

Great job, amazing how much water is running out of that field.

[@heatherlane9270]

Great to see the laser chaser in action. Kids loved the ride too. Well done DP.

[@Biggs58]

The tile plow looks better every time you get it in the ground. To see the field drain out that quickly is something. 👍

[@jeffreykbevins7116]

Nancy, I have saw you on here several times making comments and one time 3 months ago my comment was just before yours . I am glad that you like watching Dirt Perfect, and you are so cute . Dirt Perfect is one of my favorite on here and I love watching them working and joking and laughing . They always have great content on the videos and are so enjoyable to watch . Maybe see you later on another one, so take care Nancy . I live in Lawrence County, Kentucky ( that is in the Eastern part of Kentucky ) on my farm with my 4 dogs . As always, Jeffrey !!! 🤗👍💫

[@Biggs58]

Jeffrey not to lead you that is a picture from 1981. Also I am her husband and use the same account. My wife still looks this way in my eyes not so much in others. Please you shared with us and glad you have such a peaceful area to share with you animals. Peace

[@kopenhagenkid]

Great job guys

[@archiereid4474]

Dp another great video, u should fit a bar with a a steel car rim with bearing to the top off the plough to help the pipe in

[@dirtyduck1947]

nice to see the farmers children taking a active interest in whats going on here ! good kids

[@DirtPerfect]

Agree

[@robertwinton2649]

A job very well done I love it keep up the good work

[@waterchickenwoodworxbydanb42]

Love that you let the kiddos go for a ride! Somebody like you let me ride on a dozer and a pan when I was a kid and it still one of my best memories, then got a job running equipment and made sure to do the for kiddos! Hey also do you do an as built for the tile jobs so if anything comes up down the road or want to add or change anything later you know where it is ? Great video Mike thank you

[@pinwizz69]

Looks like Y'all finally had some wonderful sunny weather and a couple of younguns to supervise Matt helping put all that tile in. Don't know if that was Farmer Chris or some other farmer you put that tile in for but given how much you did they had to be extremely happy you did Mike. Well, I've fed our Kitty Pumpkin and had my breakfast and some entertainment but I was up rather late so I'm going back to sleep and I'll finish this later. Kitty woke me up for his breakfast and he was outta water. Thanks Mike for some nice Monday morning entertainment. 🌄. God bless you and your family plus Matt.

[@bump6469]

Dude you have created an awesome attachment you are gonna be the new master pipe layer love the content and love the hard work. 👍👍👍👍👍👍👍👍💪💪💪💪💪💪💪💪💪💪

[@brentoconnor6127]

I saw that cable, and the kid standing near the ATV, and I cringed. Longer cable means more failure points. Thankfully no one got hurt.

[@johnbradbury433]

DP! You could have cleaned the back window! The Aaron boot working a treat. There no stopping you now. MBTS. He will be tuffed to bits with is welds. Money well spent. Told ya. As you would say.

[@thebear5454]

Your 850J is an amazing machine. Pulling the plow through that muck surprised me. Nice job Mike & Matt.

[@DirtPerfect]

Thanks

[@grahamheath3799]

Looking Good All you need now is a spool on the dozer to hold the pipe sorry tile.

[@dennis2376]

Looks like you got to make a recycling run. :) Thank you and have a great day.

[@haydenuk02]

Top work and thanks for sharing this with us take care

[@mauricekeithjohnson2598]

IMPRESSED !!

[@garymessina1609]

You couldn't ask for better than that good job fun video

[@paulprigge1209]

Thank you!

[@mangrove21]

lookin good,wish our long term renter would tile our back fields ,natural spring has 6 acres un plant able,,but i understand cost versus yeild,keep pluggin at er

[@jimbo5056]

Very nicely executed game plan ! A well deserved ATTABOY for MBTS skills, knowledge and foresight to build a accessory that will make you "THE MAN FOR TILING " for years to come. Well done DP ! An honorable mention goes out to Matt with his skills and "tolerance" , if ya catch my drift? Enjoyed the heck outta this 'vidyah' (LW). 👍😀

[@DirtPerfect]

Thanks and agree

[@charlesmayou1741]

@DirtPerfect, you should look into building a "Tow" bar to use when you need to Pull the 850J with the 850BLT that way you are not having to rely on cables that can snap and kill someone or a chain that may or may not be strong enough. You could use the tie down holes on the front of the J an the tow point on the B to attach the Tow bar to, this could also allow the 850 b to steer the 850J a little.

[@kenking5870]

Now you need to make an attachment that can cover the pipe in one pass.

[@bobsmith6484]

great to see water coming out of the pipe shows pipes were lade wright good job are you going to fill in the out tranches now that you have pipe in the ground?

[@apollorobb]

Looks like the ole Flaming dirt system is still kick. Good job fellers

[@maxobara1496]

Great job DP and Mr Millennial, putting a lot of pipe in the ground and making it look easy. Just imagine if you had to dig all that and get pipe in before the sides collapse 🤪 Keep plowing away 👍🇺🇸

[@tomkeating65]

Back in the day, Cat offered a tandem in line tracked machines whose sole purpose was to push pan scrapers. You need to fabricate a tow bar between your two machines when you need that extra grunt. 🙃🙃🙃

[@randallnottingham799]

That plow blows me away on how good it puts the pipe in the ground DP

[@sandrastaley5333]

Love the kids playing in the bucket.

[@tiagovilhena3975]

É tão bom ver as crianças juntas no ambiente de trabalho parabéns

[@petenolte4192]

That's hard to make a curve with the plow and using both 850s. Great job!!! With that 1st run the water was probably running in the tile before you left for the day

[@sparksalot4950]

Great job!

[@k1n2g4]

Nice shot at around 11:33 how you can see and hear how you break through the resistance..

[@benchipley]

Excellent work! I hope you’re working on your patent paperwork. 👍

[@marknunya3035]

And somewhere Flaming Dirt is has a swelling of pride as his hardware and software work flawlessly in unison to keep DP on grade. As always good luck and God Bless

[@bobjoncas2814]

...great way to test the plow for weak parts....lol...good one, keep safe...