8 жыл бұрын
Пікірлер
@48blackshadowcafe32 Ай бұрын
I thought about the stator in mine but nope. Regulator/Rectifier gone bad will drain battery and not start. I have 2 Suzuki Eigers. Ask me how I know, 😂
@unclemarvin5606 8 ай бұрын
Flywheel magnets come lose, and causes both spark and charging issues. I am currently working on this exact problem, and the Flywheel magnets are definitely the issue. I hope this helps.
@SuperMichaelbennett 11 ай бұрын
I thought poor sparking was the fault of a bad coil. I bought a new one but I had someone who is a veteran of small engine repair found that it was a chafed wire. Not the 56 dollar coil. He did not use any electrical gadgets ,just followed the wiring and found it. Repaired it. Suzuki Eiger works fine now.
@liviuiobagi8366 Жыл бұрын
Cum sa reglez ambreaju
@scottfrye7956 Жыл бұрын
Its in reverse thats why you don't have spark no power to the key switch
@tommyorrison9659 Жыл бұрын
For all the people who installed new stator swap the leads in the plug coming from stator i had thr same issie and this fixed it.
@xxsilverxxfox5153 Жыл бұрын
Can u elaborate. Do u have a wiring diagram?
@renaudjacob1497 Жыл бұрын
Sounds like you're stator and or flywheel if draining the battery
@josephombago7446 Жыл бұрын
It can be your handle on and off switch your headlight switch on and off switch replace that
@Kadenfields6571 2 жыл бұрын
Change the key ignition switch
@jsimm4587 2 жыл бұрын
Flywheel sensor or coil , magnets on flywheel or stater bad again or cdi box bad wire . Get a multimeter verify signals are working. I don’t think the brake light working has anything to do with firing
@kamakeboi4881 2 жыл бұрын
Doesn't it need to be in nutral
@bluufus6176 2 жыл бұрын
Do you still have the wiring diagram for it?
@dalegranroth4833 3 жыл бұрын
I mean SUZUKI one! oops.
@dalegranroth4833 3 жыл бұрын
update. I discovered the $165 aftermarket flywheel i installed did not have a strong enough magnetic field to activate ignition. I installed the $500+ polaris one and problem solved.
@seandonnelly3150 Жыл бұрын
Polaris?
@dalegranroth4833 3 жыл бұрын
there is also an ignition fuse in the box under the seat to test while cranking. I also have changed the flywheel {updated} stator, cdi and coil and tested continuity of wires,etc. and still no spark. Do these things have an oil pressure switch that can affect ignition?
@beebo4588 3 жыл бұрын
I’m having the same issue and I’m lost
@waynedolan4836 2 жыл бұрын
Swap the yellow and the white wire around cause the magnets done changed polarity
@michaelshreve5997 3 жыл бұрын
Fly wheel
@michaelshreve9267 3 жыл бұрын
Fli wheel bad
@chadwright9988 3 жыл бұрын
Did you ever get this figured out? I’m having the same issue.
@chadwright9988 3 жыл бұрын
Did you ever get this figured out? I’m having the same issue.
@polaristopten8515 Жыл бұрын
Replace your flywheel. The magnets come loose and cause a random no spark issue. It is a defective design by Suzuki.
@chadwright9988 Жыл бұрын
@@polaristopten8515 … that was the issue.
@chadwright9988 3 жыл бұрын
Did you ever get this figured out? I’m having the same issue.
@ifnotnowwhen6914 3 жыл бұрын
I'm dealing with an arctic cat (uses same engine/ignition) that had the magnets on the rotor/flywheel come loose. Put a new rotor, stator, and pulse coil on. Still no spark. After lots of research and testing etc I found out the polarity of the magnets must have been reversed and after repinning the wires from the stator and pulse coil I did get spark. Pretty common for these suzuki and arctic cat atvs according to forums. Still hasn't started the machine though as the timing seems out but I haven't had enough time to dig into it for sure.
@chadwright9988 3 жыл бұрын
Did you ever get this figured out? I’m having the same issue.
@jacobpintye150 3 жыл бұрын
Check the flywheel magnets
@beaucranston5444 3 жыл бұрын
Yeah dude you need to hold clutch
@beaucranston5444 3 жыл бұрын
I have that bike too
@Kirayamatoplay 4 жыл бұрын
well when u turn ur key on do u see ur N night light up if not then check the light bulb and if the light bulb good then ur gear shift Sensor not working because less ur in N it wont give u spark
@Kirayamatoplay 4 жыл бұрын
u know it wont start if the quad is in Rev right
@beebo4588 3 жыл бұрын
I have the same on it won’t even crank if it’s not in Neutral
@kanestokes1850 4 жыл бұрын
Bad switch up on your bars?
@joeclark7471 5 жыл бұрын
Um um um um
@johndedo8403 5 жыл бұрын
Yes . when I jumped it from the starter relay the bike fire it up. And now I can't get the bike 2 crank it's like when I try to jump it from the starter relay there's something draining the battery it's like the battery is going dead.
@brianmeredith4248 5 жыл бұрын
Rectifier check that had a Kawasaki have that go out no spark and wouldn't charge battery ATV died on me middle woods hope that helps I work on machines alot and have the same machine might be the solution
@lawrencemiller2379 5 жыл бұрын
I have a 06 arctic cat 250 fourwheeler with no spark. Is mine one with the magnets falling off the flywheel ??? I held my spark plug while spinning it over I felt one single spark as I flipped the override if that says anything.
@gregoryjones6714 4 жыл бұрын
Sounds to me like a neutral saftey switch. There's one at the foot brake and the transmission. Mine was the master kill switch. It was only getting a week spark. Replaced it and it ran fine for awhile, now got new issues. SMH. Good luck
@skulledmonte84 5 жыл бұрын
Did you try holding the clutch lever in
@gl1800se 5 жыл бұрын
YOU ARE SERIOUSLY F$%^&*KED UP CHIEF !
@balltime3377 5 жыл бұрын
did you get bike running yet
@micflynn1 6 жыл бұрын
The sad thing is your Suzuki dealer knew what was wrong (flywheel) and if they didn't they don't need to be a dealer!!!! But they cost you a shi7 load of money!!
@harrisonlowry3428 6 жыл бұрын
Nice vid sub back to me
@darynhammons4981 6 жыл бұрын
did you ever figure out this issue I have the same thing happen
@wa73junior 7 жыл бұрын
Been there done that,luckily I got mine used and hardly put much into it,but all these issues I had,changed to the new fly wheel with the magnets enclosed,4 wheeler hadn't stopped running since
@brandoncase6002 7 жыл бұрын
I didn't buy a brand new Fucking bike to spend 1500$ more just to keep it Fucking running
@brandoncase6002 7 жыл бұрын
Suzuki needs to figure there Fucking shit out because this shit is pissing me off
@brandoncase6002 7 жыл бұрын
same exact Fucking issue
@TheEigerGuy 7 жыл бұрын
Brandon Case I had theses issues 2 weeks ago. flywheel magnets were shot. 618.00 to repair. I took it to a can-am dealer cause Suzuki wanted 750.00.
@teamhex 7 жыл бұрын
Did you have to pay $400+ for the CDI? I'm looking for one right now. My 04' seems to need one.
@johndedo8403 7 жыл бұрын
I would go on eBay for an CDI box
@DirtNastyMoto 7 жыл бұрын
im having the same issue check magnets on flywheel
@MiguelMartinez-le4hu 7 жыл бұрын
Did you ever figure this out? I have the same issue. Thanks!
@yurimunrayos69 7 жыл бұрын
Miguel Martinez same!!
@gregoryjones6714 3 жыл бұрын
Magnets in the flywheel is a common problem with these models
@muherd79 2 жыл бұрын
@@gregoryjones6714 it’s trying to start no the starter
@skulledmonte84 8 жыл бұрын
Eigers are known to have fly wheel magnets come unglued i got an 03 eiger never had a problem with mine but during my 2 years of having it. i have read a lot about the magnets ,i got a regular stock flywheel and the upgraded on no issues yet.Be prepared these flywheels are not cheap and require a puller to pull it the "right kind" Was the shifter in neutral ? couldn't really tell look like it was in reverse. Ebay is that place i get most parts for mine have any question man let me know
@teamhex 7 жыл бұрын
the CDI boxes are $400-$500 right now. My dad had the magnet issues on our 04' and it has been a nightmare. Got all the parts replaced and the bike put back together...no spark. So we're assuming the CDI is bad. Interesting though.