2011 Jeep Patriot Replacing Temperature/HVAC Actuators Fixing "Clicking Under Dash"

[@otbmikesrides1476]

Best video of all I've watched. The others don't even mention that there are three actuators with different functions. I had to find this out by trial and error. Now, I have to buy one actuator and put everything back together. Thanks for sharing your experience. By the way nothing has changed. I have a 2016.

[@nfamouzcookie]

Literally same! Changed the first one I seen, then found the right one thanks to this!. I have the 2016 as well

[@BeetleBuns]

yea I replaced the driver's side actuator that regulates air temp because it had a damaged gear, then it started clicking again a month later so I got another and went to replace it _again._ Turns out it was fine and the passenger's side actuator was the one that was busted. Great.

[@shaunpfund3370]

I wanted to let you know that I found the best approach to replacing this part was to remove the passenger seat in my 2015 Jeep Patriot, place a couple of cushions in the gaps to save your back and slide under the dash, near the fire wall, face up, where you can get at least a glimpse of the actuator. It was still not easy, but we got it done. This part was held by two screws and yes you guessed it, the top one was a B...h, your screwdriver and hand are smack up against the firewall. The reinstalment of the part was a bit easier, but still a challenge.

[@adrianabishop9579]

Thank for you help I’m definitely gonna do that to make it easier

[@GuillermoGarcia-zw2xp]

Man have you saved me money!!!! I couldn't for the life of me find where that 3rd one was (the air changing actuator) you're the only video I've found that has showed where all of them are! THANKS MAN! Do you happen to know the part number for that one?!

[@SojournNative175]

Thank you for showing all the specifics!

[@dannylewandowski2822]

Thank you! Someday I will have to tackle one of these and it’s good to have prior knowledge.

[@willcorrea]

OK. Found out what was causing the Clicking noise. The Air Conditioning filter was not re-installed properly back into the tray inside the glove box. Whenever I take my car to get an oil change, or an inspection, they always try to upsell you on stuff. That Air conditioning filter is one of them. They just put it back in incorrectly causing a jam that causes it to catch internally making a clicking noise. UGH. Glad I watched this video, and almost bought a new actuator, but that was not the issue. Just going to buy a new filter online, instead of the 4X markup they do at those service stations. Also changing my own oil again from here on out.

[@patrickmurphy8619]

That's the first I've heard of anything like that but at least it saved your money

[@samanthapena6802]

Patrick great video!! Thanks for showing where all actuators are. I had a question. I have been experiencing the popping and opened up the glovebox to see. As i switch my air controls to ON i see the white filter switch forward but then i see it get caught and the clicking starts.. is this an issue with that piece or would this still be considered the right actuato ??

[@rikegasstation]

Great video, really helped trying to locate these actuators! Thank you

[@JD-zq3ke]

Patrick, extremely helpful video! Do have a question though. I replaced the two actuators behind the glovebox. The actuator on the left side that controls the air direction I must have bumped when I put it back in because now it sticks halfway through the cycle. Any idea how the white plastic pieces align behind the actuator at the video 2:00 mark? Or what that part name may be so I can order a new one? It appears to be captured by three screws and the paddles ride in grooves on that large white piece to adjust the air flow

[@leilanymarquez319]

What is the part called for the clicking sound you did 1st

[@Mostlyanxious]

Mine used to click as well as a delay of about 1 minute. It doesn’t click anymore but it still takes about 1 minute to turn on the a/c. Would this be my problem or maybe something with the hvac controls?

[@Mr_BUSINESS_24_7]

Do you absolutely need to initialize / calibrate the motors with the scan tool after installation ?

[@wellcastro6048]

Hello is the 3 actuator have the same part number? Or each of them have different part number? Before i order? Thank you.. very helpful video

[@VATAWC]

The Actuator closest to Passenger window....does the dashboard need removed in order to get to the screws to take them out?

[@fernandomcc7954]

Question. Are those three actuators the exact same model? My 2017 Patriot has those noises from the driver and passenger side, but I'm not sure if I should be looking for different part numbers. Thanks a lot for your video!

[@marilynpham3668]

Thanks for the education. Happy New Year 2022

[@corisantiago2627]

So if it sounds like a knocking would it be a temp acuator? Its to the right of car that i hear the sound.

[@tracytrett2392]

Extremely helpful. Thank you.

[@123456BRye]

How did you get the bolt out of the one that changes the vents beside glove box? That is my predicament at the moment.

[@jeffsmith8842]

I have the same vehicle but different control....... they are manual..... not electric...... do you change them the same way.. ?

[@gena2x_]

hey. what do i do if the rope that changes the air flow is broken. i have a 07 patriot so it looks a bit different

[@JeepLJ]

What is the one called that was under the driver’s side?

[@seancaron3323]

Blend door actuator part#604-029 The one on the center console is the mode actuator part# 604-021 and the one on the outside of the blower motor on the passenger side is the recirculate actuator #601-029

[@randy3416]

Thank you for the video 🎉

[@jacobramage]

Interesting. I have a 2012 Jeep patriot that has the intense clicking, like baseball cards on a bike wheel. Also, I've notice the air doesn't get quite as cold as it should. It's like the main front center vents are blowing cool air, but the side vents are blowing colder air. Super weird issue, i'm going to look into it though! Any tips/thoughts?

[@patrickmurphy8619]

That sounds like one of those things

[@hectorescalante7817]

Patrick your information is amazing but I have one question my heat doesn’t get to the floor so I am assuming that is the second one you displayed in your video

[@patrickmurphy8619]

I can't remember anymore you have to watch the video I must explain it in it

[@Brenda-nc7fq]

Very good video and information. Thanks

[@valytiger01]

Hello, Patrick, I have a 2011 Patriot 2.2 diesel.the water temperature rises above 90 degrees after a maximum of 30 minutes of driving. The heat also does not work. I also changed the water pump. Do you think the problem is also from the actuator? thank you in advance!

[@patrickmurphy8619]

Just grab the hoses going to the heater core. If they're both hot and your heater core is working and you should have heat

[@patrickmurphy8619]

But another thing is if you just change the water pump I'd make sure you don't have air in the system

[@brainkill7034]

Yeah definitely want to make sure you bleed the cooling system properly with the heat turned on to ensure there aren’t any air pockets.

[@stephenball369]

So what was clicking

[@louiedee279]

Now my heat not working! Had mobile mechanic change one actuator where it clicked on passenger side.

[@VictorRodriguez-cr4so]

What's the exact part called

[@alexz6807]

My light on ac knob and circulation don’t light up when depressed only the defrost light works. I saw your light working on ac knob what makes that light work? Ac not working 2010 patriot

[@patrickmurphy8619]

Most likely a problem with the ac system

[@ManJO601]

Pat I have a 2012 jeep patriot 2.4 engine All vents are working well when in use for heat. ETC. The problem I'm having is I get like a film on my windshield have to clean about every 5 days.. I did a pressure test on my system & found no leaks from heater core and back to radiator. Just need to know if you have ever run across this please??

[@patrickmurphy8619]

If it's not coolant could be AC leak

[@patrickmurphy8619]

Weird smell is usually coolant, and I've had pin hole size leaks before, might not show up on a pressure test.

[@ManJO601]

@@patrickmurphy8619 coolant leak does not smell on my windshield film when i test it ;is like a fog film and cleans up easy and have to do it every 5 days. AC is ok have checked its full if anyone can suggest idea Thankyou

[@googlegoogle-lj6fg]

Hello Patrick, I need your advice about an issue on my 2010 jeep patriot 2.0 CRD (manual) already. Sometimes there are popping (or air blast) sounds coming from behind of air blower and behind of cluster area. While the sound stopped after about two seconds, the heater isn't blowing hot air. Considering the possibility of clogging somewhere in the system, I cleaned the heater radiator with using chemical but nothing changed. I think there is some air in the system but I couldn't find the reason. What would be the reason and what part I should focus on? Thank you., Selim

[@patrickmurphy8619]

That's the actuators I speak of they pop or click when they try to turn. Watch the video if you have no heat it's because the one that goes from hot to cold isn't moving

[@seancaron3323]

Are they all the same part number?

[@patrickmurphy8619]

I believe so it's been awhile though

[@seancaron3323]

@@patrickmurphy8619 thanks dude 👍🏼 only place on the internet that I’ve found this information in once place

[@GuillermoGarcia-zw2xp]

same!!!@@seancaron3323

[@advillobotomite1196]

Very very useful video. Thank you.

[@maninthemiddle55]

Nice video. What's the correct name of the actuator to the right of the glove box, the one that controls the air flow? I'm not sure I'm finding the correct part when I search using "air flow actuator".

[@patrickmurphy8619]

I want to say some of them are the same. I can't remember anymore. You'd have to do the research. I don't know what you have for parts stores but NAPA and the Northeast is really good about finding the right part.

[@maninthemiddle55]

@@patrickmurphy8619 Thanks for the quick reply. I think I found the correct part on Amazon under "HVAC Air Door Actuator". Of course I won't know if that's actually the correct part until I install and test it.

[@julianmassey2062]

I have a 2010 and it doesnt blow out at all but makes the clicking noise though it was blower motor but imma give this a try

[@John-oe6pp]

Does anyone have a part # ?

[@louiedee279]

Chrysler dealer jeep said actuator can't replace they do housing for $470 ridiculous!

[@patrickmurphy8619]

Small 1/4 inch socket wrench

[@colinfromfreddybeach4652]

Finally!

[@goku123razor4]

Thank you

[@louiedee279]

I purchased the actuator and I will try to replace myself . Click on passenger side.

[@louiedee279]

Just want to stop the click. I hope its the one. Easy to remove.

[@louiedee279]

Mines clicks and then after 1 minute it goes off

[@austinseigel8270]

Does urs do it anytime u turn the ignition on?

[@louiedee279]

@@austinseigel8270 yes I just had it fixed with mobile mechanic

[@shaunpfund3370]

Of course now a year later the HVAC needs replacement, tight spaces and limited ability to see are the obstacles here....

[@louiedee279]

My heater is good