बाइक के इंजन में ओवरहीटिंग क्यों होता हैं? | Engine Overheating - Causes and Ways to Prevent it

To prevent a motorcycle engine from overheating, you will need to keep up with basic maintenance of the motorcycle such as regular oil changes and having proper coolant levels (for water cooled motorcycles). Make sure the idle screw on the carburetor is at a decent spot so the motorcycle does not maintain a high idle.
Air cooled vs Oil cooled vs Liquid cooled - Which engine is the best? : • Air cooled vs Oil cool...
How many km should a motorcycle run continuously? : • मोटरसाइकिल को लगातार क...
What are Engine Oil Grades : • What are Engine Oil Gr...
How often to change Engine Oil in Motorcycle? : • How often to change En...
CAUSES AND WAYS TO PREVENT IT
Initial start: When you crank up your motorcycle to leave for work everyday, please do not over rev the motorcycle as soon as you start it. Keep the engine at idle for a few minutes and let the engine oil do its job. This process is called engine warm up and doing this will keep your motorcycle’s engine healthy.
Carburetor setting: The mixture of air and fuel entering the engine cylinder must be correct in order to overcome overheating of the motorcycle. If air/fuel mixture entering the engine is lean then there are chances of your engine overheating. So setting the carb to give a perfect mixture is really important.
Engine oil check: Always keep your engine oil at check to overcome engine overheating. Low engine oil will lead to inadequate cooling of the engine. Engine oil must be changed at correct intervals for a healthy engine life.
Coolant check: Liquid cooled motorcycles come with a radiator setup which circulates the coolant inside the engine to cool the engine effectively. Proper coolant capacity and a perfect mix of the coolant with distilled water makes way for efficient cooling.
Faulty radiators and radiator fan: Radiator is a part which circulates coolant into the engine. The coolant when circulated, carries all the heat. If the radiator is covered with dust and waste particles, the heat dissipation will not be complete and the coolant will not cool enough to enter the engine again. Keeping the fins of the radiator clean is a very important part to aid for better cooling.
Radiator fans are used to cool down the coolant in the radiator when the motorcycle is stand still and the coolant temperature exceeds. Improper functioning of the fan leads to consequences.
Coolant leak: Make sure the coolant level is correct at all times. If the level of coolant is below the recommended level, immediately top it up by adding distilled water to avoid heating problems. Fix the leak, if any and continue riding.
Riding at high speeds for a long time: Riding at high speeds for a long time means keeping the engine revving high. Revving the engine high for a long time will keep the pistons moving and the combustion of fuel takes place without a break. Its best to stop the engine and let it cool for about 10-15 minutes and carry on while taking break intervals thereafter.
#EngineOverheating #Motorcycle #Safety
Join my channel and become a member : / @mechanicaltechhindi
The wait is finally over. I am here with KZbin's very first Automobile & Mechanical Engineering Channel in HINDI.
In this channel i will upload videos related to automobile and mechanical engineering topics such as engine, I C engine, Cars, Motorcycles, Production, HMT, Thermodynamics, FM, CAD/CAM etc.
So subscribe my channel and learn everyday
Follow me on twitter: ⤵
/ dashingdanish11
Add me on Facebook: ⤵
/ danish.ali.754
Follow channel on Instagram: ⤵ / mechanicaltechhindi
Contact me: ⤵
[e-mail]

[@Rajatkumar-tp3rg]

Is tarah ka video plz banate rahe sir... vehicle problems and their solutions...plz sir...isse naye students ko bohot help milegi

[@MECHANICALTECHHINDI]

😊👍👍

[@arizakram6517]

i feel another possible reason behind engine being over-heated is riding your bike roughly in a careless manner with the frequent variation in speed and acceleration.

[@zuber_rao]

100%agree😅😅

[@gyanprakashgoutamknowladeg5831]

😊

[@Carguyhere17]

Nop. Only when you redline for an hour.

[@ayushkumarsingh6213]

Your videos are very helpful for mechanical students.I have learnt a lot from you which I have not learn from my college also. you are doing a tremendous job for us who belong to a very poor class family. Thanks a lot Sir . god bless you always🙏🙏🙏

[@dayanandprabhu7153]

बहुत ही बडीया इन्फॉर्मेशन दि धन्यवाद मेरे दोस्त

[@MECHANICALTECHHINDI]

😊👍👍👍

[@raazivkr3086]

First time I searched.. I m facing nd finally I got right answer by A Right PersoN 🙏Thank you Sr..😊

[@secure1237]

You're a gift to everyone you meet. Motivated and hardworking.

[@MECHANICALTECHHINDI]

😊👍

[@eunlawon5290]

Ek no. Information diya , bhai Saab. Bhot bhot dhanyawaad🙏 thank you very much. Aise hi Vidya badatein chale. 1 million subscribers aapke channel Ko.

[@MECHANICALTECHHINDI]

😊👍👍👍

[@vinodbhatt5572]

Sir you are right, but as per my knowledge oil need to be completely changed, after some km riding of the byke, oil looses its ability to absorb heat from the engine and reject to the atmosphere so oil needs to be completely changed.

[@nirajraj2273]

Bahut hi achchha laga video sir ji bus aesa hi video banate rhe

[@MECHANICALTECHHINDI]

👍👍👍

[@PawanKumar-im1ru]

Thank you sir... it's very helpful information.. it's because of your guidance and instructions I have driven my Activa 5g from Delhi to GORAKHPUR...approx 953km and my scooty is in good condition.. again.. Thank you so much :)

[@MECHANICALTECHHINDI]

U r most welcome 😊👍

[@ganeshbharadwajshooter1913]

How many days u took? Fantastic job

[@PawanKumar-im1ru]

@@ganeshbharadwajshooter1913 bro..it took 28hrs... since it was new scooty..so I have to take breaks after 70-80km and the long halt was at Lucknow for 4hrs

[@biswajeetchoudhury191]

Bahut shandaar tarike se aap humko samjhadiye Thank you Sir

[@dipakpancardexpert]

kaun kaun 2024-25 me yeh video dekh raha hai ?

[@subashchhetri2529]

Carburetor setting vid pls😁

[@MECHANICALTECHHINDI]

Okay

[@SinghVlogs1]

@@MECHANICALTECHHINDI bro car ke coolent me paani mix karna hai?

[@mhatretech3536]

Another reason for the engine to overheat is that if you set the taapet clearance setting properly, the engine will run very smoothly.

[@indranilsarkar6834]

Sir your manner and technique of explanation shows your love for the subject and in depth knowledge. If I had got a teacher like you who calmly and patiently explained everything in a very simple manner I would have been a different person altogether and would have achieved great success in my life. Anyways lots of love to you 💖🙏🙏

[@MECHANICALTECHHINDI]

Thanks 😊👍

[@shakiransarishakiransari3263]

बाइक के रेगुलर कितने किलोमीटर

[@NareshPatnaik369]

Omg sir very nice knowlage thanks very helpful ❤️💕❤️💓💕

[@techajeetofficial]

Really apki video kafi useful hoti h

[@MECHANICALTECHHINDI]

👍👍👍

[@techajeetofficial]

Half engine bana ho agar wo overheating ho rha h to kya problem ho skti h bro

[@tkpcreation1318]

Maine jaisa socha tha jesa apply bhi karta hu bilkul sahi bataya appne Tysm

[@akhilesh.ad1399]

10000%%%% CORRECT V YSEFULL POINTS YOU COVERD

[@amitaman108]

Your video and it's content is far better than thumbnail

[@ashutiwari940]

Nice knowledge diliverd by u danish Bhai😊😊😊🙃🙃🙃🙃

[@MECHANICALTECHHINDI]

😊👍👍

[@middyaentertainment5766]

Thanks DaDa Very Useful Video

[@MECHANICALTECHHINDI]

👍👍👍

[@randomeditz2484]

So much knowledge butt still people think mechanical engineering is not good

[@niteshkumar2116]

Thanku sir for your information 🙂👍

[@prashantchitre9355]

सर उत्तम जानकारी 🙏🏻 १ ख़राब पेट्रोल २ टायर प्रेशर कम होना ३ ब्रेक फ़्री प्ले कम होना भी इंजन ओवरहीटिंग कारण हो सकता है

[@sanjaychakrawarti73]

गुरुदेव आपके द्वारा जो जानकारी दी गई है कि वह आउटपुट प्रोब्लम है और महोदय जी के द्वारा बताई गई जानकारी इंटरनल प्रोब्लम है। आप दोनों के द्वारा बताई गई जानकारी बहुत ही अच्छी है और उससे ज्यादा यह दोनों समस्या मकैनिक पर निर्भर करता है। धन्यवाद!

[@kisandeykisandey7274]

Koie mat kored na Honda chor company ha enjen over hitng proplm kobe thik nihe hoga

[@thememes8223]

Very good information bro 👍🏽🤟

[@MECHANICALTECHHINDI]

👍👍👍

[@RahulSingh-su4sc]

Well explained ❤

[@garrysingh5337]

bhut hi acha video hai sir..

[@madhusudansharma7368]

Jabardast vedio suggest best engine oil for Passion pro

[@suneelmaurya3119]

Most important your information I like it

[@vishalmanohare6966]

Bahut achi jaankari

[@shameemfathima6735]

Very useful information Thank you Sir

[@thegame3265]

Nice information..., dear have u any Yamaha rx 100...old one..

[@vijaybhatt9638]

Jabardast information about engine heating 👌👌👌

[@bhargavbhat9380]

sir kya car ka coolnet per also distilled water use karna chahiye?

[@ZakirHussain-tk8jy]

Sir bahut achi jankari hai apki

[@bijendaryadavmp9739]

You are right... Awesome ji

[@MECHANICALTECHHINDI]

😊👍👍

[@nirabhmani9523]

Can you please suggest possible reasons?

[@VishwajiTVermA-yo6ip]

Nice video sir mere costume ka ye problem that

[@MECHANICALTECHHINDI]

Achcha

[@VishwajiTVermA-yo6ip]

Ha sir mera whatsepp PR SMS kre 7492050151

[@inspireandwealth.2870]

Hi sir Xtrem 160R ka engine long ride ke liye thik hai kya 163cc aur air cooling engine hai

[@pyradogaming9404]

Nhi

[@shivanshuprajapati5864]

नमस्ते गुरुदेव गुरुदेव आप तो पूरे यूट्यूब पर छा गए हैं l अब तो यूट्यूब पर आपके विडियो के सिवा कोई वीडियो देखने का इच्छा नहीं होती है l love you my dear sir गुरुदेव बहुत ही शानदार आपका चैनल है गुरुदेव आपकी मुस्कान बहुत प्यारी है और आपके वीडियो के बारे में क्या कहे गुरु देव आपका विडियो तो you tube top thanks Gurudev ji

[@MECHANICALTECHHINDI]

Bahut bahut shukriya 😊👍

[@amitkumar-ue4bl]

Plz share CC wise riding schedule

[@jamesdebbarma3036]

thankou for information sir

[@MECHANICALTECHHINDI]

Welcome

[@KiranPatel-ef3gh]

Wow superb information thank you Sir...

[@Jitendrajksaini8190]

Awesome 👍 sandaar 👌

[@SinghVlogs1]

Car ke coolent me paani add karna hai?

[@anilprasad517]

Thanks for the information

[@anilkumar.r.toravi7830]

Whether engine overheatng could be caused by thinning of oil density also?

[@jyotiprakashsingh9222]

Very nice knowledge

[@MECHANICALTECHHINDI]

👍👍👍

[@jor_dj3522]

With so many risk its best to use public transport🤣 Less pollution#less risk🥳👍

[@speedawayyspeed9736]

Public transport is very boring and don't understand how ppl use it I feel very boring by going that city bus which is filled with crowds. car and bike best

[@satishvasane6812]

बहुत अच्छा भाईसाहब धन्यवाद

[@MECHANICALTECHHINDI]

👍👍👍

[@RaviRavi-gm7mi]

Give tips for change Tyre. how many km Tyre change?

[@sanidash6302]

Air fuels mixer tight karne se v engine heat hoti hai isliye tight na kare or timely oil change kare.

[@Girja_Shankar]

Missing problem bhi ho rha h sayd essi ke chakker me

[@vickee86]

Good

[@ShubhamSharma-cn6db]

Thank you sir very informative video Kya aapki bhi workshop h

[@anjanisharma3964]

Nice explation ❤️❤️❤️❤️❤️❤️

[@MECHANICALTECHHINDI]

👍

[@jagdishparmar7447]

Sir plz help mere pass krizma r modal hai shubah shubah stat problem hoti kya katu

[@ranjeetchoudhary7298]

Sir wheel bearing free na hone pe ya break pad drum se ragad k chalne se bhi engine heat hotabh kya??

[@kaleyvai3529]

yes

[@ManishKumar-yp9dk]

yes engine pe traction load badh Jata hai or jyada heat hone lagta hai

[@Ashish98357428]

Bahot jyada clutch lekrrr drive krna.Kya isse v engine prrr bad effect pdta hai.aur heating issue aata hai kya

[@ruatahanghal5121]

Very informative👍👍🤶

[@engineerirfan]

AWESOME VIDEO SIR 💜

[@kundanmalavkar7486]

Sir honda unicorn k liye best ingine oil konsa hai..aur kitne km main change karna chahiye

[@msi9209]

Shell semi synthetic aur 2000 ya 2500 km k baad change kre

[@radhaballabhsaha3391]

BOHUT HI boriya tips Diya hai AAP. Special Thanks AAP ko.

[@MECHANICALTECHHINDI]

👍👍

[@srk3659]

Sir bike wash karne ke bbd new jaisi bike lagti hai pr bike ki engine thori purani lagti hai koi solution ho to bata Dijye sir ..? Please 😊

[@sharma_80766]

I have a splendor+ bike , which has covered nearly 87000 KM and have show room look , I follow all those rules which u discuss , thanks for giving these tips .

[@sandeepkale6584]

Honda shine bike ka carburettor setting kaise karaneka video banao pls🙏

[@goodboy882]

Sir ek question hei Ower heating me engine ka tamp kitna hota hai 😊

[@tabishkondwilkar5791]

sir mere pass fzs v3 2020 model he . sir mai mere bike me chain kit bada laga sakte he ya nahi

[@durgeshthakre7993]

Very nice video sir

[@MECHANICALTECHHINDI]

👍👍👍

[@satyajitrout8616]

Hello Brother. Good evening. Mujhe ye Janna hai Ki pulsar 150, pulsar 220 f buy karna Achha rahega Ki nahin. Because some people says that pulsar bikes are not good. I have no idea about bike. Please help me with honest suggestions.

[@biswajit1193]

Tvs raider la lo bhi sasta ho aur acha bhi ha

[@rajeshvispute1884]

Great information sir, thanks 🙏🙏

[@gauravverma8150]

Sir maine new hf delux bs6 li hai 1 mahina hi hua hai par overheat ho rhi hai or smell bhi aati jai rubber jalne ki kya dikkat ho sakti hai pls reply kare mujhe tension ho rhi hai kahi engine mein problem to nhi ya new bike overheat karti hai starting mein

[@amartayade2525]

Very good & useful information.

[@MECHANICALTECHHINDI]

👍👍👍

[@sumitverma154]

Best engine oil kon sa hai .

[@subhankarbera6750]

Sir Mara pas honda xblade hai Kon Sa engine oil dala please bataiye

[@hbhatana3227]

Mere pas cd deluxe h kya me hf deluxe ki timing chain istemal kar sakta hu

[@sunildon6981]

You are bike guru keep it up

[@MECHANICALTECHHINDI]

👍👍

[@amitaman108]

Most of the time I miss your video because of thumbnail But I see by searching your channel

[@MECHANICALTECHHINDI]

Okay

[@surajfreedish9777]

Nice information सर thanks

[@rajdidwania6568]

Sir itna knowledge kahanse aya sir aapko thankuu

[@rajdidwania6568]

❤

[@ajayuadhyay2595]

Very nice sir

[@MECHANICALTECHHINDI]

👍👍

[@mohammadmohsinhanafirazvi]

Kya Hamein Honda Shine BS6 5 Gear Me Engine Guard Lagana Sahi Hai

[@mdnoushadansari7240]

Apache k liye koun sa best engine oil hoga plz help me

[@Rider2769]

bhai honda xblade160 ko 1 bar me kitana k.m calana chaiye konsa injan oil dalna chaiye samisintatik ya sintatik ya mineral

[@MECHANICALTECHHINDI]

Semi synthetic behtar hai 70-80 km

[@mufaddalmerchant8868]

Give tips of Activa maintenance.

[@dukdahal]

thanks a lot for information

[@parulchaivala5638]

Sir xpro hit ho rha kya cluch plate ki jali me koi problem ho sakta hai

[@mdsaidurrahmankhan6312]

Good explain

[@balsonnaoshekpam6240]

Thanks for the Video

[@pankajsculptor]

Sir xpulse 4v bs6 yesterday mene buy ki oush ka engion bohat heat ho raha hai Showroom Wale keh rehe hai new hai is liye ho raha hai 😢 first service ke wad theek ho jayegi chal kar

[@RizwanKhan-wf5oy]

Thanks ❤❤❤

[@BARDACHYT1297]

Bhai me Meri splendor bahut jor se aur vibret karake calata hu Kya hoga please reply ❤

[@rohitkaushik3415]

Sir mere pass hayate ep hai aur mujhe 160 km jaana hai subah me exam dene continues 160 km chalane me koi dikkat nahi n aayega.... please bataiye

[@balsonnaoshekpam5680]

Nice explanation Sir 👍 Plz tell us for car also

[@waheedalikhan7606]

How many k m journey continue bike 100cc plz tell me.long journey

[@kundanjasud7700]

Pichle tairko disk breg nahi hai kya usko disk breg laga skte hai ,,

[@dayalankp9442]

sr very useful vedio thanks

[@nadimsindhi997]

Best information

[@MECHANICALTECHHINDI]

👍👍👍

[@rahulsah4646]

125 CC say hilly areas may 1300 km 2-3 din may travel kar sakty hy kya

[@YatendraAdhanaVlog303]

Aap ke shop kha h ji

[@MECHANICALTECHHINDI]

Koi shop nahi hai I am mechanical engineer

[@YatendraAdhanaVlog303]

@@MECHANICALTECHHINDI मैंने अपनी बाइक को मिस्त्री को भी दिखा लिया है पर फिर भी मैं यह महसूस कर रहा हूं कि बाइक का इंजन हिट हो रहा है कल में 4 किलोमीटर चला और बाइक का इंजन ऐसे गर्म हो गया जैसे 15 20 किलोमीटर चला हूं अगर आप कुछ बता सकते हैं तो मुझे बता दीजिए मेरे पास सीबी शाइन बाइक है

[@pravinrasamwar6008]

My bike recommendation 10w30, but itll cause many problems. So i top up 20w40. Then getting smooth riding. Will it ok?