Car Turbo Maintenance - Turbo கார்களில் இதை மட்டும் செய்யக்கூடாது | Turbo cost | Birlas Parvai

[@Sobin16]

Turbo is a bliss compared to naturally aspirated configuration. I am not sidelining NA engines but turbo is the soul of every enthusiast car. A turbo in car is the same as an aircraft engine only smaller in size. As aircrafts need to take off on short runways, they need instant boost of power and it's not very different in the case of cars and trucks. Just different fuels and different RPMs. Turbos force-induce air into the combustion chamber to create oxygen-rich environment. More oxygen results in bigger explosion/combustion. This is how turbo boosts power so cars are quicker off the starting line. But then all turbos are not the same and the performance varies between car makes. Garett is one of my personal favorites and it comes factory installed in ford cars. They are well made and last a long time if pampered well. Love the sweet whistle and addictive torque spread across the rev range. But most folks have poor knowledge of how turbos work and how to maintain them. All they know is turbo= power, which is not wrong but there is more to that. This is why buying used diesel cars are tricky. Unless you know how the car was used and its maintenance history, it's difficult to tell if turbos are worn or near end of life. With a machinery operating at tolerances and often at unimaginable RPM (around 15000~30000), there is a specific way in which a turbo should be maintained. First is regular oil change and second is usage habits like idling 40 seconds after a cold start and then repeating it after after a long drive. As turbo RPMs are high, even a brief moment of dry running will accelerate wear in the spindle and bearings. This is how play develops until catastrophic failure occurs.

[@sermanathan.b6931]

டர்போ பற்றிய விவரங்கள் இருவரும் நன்றாக விளக்கினீர்கள் மிகவும் நன்றி

[@rajaramanrameshkumar]

Just to clarify one point here. When you were referring to exhaust its actually meant air intake. In simple layman terms turbo makes it possible to boost the air intake by way of a compressor pump. In Naturally aspirated engine the air intake is happening because of the suction created by the engine itself and there is no external push of air. Since there is one more additional moving part that too rotating at a very high speed to create required air pressure, it needs adequate oil supply and a clog-free air supply. That is what our Balaji Bro is insisting that we should replace the oil at regular intervals along with oil filter replacement and also replace the air filter periodically so that the turbo gets a clean oil and adequate air which will increase the life of the turbo charger. Awesome explanation and now we do understand the importance of maintaining the turbo and we can bust the myth that turbo causes problems.

[@fullforcearun]

Your explanation is worth it

[@kumaresan.4302]

Today only I got clearance about turbo.. very super explained.. I don't have own car. But I known well driving last 16 years..

[@kappalottumtamilan598]

Mr.Birla I think in the middle of the video u explained better than that guy... He doesn't know even the parts name of the turbocharger... He can't explain how power will get increased when compared with naturally asperated engine... He might be a good mechanic who can repair the parts but he doesn't know completely about the topic... 1. Mostly turbo fails due to improper lubrication of the bearings which will be inside the turbo housing. 2. In a non turbo engine we can increase the amount of fuel injected into the engine by varying the size of the fuel pump but we cannot increase the amount of air intake to engine since its almost fixed. So they introduced turbo so that without increasing the size of the engine more amount of fuel and also air can be forcefully admitted into the engine by turbocharger and hence we get more power. 3. Size of the turbo depends on the no of cylinder, it's bore and it's stroke length so we shouldn't change the makers turbo which will lead to turbo failure or sometimes engine failure also... 3. He mentioned that turbo rpm is 6000... Actually when the engine is in idle condition, the turbo rpm will be more than 10000 and when engine rpm increases then turbo rpm will be as high as more than 1 lakh....

[@xb-2097]

This is really nice explanation broo

[@vssunilkumar]

Well explained 👏

[@srinitheultimate]

It may go up to 1.5 lac rpm

[@karthikcb350]

That is the difference…normal mechanics will know what is needed to make it work but will not be able to explain why or the reason behind because of the lack of the proper technical training. They work by experience from their previous senior mechanics.

[@Kevinpietersen24]

Cool bro !

[@anniyaninternational]

4:48, bro not for same fuel........... with more air, ecu compensates it by putting more fuel as well........... more air + more fuel = more power................ thats why if turbo petrol revved hard, gives very less mileage

[@vijayendranvijay4538]

After a long drive in highways, its always advisable to cool off the turbo engine atleast for 1.5-2 mins.. Do not switch off the engine immediately..City drive mostly it's not required as we have frequent stops and drive only in lesser rpm's but its always better to wait for few secs before turning off the engine...

[@shivakumarkumaravelu876]

Sir in ciaz they have smart hybrid they switch off the engine any difference are there if we switch off on the highway ride

[@senthilurs]

@@shivakumarkumaravelu876 ciaz doesn't have turbo so no worries

[@mkarthi1992]

You are correct, turbo charged engines shudnt be stopped abruptly after a high rpm drive. The reason is, the very hot turbos are being cooled by circulating engine oil, if the engine is turned off abruptly, the oil near the turbo might stop circulating and remain exposed to high temp. Of turbo compared to the oil in d rest of the loop. So kindly after comming to a stop let the engine run for few minutes at idle so that the oil has enough time to cool down the turbo.

[@vijayendranvijay4538]

@@shivakumarkumaravelu876 ciaz doesn't have diesel model and any turbo petrol engines... So not to worry...

[@vijayendranvijay4538]

@@mkarthi1992 well explained bro👍👍

[@chandank9285]

Yenoda car vandu TATA INDICA DIESEL (TURBO) 2006 model..... Tq.... Maintenance pathi video potridrikke... Super anna.... 🍺🍺🍺🍺

[@Yamahaempire]

Bro avara vida neengale super ah explain pandringa🤟🏻ungaloda videos mulama na automobile paththi neraya therinchukitta romba tqs bro 😊🤙🏻

[@Badboy-RX8]

Bro ஒரு video போடுங்க how to install turbo

[@sabarisarasharan]

Super 👌👌👌 Master. Usually Turbo Engine Cars are Comes with High Acceleration Idle So Initially No need to Raise the Accelerate Pedal. In My Scorpio(4 Cylinder Turbo Engine) Upto 3rd Gear No need to Accelerate, Because Defaultly the initial Idle speed upto 40kms @ 800 Rpm. IN my car after Switch on the AC No changes in rpm it's remain the same 800Rpm. Thank you 🙏🙏🙏 Master 🤓🤓🤓.

[@karthiktamilselvam4925]

Surely I will gave 5 star rating for his effort. Actually I have an 13 years old Ford fiesta car. I purchased this one last year. I noticed the black smoke in recent days. Local mechanics are not suggesting for the turbo, injector and fuel pump service. Recently a mild leakage identified in turbo joints. Ford service center has given only to change the entire turbo. So I contacted Venkateshwara fuel pump service owner in last week. I explained the problem cause and send the picture in WhatsApp. He assured that issue will be sorted with service or one part change in turbo. He had a skilled team on the service and he suggested the mechanics for parts disassembly and assembly purpose. Those people's also a fine tuned team, dedicatedly taking care of the process. Since I came from my native and next day I have other priorities I need to complete the service in one day. I told to service the turbo, injectors, fuel pump and cleaning the egr valve. They prioritized to me for the service and gave the spares by on time they mentioned. They started to assemble the parts at 4PM and spend up to 11:30 PM and do their work without any objection. whole day I saw their effort and challenges on this work. I am very much thankful to the team. I am very much satisfied with their work.

[@vighneshninja]

What was the quote given by ford and how much he charged to service it bro?

[@tamil9394]

That workshops details?

[@pandurajur9522]

Recently done my Swift Dezire car turbo and egr service ,less noice and more picup am very happy now , Thanks for service

[@premgopal6101]

can turbos fit on tata tiago ? We can fit separately like that ahh ??

[@tsptexx4533]

பல கோடி நன்றிகள்..

[@shanks144]

In many cars the ECU will auto check for error codes and activate limp mode to avoid further damage

[@sarathkumar-sh2ei]

Hi sir u explained very well I visited the shop and serviced my Fiat punto turbo but they cost me too much service also not good after service with dem only I got oil leakage problem low pick up better avoid going to this shop after servicing also I visited 4to5 times but problem not solved very disappointing 😔

[@natt1948]

The Techinician, explained in a very simple & interesting manner. Thank you for this video.

[@SasiKumar-kh8wk]

Thanks. Very Usefulinfo. Now I know how to take care of the turbo. Currently I am having turbo issue on my S60, T4, 2012..

[@ManiKandan-rt1ke]

Bro xylo oil கொராயது என்ன காரணம் யாராவது சொல்லுங்க பிளீஸ்

[@rajeshnvp4725]

Semma bro vera level explain super content... 🥰👌🏻👌🏻👌🏻

[@prabhakars5926]

Very detailed information. Thanks a lot 🙏🙏🙏

[@saravananjguru361]

Very useful and clear information. Thank a lot.

[@Verifiedbuyer]

Same amount fuel and excess air kudutha power kami aairum man. Both Fuel and air intake adigam aagum

[@srinaths4374]

Explanation of the technical details was so easy even a layman can understand. Thank you

[@appukannu97]

நல்ல பயனுள்ள தகவல் நன்றி

[@cruise_control]

Also I saw somewhere that you must run the engine at lower rpm for 1 or 2 minutes before switching off. This will remove the hot air inside engine preventing engine damage.

[@nmahadevan3441]

கார் இஞ்சின் தீ பிடிப்பது எதனால் ஏற்படுகிறது விவரம் ஒரு வீடியோ போடுங்கள் சார்

[@drdineshbhms]

Can you pls make a detailed analysis regarding the pros and cons of modifications or alterations that are made in a brand new car. What accessories should not be added to a brand new car. It will be very helpful for many new car buyers.

[@rockhs18]

POow

[@anbazhaganeb2227]

அருமையான பதிவு மகிழ்ச்சி

[@madeinhome4529]

Your videos are so much helpful Which Budget friendly car pls tell sir .

[@Kevinpietersen24]

Thank u so much.!:).. U own a huge part in me educated.! Now I prefer 1.5 NA engine than 1lt TSI or turbo..

[@jack59055]

@partha sarathy bro I own a 1.5L Nissan Kicks NA sometimes what I Feel is the car is under powered at lower rpm's hence at that times I feel that I could have bought an turbo variant in it as it has instant pickup due to higher torque in itbut the engine refinement and 4 cylinder at 1.5L is best. This is completely my idea correct me if I am wrong

[@Kevinpietersen24]

@@jack59055 Wow..! Thank you so much for you're volunteering suggestion or you're experience.! I'll definitely think again in the terms you have mentioned..! You're so kind brother...! Thanks again.! :)..

[@mohamedsala6740]

Hi, good explanation, calmness in explanation, keep it up sir, good for your future business relationship.

[@murali6188]

Thanks Bro. This knowledge is a must. Looking for more videos on Technical specs. 🙏

[@arulraj8211]

Egr cooler பற்றி விளக்கம் சொல்லுங்கள்

[@mohamdgani4445]

Please suggest how eco mode works on 6 cylinder engines.. if there is any video already, will be helpful

[@antoprince7070]

Thanks for the information brother .,. However trubo core itself costly merely 5000 ( for ford fiesta) but servicing cost 4000! Which is too bad of a ethics brother!

[@logeshkumarankarthikeyan6770]

Skoda rapid after off engine some sound வருது... Why

[@ashoksan14]

Good 👍, put some video like ceramic painting for cars. Why need to go and what benefits or disadvantages on that.

[@ganga12345123]

Long time doubt cleared sir thank you very much

[@pongalurvadivel15]

பயனுள்ள தகவல் 👌

[@dcbcministriespuzhal4632]

Good debate...Superb Sir..

[@pilliyarvenkatesan3372]

Hi ! I am mech engineer...how turbo gives power? -answer- when we say 1000cc (1 litre):engine or 1300cc (1.3 litre) engine - it means engine can suck so much air ( 1litre or 1.3 litre) . We can burn only so much fuel as much air is inside the engine at every stroke. Turbo helps these engines suck more air than its capacity by compressing air...so now they can burn more air and so more fuel and so more power...hope it's clear

[@pilliyarvenkatesan3372]

So now 1 litre engine with turbo can suck 1.3 litre air with help of turbo and so we get 1.3 litre engine power from 1 litre engine using turbo ..

[@dhineshm6403]

Continue like this video 👍

[@josephd.r3581]

Extremely high speed shaft..needs lubrication of bushes..

[@easwarv2308]

Thanks for the video on topic which is in trend now.. 👍

[@sureshkumarksr1949]

2007 model scorpio voda turbo core change panna illa service panna evlo charges agum.

[@dineshspd8072]

மஹிந்திரா 595 டிராக்டர் கம்லைண்ட் ஆயிடுச்சு எப்படி சரி செய்வது

[@OL8able]

Intha video va paatha turbo vandi eduka vendam nu thaan thonuthu 😢

[@gurudharmalingam9153]

காலைல மட்டுமில்லை.ஐடியலில் ஆக்ஸிலரேட்டரை மிதிக்கவே கூடாது

[@marsmerchh]

Good video !! Helpful and useful

[@vino5580]

Thanks to maruti suzuki for brezza with NA 4cylinder non turbo engine block...

[@suryakala7596]

Mr, Birla I want a Turbo charger for Fortuner TYPE 1 & Model 2009

[@vadivelu3269]

Secondary டர்போ கூலியில் ஆயில் படிகிறது காரணமாக இருக்கலாம் விளக்கவும் சார்

[@munusamisreenivasan4696]

Very useful explanation.thank you thank u thank u

[@kannanmatrimony9337]

Stability control working video PODUNGA sir please

[@rameshram1628]

வாழ்த்துக்கள் வாழ்க வளமுடன்

[@saranmatic2347]

Please make an video on imt transmission......

[@akhilsteephen4696]

I do have a fiat linea mjd .there was black smoke ,egr cleaned and now turbo starts spinning only above 2k rpm ..no check lights ..what may be the reason

[@samdaya8152]

Turbo charger for Mahindra bolero Bs 3 and bs4 are same?

[@syedashrafali9058]

sir I have mahindra tuv 300 sometime when I trying to start car engine noise increase and highly vibration coming

[@elumalaivenkaiah6818]

Sir, is the grand i10 petrol have turbo engine ? If yes , where is the turbo in grand i10 ?

[@ilangovanthirumalaisamy7317]

Good explanation. My suggestion why not you contact Mr. Jyavel, Skilled mechanic tamil at Thirumullaivail, Chennai

[@birlasparvai]

If possible share his contact details to [e-mail]

[@sasisabhari5471]

Hi Sir, Can u pls review or make a video about 2022 Mahindra Scorpio (Launch date and new features and price)

[@PrathapRaja-v9y]

How much does it cost for servicing my turbo... Ford Fiesta diesel

[@veeramaniv3176]

For servicing Turbo in tata zest asked 20 k while the replacement costa is 50 k is it ok to give 20 k for servicing , will there be any problem for Turbo ?

[@gowthamkanagarajan3601]

Anna intha mari maintanence vedios ah orey playlist la podunga plz 🙏so that we can watch the other vedios you made for maintanence

[@birlasparvai]

It is already in maintenance Playlist only

[@gowthamkanagarajan3601]

@@birlasparvai thank you anna

[@tamizharasan881]

Birla sir Volkswagen modified engine pathi oru video podunga please 🙏❤️

[@manis4676]

Basically nothing much to worry, almost all the diesel cars will have Turbo and few petrol cars top model will have turbo and if oil, oil filter and air filter are changed properly it will run for Lakhs of kilometers

[@dhayadivya2053]

Ford figo 2010 model How much for turbo service cost?

[@mohanraj3083]

6:45 TTF Videolea Maruti Dzire Video Neayapakam Varavanga Like Podunga 😊

[@saranki95]

Naturally aspirated engine no tension no insecurity

[@waransteelthunderbolt]

I have Hyundai fluidic Verna i had a same VGT model turbo diesel issue how should I service and replace how should I contact you

[@birlasparvai]

His contact number available in description

[@JayJay-lc6zi]

I have mahindra xylo , when I drive after 40 &50 km reached. the speed decrease automatically maybe 30-40km speed only. I give full acceleration but the speed will not increase. Anybody know about the problem.

[@preethladybird]

Vivid explanation. Thank u🙏

[@mugundhann5905]

Good information bro

[@GV_Memes]

Increase of Power is OK, is it good or bad

[@bhavani8294]

Hyundai xcent diesel turbo core how much 2016

[@arunprakash7397]

Usefull message

[@raghu2026]

Is it possible to set turbo for qualis and if so is it improves efficiency

[@tn19photographyvideography99]

Hi birla sir kindly make full video sir bcoz my vehicle Hyundai xcent full heavy black smoke issue.. service centre kuduthae sir turbo problem sonae then New turbo change panae appram smoke issue....then engine rebore work panage so enaku ithae pathi koncham full video podugae birla sir.......own vehicle only 58km driven only 2017 vehicle.... kindly reply me sir...??

[@venbas2]

Bro when Turbo gets damaged you need to clean the engine head after replacing/servicing the Turbo components. Otherwise the carbon deposit and soot will damage the engine with bore/stroke problem as the last step. Had a problem in my Ritz VDI and found out the hard way 😭. For this reason NA engine is still safer.

[@kalarajai4622]

அண்ணா என் வண்டி டாட்டா ஏசி மெகா டர்போ சர்வீஸ் பண்ணனும்னா

[@ashwathaman1819]

Can we install a turbo in a naturally aspirated engine?

[@selvakumark4715]

Engine back compressor problem irunda turbo fail aguma

[@vinothkumarkumar9981]

அண்ணா உங்க Shop, எங்கே இருக்கிறது அண்ணா

[@arunkumar-gl5xl]

Bro what if I buy 3 cylinder without turbo. I am just a normal user

[@vijayjoan4202]

Very useful info

[@Mohamedghouse9872]

Bisme total all cars sarvise and second hand parts pondy

[@subashnikesh7997]

Sir where is this service centre ??pls share location??

[@ramnadvlogger162]

Bro en ford ecosport diesel ah turbo malfunction airchu naan 2.5years ah aptiye vachi drive pantu irken ithu naala ethachu problem Varuma?

[@ShunmugaKumar]

One day engine thidirnu oil full ah leak agum, gasket pogum, coolant oil/water engine ulla pogum, thermostat pogum, micham iruku oil burn agi kosu marunthu adicha mathiri pogum engine off agidum. Additional bonus ah injector heat la athum poidum. Periya selava vaikum so konjam check pani sari panrathu better Ilana car sell panidunga

[@palaniappanmba]

இந்த மெக்கானிக் சாருக்கு டெக்னிக்கலா சுமாராதான் தெரிந்து இருக்கு. டர்போ சர்வீஸ் செய்வார் அவ்ளோதான்

[@bharathiadhiri]

How can we check the exact KMPL(milage) of our car?

[@nagabala5011]

Enathu maintaince 4000 huh middle class car vangura asai poidum polaiye 🙄

[@Siddurachu143]

Hyundai xcent 2017 model hil leakage

[@RamKumar-tk5rn]

Better to go for TURBO or NATURALLY ASPIRATED engine???

[@onepunchman6165]

Turbo

[@kumaravelsubramani8249]

கார் நிறுத்தும் போது சிறிது செகன்ட் ஐடிலிங் விட்டுதான் ஆஃப் பன்னனும்

[@ebenezer3896]

To increase volumetric efficiency

[@HasanAli-ze4bw]

post related vw vento TDI

[@dhayadivya2053]

Ford Figo turbo service cost?

[@arunprakash5629]

Anna... Mg astor manual review pannunga

[@sathiyanarayanan1850]

Innova clutch problem