Coleman BT200X Basic Maintenance - How To and What To Adjust, Replace and Service

[@Tatboy211]

So cool watching a man include his boy. We're missing this in the world. I dig your sweet up. Thanks for sharing this info.

[@FitInMy50sVlog]

Thank you Daniel

[@OH.TAY18]

“If you looking at my tender profile then im 6’1 210” i love it😂😂😂

[@danobryan9497]

That was exactly what I needed. Just got my first mini bike ,the same one only my fenders are green. Thank's and thanks for not using fow language.

[@CGGarage]

Just got this bike today bro.. I APPRECIATE YOU A LOT!! Learned a lot about this bike and its functions.

[@thomasmoje5926]

I've had one since June of 2021. Seems to be a sturdy dependable minibike..except I had to replace the recoil starter assembly it failed when I tried to start the bike this past spring. I found a direct drop in replacement from Hipa. Took me about 10 minutes to install. Final drive chain adjustment can be tricky there's a fine line between 'too loose' and 'too tight'. Better to keep it on the loose side rather than too tight. I keep the chains well oiled and put a few drops of oil on the end of the crankshaft on the outboard side of the clutch every once in a while. The owner's manual recommends checking valve clearance after 10 hours of operation but I've yet to do that it's about due for that the engine runs well and usually starts on the first pull but it has to be choked some for every start up. Regular maintenance is quite simple. Good tips in this video.

[@scubei]

Thanks so much from northern Louisiana. Exactly what I needed to see. You rock man

[@Oldbass40]

I appreciate all your tips. I just purchased my 9 year old grandchild this model and needed to know how to best take care of it.

[@Element0f_1]

Getting my 1 st bt200x on Tuesday and you're nominated as my mini bike guru !

[@LuhKB3000]

bitaminv21 there so fun to ride I got mine yesterday

[@Element0f_1]

@@LuhKB3000 totally brother! Minis are the coolest addiction 🤜🏼🤛🏼

[@seanblas]

Thanks so much for sharing your knowledge and advice. I just got the BT200x today 👍🏼. New subscriber here and look forward to future content on the mini bikes.

[@FitInMy50sVlog]

Sean Blas awesome!

[@BradAcquilin]

Just got mine today. Orange with white fenders. The dream cycle. BT200X

[@MrTestpilot7]

hi dan thanks for the video i just bought a bt200x and all the info was helpful for keeping the bike running good.

[@FitInMy50sVlog]

Awesome!

[@JewishJuice]

Excellent video! Thank you

[@matthewfaulkner1699]

Thank you for doing videos on the bt200x! I just bought one and am waiting for it to arrive at my local Walmart. I’ve been watching all your videos on the bike to familiarize myself as I am new to these mini bikes.

[@alexisquintero2782]

Hey great video I don’t have my bike yet but this was very useful

[@vincentcortes3601]

Just grabbed a 2019 Ct200U-C real tree and it’s been so fun. Looking to take it on a 20 ish minute ride and see how it does

[@ibeatoffroad]

Great video! Helped me out a lot to make sure I take care of my bike!!

[@robc8468]

Converted My Coleman BT200X to NGK BE6ES non resistor plug. I use on my Honda GCX160 lawnmower Champion 3500 watt generator and Ariens 208cc snow blower. This makes these engines start on 1 pull unless sitting for 6 months then two pulls max. I also use B&S 5W-30 Synthetic on all these engines. Coupled with recreation grade non-ethanol blend gas with seafoam and these engines all run better than new.

[@ryan93civic1]

Is that ngk a direct replacement?

[@Truerican213]

Love all of ur videos!!! Legit the best ones. U are so informative and easy to follow and understanding and how you break it all down is so cool. God bless 🙌🏻👏🏻

[@FitInMy50sVlog]

Thank you very much

[@lorenzolopez7207]

Hit him up on tinder 😆

[@Truerican213]

@@lorenzolopez7207 that’s for ur mom to do she sucks and swallows everything for money

[@Redneckrino]

Absolutely great video man thanks 👍🏼🇺🇸

[@teshuvahemmet3036]

Thanks for the info

[@brianajenkins4595]

GREAT VIDEO

[@FitInMy50sVlog]

Thank you

[@juicy5836]

We just got our bike ...it's eXcellent

[@FitInMy50sVlog]

Yayy!!

[@blink182-m5z]

Watching this before i buy mine

[@djmatthewsol]

Nice work Dan! Thanks for putting that video out!

[@FitInMy50sVlog]

Thank you!

[@ADHDBROTHERZ]

great video

[@blacksmithrick]

Purchased a Coleman BT200X to use as a tote-goat for following streams up the mountains. Put a gold pan in the backpack, strap on the .357 mag, and go explore. My interest is how far and long will a tank of gas take bike. Rick in WA state.

[@FitInMy50sVlog]

Depending on how you use the throttle almost all darn day!

[@markcollins5026]

Man, that's what I want to get one for exploring, and with my .357 mag. !

[@Amunrad]

Good basic maintenance video. Noticed your plug was indicating your running a little rich.

[@RussellFougere]

Great video!

[@Roughneck-mm2df]

Good vid

[@daniellaswell1247]

Awesome video

[@FitInMy50sVlog]

Glad you enjoyed it

[@keithsada1380]

Mini bikes. Not changed much since the 60s. Ride them for an hour and then work on them for 3 hours.

[@FitInMy50sVlog]

And require a lower back massage as well 🤣

[@riffafrank]

Thanks very much

[@Efntodd]

That was fun thanks. Looking to get my kiddos into bikes and seriously considering getting one of these for myself to ride with them. Big dirt bikes would potentially just leave them in the dust. Plus minis are fun 🤙

[@johnhotine4196]

My son's on a fifty and I trail him around on one of these to coach him!

[@victorreyes1010]

Hey Dan when are you going to post more of the mini bikes? I like them and I want to watch more!!

[@imfatkid420]

Dude put a time stamp of the different areas cause I was just looking to do the oil on my coleman bt200x that I just bough off of facebook market place used but it works awesome but I'm changing everything I just got a new spark plug I have the oil and got better oil cause the governor is gone so every one says to use 10w-40 instead of the normal 10w-30 I dunno but I'm about to put it in I looked all over and that's the basic consensus of it

[@projectgarage4239]

Great how to video!

[@FitInMy50sVlog]

Thank you Tony

[@DAVID-xe9yh]

I love this video. Thank you for doing it. Great info and a good Tinder joke haha!

[@davegutierrez3216]

How’s it running to this day… I jus bought one a month ago.. so fun.

[@T14PRIME]

My wife got me the EXR for Christmas, I removed the stopper that hits the screw - went 5 miles faster ... removed the spring now I’m doing about 35 . Governer is still on . Is it going to explode 😂

[@CentralNH]

Awesome video. Like your other channel I love how you are so real and honest. I think I'm blocked on mowing channel cuz it wouldn't let me super chat. God bless and keep up great work.

[@FitInMy50sVlog]

Not sure why you are blocked but I will check

[@Sherrysanchez-r5c]

Can you show what to do my chain to tight so it hard to move it stay stuck and drags when I go forward what do u do

[@joeh42032]

Great info!! Thank u

[@FitInMy50sVlog]

You are so welcome!

[@ryan93civic1]

Do you know what other spark plugs will work. I just got the BT200x. Thanks

[@kelvinvega2995]

I have a problem with my mini bike bt200x. When the motorboat runs, gasoline leaks out of the gas tank cap. I already changed the cover but it is still the same, what will it be?

[@Captainkleen]

Those are the best Coleman 200X mini bikes compared to others I wanted one but couldn’t find one so I bought the ct200U instead to go with my Mega moto 212cc max. They are both good bikes but I prefer the disk brakes on my Mega moto max over the drum brake on my Coleman ct200U.

[@TeleCaster66]

I would suggest the chain may be a little bit too tight. Great video, I leaned a few things!

[@CashJohnston]

I got one just like that a couple weeks ago. It idles too high and moves unless I keep the break on. I can’t find an idle screw like I’ve seen on older models. Do you know how to adjust the idle down?

[@CashJohnston]

Richie Hembree Thanks! I’ll give that a shot.

[@danielmorin2461]

What kind of oil i should put, thank you

[@WiseQuack11]

10w30

[@johnhancock2914]

Synthetic 10w30

[@johnmartin5153]

How many hours did you have on this bike when you did this maintenance?

[@imfatkid420]

I just wanted to change my back tire cause I've never had one of these bikes before and no one has just made a video on how to change the back tire with out messing up everything and even after watching this I'm still just as in the dark but I do know random little fact tho so that's nice but can you just make a video where you change the back tire for the BT200X

[@horsedude01]

what auto parts store did you get the oil dispenser from?

[@FitInMy50sVlog]

George tag Advanced Auto Parts

[@horsedude01]

@@FitInMy50sVlog Thanks

[@largestnerky]

Just got mine the other day!!! This video was so helpful. Also noticed how clean your bike is, how do you wash the bike? Is it okay to just spray it down with the hose and soap?

[@FitInMy50sVlog]

That’s how I do it! Just avoid the carb

[@cwmaxfield2000]

I live in a very cold climate. Can I use 4 stroke snowmobile oil in my EX ??

[@cwmaxfield2000]

Anyone run studded tires on these?

[@frankag227]

i need help man my chain tensioner keeps coming off and you can see the bearing coming out can you please help me with this problem.

[@nikolaskaras3390]

How do you fix a engine lock on this bike?

[@NickDrinksWater]

Ive been wanting to get the bt200x but ive heard they dont have parts for it? I currently have the 200 U camo

[@FitInMy50sVlog]

I think the parts are the same besides the front fork

[@Deucealive75]

I'm wondering if this is just a case where their system just isn't set up properly? I know it took them over a year to have a correct and more accurate 200U parts listing. shopping.na3.netsuite.com/s.nl/c.3546502/sc.27/category.141758/.f

[@maxsanchez8058]

These bikes are a blast. My throttle is a little stiff. It feels like my wrist is on fire after about 10 minutes of running ha ha. Maybe I'm just a weakling. I probably need to make some adjustments.

[@FitInMy50sVlog]

Check the cable for kinks and try to inspect the moving pieces of the carb linkage for over tightening. Lubricate the throttle cable on both ends with a nice thin lubricant such as 3 in 1 oil or a good bicycle cable spray lube

[@scottnadeau5280]

I just picked one up it’s still in the box can you make a video on the proper way to Grease and service the clutch that be awesome

[@FitInMy50sVlog]

scott nadeau You don’t grease and service the clutch.

[@Deucealive75]

@@FitInMy50sVlog Oh yes you do...or should. Coleman even has a video here on youtube.

[@bradenwest6677]

How do you turn the headlight on?

[@jimtinter4397]

Lots of good info but I wish you would have tried to rotate your rear wheel after adjusting your chain and brake and tightening the axle nut. I've been have a lot of issues with my CT200X and CT200U-EX where the rear wheels starts to bind as I tighten the axle nut - even when the brake is completely disconnected. New bearings installed and the axle/spacer/washer assembled correctly but I am stumped! Any help anyone could offer would be greatly appreciated.

[@726rj]

Hey what size chain do I need for that bike

[@scottnadeau5280]

Where do you buy those air cleaners I can’t find them

[@MarcM143]

How important is it to shut off the fuel supply line when not in use?

[@alexisquintero2782]

Hey dan when you wash you bike do you hose it down?

[@FitInMy50sVlog]

Yes but I try to avoid spraying directly on the air cleaner cover

[@jeffreyhahler3022]

Any ideas of how to stop gas from leaking out of the gas cap ? ,the cap does not stay on. I even replaced it with a better built autozone cap, still the same problem

[@garysavala665]

Mine does the same thing I used a piece of plastic bag under the cap ghetto but it helps not get gas all over your pant leg .

[@garycrandall1652]

Have you checked your valve adjustment

[@chrissharp8518]

Dan question, i have the same bike brand new, is it normal to have the bike half throttle before it starts to take off, the engine boggs down until about half throttle before it starts to take off?

[@FitInMy50sVlog]

No it should launch as soon as you crack the throttle. Make sure the clutch is not messed up.

[@Deucealive75]

Remove the jackshaft chain and see if it bogs without a load. If it does it's an engine issue, if it revs nice it's a drivetrain issue.

[@tashahamilton4715]

Do you have any suggestions the pulley wouldn’t start and now it is leaking oil I have only had the bike for one day

[@FitInMy50sVlog]

Take it back

[@natemcalexander4284]

I love how you go through everything slow and a teaching moment for the new riders Are you thinking about getting a stage 1 kit from gopowersports for the engine

[@FitInMy50sVlog]

Thank you. I am considering it only because it looks cooler to dump the factory exhaust and intake box. The speed and power is fine as is for where we ride so it would be a $80 (?) investment just for appearance...

[@natemcalexander4284]

It adds about 1.5 to 2 horse power It takes about 10 minutes to install And cost around $80 I love it, it is a great buy Did you take out the throttle screw to go around 25 mph

[@FitInMy50sVlog]

I did not adjust anything on this bike yet. I did however reach 25mph on the MM80 by only backing off the throttle stop screw. I show that in the video I posted last month where we rode at Big Nasty ATC park (Thumbnail says “Riding Dirty”)

[@lazydog1964]

The torque you’ll get for climbing and speed is incredible with the torque converter is worth every penny

[@princedeepj]

Hello there my friend , I had a question if you could help me out . Are we supposed to add 2 cycle engine oil to the gas ? Or none at all , just gas only ?

[@FitInMy50sVlog]

Prince J these engines are 4 stroke so no oil in the gas. Motor oil goes in a separate area in the engine

[@princedeepj]

Dan's Vlog Gaming okay nice that’s what I assumed but I noticed that everything starts getting hot really fast so it kind of worried me a bit , but I’m going to add a stage 1 kit and a torque converter this upcoming week so I’m excited for that , your videos helped me out a lot so thank you for the tips ! How’s your bike been treating you ? Any upgrades or mods done since the videos ?

[@paulbunyun3663]

@@princedeepj you blow your bike up yet?

[@princedeepj]

@@paulbunyun3663 bike still rides like a charm after one year of it having aftermarket parts on it just been having the problem of bolts getting loose too fast and chain falling off but I will fix that ; when that’s all good it rides great !

[@derrickross5040]

I need a bolt 🔩 that hold the clutch i does not know the size it have a washer with it

[@lacarti_4L]

Lmao did bro just say his tinder 🤣

[@ammkad]

Is this the same procedures for the Ex?

[@jacksont8760]

Yep

[@victorsanders3439]

Hey Dan, I have a similar bike. Known as the Coleman ct200u EX and I've been having this constant problem which seems to be getting worse. My bike will not stay idle and it wants to move forward on its own. I have tried adjusting my throttle but it did not seem to make a difference. I was wondering if you had any suggestions on how to fix this problem. This is my first bike and I have limited tools, I also have not been able to find much on this problem. It is a 196 cc 4 stroke engine. It's pretty much brand new I got it late last summer and btw I live in Canada so I did drive it during the harsh winter.

[@FitInMy50sVlog]

Sounds like the clutch is engaging too early. Might have a broke spring in there

[@davidtaylor2392]

I had this issue recently and noticed the throttle was not returning all the way after I did the throttle stop delete

[@hacksforlife3126]

How often should I change the oil?

[@WiseQuack11]

When brand new change it after the first 1-2 rides then every 20 hours or so there after

[@anthonyrivera657]

My rim just won’t quit squeaking any ideas?

[@mowerbro4212]

I can't find that oil funnel any suggestions

[@FitInMy50sVlog]

Autozone

[@rezeile4393]

How to take off the chain tensioner?

[@rezeile4393]

I was trying to take off mine but all I did is broke it off 👎

[@FitInMy50sVlog]

I think a 13mm wrench and socket

[@michaelbluth8096]

what do you do if the spark plug is so tight you cant get it out even with a spark plug wrench?

[@FitInMy50sVlog]

Turn harder

[@rpg3783]

This bikes are made in Tempe Az

[@ReisterJP]

Too bad they are not made in Texas.

[@christianbudd7201]

Mine will only run when the air filter is off. When I place the filter on it starts to bog down and dies. Any suggestions?

[@FitInMy50sVlog]

Make sure the air cleaner is new

[@timlovejoy7616]

With regard to the amount of oil these engines take. I have three of these bikes, and I cannot get more than 16 ounces of oil in any of them, despite what the owners manual says. I called Coleman directly at the number supplied in the assembly booklet, and asked them. The person I spoke with had no idea and said nobody ever asked her that question before, so she asked the "mechanic" as she referred to him. According to her, the mechanic said 16 ounces is all the correct amount of oil for these engines.

[@535tony]

I think it is important to change the oil after the engine is broken in to remove any metal pieces that might get in the oil during breakin. Then change at least once a year after.

[@FitInMy50sVlog]

I agree. No more than 5 hours max on first run but I change my oil very often in non-filtered engines.

[@outdoorobssession8479]

Does it matter if the oil tube comes out

[@FitInMy50sVlog]

Push it back in

[@outdoorobssession8479]

Okay I did it was fine thank you

[@dave5611]

What of gas do you use?

[@FitInMy50sVlog]

Ethanol free gas

[@l.a.m7645]

How much does bike weigh?

[@Sherrysanchez-r5c]

Also it's hard for me to start it by puing the chain and holding the gas cuz it takes off on me cuz I have to start it off the bike but so when I'm sitting on I can't start it I have to start it when I'm off I'm not strong enough to pull the string using there some other way to make it easier for like switch or something ..I am a girl so

[@timothydemarco31]

Hey I just bought a brand new bt200x it runs until it warms up and then shuts off

[@FitInMy50sVlog]

That’s not good. I think maybe could have debris in the carb bowl/float where the pick up jet is

[@entertain4me73]

Your front wheel is on backwards! The deeper recess belongs on the left side in order to center the wheel with the frame. There is an arrow mark on the tire that should be pointing in the forward rotation direction.

[@FitInMy50sVlog]

Thanks bud. The tire shows correctly but the rim... will have to check

[@devonhill8127]

Oil specification is .63qt (.6L)

[@ryancole7814]

Help my latch cap fell inside the bike somehow

[@Sherrysanchez-r5c]

And my break don't seem good when stopping I

[@haydenrhodes8782]

The stock spark plug coming on all of Coleman mini bikes are terrible they last 6months to 2 years and tend to crack very easily I’d recommend to get a ngk instead

[@FitInMy50sVlog]

I agree

[@dbpiercy1]

got the same one but mine is red

[@FitInMy50sVlog]

Nice color!

[@johnhancock2914]

SHOCKED THAT NOT ONE PERSON COMMENTED THE MOST IMPORTANT THING WHEN USING THESE COLEMAN MINI BIKES OR ANY SMALL ENGINE RECREATION VEHICLES, AND THATS THAT U MUST ONLY RUN NON ETHANOL GASOLINE!!!!

[@FitInMy50sVlog]

You are correct! I always only use ethanol free gasoline

[@johnhancock2914]

@@FitInMy50sVlog correct, you won't have carburetor problems for years if u run ethanol free gas meanwhile everyone else running ethanol gasoline will be having problems with carburetor and gunning issues very soon

[@jdsolberg7613]

80W-90 gear lube applied with an acid brush is all you need to lubricate a chain. No need for snake oil lubricants.

[@derrickross5040]

This bike do so much shaking the screws that hold the gas tank ripped the tank so im holding down my gas tank with bunji cords

[@ahahaa1602]

I recommend ordering a performance kit from gopowersports.com The kit I have from them came with a straight pipe exhaust, performance air filter, a bigger jet for the carburetor for more fuel

[@FitInMy50sVlog]

I agree and this summer, I intend to do this upgrade as well

[@lacarti_4L]

Wow I put oil on my filter

[@lorenzolopez7207]

Did he just throw out his tinder profile 🤣 💀