DD15 fuel pump failure\\ fuel pump failure/ fuel pump failure symptoms/ fuel pump failure/ DD15/DD16

[@CodyRakowicz]

If you find metal shavings in your fuel filter housing. Doesn’t always mean bad news. Take a magnet and put it up to the metal shavings. If they stick to the magnet then it’s steel and more than likely your fuel pump. If it doesn’t stick to the magnet, it means its aluminum and its metal shavings from your fuel tank. Your fuel tank shaves metal everytime you put the nozzle in it at the fuel pump. I learned this from one of our master technicians and it has taught me so much.

[@cagrangersealninja3720]

Had a road call for a crank no start on a dd15. Pulled the fuel filter and it looked like someone dumped glitter in it. Also a good practice for a pm tech to always look inside the housing when changing the filter.

[@MrEGato]

Yes sir I think I’m the only tech in my shop that does this if I see dirt anything I clean it I never get a thx but knowing he’s good to go make my day

[@armand49100]

​@@MrEGato9 0:00 09😊99😊😊😊

[@cl3344]

Had mine go out on me outside Louisville KY. Parked it the night at our shop next morning didn't make it they couldn't figure it out. They ran a regen on it right after it started making that exact noise again. Great video

[@TATEXPRESSINC]

CL, thanks for watching and be sure to subscribe. Good luck 👊🏼💪🏼🔧🇺🇸

[@antiochaldo6299]

What was your mileage when the pump went out?

[@lonnyellingworth1717]

​@@antiochaldo6299 Good to now ?

[@jasonlovett9334]

Thank you. Your video helped me confirm my last road call

[@TATEXPRESSINC]

Thanks for watching. 🔧👊🏼💪🏼

[@alexchavez3912]

When metal shavings are found in the fuel filter housing should the complete fuel system be flushed out? If so, how would you recommend that be done?

[@shaneshane1379]

DD pumps 250 to 300 k miles, then change it again 500 to 600. That pump and pressure compensation valve are the only thing I would call POS on a DD engine. I have one fleet that I got the drivers to start putting a quart of oil in 90 gal tanks when refueling. Maybe that will help the pump last longer.

[@supersaulflores4055]

What about shiny metal shavings in the ft uel tank.do completely drain and wash fuel tanks?or do you let the filters do they're job and not drain tanks?

[@sperk034]

I'm having a crank no start issue with my 2010 DD15, after changing the fuel filters & fuel/water separator it ran fine for 3 days now it won't start on it's own. It starts with starting fluid, but will not stay on nor start on it's own. I've pumped on the primer for hours & there's no pressure there as if it's sucking air.

[@sperk034]

the last 6 of my VIN# AN0751

[@TATEXPRESSINC]

Shirod, starter fluid could cause damage and it is not recommended. Replace fuel filters again and if problem still exist, check all fuel lines for signs of leakage.

[@jasonlovett9334]

When pull the filters out check for the little locator tab thing at the bottom of the the main filter. If that brakes off good luck getting a prime

[@joseriera097]

Did you happen to figure this issue out??? i am on this same exact sittuation.

[@lightningguy4897]

Happen to my first freightliner DD15 at 600k miles. MY new cascadia I put hot shots LX4 addictive in it once a week. I got 790k on this pump with no issues yet. I recommend the LX4 BY HOT SHOTS to help prevent this.

[@classicjay7786]

Absolutely I use this stuff too $80 for a gallon that’s treats 3200 gallons last me about 1 month totally worth it. You will not miss $80 a month if it’s going to extend the life of your fuel system don’t be cheap to your truck.

[@Ayekody]

Do most truck stops sell that additive?

[@lightningguy4897]

@@Ayekody I'm not sure if truck stops sell it I get mine directly from thier website. They also offer a CDL discount.

[@commonman44]

So what's the purpose of LX4 ? New to trucking

[@lightningguy4897]

@@commonman44 ads extra lubricating to the fuel system. These modern fuel pumps are very high pressure and are designed overseas that don't have the biodiesel requirements that the US has. The US has more biodiesel content which burns well but doesn't lubricant well. SO LX4 ads lubrication extending your fuel pump life.

[@successj349]

Hey man, this is exactly what happened to my truck three days ago. Great

[@TATEXPRESSINC]

Sorry to hear that. We hope you got your truck fixed.

[@ghostbuilder3187]

Do you think any of the metal shavings are gonna be holding any check valves, relief valves, or any other valve partially open preventing full closure in the fuel system.

[@TATEXPRESSINC]

The driver shut truck down as soon as he heard the irregular noise from pump. In most case it is recommended to replace the entire fuel system but, of course we try to save what we can.

[@stevendan9878]

I just found some metal shavings in water separator but not in the filters i wonder whats going on

[@TATEXPRESSINC]

Possibly the water pump.

[@kingpin9733]

I thought DD15 also had a inlet fuel filter to protect and filter fuel from the tank, correct? If that's the case even if contaminates did make it back to the tanks it would be filtered out.

[@TATEXPRESSINC]

This system was completely contaminated. Detroit recommends replacement of all injectors. We can run to same injectors if they are not already damaged Thanks for watching and be sure to subscribe. .

[@yangw4465]

My truck just has this problem,replace fuel system,dealership asking 13700 $,Good luck DD15

[@raymondville942]

Why will you spend $13700 in replacing a fuel pump when you can invest $10k to get back $70k on a weekly basis through bitcoin mining

[@MackTheGovnah]

This is a bad and expensive failure. I know it happened to me. You have to check the fuel injectors to ensure that the metal didn’t “kill” them. Be careful you drivers with a DD15 over 500k. It’s a good ideal to order/install a new fuel pump ~$1700 then to allow an older pump failure that will require you to have to replace most of the fuel system if it implodes.

[@TATEXPRESSINC]

Thanks for the input Mack. Thankfully this drivers injectors were still functional, it may have been from him shutting down as soon as he heard pump failing. And yes this can be an expensive failure. Thanks for watching

[@MackTheGovnah]

TAT Express Inc. you got it. Keep the informative content coming!

[@stilliraise9201]

Can we replace them ourselves?

[@KNGHT1]

@@TATEXPRESSINC is it the same for a Cummins? I have a 2014 Cascadia with a Cummins ISX 15

[@raymondville942]

Do you know how much $1700 can give you back within 10days when investing in bitcoin

[@billyg.1212]

I have a 2014 DD 15. Has approximately 640,000 miles. When should the fuel pump be changed before failure. I do appreciate your help

[@Lasharella]

I’ve been looking for this answer for week now, I have 13 Cascadia dd15 after 1mil I did engine overhaul replaced turbo even though everything was still running good, but now my fuel mileage is 5.5 t at best running 65-70k lbs so was thinking replacing fuel pump as I never done it since I got this truck at 380k miles, no noise or any problems but it’s been so long so been trying to find out if I should spend $2k just in case but no luck so far.

[@raymondville942]

@@Lasharellacan i suggest something for you ?

[@NYtoddler]

hi ,i have 2015 freightliner dd15. i have extended warranty on it. the problem i am getting with this truck since i bought, it is giving me fuel system problem detected. i have changed the fuel pump and lot of others tests are done by detroit dealer but still problem is not solved.

[@harneepsingh4762]

hi i have same 2015 and replaced fuel pump bt it gives same problem?

[@carbombtorres1761]

Ok I've got a question about a 'looping' idle that I got on my truck. I replaced the fuel pump back in November of 2019 and everything was looking and sounding nice ...until a week ago. Now it has a this looping idle with what assume is the fuel quantity valve ...I had changed that valve once before. My question is why does the fuel quantity valve fail? Bad fuel?? Bad bio-diesel?

[@TATEXPRESSINC]

Carbomb, I would change fuel filter and inspect fuel lines for leakage. You should not have to change PLV again if pump has been replaced. I would recommend testing the fuel system

[@carbombtorres1761]

@@TATEXPRESSINC fuel filters were changed a month ago. The truck just has that little looping 'cricket' noise

[@patsplat]

Hi, I'm curious to what diagnostics system do you use to read trouble codes?

[@sergeylekarev1667]

I have 2018 Cascadia with DD15 Fuel filters assembly doesn’t have any metals when it’s idling Doesn’t have any problem When I start to accelerate It making noise and works roughly Mechanic already check fuel injectors It’s good And when I drive it has low pressure code on dashboard Do you know the problem?

[@Ephesiansverse3steadyprogress]

Great content bro. I have a dd15 cascadia 2011 ..my truck is not starting as quick as used to i hear a noise coming from driver side near diesel quantity fuel valve wich i replaced 2 yr ago ..the noise comes and goes any recommendation?

[@TATEXPRESSINC]

Thank you for watching. I would change and inspect fuel filters. If noise continues I would have the pump inspected and find the source of the noise.

[@Ephesiansverse3steadyprogress]

@@TATEXPRESSINC thanks keep sharing knowledge ..because we need it ✌🤣

[@TATEXPRESSINC]

Im glad you find the info useful

[@jamesharman2851]

2009 dd15 no start because of fuel pressure leak down. I know how to fix the leak down but it sounds like a slight but steady surge when running. Is that normal or a problem with injector or fuel pump?

You are prefect bro 👏🏻👏🏻👏🏻

[@TATEXPRESSINC]

We appreciate the support

[@franciscoperez2079]

One question my truck has a DD15 engine. In the future I want to make it a DD16 to have more power. The question is, are they the same on the outside? Does the dd16 fall on a 2016 cascadia freightliner?

[@Lucky1313Vlogs]

Nice videos bro. Thanks. I have question: my 2013 Freightliner cascadia DD15 vibrates at 45mph...less then 45 or over 45 it stops. Can you please help. I have them balance the front tires...still vibrates but 50% less now after front tires balanced.

[@TATEXPRESSINC]

Most of the time a vibration like that is a tire. Could have bad tire or worn from king pin or tie rob play. Once the tire is worn it’s best to replace

[@Lucky1313Vlogs]

@@TATEXPRESSINC Thank you

[@kirkbrown2147]

What about a CV joint

[@pakistanitruckerinusa2397]

I have 2017 cascades runs rough on going up hill kindly let me know the cause

[@TATEXPRESSINC]

You can start with the fuel filters to ensure enough fuel supply to the engine.

[@iMasterMechanics_1]

you give me manager vibes dude

[@devante5885]

Keep up the good work. I wish you had a podcast.

[@davidduron8360]

2015 dd15, after about 4-5hrs of engine running and I make my first stop or slow to lower gear truck jumps like “I’m learning to drive stick for the first time “ only speedometer goes back and forth from 0-85 if I take my foot off pedal and reapply I get nothing, I can pop clutch to rein gauge power but it will either continue same process or finally catch and drive normal. Happens everyday, no codes, check engine comes on for 30secs or so then turns off, every now and then it will happen at high speed, also noticed my cruise control won’t work when stopped and trying to idle up, recently replaced pedal assembly but no change, any help or direction would greatly appreciated, live in Mississippi or I’d just bring it to you.👍🏽

[@702trucker]

Another great video!Hi, I have a 2016 Freightliner Cascadia. I have to warm up my truck to at least 150° degrees before my dt12 will shift from 6th gear to 7th or 8th gear. Does that sound like a warranty problem or non warranty transmission problem. Freightliner charges $179.00 just to find out what I already know!

[@TATEXPRESSINC]

I would have to pull codes off of transmission to better assist

[@Evry1srolemodel]

dd15troubleshooting.com/dd12-not-going-into-gear-split-rod-bushing-repair/

[@Evry1srolemodel]

I'm an owner operator of the same exact truck as you! 2016 Cascadia Evo 125, message me at 203-906-9979.

[@702trucker]

@@Evry1srolemodel It was the piston seal I was told. They fixed it!

[@Evry1srolemodel]

@@702trucker my truck has a hard time going straight into 2nd gear when cold, I actually have to go into reverse and back to neutral a few times before I can actually take off. My truck has been like this ever since I bought it almost 2 years ago.

[@ohantrucking3233]

hey i like your show . i have a question. i just purchaced dd15 engine ad it has a rough idoling . there is no check engine light on and right by the fuel pump there is a squeaky noise. i hope you guys can help me solve this problem . Thank you and how much would you think itll cost?

[@TATEXPRESSINC]

Ohan, where are you located? We can check it out for you. Thanks for watching and thank you for the support. Make sure to subscribe and turn on notifications.

[@jasminhodzic7769]

Hi there i have a question and need some advise. I have 2014 freightliner coronadi 122sd with DD15. Had blown engine had mechanic swap engine got it running great at cold start but after a wile of driving chokes and blowes white smoke on low RPMS open highway runs great just on take offs and low rpms smokes and hesitates. Injectors are less than a year old with maybe 10 000 miles on them. Not loosing any coolent and its not happening all the time sometimes more sometimes less and sometimes not at all What could be causing this? Thanks

[@AntJordan-w5d]

hey guys love the Information that you bring to us truckers have a question I have a 2014 Cascadia dd15 not all the time but it surge sometimes when I'm on the highway motor going up and down don't cut off or anything just surging pull over wait for 10min and I'm good happens a lot could it be the fuel control valve?

[@blazekicker6582]

2011 cascadia with dd15 getting lot of coolant in fuel system while running and while running losing alot of coolant. Besides cups is there anything else could be doing it. Mechanic think it wouldn't be entirely cups cause it would lock up injectors. 20 mile drive lost a gallon. Coolant was in separator. And the davco is 482 where there is no coolant running thru fuel heater. Truck has not overheated either.

[@DVoured]

Fool smile got me subscribed.

[@GarrettColeman-uc3ot]

Is it possible to source the manifolds/plates for the low pressure side of the pump? I work for a diesel remanufacturing facility in SC and we are exploring the option of remanufacturing this fuel pump but i am having trouble finding these items

[@joannanorton8342]

Have a 2010 Freight liner Cascadia fuel isn’t equalizing/ drivers side is fuel an passenger side empty, gas meter reads full all the time now what would you think this is?

[@nramroop79]

If I have to replace the fuel pump on a D 13 Volvo do I need to drain the oil from the motor

[@TATEXPRESSINC]

If diesel did not enter the oil, than you should not have to replace oil.

[@jugdeepsirpal6154]

Hi, my friend has a 2003 freightliner Columbia Detroit 60 series, after having all injectors replaced,truck misfires/backfires with puff of smoke about 1300 to 1500rpm. New Manifold pressure sensor and intake temp sensor. Any advise please. Thank you

[@TATEXPRESSINC]

Problem happened after repair? Be sure to subscribe

[@JoseGonzalez-qd7kb]

I was told my Fuel quantity control valve need to be replace because engine surge a little at idle. Some time when I start the engine I hear a ticking sound for a few seconds, not while engine is running. Would I be concern about the fuel pump? My engine have 614k miles.

[@TATEXPRESSINC]

If there is ticking before start up than it would not be the fuel pump. Changing the QCV will stop the surging. I would check fuel filter and fault history for any fuel related faults. I have seen pumps needing replacement after QCV repair.

[@JoseGonzalez-qd7kb]

TAT Express Inc. I’m the only owner this truck had. The surge is be happening for over a year. I notice some bubbles inside the water separator. In the summer when I keep the truck running some times I get the check engine light and the level on the fuel water separator drops, but after I restart the engine the light turn off. I get codes, never the same one, but like I said if I restart the engine and drive away they disappear. I’m taking the truck to the shop tomorrow. Thanks for your reply and keep making videos. You give some awesome information.

[@TATEXPRESSINC]

Jose thanks for watching. Let know what you find out.

[@joeygarza4270]

My truck is revving up and down. Its a freightliner cascadia dd13. When I'm driving it when I hit gas pedal it delays for about a second before it catches. Then this morning when I started it up it make like 10 load clicking noise. It started but engine didn't sound right. And it wouldn't Rev up pass 10 rpm. Any idea?

[@dankruger2890]

How many miles did that truck have? Is a average mileage one can expect this pump to fail?

[@TATEXPRESSINC]

This engine had 350k miles but, it has been sitting for a while.

[@snappleshibes26]

This just happened to me on my truck (2019 Freightliner) Friday. I also had to have a fuel injector replaced on the truck in November. Seems like I haven't had much luck with the fuel systems on it... But thanks for the information, this video was helpful.

[@TATEXPRESSINC]

Thanks for watching. What was your fuel filter change interval?

[@snappleshibes26]

​@@TATEXPRESSINC Company wants it done ever 37,500 miles I believe. I last did it in mid April and I think around the time the injector went out as well. I've only had this truck since late October.

[@2010schmity]

Did the ticking stay the same at high idle ? Go away or stay the same? I have same noise but goes away on high idle. 23 with 90k

[@versace14karat2]

i have a freitghtliner 2019 sleeper truck, the truck is not equalizing the fuel tanks, what can i do in this situation ?

[@TATEXPRESSINC]

Versace, ensure there are no fuel line restrictions or blockages. Also inspect the fuel tank breather line and ensure it is free from bends or blockage. If all fuel lines check out, then a new splitter valve may be needed.

[@robertpope3619]

Had a quick question, I have a spn 157 fmi 17 rail pressure fault. No start as well. Noticed the PLV has 212 counts so I have requested it but I'm still going to continue the diagnostic steps. Do u think the PLV could cause this fault though? The steps haven't had me check the PLV yet.

[@TATEXPRESSINC]

Deadpool, did this fault set after a fuel system repair?

[@TATEXPRESSINC]

212 counts on a PLV would indicate a failure. I would troubleshoot PLV as well.

[@robertpope3619]

@@TATEXPRESSINC the FMF qas replaced on April 2nd

[@usturbonater5678]

Same problem But I wasn’t lucky It cost me about 11k to fix it at Freightliner dealership. Thanks for explaining

[@emrahb2284]

Did they change injectors?

[@usturbonater5678]

@@emrahb2284 they will change fuel pump and fuel lines, injectors

[@emrahb2284]

@@usturbonater5678 That should cost more than 11k I guess. I have same problem. Dealer said 10-12k estimate without changing injector! Do I have to change injectors? Thanks

[@usturbonater5678]

Well they told me 11k and took half down, for injectors I’m not sure . They found metal piece in fuel lines , They’ll cleaned it up drain the diesel and reuse it . And they assured me 100%. Let’s see

[@emrahbozoglu3903]

@@usturbonater5678 Hey man. Did you get you truck?

[@cdun6969]

I’ve got a dd13 That’s got a loud squeak sounds like it’s coming from under the valve cover, cylinder 1 or 2 loud chirp sound

[@marrtin88]

Hey i got the same loud sound. How did you fix it ?

[@uncltod8801]

I have a 2014 freightliner Cascadia, with a DD 15, I need to change the fuel quantity valve, But there are no 4 black hoses that need to be disconnectedL like it shows in other videos ,do you know why, is this normal,?

[@TATEXPRESSINC]

Some of the lines have been updated. Thanks for watching and thank you for the support. Make sure to subscribe and turn on notifications.

[@Lasharella]

I’ve been looking for this answer for week now, I have 13 Cascadia dd15 after 1mil I did engine overhaul replaced turbo even though everything was still running good, but now my fuel mileage is 5.5 t at best running 65-70k lbs so was thinking replacing fuel pump as I never done it since I got this truck at 380k miles, no noise or any problems but it’s been so long so been trying to find out if I should spend $2k just in case but no luck so far.

[@raymondville942]

Do you know how much $2k investment will give you back within 7 mining days without having yourself stressed out working through Bitcoin?

[@augiegarza2454]

Hi i have a dd15 2016 cascadia before i replaced all 3 fuel filters truck would stall out going down the hwy i notice it would chugg when going uphill i cant figure it out

[@augiegarza2454]

It is loosing its prime like running out of fuel when it stalls out I have to prime it and shoot starting fluid to get it going again until it does it again it's getting dangerous to drive

[@ivandiaz5868]

I had my fuel pump replaced along with fuel filter housing but now i am getting low oil pressure and i've notice fuel in my oil pan Any suggestion would help on what causing this

[@superfly4137]

Look into O ring replacement.

[@mehmetg1137]

on a dd15 engine is the primer pump suppose to be solid where you cannot push it down while engine is running?

[@superfly4137]

guys i gotta a question. Should you buy a used freightliner that had fuel pump failure with metal shavings that made it into the fuel tank? the fuel pump was replaced, along with a flush of the fuel tanks, lines and replaced primed. It is very likely that the fuel shavings damage any more engine components besides the injectors in the future ? thanks

[@emrahbozoglu3903]

Hi. Did you buy that truck?

[@petehansen8973]

1999 12.7 starting to miss at low RPM. Still running good at higher speeds , do you think the injectors are going bad ? Feels like one for sure...what do you think

[@jasminhodzic7769]

Did you get ansewer on this im having same problem with my dd15

[@lifeisgood4669]

Pretty good explanation. M6 dd 15 right fuel tank is draining but the left side remains full of desil. Please let me know if it's from the equalizer or if it's from something else???? Is it something I can fix or I must take it to a shop?

[@braddunlop4579]

check your tank vent hose. if 1 is plugged it will suck from only 1 tank.

[@veganwilliamdotyfreshour3665]

That seemed to be great information. Done it before!

[@TATEXPRESSINC]

We are glad the video was helpful. Thank you for the feedback.

[@fozman845]

Yep rak,rak,squeak pulled into trk stop pump failure no noise during the week nothing happened that fast. This kind of repair can put a new O/O out of business quick.

[@TATEXPRESSINC]

Fausto, yes this is an expensive repair. I hope they were able to save your injectors.

[@fozman845]

@@TATEXPRESSINC just installed new fuel pump, disassembled fuel filter housing, fuel water separater flushed cleaned. Used a Camera with 8ft wire pushed it thru the fuel return line all the way to the T connector to my fuel tanks no metal shavings. Pumped fuel tanks out separating good fuel from bad cleaned bottom of tanks out. Put everything back together and crossed my fingers on my injectors. But so far as of 9am this morning truck is purring. No engine lights or error codes showing.

[@TATEXPRESSINC]

Fausto, that’s great! I would change fuel filters more frequently before going back to regular intervals. Just to be cautions.

[@mr.hunjan3089]

I have DD15 2017 with 505 hp manual 13 speed . My truck loose power very fast at uphill . Driver side engine surrounding like subwoofer. Low fuel Efficiency. No sign no check engine light. Please suggest me.

[@TATEXPRESSINC]

Thanks for sharing. It may be an intake leak. Have you had a boost leak test done?

[@Jesusisking11111]

Did you ever figure out what was wrong with your truck I believe I have same issue when I’m going up hill loses power fast and sounds like a subwoofer

[@mr.hunjan3089]

@@Jesusisking11111 please go to good Macanic shop and check your all 6 cylinder are they making enough power.?? Mine was 6th cylinder was not making enough power . It was 20 It should be more than 90+ . It means problem with Head .and it’s common problem with DD15 .

[@Jesusisking11111]

@@mr.hunjan3089 thanks man

[@Jesusisking11111]

Hey also how much was that cost to fix that of you don’t mine me asking

[@BabaLaos]

Hey, do y'all take walk-ins, or is it only by appointment? Would like to come through while in Dallas

[@johnnybarnes9975]

How do you time the high pressure fuel pump on a dd15?

[@davidsampson5475]

What book hours on this job? Wondering how much this failure would cost to fix I know the pump is crazy expensive

[@nolimittransport7601]

What happened when your truck hesitates to crank almost as if you chest change your fuel filters and the fuel water separator as long as you can see fuel through the glass it cranks normal. But sometimes the fuel drops lower than usual and then it takes two seconds to crank very inconsistent.

[@PeterBrown-qx3zr]

Hello I have a dd15,and I power washed the motor on the side with the fuel filter, and now my check engine light is on ,and the truck is acting like it's not getting fuel and won't start?

[@TATEXPRESSINC]

Do not power wash or steam clean the engine bay in the area of vehicle electrical components, unless specified by vehicle manuals or service literature. Power washing/steam cleaning can permanently damage these components.

[@TopUpLogistics]

Just curious ..How much to replace or repair fuel pump? 2018 Freightliner Cascadia 125 Evolution. I got a quote for $4300 for part and labor.

[@alexwilliams4334]

Hey boss I'm having a problem with dd13 losing prime if I let it sit over night once I get it crunk runs and cranks fine but if I let it sit over night loses prime any suggestions

[@TATEXPRESSINC]

Check for external leaks if none are found I recommend getting problem troubleshot by an experienced tech.

[@alexwilliams4334]

Okay thanks for your help boss

[@shermanneace5875]

what makes the low pressure side and high side still good on a dd15 high pressure pump

[@Carzone94]

I have 2013 freightliner cascadia with DD15. My oil pressure gauge went down to 0 and the truck shut off. Do you have any ideas what might happen? Please help! Thank you!!

[@raymondville942]

I only have one suggestion and don't know if it will work for you

[@MirzaGus]

Two holes on the pipe where delta pressure sensors sits keeps plugging up, what is causing that? On 2014 freightliner cascadia

[@kirkbrown2147]

Take the sensor out and look at it for metal shavings

[@trinaklec2154]

I have oil going into my fuel tank. From Lakeland FL to AL I used over 12 gallons of oil trying to get my truck back to the shop. Do you have a clue to what's going on bc my truck been down for two weeks and they still don't know what the problem is?

[@raymondville942]

I only have one suggestion and don't know if you will buy the idea

[@MMartian7]

I replaced mine at around 750:000 k around costs $10000 good luck 😎 Freightliner Cascadia DD15

[@raymondville942]

Why will you do that, do you know that $10,000 can give you $70,000 within every 15days through bitcoin mining

[@85hotrod5879]

2010 freightliner Cascadia dd15. truck was running fine. pulled it in the shop to replace the hydraulic clutch. the pedal was staying on the floor or only coming half way up. removed transmission and replaced the clutch. reinstalled everything back on the truck and now it just cranks but wont start. there is fuel coming from fuel return line when cranking. doesnt look like any fuel is being pulled from fuel water separator. any idea what i need to do?

[@TATEXPRESSINC]

Check fuel lines

[@85hotrod5879]

@@TATEXPRESSINC what am i looking for? i checked the supply and return lines. don't see anything to raise any concern. is there a check valve somewhere in the system that could have gone bad?

[@TATEXPRESSINC]

If you removed transmission you may have disturbed the fuel lines and may have lost prime. Have you tried to prime the system

[@85hotrod5879]

@@TATEXPRESSINC by filling the fuel water separator bowl and using the primer pump. But not by hooking up to the compucheck fitting and forcing fuel through there.

[@markjackson4243]

I'm just gonna put this out there by the time you hear a noise from the fuel pump the lobe on the cam inside the has been wearing over time so metal is in the whole system by the time you hear anything

[@jtdehoyos]

2 months ago i found metal shavings inside fuel screen and now the motor its hard to turn... is there a chance that the fuel pump will be causing this? Thanks

[@almendez9718]

Think there was a recall on those long time ago same series cascadia FREIGHTLINER same way found the metal shavings on filter housing around 2009!!🔧🔧

[@superfly4137]

So the question has not been answered. Why did the fuel pump fail in the first place? This should not happen if it was designed with durability as a priority.

[@richardmollohan954]

These trucks the last 10 years are disposable police volume running 3 years 300,000 miles turn them in then dumbass is going by them think they got something from a fleet that would matane them and when they get a couple hundred more thousand miles on them they turn to junk. My boss had Freightliners that were from the early 2000s that had over a million and a half miles on the untouched engine and still ran great he bought 6 2012 cascadia's with a dd15 and within two years they broke him they spent more time and dealership so you did on the road

[@jonathansalazar1186]

Thank you for your education on this ..

[@DeliusFrazier]

Davao 482 never shows any fuel level. Small bubble coming up. Seem like it’s starving for fuel. . What should I do.i have a DD15

[@blackericdenice]

How much did you charge

[@jamiegilchrist-oi3tb]

What if the fuel pump is not pumping correctly or building enough pressure to send fuel to the fuel rail..

[@hasan3raxmatov326]

Hi sir , my freightliner 2021s fuel gauge making mistake on 1 or 2 quaters its showing empty about 850 miles used to show empty on 1200 miles at least now i have half tank left but still showing empty , what the problem can be ? Or can you guys fix if i go to you to fix ?

[@raymondville942]

There are lots of people who can help you fix it

[@alexchavez3912]

Any chance that the metal shavings could have made it into the fuel rail and injectors? I just ran into this issue where there is metal shavings in the fuel filters. I haven't done any other trouble shooting

[@satti1001]

It hapend to me, i changed fuel pump, did you clean tanks?

[@ubu3393]

Question...what does RAC system failure mean on a 2016 freightliner cascadia

[@sf4158]

Hello I just read your post! I have the same question, I have dd15 2015 RAC sistem failure. Do you know what is this means? Thanks 👍

[@arnoldgallegos6247]

Mine failed and cost 10k to fix, new everything. Freightliner dealer put in invoice they cleaned my fuel tanks due metal. Note they left my old fuel in it. They said they filtered my fuel. 720 miles later my fuel system clogged up. Took to a different dealer, cause fuel contaminated with metal shavings. Now dealer won't pay for my repairs. Being charged 5k Including diagnostics to flush fuel system. Can i sue?

[@TATEXPRESSINC]

@arnoldgallegos6247, it is possible that there may have been metal left behind causing it. I could not advise about litigation, but court proceedings take time and money.

[@arnoldgallegos6247]

@TATEXPRESSINC Yes, I know, but at least I would get my money and lost work time. In California, there's a law that if I win my case, the dealer would be responsible for my legal fees. But the lawyer is asking to file a complaint with the bar. I don't want to. Just wanted what I paid for. Question: What would your shop do?

[@tbren9341]

My truck has a small ticking noise like that but it goes away after I warm it up. How many miles do the fuel pump last? My truck has 970k and never change the fuel pump

[@Khmtravelvlog]

Probably need to change it ASAP oh I am late 😂

[@azaazaeva1950]

Hi ! I have a 2015 cascadia and it starts sometimes but sometimes it’s not. Any ideas?

[@raymondville942]

Get another car for lesser expenses

[@camerontarver9966]

hey Do you take Freightliner aftermarket warranties?

[@turboligno]

Hi there, how many miles on this Cascadia?

[@TATEXPRESSINC]

This had 400k, but had been sitting for a while. Thanks for watching

[@michaelguinn5260]

Hi Sir I have a 2009 cascadia freightliner with DD15 engine and I've noticed when I start me truck it takes a few tries. Once it start I've noticed engine fault codes fluctuate. Took it to the shop and the mechanic mentioned there's metal on my Cam sensor. He think it may be coming from the gears or fuel pump. Have you ran across this issue? Please let me know if you need more details. Thank you

[@raymondville942]

If your 2009 cascadia is giving you stress, you can get another one instead of stressing yourself

[@clydedurden1555]

is there an easier way to get to the one way check valve on the back of the head on a 14L detroit!?

[@Salih.EduBlock]

This ticking and high smoke 💨 is exactly what happened to me. I’m in a hotel now waiting got Freightliner to diagnose it. I’m sure that is the problem. I drove it 50mph for 30 miles to Freightliner though. I hope that didn’t cause more damage. I’ll find out once they call. I should have replaced the fuel pump months ago. 1.1 million on my 2009 Cascadia. She screams for money monthly. 🤦‍♂️ Thanks.

[@thetowndrunk988]

Damned things are money pits

[@raymondville942]

Why don't you engage yourself doing bitcoin mining to earn over $40k on a weekly basis?

[@raymondville942]

@@thetowndrunk988 people only complain when the available resources is not stable but it could be better how wished you were involved in bitcoin mining

[@thetowndrunk988]

@@raymondville942 what does bitcoin mining have anything to do with anything, that has anything to do with a Cascadia being a money pit?

[@Salih.EduBlock]

@@thetowndrunk988 This bitcoin guys a fckn Troll dude. Ignore him. They seek Any kind of attention.

[@ramanjotsingh4389]

Hi buddy. Can you help me, on my truck message comes up low fuel pressure and then it loose power. After restart it back to normal. Any recommendations thanks

[@jamiekrebs9208]

Have a Volvo d 12 new fuel pump won’t prime out of a 5 gallon jug is it bad or what

[@jaskaran725]

please make a video how to do timing of this fuel pump before start up

[@TATEXPRESSINC]

Jaskaran, great idea. Be sure to sub so your notified once video is released.

[@jaskaran725]

TAT Express Inc. done boss

[@erwindelacruz2915]

sir how to adjust fuel intake of isuzu 6sd1 injection pump.

[@TATEXPRESSINC]

Thanks for watching and thank you for the support. Make sure to subscribe and turn on notifications.

[@Lucky1313Vlogs]

If you don't mind. Can you do a video on Replacement of clutch assembly, Slave clynder, and hose from clutch resavor to slave clynder. I would really appreciate. God bless

[@TATEXPRESSINC]

That’s a good video. Thanks for the idea

[@Lucky1313Vlogs]

@@TATEXPRESSINC Thanks

[@OpinionatedGent]

My Truck Runs Fine With A Full Tank But When It Gets Under Half A Tank......It Starts Acting Up. Acting Like There Is No Fuel In The Tank(Check Filter On Dash). But When I Fill It Back Up, Everything Works Fine. Had Tanks Cleaned And Inspected Due To Being Dirt......But It Didn't Fix The Problem. Help.

[@kienhuynh7240]

I have a 2018 Freightliner 126 with DD15. Whenever I turn off the engine for an hour or two it will loose fuel pressure. I have to prime the fuel system again using the hand pump on the fuel filter so I can start the engine

[@otfogfotfogf8166]

I have the same problem did u get it fix?

[@daviddonaldson6069]

Usually it's the fuel water separator filter. You have to hold it down when you twist or it won't seal right, and cause starting problems.

[@Asliddinov1]

Helpful VIDEO BRO SAME ISSUES MY TRUCK AT THE DEALERSHIP 2020 cascadia DD15 with 270K miles does warranty covers expenses?

[@alitamari4175]

I have DD15 freightliner 2019. It has 472,000 miles how I know the oil pressure it’s good or not

[@Khmtravelvlog]

At around 500k you'll notice the oil pressure is less than normal. I just changed the o-rings in the pickup on mine and increased oil pressure