DIY - 2016 Kia Cee'd 1.6 GDI: Change the manual gearbox oil (transmission fluid)

[@johnwilcox8883]

Thank you for posting, very informative. I must say your command of English is perfect.

[@TheMissingBolt]

Thank you very much! I'm very happy you enjoyed the video!

[@adriancostea2869]

Multumim pentru video . Te rog ,imi poti comunica de unde unde ai cumparat saibele originale .Nu le gasesc ! Multumesc frumos , o zi frumoasa iti doresc !

[@TheMissingBolt]

Salutare! Le-am comandat pe baza codului original de la reprezentanta Kia din Jilava (International Motors Group).

[@Teolupo82]

Good video, thank you!

[@TheMissingBolt]

You're very welcome! 🙂

[@tafobasket]

Hello man, great video! Do you know how much oil I need FOR 2015' Kia Ceed 1.6 CRDI 136 hp automatic gearbox? Thank you!

[@TheMissingBolt]

Just to confirm - do you have the 6-speed torque-converter automatic or the 7-speed dual-clutch automatic?

[@tafobasket]

@TheMissingBolt Its 7-speed dual-clutch

[@TheMissingBolt]

@@tafobasket In this case, you have the D7UF1 transmission, which requires 1.9 - 2 liters of 70W / GL-4 oil.

[@fazilalptekin7337]

Bonjour. Oui, j'ai utilisé cette huile dans la transmission manuelle Hyundai Tucson 1.7 et j'ai obtenu un excellent résultat. Les changements de vitesse sont devenus fluides. Quant au joint, n'importe quel joint en aluminium de 16 mm peut être utilisé. une huile parfaite

[@TheMissingBolt]

Bonjour! En effet, mon ami est également satisfait du comportement de sa boîte de vitesses avec la nouvelle huile. J'ai utilisé Ravenol pour toutes les applications au cours des 3 dernières années et elles se sont toutes très bien comportées jusqu'à présent. En ce qui concerne le joint, je préfère le joint d'origine car je ne sais pas si l'alliage d'aluminium d'un joint standard à usage général est suffisamment souple pour créer une étanchéité appropriée.

[@rafakaczmarek1265]

Do You know size of this gasket in cm?.

[@TheMissingBolt]

I don't have the old washer available to measure it, but you can remove the fill / level bolt and washer from your box, measure its size and then put it back (reusing the washer one time shouldn't cause any problems, especially on the fill bolt).

[@fazilalptekin7337]

16 mm

[@azizmouminin5863]

Bonjour monsieur, j'habite en Angleterre et je voudrais savoir quelle huile de boite manuelle me conseillé a mettre pour une kia picanto 1.2l 2014 essence et aussi combien de litre a mettre? Merci d'avance

[@TheMissingBolt]

Bonjour! La Kia Picanto 1.2 de 2014 utilise la boîte de vitesses manuelle M5EF2, qui nécessite 1,9 à 2 litres d'huile avec une viscosité 75W85 et un indice API GL-4, selon le manuel d'utilisation.

[@luismar9971]

Buen dia cuantos litros lleva la transmicion de un kia rio 2003 Gracias

[@TheMissingBolt]

¡Hola! ¿Qué motor y caja de cambios tiene el coche (cuántas marchas)? ¿Es manual o automático?

[@lzkams]

Would you happen to know where I can get these washers from? I searched the web and i cant find anything with the same part no. in the UK

[@TheMissingBolt]

I got them genuine from a local Kia dealer. If that's not available, one alternative is to buy a copper washer set and pick from it 2 washers of the closest size to the original ones.

[@tiennguyen-gt4yw]

Thanks a lot . from vn.

[@TheMissingBolt]

You're welcome, I'm glad you liked the video!

[@Plikten]

Does it help to remove the front tyer to fill the gear box

[@TheMissingBolt]

It definitely gives you more room to work, but be careful to firmly secure your car on a jack-stand if you want to remove the wheel for this procedure.

[@andreiverza1024]

Salutare, am si eu aceasta masinuta (primita mosternire eu mai avand si un i30 2020)...stiu ca sa schimbat kit de ambieaj la 175000, masina avand acum 205000 face putine figuri...cu motorul rece intra greu intr-a-n 1a , dupa circa 10-15 minute de mers cu ea intra relativ bine, crezi ca poate fii din cauza uleiului ?

[@TheMissingBolt]

Salutare! Da, este posibil. Daca uleiul nu a fost schimbat niciodata sau a fost schimbat cu unul mai gros decat cere producatorul, se poate ca la rece el sa fie prea vascos ca sa asigure o intrare lina in viteza. O data ce apare miscare in cutie (pe masura ce mergi cu masina), vascozitatea uleiului scade pe masura ce el se incalzeste de la frecarile din cutie. Dat fiind kilometrajul masinii si fiind vorba de o cutie manuala, un schimb de unei s-ar putea sa rezolve problema. Eu am avut ceva similar la Opel, unde am pus un ulei prea gros (75W90) si tot asa, intra greu in treptele 1 si 2 la rece; am rezolvat problema cand am trecut la un ulei mai subtire (75W).

[@andreiverza1024]

@@TheMissingBolt îți mulțumesc frumos pentru informații, urmează să merg cu ea la mecanic..sa controleze totul cap coada

[@יוסיד-צ7ע]

is the a filter to replace?

[@TheMissingBolt]

For this manual transmission no, there's no filter to replace.

[@tubeyou1216]

is gearbox and differential basically the same or there is different fluid that goes into diff ?

[@TheMissingBolt]

They are both combined into one unit (it's technically a transaxle). So the same oil is used for both the transmission and the differential.

[@tubeyou1216]

@@TheMissingBolt thank YOuso much for quick reply ! I was scratching my head and i was 99% sure but there was that 1% off doubt ! haha :)

[@TheMissingBolt]

@@tubeyou1216You're very welcome!

[@tubeyou1216]

@@TheMissingBolt one more question,could you tell me is it possible to change valve stem seals on this engine if head is still on the block without valve dropping into combustion chamber if you put piston on TDC ?

[@TheMissingBolt]

@@tubeyou1216As far as I know, it should always be possible to change the valve stem seals without having to remove the head, on pretty much every engine. Since you need to remove the cams in order to access the seals, all valves are retracted and you should be able to turn the crankshaft more easily to bring each piston at TDC as you need. But for the particular details about this Cee'd engine I'd go for a second opinion from an experienced Kia technician, if possible.

[@Italianborn]

Wow i drained mine in my 2012 hyundai ix35 with 135k kms and it was black ! With metal shavings in it too !!

[@TheMissingBolt]

It's recommended to not go past 100K km without changing the transmission oil. Having said that, a very small amount of very fine metal shavings (with a glittery aspect) is expected, since there's always a very small amount of grinding of the synchros whenever gears get changed.

[@Italianborn]

@@TheMissingBolt i haven’t had the car since brand new so i could only do it now..and isn’t automatic, therefore there is no trasmission , is only a closed gear box, and it wasn’t small shaving 🥵🤦‍♂️ there was actually some small metal grinding in there..i hope i wouldn’t have issue

[@TheMissingBolt]

@@Italianborn I'm wondering if you've encountered many times where you had difficulty engaging gears - that kind of forced griding would indeed result in larger metal shavings... and it typically indicates that the clutch doesn't fully disengage when changing gears. Is this the case?

[@Italianborn]

@@TheMissingBolt the clutch it’s so freaking tight on this car you have no idea, as soon as you let go of the pedal it goes..i’ve always known that usually the clutch goes bad when the car moves when you almost let completely go of the pedal, but anyway when i step on gas the rpm and vehicle go well, there’s no hesitation on the engine , when rpm go up the engine goes also up so that is a good sign at least..never mind it all right now i’m having another issue . P0299 , underboost turbo, i’ve checked intake hoses, turbo actuator, cleaned sensors and throttle body which was really build up in carbon residue..the last owner must have treated this vehicle really poorly..🤦‍♂️

[@Italianborn]

Now should take the intercooler off to clean it and ultimately see if changing turbo will fix it but i can’t spend days trying to find the issue with a car in the driveway all apart..so this time i would have to a mechanic and unfortunately leave it up to them..

[@asaadmiadi2122]

Elle a pris les 2 litres ?

[@TheMissingBolt]

Voir à 13:55. J'ai utilisé un peu plus de 1,7 litre d'huile, exactement comme spécifié dans le manuel.

[@tomwang2668]

Spark plugs?

[@TheMissingBolt]

Hopefully this year I'll get a chance to do another full service (oil and filters) and this one should include spark plugs as well. So stay tuned! 😃