How To Check & Fix Auto Choke & TPS In Pulsar 135 LS BS3

[@jyo901]

I bought a new TP sensor but I also need the connector that connects the sensor to the main harness. Where to buy it?

[@M-DIY]

Your bike should have that connector, if your bike's wiring harness doesn't have one then you'll need to repair its wiring. BS4 pulsar 135 don't have TPS, earlier models had that.

[@dharmeshojha3515]

The comment section is a goldmine for 135 LS owners.

[@M-DIY]

True!!!!

[@jyo901]

My TPS was damaged by a mechanic. Should I replace it or remove it completely

[@M-DIY]

Replace it

[@SRINI064]

Very very thank you very important matter thank you 😀🙏👌

[@M-DIY]

Glad you found the video helpful!

[@SRINI064]

@@M-DIY 👍👌🙏

[@balachandar3138]

Hi, mine is 2010 model pulsar 135 LS with issue in carburetor. Since the same model is not available, can manual choke model of later version of pulsar 135 be fitted? Thanks for the useful videos!

[@M-DIY]

Carburetor of BS3 pulsar 135 has a TPS cable which goes to the CDI, whereas in BS4 pulsar 135 there is no TPS because its CDI only has 6 pin connectors as opposed to 8 pin connectors in BS4 version. Along with carburetor you might have to change CDI too and then check whether bike runs fine or not. Another change in BS4 engine is addition of SAI (secondary air injection) system which provides excess air to engine when engine is cold started, so this may be another factor to consider. Search BS3 carburetor on 99rpm in case service centers aren't making it available for you, because that's the easiest and most affordable repair or change individual components in it, that will be even cheaper, I have shown it in this video: kzbin.info/www/bejne/oWWkcn1spLB7g5I

[@RameshSharmaSharmajii]

Bhaiya mere pass 135 cc Pulsar BS3 chauk ka tar laga raha hai to gadi engine race rahata hai aur down nahin hota hai chauk ka tar nikal dene per engine kar race kam ho jata hai bahut pareshan hun bhaiya iska solution bataen chauk ka tar nikal deta hun to chalu hone mein dikkat hoti hai kripya karke uska upay bataya jaaye kaise theek hoga

[@M-DIY]

Temperature sensor check karke badal lo pehele: kzbin.info/www/bejne/pampfWOmp9uEopY Fir bhi issue aaye toh choke solenoid ki functionality ko check karo taaki vo choke ko andar bahar theek se kare, video mein bataya hai. Lastly agar fir bhi issues aye toh CDI replace karna padega, kyonki auto choke ko CDI control karta hai BS3 waale model mein, joki 8 pin waala hota hai. BS4 mein 6 pin waala CDI hota hai.

[@chandrakantindapurkar8738]

How can I get Bajaj Service manual which you showed in video, I want to purchase it Please send me information regarding the manual Thank you

[@M-DIY]

kzbin.info/www/bejne/gqLEY6KmrMekmac

[@afrann1550]

Hi bro, my pulsar 135ls bs3 2014 model thermal sensor cable broken and how to fix that. Yesterday i replaced new carburetor and there is rpm fluctuation idle rpm and running time also rpm fluctuating. And getting missing. Slow speed also lowering at the time of cold start. Bike running was not smooth as before. Whats the reason for this 🤷

[@afrann1550]

Then I noticed that thermal sensor cable was connected to the cylinder block was broken

[@M-DIY]

Watch this: kzbin.info/www/bejne/pampfWOmp9uEopY Check thermal sensor and replace it in case of issues. Cable will need to be jointed in your case with proper sized ring sonnector.

[@shreenathjifashion2296]

Unicorn bs4 150cc (2016) me TPS sensor me zero throttle (butterfly valve closed condition) pe Aur idle RPM pe Kitne Voltage output (factory default) hota he?

[@M-DIY]

Sorry bro, hard to say. Aapko apni bike ka service manual dhoondhna padega usmein saari details hogi.

[@shreenathjifashion2296]

Dear sir, jo bike saath vali service manual book me nahi he aur company vale ko malum nahi, Manual kaha se milega iska suggest karye, ho sake to dhoodhne me help kariye please........

[@vrcvlogger]

नमष्कार 🙏 भाई एक बात बताए ये जो थर्मल सेंसर होता है इसको अगर मल्टी मीटर से चेक करेंगे तो किस तरह से करेंगे मतलब कंटीन्यूटी पर चेक करते है या फिर किसी ओर पर

[@M-DIY]

Thermal sensor ka resistance check karte hai. Room temperature (25-30 degree C) pe resistance service manual mein diye gaye values se mila ke dekhna padega.

[@ramchanderbishnoi]

Bhai Mera pulsar 135 LS 2013 model auto chock h. Vo slow rpm pe automatically bnd ho jata h. Ideal rpm pe start nhi rhta konse se sensor me problem h or online konsi site se sensor order kren please btaye.

[@M-DIY]

Auto choke ko signal toh CDI deta hai, toh most probably wahi faulty hai. Ek baar temperature sensor ka resistance bhi check karke dekhna, kahin usmein fault na ho. 99rpm website pe aapko spares mil jayenge.

[@ramchanderbishnoi]

@@M-DIY thanks for replying 🙏

[@suvomyself]

Sir ji mera bs3 pulsar 135 ka carburator change kiya 2 din huye but new carburetor pe jo tps coupler laga hua tha wo thoda purane wale se alag tha isliye purane carburetor se wo tps coupler nikal ke new carburetor pe laga diya isse koi problems hoga kya?

[@M-DIY]

TPS sensor ki adjustment karni padti hai nikalke lagane mein, agar karni aati hai toh karlo nahi toh rehnedo. Waise maine videos mein bataya hai use set karna. Baaki service manual par next week video ayegi.

[@suvomyself]

@@M-DIY sir ji carburetor main jo laga hua tha wo purani wala se laga diye isme kya mileage ki problem ho sakta hain?

[@M-DIY]

Nahi, agar RPM and engine ki running mein koi farak nahi hai toh nahi ayegi.

[@balajidange2280]

Bro..mere pas bhi 135ls hai..maine haal he mein engine work karaya hai..but iske baad engine ka sound weird ho gaya hai aisa lagta hai ki block se 'tak tak' jaisi aawaz aatai hai..mistri bolta hai ki kuch din baad engine set hone ke baad aawaz band ho jayegi kya ye sahi hai?

[@M-DIY]

Isse aapko aur jaankaari milegi: kzbin.info/www/bejne/qIfLYX6Yer2Zpsk

[@sunilsoni39]

Sir pulsar 135 ka fuel mixture ko kaise set Karen ki jo milage achhi ho jay

[@M-DIY]

Video banaunga ispe

[@vrcvlogger]

नमष्कार🙏 काश आपके पास पल्सर 135cc ना होकर के डिस्कवर 150cc होती जो 2010 मॉडल है तो बोहत ही अच्छा होता वो इसलिए क्योंकि हमारे पास डिस्कवर 150cc बाइक है 🙂 बस हमे तो इसी चीज का इंतजार है कभी तो हमारी बाइक की जो सर्विस मैनुअल बुक है वो कही ना कही से तो मिलेगी जैसे आपके पास है उम्मीद है कि आप भी हमारी हेल्प करेंगे हमारी बाइक की सर्विस बुक को ढूंढने में

[@M-DIY]

Maine kaafi time lagaya discover 150 ka service manual dhoondke ki, lekin kisi ne bhi is model pe service manual nahi upload kara hai. Discover 150 bohot hi kam chala tha, pulsar 135 LS se bhi kam, toh aap samajh sakte ho. Online nahi milega iska service manual, aur service center pe bhi mushkil hi milega, zyaadatar service center andaaze se kaam karte hai. Kisi service center se request karke dekhna padega aapko.

[@decentrider7740]

Fuel gauge repair ho sakta hai kya ?? Bs 3 ka If yes please upload a video on it

[@M-DIY]

Dost reliably repair karna mushkil hai. Personally maine repair nahi kara isiliye keh nahi sakta.

[@KBINDIA]

मेरी बजाज पल्सर 135 ls में nutal lite permanent on rahti hai चाबी ऑफ करने के बाद भी, इससे मेरी बैटरी ज्यादा खर्च होती है मैं गाड़ी को गेर मैं डाल कर रखता हूं जिससे लाइट बंद रहती है इस problem ka सलूशन क्या है

[@M-DIY]

Maine aisi dikkat ke baare mein pehli baar suna hai, no idea.

[@shashankpawar9163]

@@KBINDIA Bhai Meter problem hain tumhara, Barish main Aap meter cover use kijeye.

[@shashankpawar9163]

@@M-DIY Hello Bhai Agar Hum 10 saal purana pulsar 135 engine khol ke engine Restoration karein toh Pehle jaise new bike thi Same average denge kya ? Thanks you

[@adityamishra707]

Bhai meri 135 ls 2010 model hai usme clutch lene pe exilatar bad jata hai ..macanik bola hai ki carvator chang hoga itni purani bike itna paisa nahi lagane chahta pls help ..aur apki location kya hai

[@M-DIY]

Clutch aur accelerator cables ki conditions theek hai?? Aur unki location sahi jage se jaari hai ki nahi? Kai baar clutch aur accelerator ki cable ki housing aapas mein ada ke mechanic laga dete hai, usse dikkat aati hai, handle modne se bhi race badti hai un karano mein. Carburetor 2500 ka ayega, joki kaafi mehenga hai purani bike mein lagane ke hisaab se. Main delhi mein rehta hoon, lekin main mechanic by profession nahi hoon, isiliye main aapki sirf videos se hi madad ka paunga.

[@KBINDIA]

Thanks 🙏

[@aniketb9264]

pulsar bs3 135 jabbhi Gear change karne ke liye race kamm karta hu to auto race badd jata he like rpm 20 pe hota he to 30 tak jake fir 2-3second me down hota he please problem ka solution hoga to patavo my bike is totally in good condition time to time service and average is also good 45-50kmpl in city

[@M-DIY]

Carburetor kab service karaya tha? TPS sensor check karke badlo. Is video mein carburetor pe aur jankaari hai: kzbin.info/www/bejne/oWWkcn1spLB7g5I

[@aniketb9264]

@@M-DIY bhai survice to 1 month pehle hi ki he or ye problem mechanic se bhi nahi salve ho raha he carburator change karne ko bola he or vo bohat mehga he 3050 ka to koi or solution honga to dekho plz

[@M-DIY]

Carburetor ki service kab kari thi? General service ki baat nahi karra.

[@aniketb9264]

@@M-DIY ji carburetor ki hi service ki thi or jo rubber tube jesa hota he o fat gaya tha to usse change kiya tha

[@M-DIY]

Dost aise keh paana mushkil yai, kyonki aapke mechanic ne kya kara hai aur kaise kara hai yeh toh wahi jaanta hai. Main aapko videos se through information hi de sakta hoon.

[@nishantagade1020]

Service manual kaha se mili bhai, bs4 ki kaha milegi

[@M-DIY]

Download here: docdro.id/ymBlp8D OR www.scribd.com/document/448727632/Pulsar-135-Service-Manual-Training-Notes

[@dharmeshojha3515]

@@M-DIY Thanks.💛

[@randomfile1]

Sir ls 135 bs3 k mileage kitna hoga please bato

[@M-DIY]

55-60 kmpl

[@ajitsahu3445]

Mere pulser 135 ls me sahi tuinig nahin rahata hai kabhi kabhi tuinig race hojata hai toh kabhi bilkul bandh hojata hai please batana sir kyun aisa horaha hai

[@M-DIY]

Carburetor kab service kara tha?

[@kiranmv4701]

My pulsar 135 ls had choke problem where choke used to be on forever. Now with good mechanic, i replaced auto choke and now ut gets ON everytime when engine is started. Is this normal??? What is the exact solution

[@M-DIY]

If after getting on, it gets off automatically after a while, then it is normal, watch complete video for detailed information.

[@kiranmv4701]

@@M-DIY it will get off but it gets turned on on every start.. It should turn on only during cold season or morning times. Is there a way to change thermal sensor alone? I guess problem is with thermal sensor. I don't understand hindi much

[@M-DIY]

Note the engine temperatures in Celsius and auto choke solenoid turn on time in seconds respectively: Less than 15= a minute or two 15-20= Few seconds 20-25= Fewer seconds 25-30= Very few seconds More than 30= choke off If your auto choke system is working within the following limits, it is nornal.

[@kiranmv4701]

@@M-DIY thanks noted it. Can you help with sharing the manual used in video. I can go through once it will help me a lot. I m facing this issue from 2 year. Not able to get proper manual. If not off atleast send me choke related pics , to 9611020998 in whatsapp. Please bro ir will help me a lot

[@M-DIY]

@@kiranmv4701 I will post a video on user manuals of this.

[@SonySingh-yj3vm]

Meri baik bjaja 135ls hia or bo res jada or com hoti hia keaa hua hia usko bahi

[@M-DIY]

Carburetor last kab clean kara tha?

[@chinmoypati3115]

Does pulsar bs4 engines has TPS ??

[@M-DIY]

Pulsar 135 doesn't, I can't say about other Pulsars.

[@uniquerider694]

Ye wala book chahiye mujhe kaha milega ..

[@M-DIY]

kzbin.info/www/bejne/gqLEY6KmrMekmac

[@lovepreetmuktsar3727]

Bhai pulsar 135 bike slow thik chlti hai race dene per bnd ho jati hai or filter jo hota hai uske piche hath rakhne se race pakad laita hai lekin haath hta dene k baad fhr wahi problem hai

[@M-DIY]

Fuel kam milra hai aapki bike ko, lagta hai main jet block hai, isiliye band hoti hai race dene pe. Yeh dikkat carburetor ki service karne se theek ho jayegi. Is video se aur jankaari milegi: kzbin.info/www/bejne/oWWkcn1spLB7g5I

[@lovepreetmuktsar3727]

@@M-DIY sir jet bde wala new bhi daal diya fhr bhi whi problem hai

[@M-DIY]

Hmmm. Baaki carburetor components ache se check kar liye video ko dekh ke?

[@darshanarajapaksha8136]

this book pdf plz

[@M-DIY]

kzbin.info/www/bejne/gqLEY6KmrMekmac

[@vrcvlogger]

TP सेंसर को अगर मल्टी मीटर से चेक करना हो तो कैसे करेंगे

[@M-DIY]

1:16 se video dekho

[@ganeshrajrv4700]

I disconnected auto choke

[@rjvlogs1343]

Tps sensor price

[@M-DIY]

Kaunse year ki bike hai?

[@BabluSingh-qn7bz]

भैया हमारी गाड़ी पल्सर 135 रेस कम ज्यादा हो रही है इसके लिए क्या करना चाहिए हमने टाकी के नीचे जो क्यूट रहती है गोल गेट सिंगल वायर की उसको नवी बिठाई है फिर भी रेस कम ज्यादा हो रही है और कारबेटर उसको अच्छा प्रेस कर कर बैठा दिया फिर भी रेस कम ज्यादा हो रही है

[@M-DIY]

Carburetor ko service kara hua hai ache se? Carburetor ke jets saaf hai?

[@KBINDIA]

Pulsar 135ls बाइक गर्म होने के बाद रेस बढ़ जाती है,race kam karte Hain तो जब गाड़ी ठंडी होती है तब स्टार्ट नहीं होती इस समस्या का निवारण करें 🙏

[@M-DIY]

Koi nivaran nahi hai iska. 1500 pe rpm se karlo, best hai, baaki thanda engine band hota hai shuru mein, vo normal hai, choke dene se jaldi engine warm up ho jaata hai.

[@M-DIY]

Choke related video toh maine aapko pehle hi bhejdi thi.

[@M-DIY]

Dost aap decide karo, aapse zyaada aapki bike ki condition ke baare mein main nahi jaanta.

[@varatsinghhamal2343]

Vai hamabe chaya carbater chaya 135 la pulsar

[@M-DIY]

Service center ya 99rpm se mil jayega aapko.

[@enowhealthad5050]

No english subtitle? 😳

[@M-DIY]

😓 i will try to add them sometime later on, don't worry.

[@enowhealthad5050]

That would be great. Thank you