VW/Audi Fan Relay Cooling Fan Control Unit Module Relay

[@dorianpannell9046]

Im a 20 year Tech and a Army vet used your video to verify my problem on personal vehicle great part is new modules are only around 40 bucks, keep up the good work!

[@autremen]

Great video, you saved me a lot of money. My fans were switching on and off every 5 seconds from the time I turn on the car. Changed out this part and it fixed the issue. Thanks a million.

[@hakeryk]

Is Your engine was going to 1100 rpms when this was happening? Because my fan is starting randomly and enginge rpms are going from 900 to 1100 on idle.

[@autremen]

@@hakeryk yes the RPMs did go up slightly, I believe it is because when the fans turned on the altenator would have an extra load on it and to compensate the engine would speed up a little to keep from stalling. I'm no mechanic it's just what I believe.

[@hakeryk]

@@autremen ok, so this might be worth to check. Thank You for reply :)

[@gregoryalpizar189]

Same problem here. My fans were switching on and off at first and the AC wasn't cooling as expected. Heard a weird noise (clicks) coming from that box and then the fans just stopped working. At that point, a blue-ish/Black-ish smoke started to come from the exhaust. I replaced the box with a new one and all problems solved :)

[@AM-yd8xi]

labor intensive job and if you're out of shape like me, it will double the replacement time. It took me a little over an hour and thats with on and off rain. I just unhooked connectors from the top, I did not unhook connectors from bottom. It was much easier this way. The bear was unsnapping the smaller of the connectors from module terminal. The key was to listen to the ''click'' while inserting flat tip screwdriver. I did the whole job as he instructed Wouldn't have found module or been able to complete job without this video. Really helpful and thanks for taking the time to share your knowledge! BTW, I did it on my 2001 Audi TT so instructions and part are the same as this video describes.

[@ryansavage3675]

THANK YOU! No one ever shows how to unclip those damn harnesses. That's all I needed. THANK YOU THANK YOU THANK YOU.

[@amicosta753]

I bought this VW beetle 2000 for my wife. From your videos i was able to fix the radiator fan, thank you for that! My problem now is the AC is not working and neither the heater. The blower only works on the maximum speed number 4. Even putting it on the highest speed the AC does not work, it only blows regular air. Thank you for all your help, you are the best!

[@rolfgerig9829]

Jamie Jones, thank you for all that information, brilliant! You are the first American I have come across to talk metric which I can immediately understand. The US appears to be the only country on this globe left adhering to the somewhat outdated and most impractical system of Imperial measurements except for aviation and nautical industries. Cheers!

[@Fabyfakid]

My 98 Beetle was giving me all sorts of problems, first the fan wouldnt turn on unless the ac was on, then the fan wouldnt stop spinning even when the car was turned off, removing the module was a bit of a pain but definitely doable, maybe a two person job if you got fat arms like mine hahaha, found the module on amazon for like $20, free shipping, replaced it a few days ago and the problems are gone, thank you so much for the help sir :)

[@jamiejonesthecarman]

+Fabian Rivera awesome great job

[@carlgallerbuilds7990]

Great video Jamie! Really helped me with my fan control module replacement! Hey, I'm a fair to middlin' wrencher and wondered if I could do the R&R from below...and guess what? Knocked out the whole job in 15 minutes with the car up on ramps and me on my back. I just uploaded the video to my Carl Galler Build KZbin channel, and gave you a BIG shout out for your guidance! Thanks brother!

[@jamiejonesthecarman]

That’s awesome brother

[@carlgallerbuilds7990]

@@jamiejonesthecarman here's the full episode, if you're interested. 👍 kzbin.info/www/bejne/b3jbaoetpM12jsk

[@p.vargas5021]

This video helped me. My A/C blows really cool air. The compressor was switching on and off, the fuses were all good. The second fan would not kick on like it should. Anyway this was not easy to remove, But I got it done..thanks guys..

[@laynewestbye]

Hey man, Got an old vw polo, and I've been beating my head against the wall on this cooling fan issue. Replaced temperature switch, measured voltage etc. Replaced temperature sensor... And here you are, like a blessing from above 🙏😇 appreciate your video, and the informative presentation, was awesome ✌️😎 👍👍👍

[@LuckyEdit]

Dude your simple yet awesome video prolly saved me $100s of dollars! Thanks!

[@jamiejonesthecarman]

Yeah I don’t know why volts wagon so weird but that relay thing I can’t tell you how many of them go bad it’s ridiculous

[@meirseluk8410]

@@jamiejonesthecarman thanks man you help me a lot with this video

[@hm3426]

Thanks, guy. I know the video is 2015. But, it is helping me today. My friend had issues with his 2000 VW Golf 2.0 Liter engine fans and this video came in handy.

[@josephcarter7]

Thanks I swapped mine out on my 2004 new beetle TDI and now the Air Conditioning works and cooling fans turn on woo hoo thanks!

[@firedup4653]

You make videos cause your bored....a man that can fix things is never bored

[@timbo9768]

Thank JamieJones, I have been blowing through these on several Mk4 Golfs, but need to note the 2003 GOLF VR6 uses one with an "N" not a "K" and Gates, which makes aftermarket ones, also has it listed as a separate part number. What I have found after replacing six of these on a few cars recently is that the cheap clone units I bought use a thinner gauge relay which is less tolerant of the aged electronics in older cars (old fans pulling too much current, corroded wiring and fuse box, etc.) All the ones I opened up after a failure had melted relays, and all were clones I got for $25 or so. Thanks for all you do to help us fix this stuff!

[@jamiejonesthecarman]

cool tks for for the info

[@mekishalemke8873]

Your videos are Wonderful! ! You use 'easy to understand' phrases, instead of a bunch of technical jibberish. Haha. I subscribed to your channel the first time I watched. Your videos have helped me fix Numerous problems with my Bug. VWs are confusing and aggravating lil ol things, but I got too much work in it to just give up. And not to mention the Outrageous Prices at the dealer and most mechanic shops. HUGE THANKS TO YALL!! Keep up the good work! If you ever do any Interior fixer upers that would be Great!! I will be watching.. 👍✌👍

[@11SEXMACHINE]

Ahhh haaaa!!!! So that's why the ac doesn't work. I did a diesel purge on my 99 beetle and noticed the fans didn't come on. The ac has never blown cold so I wondered if the two were related. Great video, I just discovered you and will be watching!

[@mrmpholeonard1075]

Good info... really helpful. guys are killing us with their crazy charges here in Africa. Thanks

[@Danpgood]

My 2009 Volkswagen Jetta started overheating a few years ago, I soon realized that the fan was working erratically. For example, it never overheated while running on a hot day when there was no traffic - only in stop and go traffic. It seems when air was moving through the engine, the engine stayed cool. Recently, the fan stopped turning off at all when I turned off the car, it would keep running until the battery drained. Now, every time I park the car, I have to unplug the battery to keep it from being dead when I return to my car. I'm going to try to change out the relay myself and see if that fixes the problem. I'll respond if it solves the problem. I appreciate a 25$ fix over a 750$ fix from the mechanic!

[@johnwetu5227]

Yes John, did you fix the problem.? I have jetta 5 2009 model with issue of fan staying on.

[@Gustave67]

Thank you!!!! Fixed my Mom's 1997 Jetta... Your the man!!!!

[@davidg2549]

Was your moms car overheating?

[@iangeraci]

This is a great help. My 02 jetta 1.8t fan is turning on too late and my car is overheating. Thanks for the great video.

[@pedroariza3436]

Amazing video, long time subscriber!

[@soyeldiego4878]

You guys are so cool! Thank for the great info. Will be working on this project this weekend...I’ll have a beer for you guys too 🍺

[@elisabethvallieres8106]

Best video yet for this situation

[@wranglercjseven69]

i just did the same on my 2002 audi tt loved your video brother very down to earth to the point and fun hope you got your beer lol if not ill send you one of mine

[@piercemyers4281]

was it in same spot

[@sizweamos9455]

I was sure you were about to hit someone at the beginning of the video!!! 😹😹😹 good one mate.

[@ramongalavis3328]

Absolutely nice Video thanks for Share . Greetings from Venezuela ❤

[@timdunning7724]

Thanks for the video! I am in the middle of this job, my issue was a broken wire but I also suspect the relay. I just ordered parts. mine is a 1J0919506Q, which I believe is compatible with the K? it is a 2001 Jetta wagon TDI. My understanding is that if it is the 14 pin it will work, thoughts? Thanks again!

[@justinteabo1619]

Great video helps me out.wish there were more you tubers out there to help with cars. I do have a question tho. I'm thinking I need to replace the fan relay like in your video but is there a way to test the relay before getting a new one or two from the junk yard. my fans don't seem to kick on and after driving for like 10 mins in starts to overheat I have a 2001 jetta 2.0 If you have a video already could you point me in the direction of it. Thanks in advance!!

[@anthonythomas1323]

How wold I test my VW Jetta 2002 gl radiator fan to see if it still works

[@MrJinwright]

Thanks Jamie I just bought one today with P0480 and P0481 I think this is the fix

[@JustMagicTrack23]

Hi, I am trying to find the cooling fan control module on a 05 VW Golf, Australian model. Just wondering do they all have a control module. This one has a module on the back of the main fan, but for the life of me I can’t find the relay you all talk about. The fans and AC compressor are not working.

[@jamiejonesthecarman]

OK not 100% sure on the Australian models but generally it’s hidden somewhere underneath the bumper cover inside the bumper but when you do find it come back and post so other people can see it because they had that thing everywhere so the more people we can get the share of the better off it is in good luck

[@shelleytucker2054]

I own a 2003 vw new beetle 2.0. Is there a way I can check the control module with my probe light or multimeter before pulling it? If so could you please explaine how to and ball park figure of good readings or what pins do i probe??? Any suggestions, advise would be greatly appreciated. And by the way you and your wife's videos are awesome. Thank-you, Shelley T.

[@jamiejonesthecarman]

Generally speaking that module generally goes bad and you can tell it’s going bad by there not kicking on when you turn on the AC or if it runs and doesn’t cycle or if it runs and stays on it doesn’t shut off

[@aymanshwayyat8880]

Good job, but I just got 2013 VW Passat TDi both fans won’t come on? Any help

[@maxximum18]

Good vid man Now i have to find where mine is on my 2008 jetta is it in the same place as the car you are workin on

[@dominiqueeybers9186]

Power to my ac do not go over 4volt, iv read some articles that say this relay can be my issues. Can it be?

[@jamiejonesthecarman]

Absolutely this 100% can be your problem

[@dave2574]

I have a issue where the fans only some on when the temp gauge gets to 3/4. And the fans do not come on when the AC is turned on. Is it likely to be a issue with the relay box you showed in the video?

[@40games]

So if that solder joint is what usually cracks do you think just resoldering could fix or does the componant on the PCB go bad too?

[@ellisfreeman7050]

Thanx for the informative video ...how do I replace a fan control module 2008 Audi A6 with 3.2L

[@mehrzad2200]

Thanks man...my 98 Golf Mk4 has issues with this part and I bought a new one with the number ending in E and I'll change it as soon as in arrives

[@OscarRodriguez-py7xk]

Good explaining, I have a 2003 vr6 fan are good but no high speed, how can I test my fan module and can I use a 2004 jetta module will it be comparable

[@rogerlee2]

I’ve been trying to locate this fan module on my 2007 Jetta 2.5 and haven’t been able to find it. I’ve searched the internet and have had no luck. Is this the same setup and location for my MK5 Jetta? Any help is appreciated. Thank you

[@christopherrichardson6092]

You're right bro... NO money... but some time ... wicked cool - one big family of DIY!! ;)

[@madhavas.8103]

Ur videos r awesome and I have a 1.5 TDI the cooling fan runs fast and vibrating , any idea of the problem ?

[@gedman9527]

Is this.the same on 2005 Skoda Octavia they are vw based aren't they ???

[@njroyalty]

need this vid for a 2012 passat- fan won't cut off .

[@jamesdice1491]

Do this controls the electric ac fan too on 04 vw Passat b5

[@leeisenberg]

Hi, thanks for sharing. Where is it located on the next gen 05-2011's? Just replaced the AC control valve in my 2006 Jetta, charged up the freon; Nothing, same crap, just blows ambient air. AC fan NOT kicking on w/ the AC switch on dash. Do I need to bypass the high pressure switch? Had to on a friend's car to get it to start working. How do I bypass the high pressure switch? Inspected connector at high press switch, looks fine. Any idea/s much appreciated. - thanks, take care

[@thefuturecmb]

I just replaced in my Jetta. My new fans aren’t turning on when AC is on. I replaced it with a new fan module but still nothing. I have checked my fuses all good there too. My fans and fan motor are new and work when tested. Any other ideas ?

[@jamiejonesthecarman]

So that particular model gets its signal from a few things like the engine coolant temperature sensor are also there’s a few relays what would be nice if someone could put it on a scanner for you that can actually test the system that be the way to do it you can do that pretty inexpensive my scanner does it but I would think you can get about any shop to run a scanner on it and pinpoint it and it be cheaper than keep trying to switch out parts because you’ve already done the basic if it’s not the module are you sure the fans work

[@jamiejonesthecarman]

Oh my bad I just seen where you said you put brand new fans in so if everything’s new then you’re probably dealing with a relay or some break down in the system electrically so I would definitely put it on the scanner you should be able to get it done for 50 to 100 bucks

[@jamz90210]

I’ve got a 1.6 fsi and the fans are constantly running from start up, I’ve replaced both coolant temp sensors and flushed the system, would this be the next part to replace?

[@ismaelcarrillo3956]

Good video. Same fix for a 2014 Jetta with same problem?

[@tanyonderrick168]

long shot but i got a 2014 jetta as well, did you ever get yours taken care of?

[@carlosgudiel1501]

Will this help for a 2014 passat??

[@dgrima3214]

I have a 2007 2.5L VW Jetta, I have been trying to Google the location on mine but cannot seem to find the location for it

[@jrlopez3749]

Can you tell me what you think about 2000VW2.O GOOD CAR OR WHAT I GOT FAN TROUBLE BUT I LIKE WHAT YOU SAID THANKS

[@jairodiaz812]

Do you know if a 2013 Jetta tdi has one or there in the fans?

[@johncowan5924]

Hi does this relay control the heater fan inside the cabin too

[@mikejacklyn1221]

Hi Jamie, I have a 2017 golf, do you know the part number for me? I’m in Canada and my module died after a battery boost, dealer told me $871 for the module ugh 😮

[@lincolnburns4996]

Hi. I don't have ac running. And no slow speed fan just high speed at 105. I jumped the hi lo speed wires and only high works. could this module be the cause or is it my slow speed resistor thanks ?

[@earlwright3613]

So is this before or after you replaced the radiator, I need to know because I'm working on a 99 model and just the auxiliary fan isn't working, and I replaced the radiator already and the thermostat. I had to replace the radiator because she wreck the car. The fan on the passenger side works great just the auxiliary fan isn't.

[@michaelhammond9459]

Is this same part on a 2013 tdi Jetta ?

[@erickalukonya35]

i have a 1999 mk 4.does it also have fan relay cooling control unit module coz i bought mine which was dead for 8 years which i think i must have been vandalized coz my cooling fan are connected to the battery.

[@Awkwardlife]

Is there something that causes them to go bad? A cause for them to fry? My car has been over heating this problem caused bigger issues in my car u had to fix.. my first relay from the junkyard worked but my fans are being temperamental again and over heated today 2ce had it towed...

[@dentasla]

I need to run to pull a part....Ill stay with Y'all

[@jamiejonesthecarman]

Yeah not too bad of a job

[@MrGuz45]

I have 2007 VW jetta with a error code p2181 and I noticed when turning on the AC that only one fan works. Does this fan relay solve the problem. Thanks

[@lendellkatwaroo7371]

This is an awesome video! Really helpful. Cheers!

[@jamiejonesthecarman]

+Lendell Katwaroo yes that little piece of information helps when you need to know what it is LOL

[@naaflewis2586]

Hi Jamie, my audi a3 2009 tdi ac light is just blinking. can you help me fix it?

[@jamiejonesthecarman]

More than likely it’s going to be in that relay that we talk about but you’ll probably need a scanner to isolate the problem

[@terrancehill6433]

Hey there Jamie! I bought my daughter a 2014 Jetta last year and her car overheated the other day and I noticed the fans weren't spinning in the front, took it in for an oil change at the dealer and they looked at the cooling system. Told me they needed to "retrieved DTC P194600: Radiator Fan Control Module 1 Faulty/Open circuit in voltage supply from BCM. Fans do not activate with AC on MAX or with output diagnostic test mode. Recommend replacing both radiator cooling fans to correct overheating issues. Would this be a similar fix and should I look for the same Fan Relay Control Module on the 2014? Thank you sir!

[@alfiesurguy2232]

Is this a single or duel fan module

[@woodysmothers1887]

Will this video hold true for a 2015 Passat?

[@robinbeasse269]

Hoping you can share if that might be causing my 2013 vw beetle tdi radiator cooling fan to stay on? Only goes off when battery is dead.

[@jmedrano8854]

Radiator fan switch. Also a revised ECT sensor, it should be green. check the fuse box on top of your battery. the cable from the alternator shorts the fuses in that box, so if you see that replace it. 15$ on Amazon!

[@migueljuarez5141]

Thank you sir i was breaking my head figuring this out i will replace this module i hope it fixes my problem

[@eugeneyep]

And what? How is your fans now? Removing module controling fans was helpful?

[@karafyllos]

Is it possible to keep the air conditioning compressor always engaged by faulty module?

[@Jesus-hx5vg]

"Can I get a beer yet?" LOL WHAT 🤣

[@bertcooley8471]

Is this is the part that will cause the duel radiator fans to continuously run on high speed when the car is started and running at normal temp on a 2012 VW Passat. This occurs with the a/c on or off and the fans do kick off when the car is turned off.

[@fsd34760]

Would the Fan Relay Cooling Fan Control Unit Module Relay cause the fuse to pop?

[@chrisgrab2745]

Can you tell me the part number/ letter for 06 A4?

[@nbpt1000]

Nice info and well done. Thanks Jamie, and the same to your side kick.

[@jorgeislas2105]

Gracias bro i like your video saludos From Mexico good information!

[@stevenlynch6605]

Did you just happen to have front bumper and other parts off, or can fan relay be done with parts on? Thanks Excellent info!

[@jamiejonesthecarman]

No problem with it on the car

[@stacksflat7482]

i noticed my fan sensor is bypassed and the fan works erratically also my ac ain’t working! i wonder is it same for me B6 audi

[@timothypoblete8376]

Thank you for your great videos. I replaced my 2 fans, FCM and pressure switch fuses looks good to but I can't get my left drivers side fan to work when I turn on my A/C. I am trying to get my a/c working could it be my freon is to low? Thank you for your time.

[@nv0643391]

Hello :) so i swapped this part out and still no luck on the fans turning on! Any idea what else i can try?

[@geraldbosha6048]

can i use a fan module with part number letter K instead of L I don't seem to be getting the part number with L?

[@stoltzk]

Is the relay located in the same location on the 2007 Jetta?

[@craigsteenson5257]

Hi there need help, done all test like test fans low speed works and high speed works when i put cilp into the 3 pin plug, ok i so got a new box as there was bad ground wire, and got two coolant temperature sensors one for rad one for the clock fit it all and when i put ac on or in my car a snowflake fa happin no fans???

[@FranciscoSanchez-ft6gv]

Do the 2008 Audi A6 Quatro have it

[@HyDra312]

do u think this relay can cause my fans not to turn when i turn the ac on? my fans seems to be okay since they turn on when the engine start to get hotter ? thanks

[@horacewilliamsiii1194]

CAN YOU TEXT ME WHERE THE 2006 VW BEETLE CONVERTIBLE 2.5L FAN MODULE RELAY IS LOCATED WHEN STARTING THE CAR FANS KICK ON HIGH SPEED IMMEDIATELY.....

[@phearumdy807]

2005 jetta gli. I'm having issues with the radiator fan and A/C not working. I checked my all my fuses and they're all good. I also changed the relay( the one in the video) and still nothing...

[@11SEXMACHINE]

Have you found the problem yet? Just wondering because I have the same problem on my 99 beetle.

[@Khalid81751]

Hey there my car have problem the radiator fan non stop?

[@blackericdenice]

So you are saying the fan controller control my a/c compressor?

[@blackericdenice]

I bought a new fan control unit and my a/c is still not coming on.

[@keithott247]

I have a "99 2.0 beetle. I got the wire harness off the old relay. Ordered and received the 1J0 919 506K relay. The wiring harness plugs are too small for the relay sockets. I can't tear it down and get the old one out. Is it possible I have an older H model?

[@killerbeargaming6707]

my wife's 2000 vw beetle is getting hot. the cooling fan will not come on, but they work when I turn on the a.c.. is this the same problem you had?

[@reginawilliams378]

•KILLER BEAR• do you mean the heat

[@alejandroarredondo1997]

JJ, what if the realy has been replaced and you still have no power going to the fans? I would love to see a video on troublesshoting this whole subsystem, as summer is coming, and i live in Phoenix, the testbed for Sun explorations.

[@lite1979]

If you have no power going to the fans, it could be the fuse on top of the battery. The fuse tray there is notorious for warping/melting and breaking the connection to the fan fuse. I would also check the radiator temperature sensor. Pull the connector (it's in a really tight space in my '01 Audi TT), jumper each of the pins to ground and see if your fans come on.

[@jesustrevino3088]

Thank you for the video,

[@dillongarciajr]

Great video, can you tell me where this is at on a Volkswagen Passat 2.0? Im have fan issues , I've battery tested them , they run but do not come on when suppose to

[@fancy8365]

Same did you find out where? I have same car and even replaced fan

[@dillongarciajr]

@@fancy8365 replace the main cooling fan , it has a built in control module , I ordered from carID.com

[@fancy8365]

@@dillongarciajr all man already did that....and the ac lines and the thermostat. The ac is working now. But the outside of the engine is so hot but never smokes or gets too hot. My gauge seems to never go over half way. But feels way hotter outside hood of car.

[@dillongarciajr]

@@fancy8365 if your main cooling fan is working , and your gauge doesnt go over the middle , youre good, I also changed the thermostat, and the COOLANT SENSOR, knuckle busters! Change your Coolant sensor, its on the hose to the thermostat ,

[@fancy8365]

@@dillongarciajr great info!! Thanks I'll try it out. I think I need a new battery right now. Been using the battery pack to start. Lol But I have been getting a weird message on my dash about the Acc cruise? I can't see anything like miles per gallon left etc in the center. I did not know this car even had an acc cruise? I hope something didn't happen to my computer. I tried putting the key in like 1 min without cranking and turning the wheel. That's why I watched this video. I can't find my relay unless it's in the usual fuse box under hood on drivers side by battery ...Also wonder why the ones in my car have post but some online say the correct one is 5 post. Thanks so much for your help. Yes my hands are so tired from all this bs. But if you know what would cause the cruise message would be amazing? It's been 2 weeks it still isn't corrected itself like some said it would

[@robinpersaud547]

Hey there, just came across your channel i have a 07 vw touran and both the ac and cooling fan works continously, it was in a accident but the radiator was untouched. Any idea what could cause that, thanks

[@armandomonroy5251]

No metter if finish with G in those codes?

[@LottieJohnson-w8b]

My 2000 6N2 doesn't have air con and I can't find this module anywhere. Please help!

[@jennietull]

I just replaced the compressor in my 06 2.5L beetle. Now there’s no power to it and the radiator fan doesn’t come on. Do you think this is the issue? Thanks so much!