Never Ignore Overheating Problem Of Your Motorcycle Engine | Causes Of Bike's Engine Overheating

If your feeling your motorcycles engine heating at your foot, there can be a major issue inside the engine. Sometimes it is normal for the new bike's engine to overheat but if the bike is old, is is a big issue.
Engine Overheating - Causes and Ways to Prevent it : • बाइक के इंजन में ओवरही...
CAUSES AND WAYS TO PREVENT IT
Initial start: When you crank up your motorcycle to leave for work everyday, please do not over rev the motorcycle as soon as you start it. Keep the engine at idle for a few minutes and let the engine oil do its job. This process is called engine warm up and doing this will keep your motorcycle’s engine healthy.
Carburetor setting: The mixture of air and fuel entering the engine cylinder must be correct in order to overcome overheating of the motorcycle. If air/fuel mixture entering the engine is lean then there are chances of your engine overheating. So setting the carb to give a perfect mixture is really important.
Engine oil check: Always keep your engine oil at check to overcome engine overheating. Low engine oil will lead to inadequate cooling of the engine. Engine oil must be changed at correct intervals for a healthy engine life.
Coolant check: Liquid cooled motorcycles come with a radiator setup which circulates the coolant inside the engine to cool the engine effectively. Proper coolant capacity and a perfect mix of the coolant with distilled water makes way for efficient cooling.
Faulty radiators and radiator fan: Radiator is a part which circulates coolant into the engine. The coolant when circulated, carries all the heat. If the radiator is covered with dust and waste particles, the heat dissipation will not be complete and the coolant will not cool enough to enter the engine again. Keeping the fins of the radiator clean is a very important part to aid for better cooling.
Radiator fans are used to cool down the coolant in the radiator when the motorcycle is stand still and the coolant temperature exceeds. Improper functioning of the fan leads to consequences.
Coolant leak: Make sure the coolant level is correct at all times. If the level of coolant is below the recommended level, immediately top it up by adding distilled water to avoid heating problems. Fix the leak, if any and continue riding.
Riding at high speeds for a long time: Riding at high speeds for a long time means keeping the engine revving high. Revving the engine high for a long time will keep the pistons moving and the combustion of fuel takes place without a break. Its best to stop the engine and let it cool for about 10-15 minutes and carry on while taking break intervals thereafter.
#Motorcycle #Engine #Overheating
My Moto Vlogging Gears :
1. My Vlogging Camera (GoPro HERO9 Black) : amzn.to/2MUeDHq
2. Mic (Kodak M11) : amzn.to/3qskRNl
3. Mic (Boya BYM1) : amzn.to/3pRxscL
4. Go Pro Accessories (61 in 1 Action Camera Accessories Kit) : amzn.to/39IX06d
5. Helmet (Steelbird SBA-1) : amzn.to/36GA7OK
6. Helmet (Studds) : amzn.to/3cFrBnh
7. SanDisk Extreme uSD Memory Card : amzn.to/3oLhMGM
8 . GoPro Hero 9 Media Mod : amzn.to/3qrcwts
9. Riding Gloves 1 : amzn.to/3gEnmrK
10. Riding Gloves 2 : amzn.to/3nf5Wos
11. Riding Face Mask : amzn.to/3hcEl4U
12. My Bike : • Why Did I Buy BMW G 31...
My Studio Gears :
1. My Camera (Canon 200D) : amzn.to/3qsn0sm
2. Tripod (Digitek) : amzn.to/2NAjQUQ
3. Mic (Boya BY M1) : amzn.to/3pRxscL
4. Studio Light : amzn.to/3aqCzvc
Join my channel and become a member : / @mechanicaltechhindi
The wait is finally over. I am here with KZbin's very first Automobile & Mechanical Engineering Channel in HINDI.
In this channel i will upload videos related to automobile and mechanical engineering topics such as engine, I C engine, Cars, Motorcycles, Production, HMT, Thermodynamics, FM, CAD/CAM etc.
So subscribe my channel and learn everyday
Follow me on twitter: ⤵
/ dashingdanish11
Add me on Facebook: ⤵
/ danish.ali.754
Follow channel on Instagram: ⤵ / mechanicaltechhindi
Contact me: ⤵
[e-mail]

[@praveenmunda1896]

Engine heating 🔥 problems solved out your understanding💯 👌 👍 .Thanks🙏🙏🙏🙏🙏 Machnical tech.

[@satishkuvar5612]

Merit baik over hit horhi hai shin 125 .2016 madel .air filtar oil.oil filtar .plug.will fri. For bi hiting problem ho raa hai

[@abhiadsul6538]

Your videos are so helpful for 1st time 2 wheeler owners "

[@sanjoydasadhikari4533]

Bahi may v bike ka kam sikrahnoo (3year) up ke video se parsonaly mujhe itna knowledge milta hai jo mujhe kuch na kuch comment karne mai majbur karda hai ❤️ from Kolkata 🛵🛵🛵🙏❤️🙏

[@mechanic3d]

Motorcycle engine overheating is not caused by a single problem. There is a line of problems behind it which causes the motorcycle engine to overheat. A motorcycle overheat indicates that the engine is on the verge of collapse

[@hello-dz8co]

How to solve it?

[@yeahrightmate]

Hi,can you give me a bit more info on what can be the problem, my 250 air cooled road bike seems to be getting hot and running poorly after about 25 kilometers of climbing a fairly steep mountain road. I am not riding it hard or revving it much but it slowly gets worse and then when It has cooled down and I head back down the mountain it is ok again.

[@yashwantsingh7758]

Sir ye channel se hame or aapke all subscribers ko very informative video's milti hai thanks Sir

[@AmitSingh-wi6vb]

Thank you sir apne mera problem solved kar diya mene new bike liya he FZ-X or starting pe engine garm ho ja raha tha to me dar ja raha tha Ab 2000 km chal chuka he or ab engine garam nahi hota he Thank you sir

[@MECHANICALTECHHINDI]

U r most welcome

[@PPKMBA]

You are two wheeler master. Very good 🙂

[@MECHANICALTECHHINDI]

😊👍

[@kanurawat6947]

Tq bhai meri bhi new bike h o bhi bahut jada hit kar raha h me samajh nahi pa raha tha ki aa kyu ho raha h but abhi pata chal gaya h abb kuchh din bad dekhunga

[@akashnangla6432]

Konsa electric vehicle lena sahi rahega ess time per because petrol rate is to much high

[@AshishKumar2507kt]

Optima

[@nuclear9977]

@@AshishKumar2507kt optima ki range battery charging time and price batao

[@AshishKumar2507kt]

Alag alag city ki alag alag price hai

[@AshishKumar2507kt]

Because of govt subsidy

[@sayansarkar4778]

Cycle le le bhai.

[@sahaniarunitm]

I have changed the Valve in Discover 150 on 1K km, now its 3.5K km, when should i replace again.

[@sanan1783]

Got new bike but having same thing you discuss in video. What should I do??

[@RAHULSINGH-hw3oe]

Bhai ab ye issue thik ho gya maine bhi new bike li hai us me over heat kr rha engine

[@chaitanyachopra9684]

Sir my bike has completed 2300 km and it's engine is overheating is this a problem ?

[@ADITYASINGH-yw3ob]

,👍👍 nice video bhai, mai tension free ho gya maine apni bs6 150pulsar twin disk jo 6 month purani hai starting me mai over heating se paresaan tha abhi kam ho gya 👌👌

[@RAHULSINGH-hw3oe]

Bhai kitne km chalane ke baad ye problem thik hui

[@supanroy822]

Waah kya bat hain..Bahut jankari mila sir apse..Dil sain danyabad..

[@akkib5520]

Mere pass boxer hai , bike pahle fat fat karti thi yane mis fire isliye plug , air filter , cdi or oil bhi naya dala lekin gadi khul ke chal nahi rahi or engine without running bhi garam hora hai so tell me what happened exactly to solve this problem

[@suryasharma6779]

Thank you for valuable information

[@prameshmaurya2762]

Sir mere pass naya bike hai usko mai Char Panch mahine Se Rakha Hoon use Koi dikkat Hoga Kya Ki Nahin sir please reply kijiye

[@ifaizanbaig9912]

Ohh god you just cleared my biggest doubt I was thinking to sale my one month old hornet 2.0 bike I was feeling hot on my legs while riding

[@debasishbharati1265]

Me too, I have bought fz-s before three days and I am also feeling heat on my legs, now my doubt has cleared

[@dammdaniel9953]

I was also thinking the same I bought Kawasaki ninja zx10r this month only the heat is so hot I thought it will burn my legs😂

[@ifaizanbaig9912]

@@dammdaniel9953 ,🤣

[@Karan-xi7mm]

Sir maine bike li friend kii ..Jo 3500 chali Hai Pulsar 250f uska Engine bahut Garam Hota Hai 10 km Chalne Me Bhi ...is This Normal Aur Koi problem Hai ?? Please Tell Me Sirr..?? 🤲🙏

[@susantakumarpalai1210]

excellent

[@jilani117]

Bhai yezdi or jawa ki bikes me ye normal he thoda sa heat feel hota hi he uske liye kiya suggest karenge aap

[@pramod.prasai]

Thank you very much brother ❤❤

[@maidulmandal1660]

220 me konsa oil dalna chahiye

[@pradipkar2685]

Bahut achcha Laga aapka yah blog Mera pass ybr 110 bike hai 2011 ka abhi tak 100000 kilometer ke upar chala hai Do aadami lekar 70 80 speed mein chalne se bahut garm ho jata hai . Kya Kare 🍁

[@RanjeetKumar-fz1dh]

Traffic me bike chlate hai to mera mt15 ka engine bahut jada heat hota hai... Can you please explain the reason behind heating

[@pradeepsuryavanshi6616]

Apka solve kaise hua bro plz btana mera v aise ho raha h

[@RanjeetKumar-fz1dh]

@@pradeepsuryavanshi6616 kzbin.info Is channel ko dekho pata chal jayega

[@mayank_raj93]

2 or reason hai ...jab engine ki heat .. pairo tak aati .. #1 jab bhut bhid me dhire dhire chalte jese navratri ki bhid ... #2 jab bike high speed pe chalti .. red line hoti ya higher RPM pe chalti .. . Maine ye 2 reason experience kiya hu.

[@zalavishnukumar5069]

Bahut achha sir ji very very nice 👍👍

[@ghnabikhan8754]

Sir merr pass apache rtr 160 hai Engine heat hota hai uska service indicator b Bliking horaha hai Oil change karna hai aur kya chezen hai mention kijiye gaa

[@jarahatke9136]

Meri 3 month purani R15 bs6 bike ka horn kharab ho gaya hai kya warranty main replace ho jayenga, ya koi charge dena padenga?

[@sarojdubey49]

बहुत ही अच्छा लगा आपका बिडियो। 👍

[@MECHANICALTECHHINDI]

😊👍

[@jahatakmaijantahoon3514]

Glamour bike ka self kam na kare to step by step kaise check karenge kisme falt hai is pr video banaye.

[@bhaskarsenapati3465]

Chappal pahan ke bad garam aata hai a problem hai

[@pranavpatil9346]

Thanks

[@VKumar-zy1rb]

Exactly. Sadly Indian riders hardly know n follow under break in precautions

[@siddharthapurkayastha5017]

Very nice and informative video.

[@pramodm2805]

Suppose if a bike company stops production and if it’s difficult to get spare parts what to do in that case?

[@NITME2]

Get the next model up. I have a 4s champion and have boxer parts such as speedometer

[@indurikarkirtan]

I have filled 20w40 engine oil in unicorn bs4 company recommends 10w30 what can i do now

[@satishvasane6812]

वो आयल निकाल दो और 10 W 30 डालो।

[@nurvousenergy7268]

10w50 better hain ...20w40 pe engine kharab ho jayega

[@x150_Sumya]

Sar I get this problem in my pulsar 150Bs6 in new run only 17 km only This is the problem or no please reply

[@RAHULSINGH-hw3oe]

Bhai ab ye problem thik ho gyi hai kya maine bhi new bike li over heat ki problem face kr rha hu

[@palassatish6453]

sir bike me piston ka kam krvane k bad kitne sal tak chalegi ?

[@anujpatro8086]

Nice video Danish. Very informative 👌

[@atulmishra734]

Proper solution provide kraye

[@sameerraj_06]

very informative video thanks sir

[@MECHANICALTECHHINDI]

Welcome

[@ramtandi3837]

Sir ek video tvs raider 125 cc par banayo na please and love your very informative video

[@MECHANICALTECHHINDI]

Ok

[@suryanshsahu8074]

Hmare bike ke doctor ho sir aap 👏

[@PerfectAutoWorks]

Milad un Nabi Mubarak Bhai, Thanks for sharing information.

[@alone_rider_baka4238]

Mere pass 2017 model bs4 pulsar 220 he tyre clutch plate baki sab okay hey bas bike engine over heat hota hey koi solution batao.... Kya piston ring change karana padega yah other koi reason

[@geeteshbanka]

Sir interstate bike transfer ke liye kya kya documents chahiye aur kya rules hain agar permanently bike ko shift krna ho to??

[@abcxyx4144]

KTM 390 mein expected hai ?

[@nishchalsharma4100]

Bhai meri sp me engine se nahi lekin catalytic converter se bahut zada heat produce hoti hai. Aisa kyu?

[@RDXGaminGGG]

Sir meri bike ko bs 1 month hua hai and 290km tk chli hai or bike bohot zada heat hori like 94 degree tk m roz 22 km ata jata hu... Please mujhe btaiye kya koi problem tho nhi aega .. Bike meri mt15 v2 hai liquid cool engine.. Please btaiyee please

[@ghostrider..rajbhai8718]

🤔🤔❣Bhai bike Launched se pahile testing Q karte hai or Testing Biike Pe Zebra wrap Q Hota hai...spotted Mai dikhta hai🙄 Video banao

[@msarmah3155]

Testing nehi koretu company ko keise pota chalega real life mein bike keisa perform korenge , kiya kiya problem aa sakte hein ? Launch hone se pehle bike ki design koo reveal nehi korna hein company , agar sob kich launch hone se pehlehi reveal hoo jate tuu official reveal aur launch ki koyee matlab hi nehi bonte ...isliye wrap hota hein ...

[@pranab6250]

Sir mera bike kharab rasta or jada vir var jagah par 1-2 km ki andar me garam ho jata hai. Or lequid coolent on ho jata hei,, kay ye prblm hei

[@atulmishra734]

Mere pas m Ns200 h usme bhi engine heating problem aa rhi h.... pr uska coolent bhi ok h radiator fan bhi proper work kr rha h....or engine oil ka level kse pta kre ki km ho gya h

[@sreedeepdey8215]

Thanks sir, i was worried

[@haribasnet5146]

ATTI SUNDAR

[@prameshmaurya2762]

Sir main Aapka Channel subscribe kiya hun Sabhi video dekhta hun

[@biswajitsaikia9959]

Glamour bike ke liya kon sa mobil sahi h

[@aakashjadham7271]

Best Video..... 🇮🇳

[@MECHANICALTECHHINDI]

😊👍

[@suvankarsaha5578]

Clutch plate jale jane se v kya engine overheat hota hay?

[@subratgaming-q2y]

Yes pressure padega lekin top speed pe

[@allmodos]

Mera clutch plate new lagaya Tapit v abjust Kiya phirbhi over hitting. Horahe

[@akshayjadhav8686]

Good Information

[@brijgupta3733]

Sir mere pass hornet 2.o hai aur jab mai apni bike ko chalata hun to pahle wo dabti hai phir accelerate karti hai phir dusara gear lagata hun to phir dabti hai please mujhe batayen kya problem ho sakta hai

[@satishvasane6812]

Problem कुछ नहीं है, इंजन ठंडा होने पर ऐसा होता है।

[@jaynath22]

My bs6 4v 160 automatic bandh ho jata hai,solved me plz....???

[@deepakkarade9362]

Sir can u plz tell me which spark plug and engine oil is best for honda dream Yuga 2015 model nd front tyre too Plz do reply sir

[@sushantkumar5093]

Manual me padho bhai

[@sawantaakst8782]

Best spark plug Bosch And engine oil in synthetic castrol power 1 ultimate

[@deepakkarade9362]

@@sawantaakst8782 thank u

[@deepakkarade9362]

@@sushantkumar5093 kk

[@sawantaakst8782]

@@deepakkarade9362 oh sorry tyre reh geya bhai front tyre TV's ja MRF ja ceat en main se koi v use kr lo best hai meri bike 2007 model hai TV's tyre lga hai front abhi tak change nhi hua

[@ayashkantswain8009]

Bhai i have a mysterious problem in my bike relating to engine over heating,even service centre walo ko b paata nhi chal raha kya prblm h gaadi m. Can you help me ?

[@anujpatro8086]

Bike ki silencer se smooth awaz nahi nikal rahi . Kya karan ho sakta hai?.Please help Danish

[@boom2hall219]

CBR 650 bike kaisa h thora bato ap

[@archiveabhi3365]

Plz make a short video on is red lining any engine is safe?? 🤔🤔#mechanicaltechhindi

[@sumittrox143]

Amazing explanation

[@ninjax5397]

Please help mere rs200 me top speed Jane ke Baad bohut overheating hota he aur dhua nikalta he, exhaust se nahi engine se

[@SantoshJadhav-nj2qu]

क्या गरम इजन से आँईल निकाल या डाल सकते है

[@satishvasane6812]

निकाल सकते हैं उल्टा अच्छा है कि गर्म होने पर आयल पतला हो जाता है और पुरा निकल जाता है।।

[@SantoshJadhav-nj2qu]

@@satishvasane6812 Thank you bhai

[@bhoopendramalviyaharda8391]

Bhai ji...Kya HF DLX me RPM 15 ho to isse koi nuksan hota h kya?kyn ki start krne par hi bahut tej acceralation hota h

[@aimlessblogger4876]

Mera fzs v3 hain 1000 ke upor vi ho geya hain mera gear shifter atak ja raha hain iska solution keya hain

[@devmahato9522]

Bhaiya pulsar 220f me ek bar me kitna litter engine oil dalna chahiye...koi kehta ek litter koi kehta h jada...plz suggest kar de

[@shahusangam4802]

मैनुअल बुक में लिखा रहता है भाई जो कंपनी गाड़ी के साथ देती है उसमे सब लिखा होता है कि कोन सा ऑयल डालना है और कितना डालना है

[@satishvasane6812]

@@shahusangam4802लोग इतनी आसान बात नहीं समझते। Owner manual एक कोपरे में फेंक देते है।

[@spkumar9]

सर मेरे पास pulsar125 bike हैं और 4200 km चली हैं इसका over heating प्रोब्लेम 2 nd सर्व्हिसिंग के बाद आ राहा है तो इसका कारण क्या हो सकता हैं please कंमेंट me

[@mohitsingh7859]

Ak he video pr bhut pahla sai video dekh raha hai

[@bomrikriba]

Meri bike 10K kms chali gayi hein pulsar 220F Bs6 Using Motul 7100 20W50 fully synthetic since 7K kms still having engine heating

[@Imrantwitter82]

Bhai motul mat dal bekar he engine heat krta h

[@keshavkaushik7945]

Yes bro isse acha Castrol power 1 ultimate h

[@7_6740]

@@Imrantwitter82bhai koyi motul bdya bolta hai koyi castrol maine experience kra castrol bekar hai valvoline bdy hai😊

[@dgthapaenos5580]

Thanks bro

[@sukhrajkaur9585]

Sir mere pass super splendor bs6 mene August me purchase kya tha but overheating bhot hori he

[@satishvasane6812]

भाई 2000 किलोमीटर तक बाइक तेज स्पीड से मत चलाओ।

[@saurabhsandeep8122]

Bro mere pas glamour bs-6, 20 model h ji ki August me purchase kiya tha. Or abi tak bike 8200 KM chali h. Garmiyo me mujhe pairo me garm hawa lagti thi jo Engine se ati thi. Us samay bike 5-6000 KM chali thi. Kya ye condition normal h? Pls suggest.

[@bhojarajghibila7001]

Normal bro....1

[@RHEMANTHKUMAR]

nice information sir thank you very much ❤️

[@Chandrashekhar-xr8ni]

Sir kya hume bike mai radiator guard lagana chahiye? MT15 mai?

[@nationalflexbansi6477]

Very good

[@rahulpathak9649]

Great video sir

[@Arjun-lh4tr]

Sir Mere Bike hero xtreme 160r ki number plat k uper ek balb laga h jo ki 5_10min bad he heat ho rha bhot jada ...uske karan bike ki tel puri heat ho rhi h

[@lethalparry7090]

Mera R15M 4800 Km chala hai ... Raditor Fan working hai coolent bhi hai... uske bad bhi 95 C tak heat ho raha hai

[@ravi_33_]

Thx u for information bhai 🔥🔥🔥🔥

[@darkjustice851]

Genuine information

[@subojeetbairagi1913]

Very nice video sir

[@kadarali1168]

Meri spelndor pro me koi khrabi nhi hai fir bhi engine gram hota hai aur akela hi ghumta hun wight bhi km hai mera uske baad bhi ingane gram ho jata hai speed 40 km tk hi bahghata aur splender plus se recing krta hun to jeet jata hun nya nya spledor plus se bhi recing kr cuka hun fir bhi jeet jata hun pls iska solution btay

[@srchouhan2837]

सर हमारी स्पेलंडर बाइक में रेस अटकने की समस्या है जबकि रेसिंग वायर भी चेंज करवा दिया .....

[@AbhishekKumar-oc8lb]

160 4v ma jayda problem ha overheating ka

[@pranabbaishya8518]

mera jaba 42 2.1 me v bhut hit hota he

[@its_me_ritam_2835]

Example TVS Apachi 160 4v

[@aksvlogs9151]

Bht heat hoti h ky.. 🤔

[@its_me_ritam_2835]

@@aksvlogs9151 Yesh Bro

[@manish7743]

Mere v bike me over heating problem hain R 15 V3 ,(2019)

[@mohdhaneef6104mh]

Overheating my activa 3g kya kare

[@godgameplay2361]

Sir may the rain dirty water can enter in the engine through the bike radiator 🙏

[@sachindr4271]

No It can't bro

[@durveshpatil3174]

For me the water entered through air filter box inside my engine

[@godgameplay2361]

Bro sabse bada reason h coolant low hona😊

[@TheTheNSAGAR]

Bro kya radiator ko guard dalna laghana chahiye?

[@MECHANICALTECHHINDI]

Akar guard ke wajah se radiator damage hota hai, to agar lagana hai to bahut carefully

[@TheTheNSAGAR]

@@MECHANICALTECHHINDI thanks bhai

[@harshitsharma6503]

Thank you bhai

[@ritikmehra2671]

( r15 v2 ) aare sir ek video bna do ya cmt me krdo rply ki.. agr bike 15-20 min bike chleee to kya Rediator Aaag ki traah gham ho jata hai kya ???? Mtlb rediator itna garm ho jata hai ki use hath b nhi lgaa skte .. Or fan b bdi deer baad On hota hai fr b radiator ko hath lagayo to boht garam hota hai Raditor