tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage

tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage
Hi, I am Saourav Kumar from INDIA
*To Follow me on Instagram
/ saourav_kumar_gajnet
*Facebook page link:- SaouravKumar...
*Facebook group link-- / 2621080847965716
*Fuel-Injection Pump Part-1:- • tata indigo fuel injec...
*Tata indigo smoke level at 5000+ RPM video link:- • 5000 RPM no smoke solv...
*Silencer cleaning video link:- • how to remove Black Sm...
*how to clean EGR video ink:- • how to clean EGR with ...
*high pressure fuel pump sensors- cam-valve sensor, solenoid-valve sensor & TPS sensor video link- • high pressure fuel pum...
*Facebook page link:- SaouravKumar...
*Tata indigo injection pump setting to get maximum mileage and lowest smoke and high pickup and it helps to tune up the engine and its sound. also helps to reduce black smoke from exhaust and helps to increase engine life.
mainly rpm is very difficult to set after 50000km manually but my video will help you.
*some extra knowledge:-
Primary Functions od IDI engine with ECU:---
1. Fuel pump injection timing control.
2. Glow plug pre & post heat control.
3. EGR system on-off control.
Secondary Functions:---
1. FICD (Fast Idle Control Device Control). This is
the device which
increases the rpm when the AC is switched on.
2. AC switch off at high Engine temperature and high
loading.
3. High altitude proportional control.
4. Fault detection & storage of trouble codes.
The ECU gets its inputs/information about Throttle
position, coolant
temperature, ambient temperature, engine rpm,
crankshaft angle & Injection
start from the following sensors on the engine :
1. Throttle Position Sensor or Fuel Level Sensor :
This is a potentiometer connected to the fuel delivery lever which is
actuated when the accelerator
pedal is pressed. It sends a DC voltage to the ECU which is proportional to
the accelerator position.
2. Temperature Sensor: This is a thermistor type of
sensor, monitoring the coolant temp.
3. RPM sensor: Part of the alternator. Gives 3
voltage pulses for one revolution of the crankshaft.
4. Crankshaft Angle Sensor or Crankshaft Position
Sensor. This is mounted on the flywheel housing and provides piston TDC (Top
Dead Centre) information to the ECU, in the form of a number of voltage pulses
per 90 degrees angle of rotation.
5. Needle Lift Sensor: This sensor is part of No. 4 cylinder fuel injector,
& sends a voltage signal to the ECU at the precise beginning of injection.
tata indigo fuel injection pump setting in detail | how to set fuel pump | increase mileage
How it works :
Based on the inputs from these sensors, the ECU
controls the following units
through Relays, Solenoid switches & PWM control :
1. Glow Plug Heaters: These are for pre-heating the
cylinders. The ECU controls the glow plugs ON time based on ambient &
engine temperature.
2. Fuel Pump: Injection timing is controlled depending on the position of
the accelerator pedal----timing is advanced automatically at higher rpm. The
ECU controls a cam actuator inside the fuel pump,
based on a look-up table stored in the ECU program ROM.
3. EGR: This is the Exhaust Gas Recirculation
system. Part of the exhaust
gases is mixed with the air intake to reduce temperatures inside the
cylinders to below 210 deg C., which sharply
reduces the formation of Nitrogen Oxides (Nox) in the exhaust, thereby
reducing harmful pollutants as reqd. by Euro / BS 2 & 3 norms.The EGR valve is
controlled by the ECU, & gets activated in the rpm band 1100 to 3000 rpm,
with small variations to compensate for engine temp & loading.
4. FICD: The fast idle control is used to increase
the idle rpm when the AC is switched on. The ECU activates the FICD through a
solenoid switch by monitoring the AC compressor clutch voltage.
The ECU also continuously monitors the engine
temperature, & switches off the AC if upper limits are exceeded.
All the sensors are also monitored continuously, and
a fault or trouble code is stored in non-volatile memory in case of a
fault, & the Check Engine Light comes ON.
IF THIS VIDEO HELPS YOU DON'T FORGET TO LIKE & SHARE THE VIDEO & ALSO SUBSCRIBE TO MY CHANNEL
I film, edit and publish each video on my own.
I have had many viewers comment and let me know how I have taught them how to fix their car themselves and save them $$$$ and I love it!
thank you.
#fuel_injection_pumo #heigh_pressure_pump #simple #Hindi #CarProblem #Best_video
#crackover #crack_over

[@debasiskaran1793]

Waaah bahut aachhi tarah samjhate hain aap,Thanx🌹

[@crackover]

Thanks sir 😀👍😊

[@darsaliksalik8412]

Cont nb plz

[@MayurShinde01]

If your technique is followed, there is a high chance of overheating of the AC compressor. AC compressor can be overheated if the setting is done with less rpm tolerance. The process is little risky when concerned with AC compressor with frequent start-stop action. I hope you get the point. Nice explanation. keep up the good work.

[@crackover]

Thanks for the comment Sir Yes sir you are correct but this will happen when your cars engine is over heated also AC is continuously working for 30 to40 km or for 45min. Yes it may happen but with proper saftey the chances for getting trouble is 2% to 3%. My car is 10 year old but currently it is giving 17 to 18 milage on Highway with AC. If fuel is good. Thanks you 👍👍👍Thanks for the comment Sir 👍👍👍😁

[@dommatasaiprasad6933]

Nice video & information bro, Jai Hind Jai Bharat

[@princeraaz2686]

❤️Thank u so much brother❤️ Aapne jo trick bataya hai ..Jaisa aapne bataya waisa karne par ...Meri car ka problem solve ho gya..

[@crackover]

Thanks for the comment sir 😁👍❤✌✨✨

[@hiteshjani6154]

👍👍👍👍👍👌👌👌👌👌bhai aap bahut achha shamjaya thanks

[@papugahir1739]

Thanks bro very nice video.

[@debasiskaran1793]

Wah kya mast samjhaya aapne🌹🌹🌹

[@crackover]

Thanks for the comment sir 🙏😄❣️👍

[@Btz115]

Thanks for ur video bro, from kerala..🙏

[@crackover]

Thanks 🙏👍

[@madhureddy3654]

Very. Nice. Explain. Bhai. Sab...Thanks

[@crackover]

Thanks for the comment sir 😁✨❤😁✨✨✨👍

[@balasahebhujare8963]

Very useful information

[@RIPANCARCAREPOINT]

Good job sir 👌👌👌👌

[@balajicartechinfo5836]

Nice information bro

[@rahmanpv6360]

waiting...

[@munnalaljanokar796]

Thanks sir ji.

[@crackover]

Thanks for the comment Sir

[@narbyari8319]

Bahud sahi he I liked

[@jarnailkhehra5122]

Nyc bhai 👌👌👌👌

[@amoljadhav6756]

Bai 1 no yar yahe problem kabse solve karna chahata tha

[@cesarjorgemurillobarientos1813]

very good my brother

[@jsb9287]

Bro perfect mileage setting

[@crackover]

Same process or setting pe bhi best mileage ayega😃👍

[@GoogleGoogle-qp2gk]

Good message bro

[@crackover]

Thanks for the comment Sir 😁👍🙏

[@akshaygohel4533]

Bro which obd scanner you used please share the link

[@genuineinfotech5777]

Make a video on Indica v2 Over heates if ac is on

[@dhanuvijaysalunkhe3436]

Me aap ke sab video dekhata hun or download karata hun

[@dilippanchal634]

Thank you Guruji

[@crackover]

😀😁

[@RIPANCARCAREPOINT]

Very NYC video sir

[@rahimuddin3159]

Sir 1 No

[@crackover]

Thanks for the comment sir ✨✌❤✨✨

[@badalrout8783]

Sir konsi obd tata indigo ecs lx tdi 2011 dicember keliye sopport lega

[@tec29]

Very nice video. Well I have 2005 indigo it suddenly does not increase the rpm on ac on And now in winter I have found the choke which usually in winters in kashmir increases the rpm for few minutes is not doing so and my car which usually starts on 1 self is taking few self's. I have checked heater plugs which R fine. Please suggest I think my ficd is not functional

[@sunilpalo7324]

Mere pass vista tdi hai aur uas mai wo ac cutoff wala screw full open kark accelerator se idle rpm set kiya to jyada mileage degi kya?

[@hyderabadibawarchi6343]

Perfect dude! Keep it up 👍 I learned a lot from it, can you please explain more about ECM functions?

[@crackover]

Thanks for the comment Sir Ji ha sir ECU pe seprate video upload karunga jaldi

[@pradeepdambe2361]

Nice vdo

[@manishshresth1675]

Meri indica v2 tc obd support karti hai kya obd continue laga k rakh saktey hai kya

[@rajbahadur2162]

सार बहुत बहूत अच्छाह hai

[@verkaoutsourse7744]

Sir g indica turbo 2007model mein obd lag sakta hai kya

[@sarojsubu7654]

My tata indigo ecs lx TDI gadi kuch problem nahi hai very good car

[@sentysidhu5953]

Super bai , thanks

[@crackover]

Thanks for the comment Sir 👍😁😁

[@sentysidhu5953]

Bai maine aap ki help se Apni indica ki milage 4 km /pl jyada bdai

[@tomgamer7510]

Hi your showing Ac ajjesment for pickup and mileage .but my dout and questions is if adjusted is done than the ac cooling will be not effective...

[@Pardeepkumar-dy1yv]

Bhai ji aap ki video dekh kr acha lga ak help chaye mere pass mandra bolero h di mtlb rotary pump vali h uska fuel set kse kru please btaye

[@crackover]

Thanks for the comment sir Ji ap mujhe watsapp pe pumo ka photo bhejyea main dekta hu.

[@mohanbabu3631]

Nice video, 👍🏽 Diesel is leaking from my pump! Can you please help.

[@Ravi-tz5tx]

Sir a setting indica v2 ls bs3 mein kar sakte kya sir.

[@crackover]

Thanks for the comment sir Ji ha

[@AlzubidiAllzubaidi]

Gooood 👍👍👍👍👍👍🌴💞🌴💞🌴

[@palanirv]

Good, I will try with my car

[@crackover]

Best of luck👍😁

[@gouravvyas6621]

guru y viedo me indigo ecs cr4 engin ka RPM set ho sakta h kya or y software ki link do

[@mazaharbaig3178]

Bhai ford ikon Diesel pump pe ek video banado....

[@dhanuvijaysalunkhe3436]

👌👌👌👌

[@bobbu8431]

Thanks 🙏

[@crackover]

You’re welcome 😊

[@manishshresth1675]

Bhai engine drane aur engine oil treatment per video banao

[@basics7930]

Nice video...............what is the idle rpm for diesel lancer with and without A/C...whether this setting applicable to Lancer also?

[@crackover]

Let me check

[@yogendravishnoi8977]

Hello, I am using 5pk 730 drive belt in my Indigo ecs cr4 2012 model, what is the right size of belt as my existing belt is making noise .

[@crackover]

Thanks for the comment Sir Please select the belt which fits the pully with edge to edge perfet fitting between pully side teeth and belt without any gap Then there will be no belt noise

[@vijaycartechnology9545]

Nice

[@rizwanpasha2594]

Hi friend kya a setting tata super ace ko karsak te hai kya bhai

[@indianking912]

Thnx sir aap kaha se ho

[@KapilSharma-yw8rt]

Head m temperature ke switch m 1wire lga hua h socket 2 wire ka h..btao esme 1 hi wire ata h kya ya 2 ate h

[@MrSandeep611]

bhai yeh obd scanner tata Indica vista 2013 pr work krega

[@crackover]

Thanks for the comment Sir Ji ha bilkul karega

[@sanuvl0g772]

Projector fogg light tata indigo me laga kr bna dijye vdo sir or door open signal bhi nd open door roof light

[@rohitkumar-lf9pd]

Tata Indigo ecs lx tdi 2014 ka clutch safety switch bypass kaise Karen????

[@hasanbag6501]

tata marina 2009 1.4 tdi chiptuning can it be done ? can u ?

[@crackover]

Thanks for the comment Sir yes you can tune the chip but updating is better option than tunning. Also I have no software to tune the chip but you can update it from the service centre

[@exploretheunknown5969]

Vista quadrajet d 90 ka video pls. banaiye

[@vinaysutar8626]

Obd scanner konsa lena sahi hoga

[@kamalbuttarkamal6823]

Sir meri wali indigo me starting problem hoti hai subha k time dussri self pe start hoti hai mushkil se uske bare batao pls reply me

[@asifjahan1471]

Bro please make video on vaccum pump and it's supply

[@crackover]

Thanks for the comment sir Ji ha bilkul next week

[@user-nb7rh8xo8i]

Sar kiya ac on krne pe rediytr fan or kneksn fan dono sat me chlna chahiye kiya

[@pramodnaik9528]

Tdi indigo pump replacement ka vidio banao sir?

[@aseemgeorgenelson3767]

Sir can I use 5w40 full synthetic engine oil in my Tata indigo ecs tdi plz plz reply

[@crackover]

Thanks for the comment sir yes you can use it.

[@aftabburan8814]

15w 40 bhai

[@devendrapandey8181]

I'm facing same problem in my car. What would be best recommended place for car service so that they look into these problems?

[@crackover]

Thanks for the comment Sir Koi bhi mechenic ye setting karna nahi janta hai sahi se I will recommend you to do it yourself

[@suchesh1]

Does tata indigo marina tdi 2005 diesel has obd port ? If yes , Location?

[@lalachandkhan6449]

Sir indigo me p1131 cood cam command value too high bata raha hay kya problem hoga sir

[@supradipdas6490]

Tata indica,indigo ka high pressure Pump remove korte waqt kiya kiya chise ka dhiyan dena chahiye iske uper ek video banaye please.

[@crackover]

Thanks for the comment sir Ji sir Maine ek video upload karunga jaldi hi

[@pushkarsharma6331]

My car Indica V2 2007 model...ran 2 lakh km..can a setting of diesel pump can be done.....as shown in ur video

[@ManiSingh-fh9xj]

👍💝

[@ManinderSingh-ur5wr]

Sir scorpio tdi diesel pump ki Bhi proper setting ki video banado

[@ashutoshpatil7999]

Bhai fault code pe video banao

[@laxmibharati5618]

thank youme banbasa se hu mere pas tataindica tdi engine overhaling me kitna kharcha ayega

[@Sk-Motors-313]

Sir 4 no injector ke sensor ke baare me information dijiye

[@arjunsinghthakuri9803]

Same question

[@ikbalchoudhury2577]

Good

[@crackover]

Thanks for the comment Sir 😁👍😁

[@jugalbarot2206]

Sir Ac me kitna rpm rehna chaiae Or offac me kitna hona chaise

[@foysalrana8697]

esi obd 2 device mahinda pe kam kare ga?

[@balwinderpal514]

Hello brother rpm check karne ke liye jo apne relay lagai hai wo kaha se milegi

[@Chandan_clips]

Hello dear Alternator se EGR tak ka air vacuum line troubleshooting kaise kare please do this.

[@crackover]

Thanks for the comment Sir Abhi MAP sensor or MAF Sensor ke video upload karunga uske bad vaccume line ko kaise test karna hai pura iska video dalunga. Thanks for the suggestion sir.

[@badalrout8783]

Sir pls e obd ka link dijie jo tata indigo me support lega

[@subhakarbindhani2054]

Clutch changing batao sir

[@arifqkhedekarkhedekar6088]

Good afternoon sir please reply me 2007 tata indigo tdi DTC p0222 hai aur throttle pedal normal hai isme sensor nahi hai

[@crackover]

Fault code me low voltage ka kuch data show kar raha hai kay

[@ashokkumarsant2553]

Meri indigo LS 2003 model hai. Kya usme ye scanner software setting ho sakti hai. Is par video Dal do sir. Isme oil pressure lamp as jata hai uspar bhi video Dal do

[@liln1840]

Sir mere pass 2004 non tdi Indigo he jisme 4no injectar me koi wayre nahi he to kya me usme 2008 model indgo ka fi pump bhita sakta hoo or kya who sahi se set ho jaega

[@shisdebadas2219]

Bhaia indica v2 dls me vi aisa setting hoga keya? Or pamp auto cut hoga keya? Plz batayega

[@sentysidhu5953]

Yes Bai , maine b kiya , 4 km pl milage bdi

[@jaypadsala4876]

Grand i10 2019 ka mileg ka video bana o sar ji

[@dillipsahoo7762]

Rpm upper niche wahit back somk

[@nawin7760]

Hi bro my indica car was when low fuel on tank it's get rpm goes full down and off and when fuel full it's normal

[@somanathburud3331]

Mere pass indica Vista tdi hai ..engine sound idelpe com jada horahai use kya karna hai

[@aseemgeorgenelson3767]

Ho sir I need a help from you I drive my Tata indigo ecs in rain and water logging after that my car start making difficult sound and when I turn on ac this sound increase a lot please help me how to solve this problem mechanic near my house told me that timing out ho gai hai please reply

[@padmabhpadmabh4821]

Full service Ka video Karo sir

[@jameerpathan646]

Bhai tavera car hai morning time let start hori hai or res bhi let horahi hai problem batao please reply just

[@mohammedabdulwahab9046]

My car rfid is work but when the ac is in it is not released after the ac is on it is same can you say me how to set it

[@atukim8325]

Pump mai fire order setting video banao

[@crackover]

Thanks for the comment Sir Biklul apne main banaunga is pe video 😁✌

[@hussainnadaf2894]

Hello sar tata super ace ka slowly accletar debate hai too ek saund gadrrr kark saund atahai

[@lokeshverma492]

mere vista me gadi khadi ho tab ac bilkul kam nahi karta aur jab gadi chalne lage tab ac kam karta h, mtlab speed me rahega gadi tab sahi kam karta h nahi to kam nahi karta kya prblm ho sakta h....

[@bhuvanesh.511]

Sir indigo cr4 engine behtar hai ya TDI...Plz suggest

[@crackover]

Thanks for the comment sir Tdi

[@frazkhan123]

Brother tmse thodi baat krni hai mere paas bhi indigo cs hai 2009 model usme yahi problem hai ho sake to reply krna

[@mistre123gangster]

Endica kar ka ac on krne or rpm high nhi ho the he Kiya problem he plj Ripley

[@jayeshpatil8462]

Indigo cs car me tharmalsted volve kaha hota hai aur use change kese krte hai Ek video banao

[@KapilSharma-yw8rt]

Sir tata indigo ecs tdi 2 lakh se chal gyi h black smoke deti h kya check kraye smoke kam ho jaye