Top 5 Problems Chevy Silverado Truck 1st Generation 1999-07

[@1AAuto]

√ *Watch the Video* √ *Buy The Part at 1A Auto* 1aau.to/m/Visit-1AAuto √ *Do it Yourself* √ *Save Money*

[@michaelviens2894]

Not one mention of the emergency brake going out immediately?

[@jenniepainter3983]

2004 Chevy Silverado like a rock

[@metubetomuch]

I have had a 2003 4x4 Silverado since new....garage kept, regular maintenance....only 87000 mi....still like brand new... . everybody wants to buy it... lol.

[@hw5091]

#6, which should be closer to #1- the shit transmission on the 1500's. 460 is trash. The window regulators as well. The worst on the market.

[@jameslawson2663]

Especially the 5.3, this truck is by far the most dependable truck on the road.

[@stickyicky2100]

The older 5.3's yes...I have an 02 2wd shortbed with the 4.8 approaching 200k with very few problems...wish the new ones were built as good

[@almost1o1]

I got a Silverado 1500 from a family member for a steal. 4.8L original engine / transmission and it currently has 406k miles and still running strong 💪🏼 I drive +|- 50 miles a day one way, and she can put up with my heavy foot lol

[@BabyTJ92]

The old Ford straight 6 will always be king. But 99 - up the 5.3 and 6.0 cant be touched

[@Littleblackrod]

@@stickyicky2100 200k is just breaking in bro the motor cycles so much that its gonna last forever perfect for a cam and tune bro id buy another high mileage silverado inna heartbeat cheap parts easy to work on

[@davidespinoza7322]

I got 1999, 5.3 and 2003, 4.8.. .. the 4.8 has been bullet proof not saying the 5.3 isn't, but its needed more tlc than the 4.8

[@getout6899]

The Gas and the tires. I had to replace those very often.

[@Christackleberry]

Speaking of tires, anyone else notice the uneven wear on the front tire when he was checking the wheel bearing?

[@paulmiles483]

@@Christackleberry when he was pulling the tire to check the bearings there was a clunck when he went from side to side.

[@travism9339]

@@Christackleberry Yeah. The hubs on his truck were bad causing uneven tread wear on the tires. Just had to put new ones on mine last weekend, but they were a hell of a lot worse than his. You could literally see the front wheels angling inwards at the top.

[@albertoascencio5935]

I'd sell it😱 you probably got a lemon! I'm still on the original gas with over 200,000 miles and I've only had to replace the spare tire because my ex slashed it. You probably shouldn't ever have to replace those items.

[@JD-526]

I have a 2003 Silverado, 144.000 miles Had some of the same problems, not bad compared to ford or dodge. Chevy is the most reliable.

[@marinecwby01]

1999 Silverado 2WD. 356K miles on my 5.3 and still going strong. He's right about wheel bearings. Having to replace mine as I'm writing this. 1A Auto is awesome! Keep up the good work guys! JC in Bama

[@HarmfulYoutube]

Twins 😂

[@jamiegarrett3869]

war beagle you silly boy

[@neilhoogendoorn8045]

The biggest problem with these truck is the leaky blinker fluid that drips onto the muffler chain and causes the tailgate motor to short out.

[@erikwilson7622]

I have a 2005 Silverado, and I didn't have the issues you describe, on mine the Bull Pinion jumped the Heifer Shaft.

[@otherstuffbybob]

Huh?

[@sammy11earle]

I remember my dad razzing me about blinker fluid when I was a kid. Love that joke. 🤣 I fell for it too 😁

[@嶋田佳子-f5f]

Muffler bearings and a can of compression gets to where I’m going ! I just need to figure out where that smell is coming from ? Any ideas out there ? Fix all day , KZbin all night !

[@noconsentgiven]

🤣🤣🤣👍!

[@jimmyramirez5461]

I still believe there reliable and a good truck .

[@richardmoreno5160]

I agree I currently own three of them. I trust all of them to make a cross country trip. They range from 132,000 to 260,000. One truck that i service for a friend is a 2005 with over 600,000 miles original engine and transfer case with one replaced transmission. These trucks are good trucks in these years.

[@easygoing2479]

I have a Tahoe with 266K, and it’s been the best vehicle I’ve ever owned.

[@Pantaro2007]

bought an 03 LT quadrasteer extended cab maybe 6 months ago(My first truck),havent done the usual maintance stuff i would do when i first buy a vehicle but have used it o move and drive it around quite a bit and still hasnt left me stranded yet. most of it's issues are just minor annoying things,it gets me where i need to go tho!

[@ricktotz4078]

There are reliable if you want to keep putting money into them repair after repair I don’t call that reliable

[@duggiebadd2804]

@@ricktotz4078 Small simple repairs like the video states isn't a lot of money.

[@peterlopez5435]

These model year truck is better built than the new model trucks that chevy makes. I currently own a 2007 and 2017 chevy Silverado 1500 and the 2007 has over 274,000 miles on it and it still running strong compared to my 2017

[@1AAuto]

+peter lopez Thanks for the feedback!

[@peterlopez5435]

@Brittain Boswell back then I had the vacuum pump replaced which affected the brakes. And right now I’m dealing with the infamous chevy shake which currently has no fix just band aids.

[@peterlopez5435]

@Brittain Boswell yea no problem. It currently has about 80,000 miles

[@xxsethxx8499]

Same here 2004 Chevy silverado 5.3 v8 has 252,000 miles and still running strong gotta love a chevy

[@jafquist27]

@@xxsethxx8499 05 Silverado 5.3 has 270,000 runs like new. I love my truck!

[@Parker_Garage]

Also the heater hose plastic fittings at the firewall break all the time.

[@digi3218]

Ive replaced both of mine. One started leaking. The other I broke while replacing the knock sensor lol

[@1AAuto]

Yes they do. Thank you for checking out the video. If you need auto parts go to: 1aau.to/m/Shop-1AAuto-Now

[@rickynelson7023]

Very common lol

[@russell6022]

Yeah, my heater core neck broke off at the firewall when trying to replace the hose, didn't know they were plastic.

[@seanvaughn7566]

How much do they cost usually ti get it fixed?

[@DontjeB]

Bought my 2005 Silverado in 2007. 14 years later I just rolled over 211k miles, and she is still kicking it. I've addressed 4 out of the 5 issues you mentioned (never dealt with a knock sensor). Here's a couple more: 1) Day time running lights 2) Airbag (impact) sensors behind the bumper 3) Stepper motors in the dash 4) Transfer Case encoder motor sensor 5) Castech heads Overall this has been a rock solid performing truck. Michigan winters have taken their toll on the body, but that's to be expected. I'll keep her on the road as long as I can. With the limited maintenance I've had to do, this truck doesn't owe me a thing.

[@tristansteiner7076]

How do you fix the day time running lights, I have an 02 silverado with 226k miles on it

[@aland9984]

Did you end up replacing the castech heads?

[@DontjeB]

@@aland9984 They were replaced under warranty at around 90k miles.

[@braveheartz263]

I have a 2005 Chevrolet Silverado, and it’s been a great truck and still is.

[@trev1481]

@@tristansteiner7076 Sensor on dashboard went out in mine causing headlights to come on in day instead of daytime lights. $14 dollars on amazon 3 years ago.

[@ArconicWelding]

For those of you with the steering shaft clunk, there is a plastic bearing under the dash board inside that is worn. There are many videos of how to replace this and is fairly easy, the part is cheap and will likely fix your issue. Try this before paying for an entire steering shaft!

[@owentimo]

The distal steering shaft (connects to steering gear) u-joint also rusts and creates some wiggle and wandering on highway. Dont get the Dorman, it's junk. Get OE

[@kendo1967]

@@owentimo I think ya just saved me there. Thanks for that 6 months later lol.

[@owentimo]

@@kendo1967 LOL, Did the Dorman rust out on you?

[@joeyblack396]

Thank the lord I’ve been looking for what this is

[@keithcronk7980]

Got a link sir thx you​@@owentimo

[@owentimo]

#1 should be the Oil Pump O-ring causing low oil pressure. $5 part and a 3-4 hour job in your garage.

[@coffeebeardtv]

Thank you

[@billargueta5458]

I've seen people recommend replacing the oil pressure sensor.

[@owentimo]

@@billargueta5458 Yes. Its a huge leak point as well. It stopped 50% of my leak, the other 50% was the oil pan gasket. All dry now.

[@dark8893]

😭 I’m about to pay 800$ for a whole new oil pump. Part and labor

[@owentimo]

@@dark8893 You try the o-ring first?

[@wiynwiyn]

When you replace the knock sensors, you should replace the intake manifold gasket as well. Common problem.

[@Patriot-bn9om]

I have a 2006 Silverado 2500HD with 145,000 miles. I have only had the tailgate latch issue and the steering column issue. Each was really easy and cheap to fix. The tail gate latch fix is a $2.00 plastic clip to reconnect the rod(s) to the latch. I solved the steering column issue not be replacing the intermediate shaft, instead by an almost free solution. I used a zip tie between the steering column plastic housing and an adjacent metal structure under the dash to pull the play out of the steering column. This held up for 3-4 years, problem developed again, so I has to put in a new zip tie, problem solved yet again, total cost 5 cents. This has been the most reliable vehicle I have ever had. I have only spent money on things that wear out such as tires, brakes, wipers, shocks, a couple of ball joints, belts, and fluids.

[@AngelHernandez-lv7xy]

Do you have a video on exactly what you did how to fix that play in the steering wheel I have that same problem and it’s very annoying

[@Patriot-bn9om]

@@AngelHernandez-lv7xy Here is a video that shows basically the same as what I did to fix it. Search KZbin for "1999-2006 GMC Sierra / Chevy Silverado steering shaft vibration rattle zip tie fix / hack / trick"

[@AngelHernandez-lv7xy]

@@Patriot-bn9om thank you I can’t believe it’s that simple and I’ve been sitting here dealing that rattling noise

[@thomassteele7451]

I’ve had my ‘03 Silverado now going on 21 years. Just had a recent surprise when I was pulled over for no brake lights. First thing I thought, a fuse. Never had fuse go out on this one. Checked a 10 amp at dash fuse box. Fine. Then tried a different switch at the brake pedal. Nope. Center brake light working. Didn’t know there were two separate fuses for brake lights. The other one I found out about when I Googled. VEH 15 amp was the culprit. As for common problems, haven’t had these 5, but had an early recall when the distributor was getting moisture. An alternator, the pumps, hubs eventually wore out. But went many years w/o anything, so I’m not complaining. The best vehicle I’ve ever owned.

[@whoisthis4130]

Out of everything that can go wrong with a truck these are nothing. I love my truck

[@catboi1188]

Which year which engine?

[@anthonybush9101]

Theses LS?

[@anthonybush9101]

Why it seems a LS ain’t nothing in a truck but everything in a car? Is it because a car is lighter?

[@sewfantastic7257]

Am with you, 1999 Silverado 2nd owner my father was the first. I only have replaced the fuel pump, a pulley, tires, windshield wipers,battery,oil brakes and a few fuses not bad for a truck that's pushing over twenty years and has been driven from New York to Texas,Oklahoma to Mexico and when she cranks up she sounds like she's fresh off the show room floor.

[@Chip57]

My 2004 Silverado 1500 4x4 w/4.8 has had 4 of your top 5, I’m the original owner and it has just shy of 214,000 miles on it. Additionally, I’ve replaced the “Cats” and O2’s. Always reliable! Go Bow tie

[@christine_penn]

I would add the following items to your list for any truck of that era. 1. Brake lines, they are very prone to rust and your going to have to replace them. 2. 4 Wheel Drive transfer case pump vein leaks. There are some nice kits out there to alleviate this problem. I have a 2005 2500 HD with Duramax and Allison. I have replaced both of these...(and lots of other things too...)

[@trevorjameson3213]

Why do people keep talking about rust? I've had my truck since '05 and there's no rust anywhere. Never even seen a truck with rust, must be the ones up north or something.

[@nulla6602]

@@trevorjameson3213 this body style wasn't as bad with the rocker panel rust but the older gm trucks are kinda known for rocker rust.

[@brianbrown600]

@@trevorjameson3213 The northern states have rust on most vehicles that see winter use. Rockers, cab corners, fenders, door bottoms, wheel well lips, rear bumpers, and even frames rust out up here. The fuel lines and brake lines get destroyed from the salt in the winter weather. I bought a 2002 Avalanche from Florida and had it shipped up here back in 2013 and kept it spotless by avoiding using it in the snow as much as I could. Rust free trucks of this generation sell like hotcakes up here. Could make a bunch getting them down south and filling the back of a car hauler to sell here.

[@buzztrucker]

Yep. My brake lines rusted out I was on the road and had a brake fluid leak. it was scary!

[@christine_penn]

@@trevorjameson3213 yup, mine is the Northeast. It's tough on vehicles up here

[@jessiecabrera8171]

I just did the smog on my 300k miles 2000 5.3 Silverado lol the tech was in love with how well maintain it was 😊😊

[@Lawnyyy-]

This makes me confident, I actually just bought a 2001 Z71 for 8 grand and it only has 80k miles on it 🙌🏽🙌🏽 taking it to a mechanic on Monday to get all the fluids flushed and make sure everything is good! It’s gonna be my daily driver/work truck from now on!

[@bergforreal]

Dude you lucked out!

[@eduardovega4439]

@@bergforrealhe did. Cant find any near me that have 180k+ miles

[@texanbull1077]

I’m about to do the same pard , I’m about to buy a 1999 z71 4x4 for 3700 with 150k miles in west Texas , should be worth it? It probably has a couple of issues , I’m gonna take my chances

[@pauloxenham2593]

I have a 2002 Z71.... 268k miles and still going like a champ. Just be mindful of the transfer case issue that develops from pump rub.... happened to mine... case saver on the back half of the case will prevent the pump from rubbing pinholes in the case. Something to look into...

[@Bford84]

You made smart investment I have a 2001 Silverado 288,000 the only major repair I’ve done was transmission rebuild s I have to fix the wheel bearings other than that it’s strong truck

[@vicarod]

4 out of 5 problems listed were summarized as: "no driveability issue" 🤣 We have over 180k on our son's 2000 Silverado. No major repairs. Been in the family since 2007. Love that truck. GMT-800 chassis trucks are bomb proof and will just rust away over time, except here in the South.

[@1AAuto]

Glad to hear that! 1aau.to/m/Shop-1AAuto-Now

[@juanguerrero2282]

I'm at 290k miles on my 2000 silverado. No major repairs needed

[@sewfantastic7257]

290k 1999 brought brand new no major problems.when she goes into the dealer for check up Dr. Always said just like the owner she doesn't look her age.

[@vicarod]

@@sewfantastic7257 200+k Still choochin' Greatest trucks ever...

[@Auden.]

I just bought one hope it lasts me a long tome

[@Mr.DirtySouth]

Just bought a poorly maintained 04 Silverado. This video saved me some headache 👊

[@RiverDayton1]

My buddy bought a 2004 for 5500. Not the best taken care of but it drives well. Just wondering if you had some success

[@alaverga173]

Rear Exhaust manifold bolts usually break in these trucks,and you were spot on about the evap system.

[@cameroncassel994]

Dont forget rear brake calipers, they are notorious for eating pads or fail altogether. Owned 2 suburbans and a yukon all had the same issue.

[@udaaz]

I have an 06 I have owned for 11 years I have done all 5 of these. I think some honorable mentions should be gauge cluster stepper motors, oil sump pick up tube o ring, intake gaskets particularly bank 1. Climate control fan speed resistor. Other than knees it’s been a great truck 210,000 miles on it doesn’t burn a drop of oil runs smooth and has never let me down

[@robertlawrence7107]

2006 with 290k miles. Having oil pressure issues and mild knock that goes away after warm up. Other than that super dependable! Love my chevy

[@DouglasPFresh]

Dash gauges, rear brake lines, airbag codes...

[@1AAuto]

Yup all of those. Thank you for checking out the video. If you need auto parts go to: 1aau.to/m/Shop-1AAuto-Now

[@Blue_Wizarded]

I have all of those problems

[@eliforbes4842]

@@Blue_Wizarded yup same lol

[@backyardtrailbuilders]

Air bag code I have a Chevy Silverado and the air bag code is on

[@eliforbes4842]

@@backyardtrailbuilders yup

[@andygrew4832]

Been driving an '06 for 15 years ND I've had to fix all of these problems. Spot on.

[@adamkorekach9936]

Anyone else have the Borg Warner ignition module go bad in their steering column? That thing totally knocked out all speeds of my heater and air conditioning fan, as well as my 4WD and ABS!! I was beating my head against a wall trying to figure out how to fix all those issues for years! Finally had a pro run diagnostics with wiring diagrams and scan tools and he found my truck’s problem within an hour. Only charged me $30! The part was like $40 and now it’s like I have a new truck again. Never give up.

[@djnee572]

You forgot to mention the stepper motors in the cluster. Definitely a huge issue

[@1AAuto]

+DJ Nee Thanks for the feedback!

[@digi3218]

The speedometer in my truck is the only one that has failed.

[@martytruelove5026]

BIG TIME

[@sammym.3346]

Should be number 1

[@Apexarmoryffl]

My truck has 116,xxx miles and I’ve already had to replace those.

[@johnjohnson2855]

200,000 miles on mine and it still has its original engine, trans and diff. No major issues just normal wear and tear items.

[@Moparguy511]

My 05 is still running like a champ. Love this truck very reliable

[@504CreoleCrystal]

DEFINITELY just repaired my tailgate handle yesterday!!! 😂 I had to replace those lil plastic clips in the inside. SUPER easy! I bought my 06 in 2013…I’m a few months shy of having it 10 years! All I’ve had to do is oil, tune up and replaced the battery! The most worry free vehicle I’ve ever had. I switched out the taillights, changed the factory radio, added amps and a few 6x9s but that wasn’t necessary….I just wanted to lol. I guess I’ll get around to getting new headlamps soon

[@Socal-1776]

Yup number one is my issue the knock sensor change it twice still throwing the engine light 😢

[@cardo1111]

I'd like to add: corrosion to the list including corroded brake lines if you live in an area that salts roadways during winter months.

[@1AAuto]

+cardo Thanks for the feedback! We'll pass this info along to our production team.

[@LoveDogs___3]

Try washing it off!!

[@squarenailco1747]

Agreed! Rusted bad even when washed frequent! My father in law keeps his clean and waxed and still has a problem in the corners, and the crevices. Not as bad as the Rams though. Still a good truck for a person that drives like an old lady!! 😜

[@MF-kb2nv]

Yep cost me 800 to replace mine on my 06

[@josephhaugen3207]

@@squarenailco1747 they make them like that on purpose

[@greenwood2194]

Got 267K on my 2004...4.8L transmission is strong...those Silverados 04-07 are hard as a damn rock.

[@relaxedgameplay8344]

Except the knock sensor, I've had all the others on my 05 100k. Also the water pump sorta exploded but super easy to replace. Great trucks!

[@Moviemaniac174892]

Pretty minor problems for a legendary truck, I love my Silverado

[@wademorris4698]

Im 45 yo and my 2000 currently has 416k no joke, real number . I've taken care if it with proper preventative maintanence. It was my first brand new truck and I will never parr from it. She is still a beast with minor upgrade and lots of cosmetic upgrades. More reliable than any human and some dogs. 23 year 416k and not shoei g any weakness . Change your oil people .

[@jeffharper7579]

Just got a 04 half ton 4 wheel drive with 278000 miles and I hope it is as dependable as my old 85 that got destroyed in late March by a tree. 287000 miles and still runs but I don't fit in it anymore.

[@jamiegarrett3869]

Wade nobody studying a DAM dog pal

[@allencooper517]

2000 with 87,000 miles, brake lines replaced, that's it, great truck

[@lernwithgern]

315k on my 06. Still strong. Tranny was slipping a bit but Lucas fixed that. Awesome truck.

[@bluegrasskid]

Which lucas? The conditioner or the normal big bottle?

[@lernwithgern]

@@bluegrasskid 340k now. Lucas makes a slip fix potion for auto trannies. Still holding up.

[@smokin19861]

In states that use salt in the winter, the rear brake line up by the fuel tank will rust out and break. I have owned 8 of these era of trucks and still own a 2007 for my work truck.

[@dailydrivensedans4875]

How do you make this list without including the 4l60e......everyone i know with one of these trucks has had too replace the 4l60e trans because if 3rd and 4th gear... i know some people on their 3rd before 200k miles. The 4l60e, tailgate handle, and balljoints are by far the most universal issues for these trucks.

[@kenman1717]

have changed tons of those knock sensors. up here in northern Alberta, the rear ones rot out, usually because of all the mud and water that gets under the rubber plug. more often than not i have to replace the valley cover also, after that rear sensor breaks off, then you have to pull the cover up over whats left of the sensor. with the seal staying underneath it usually holds all the mud in place, which is a good thing since its open to the cam shaft underneath it. and the rear hole of the cover is so rotted that it can't be reused. then i usually put a bit of silicone around the rubber plugs before i seat them in the holes, the put the little dam of silicone around the holes like GM says.

[@1AAuto]

Great tips! Thank you for checking out the video. If you need auto parts go to: 1aau.to/m/Shop-1AAuto-Now

[@jaimeocaneda394]

I’ve changed my knock sensors on my 2001 GMC. I used RTV black to seal the rubber grommets, no problems since.

[@mikemiller4954]

And here. I siliconed the fire out of my knock sensors to prevent rust. If I have to do it again I'd gonna be a mess. Lol

[@ItsRud1]

This video literally just named the 5 problems i have in my silverado. Thank you so much

[@9531-d7w]

Brake lines go bad and rust. I had a 2002 GMC Sierra, great running truck. Brake lines rusted out around 100k. Rocker panel and wheel well rust was bad. Spring hangers rusted and the rear of the leaf springs came through the bed at 170k in 2016. Engine and trans still ran like brand new.

[@staysolidstaysolid3758]

I just brought a 2000 chevy silverado 1500 vortex engine 5.3L with almost 300,000 miles truck runs beautiful im in love with it already

[@anthonymcgill2633]

Same Just bought an 01 with the z71 off road package runs beautiful make sure to check all your fluids and oils though had to change mine but got a piece of mind

[@staysolidstaysolid3758]

@@anthonymcgill2633 thanks I appreciate it i will be doing a full tune up sometime this week

[@Joe26003]

Had a 2004 Silverado 1500 for 14 years. Only had few major problems. For the Front Wheel Bearing, everything I read or watch said 30 minutes to repair. They were partly right. Took about 10-15 minutes to disconnect everything and 15 minutes to reinstall. Took many hours to get it out! Heat and penetrating oil over the day a few times and some 5 pound sledge hammering finally got it out! :) Replaced the dash instrument cluster, easy fix. In the end, wouldn't pass emissions test. It wouldn't clear two OBD, Cat and Eval. No matter what I did, they wouldn't clear. Wanted a bigger truck so traded it in for a 2021 Chevy Silverado 2500 HD WT.

[@leghumper1574]

I've fixed at least 2 of these problems in 245,000 miles. But maintenance is the biggest thing for these change your fluids keep up on greasing your hinges.

[@ItsMichaela_F]

Love this generation of chevy more than any cars and I ever owned. Never gave me huge headache on my tahoe 290k miles on original engine. The trans are little trippy but lucky easy replacement or Build one. Love these trucks. Going look for another one.

[@catboi1188]

So a good buy??? I'm looking for a 4x4 short bed

[@combativetvpilot7720]

I just got one i love those truck alot already but it has the knock sensor, evap, and tailgate issues. I plan to have it addressed asap as i want to baby and take care of this vehicle.

[@arnoldseay9118]

I had a 2003. I had none of those issues. I had problems with dash lights, oil pressure sensor, airbag sensors ,fuel pump which I remedied by putting a Carter fuel pump on and finally intake gasket at about 185000 miles. Overall a very good truck.

[@andrewpratt6020]

I cannot get my check engine light to come on therefor I cannot pass inspections. What do you recommend? I’ve replaced bulbs and it didn’t fix anything.

[@arnoldseay9118]

@@andrewpratt6020 put it on a code reader. You possibly have a computer problem. Try disconnecting the battery and totally discharging to try to reboot the computer.

[@Harold16785]

I've owned a 2004 with 5.3, and currently own a 2005 with 5.3. Both 4x4's. My opinion is the best thing about these trucks is the engines. LS are great durable engines. Other things have been money pits. I'll never own another.

[@allenfritz3437]

I found a 2006 fully loaded with 69000 miles a few years ago and have loved it so much. The only problems I have had are very minor and incredibly easy to fix. I'm about to throw some new shocks on tomorrow which I hope will help with small amount of bouncing when towing my boat.

[@jessebagwell4187]

156k on mine and the computer went out. 06 as well

[@allenbass6169]

Have a 99. They are good trucks. Easy to work on when there are problems.

[@aytviewer2421]

I've had 3 of the 5 issues with my 2005 that I bought brand new in 2005. It now has 243K miles and climbing! I think the speedometer issue should be on this list too, along with the heated seat elements (if you had the leather interior). Great truck overall. Engine has been SOLID. Oh... the three I've had is the fuel vent canister, knock sensor (I replaced both and the wire harness when one went), and of course the tailgate latches/handle that just failed after 17 years of use. My truck used to be my mining vehicle and has seen many many rugged off road miles over the years and now just pavement and beach sand these days.

[@angelmarrodxn3861]

Sounds like something I need to do

[@djleo68]

I have a 03 Silverado 4.3 200,000 miles bought it brand new not one issue runs perfect never had to do anything to it

[@miketrimm3914]

R &R Intake manifold gasket and fuel lines at 85 000 miles. 2003 v-6 4.3 litre. Brake lines and front hubs at 80,000 miles. Rusty rockers, cab corners, cab mounts. Michigan salt truck that got washed once a week in winter. Speedo and water temp. gauge stepper motor,.rear rotors rusted 3 times.

[@chrissingletary2287]

Front and rear exhaust manifold bolts breaking. If you own one of these trucks, look at yours. The head of the bolt is probably missing.

[@rudociliak6683]

yea thats true mine are being replaced soon thankfully the manifold kits are cheap themselves

[@jafquist27]

and the annoying exhaust leak as a result. It sounds much like lifter tap, but is not. Totally random too. Hot? Cold? Wet? No rhyme or reason. Sometimes it ticks, sometimes it doesn't. I still love my truck.

[@jackslack7473]

My 04 just hit 205,000 miles and only issue I’ve had is getting a light for the evap I just haven’t gotten around to replace it

[@josephhaugen3207]

I own a 2003 Silverado ss 6 liter all wheel drive 246000 miles very little problems best truck I ever owned 💪👍

[@A49907]

Same! 149,000 miles on mine.. best truck I’ve ever owned.

[@Brendan656]

150k is the break in period on these ​@A49907

[@BigBerg95]

The one you didn’t get is the ole great P0300 the mystery misfire. Can be so many things. Cheapest to start out is plugs and wires, than maybe a coil pack, if not either of those injectors plugged or never off. Always a fun chase!

[@Dr.Westside]

It's always coils and the easiest way to find it is to use HP tuners or something that can actively read the coils . It took me 14 coils to get eight good ones for the first time I changed them . Then I bought NGK. It took 8 coils to get 8 good ones . The MSD coils I bought were nothing but junk .

[@Aptenodytes]

I've had every single issue in this video with my 2000 5.3. When my knock sensor/s went bad, I dropped a bolt into the top of the head when I moved my intake off the top of the engine. I never knew and started it and ruined the whole engine.

[@AlexanderMcQueenWallet]

That’s actually tragic.🥲

[@joshmitchusson5741]

You my friend, lived an actual nightmare. My deepest condolences.

[@Aptenodytes]

@@AlexanderMcQueenWallet yeah it sucked. Still got the same truck (one in my profile) new engine and a transmission rebuild later. This happened after my original post but the new engine had significantly more power and just destroyed my 4l60e completely.

[@Aptenodytes]

@@joshmitchusson5741 yeah it sucked. Still got the same truck (one in my profile) new engine and a transmission rebuild later. This happened after my original post but the new engine had significantly more power and just destroyed my 4l60e completely.

[@TheLawrence1999]

I have been searching to shaking and grabbing looking for whatever the clicking noises were in my steering, even spent money to rebuild the front end and couldnt find anything wrong. Until I watched this video and you said something about the steering shaft I would of never known what was going on. Im finally glad to find out whats making that annoying noise.

[@UPINDAT247]

Love my 2003!!! Back when Chevy made trucks that lasted !

[@jerrystephenson1172]

Agree, my 03 has been awesome, no major issues.

[@jeffharper7579]

I just started to part out my 85 Scottsdale 3/4 ton with 278000 miles still runs great but a damb hickory tree fell front to back now my cab is touching the back of the seat. I just bought a 04 half ton 4 wheel drive with 260000 miles I hope it is as dependable as my old one. I used the old hardware and tailgate to make a work bench .

[@williamstubbs9737]

brake lines have a high failure rate. I had to replace all of mine. Thankfully it ruptured while i was working on the brakes. Pumped the pedal , then nothing. Big puddle of brake fluid on the driveway and a ruptured brake line. Check drivers side next to the frame is the most common area where they rust. 2001, 1500, 5.3, 4WD

[@russell6022]

Almost a quarter million miles on mine, replaced only the fuel pump, coil, wheel bearing. Trans slips a bit at times, otherwise no leaks, knocks, or smoke. The A/C even still works!

[@claytonsimplot9554]

It must had been assembled Tuesday,Wednesday or Thursday . Good luck on Mon.or Fri.!

[@redwolfmaddox3986]

Also I’ve replaced the entire tailgate latch and handle assembly and still need to use a screwdriver or pry at to open it

[@marvinwilliamson811]

Fuel gauge sensor on my 2000 is sporadic but I'm not replacing the fuel pump that works fine. I just deal with gauge that works when it wants too.

[@exc-ption]

Same problem with mine, it does better the more fuel is in it

[@randomshortz17]

06 1500 with the 4.3 only thing I've ever had to replace was calipers rotors brakes and oil

[@j.cooper2246]

Blower motor resistor very common, door handles,water pump block gaskets,trans,transfer case ,tow haul wire break in column, rear spring shackles,long list.miss my 97.better built than my 04..

[@digi3218]

Blower motor resistor and extended cab door handles are good ones. Ive replaced water pump gasket too.

[@digi3218]

I like my 04 and was thinking it is a pretty decent truck. Never owned anything else though

[@1AAuto]

Thanks for the replies! 1aau.to/m/Shop-1AAuto-Now

[@jaimeocaneda394]

Headlight ambient sensor.

[@jamesredmon6221]

A major issue with these, specifically the 4l60e and 4l65 trans, the sun shell retainer was a faulty product from the factory and can literally go out at any time and any mileage and will result in a trans rebuild/replacement!

[@Toolaholic7]

Left out brake lines,all 5 brake lines get replaced at the same time when they go.Luckily there are NI COP and stainless steel pre bent brake line kits out there.Poorly casted cylinder heads with the 4.8,5.3 and 6.0 from the factory.It is in the middle headbolt hole area,cracks there which there was not a middle support casted in.Complaint is coolant loss with no outside leaks.

[@jondoe4667]

My 2000 z71 has had a whole host of problems but none of these. That being said I keep it clean, and fix things when they fail. 278k and it runs smooth, and quiet and gets me where I'm going every day.

[@ykmalachi]

Nary a mention of the fuel pumps. I've changed about 75-80 fuel pumps..... not one steering shaft

[@1AAuto]

Good call! It should have been in there. Thank you for checking out the video. If you need auto parts go to: 1aau.to/m/Shop-1AAuto-Now

[@thehairyh2o458]

@@1AAuto nice humble reply.. always a breath of fresh air to see a car guy be kind! take care, I just bought a 2004 Silverado 1500... it's fantastic, thanks brother.

[@LoveDogs___3]

YEP!! MINE TOO!!

[@jaimeocaneda394]

2001 GMC SLT I have changed my fuel pump twice already.

[@Gearhart.]

I had to change out the fuel pump at 190k on my 2003 silverado 4.8l 4x4. I'm getting lifter noise now but other than that it's been very reliable.

[@rickylee4228]

I’ve owned an 05 Silverado Quadrasteer since 2009, awesome truck. I did have a knock sensor go out, I got the relocation kit and relocated both sensors. Easy peasy to get at now if I need to. A couple other things that are common problems are front air bag sensors failing (easy fix), and the HVAC fan blower motor resistor failing (also an easy fix).

[@Bassman018]

I had an 07 2500 with the 6.0, my truck had all those problems, it was still a great truck though, I miss it.

[@darioperez5084]

I got thus same truck with 117k miles v8 runs gooda

[@benanderson1933]

I’ve had the same issues on my 2006 4x4 with 5.3, 200,000 miles. Front hub bearings and brakes are easy to work on. Also have replaced the oil pressure sending unit . Another common issue is the AC blower resister located under the plastic cover on the passenger side floor board. All in all I’d say it’s still one of the best vehicles I’ve owned. Done 98 percent of the repairs myself. Way easier to work on the new stuff coming out.

[@uncannyvalley3190]

The only problem I’ve had with my Silverado is the damn heat shield rattling. I’ve already ripped off the lower half, now the upper half is about to fall off.

[@mikem6176]

I’ve read that the oil pressure sender fails a lot too. Easy fix if you happen to own the “special tool” to get the thing off & on.

[@jose9th]

Thanks for this video. It came up in my daily subscriptions page. I own a 2005 silverado and my vehicle has both of the issues you mentioned about bad wheel bearings. I already ordered them and have them but I was unsure if this was actually the issue. Now I know for sure. Thank You!

[@1AAuto]

+Z H Thanks for checking us out! 1aau.to/m/Shop-1AAuto-c

[@lynskeyti9940]

This year range are light years more reliable than todays

[@ActionMotorsportsCA]

Abs modules, water pumps, front hub bearings, knock sensors, rear e shoes on rear disc brake models

[@thooks1234]

You forgot having to take the instrument cluster out in the 2000-2003 year models and send it to ONE GUY IN THE US that knew how to re-solder all the poorly soldered connections that made the cluster look like a Christmas tree.

[@jeffalan6339]

This guy knows his stuff I have electrical problems.... Horn is inop, no power at the fuse either side. The radio and key chine when below 40 are inop. Few other problems. The first video I saw was very informative. I'm sure his shop is extremely busy.

[@hwolf8]

Stepper motors in dash, front wheel bearings, brake lines, transfer case, intermediate steering shaft, tailgate hardware, interior door handles, AC dampers servo motors, windshield washer pump and hoses, power steering fluid cooler... im sure I’ve forgotten other items I’ve fixed/replaced on this truck.

[@fordracer1415]

Transmission cooler lines window regulator

[@MF-kb2nv]

Those damn servo motors...junk

[@SharryHawley-jx7hd]

Hello I had a gmc yukon 2007my speedometer Guage not working but the rest still works, so I'm confused if it the fuse or sensor,

[@aaronsmoltz4104]

No mention of the oil pressure sender leaking/reading 0psi?

[@Pr0digy47]

Fuel pumps and water pumps are notorious on these as well

[@jimgallagher2979]

I've got 240,000 on a 2000 Silverado. Very few problems outside of normal maintenance. The only one on the list is the tailgate handle was replaced at 200k.

[@juanguerrero2282]

I'm at 290k miles on my 2000

[@caskin95]

Forgot to mention a lot electrical problems you can get a check engine light from a fog light that sucks

[@kenhorne5650]

2002 with 250k miles never had any problems except transmission. Always have regular maintenance at Chevy service

[@jamiegarrett3869]

This is the best video I've seen. This S.O.B is definitely a good technician

[@dennisa3419]

320k on mine and she’s still strong. If you take care of them they will take care of you

[@1AAuto]

Agreed! If you need parts for yours, please visit 1aau.to/m/Shop-1AAuto-Now

[@garygraham2974]

Hi I have a 08 cateyes Chevy with dual gas tanks not transferring fuel

[@sublordlord7834]

You forgot the pump rub on the transfer case!

[@dan260140]

Once you gave these issues about the Chevy made me say your pretty legit because I had all them issues lol. Your trust worthy in my opinion

[@dioad1739]

Not to mention bump stops all mine were rotted of but I can’t get hesitation gremlin out of my 99 if you need passing gear Lol.

[@TheGregWallace]

Comment.....You forgot a few more........blower motor resistor switch and wiring harness, step motors on the gauge cluster and the perndel indicator light.....

[@rockyesterline7942]

I had a 99 Chevy Silverado 5.3 339000 miles no smoke ran like new I only change the alternator new radiator new brakes new fuel pump spark plugs tires and that was about it original starter I cannot believe it change oil and filter with full synthetic oil every 4000 miles

[@bryanyoung2963]

My 99 Chevrolet Tahoe had 300,000 on it like you only did the brakes tires one set of plugs and wires fuel pump and I used regular Pennzoil motor oil 5w30 didn't use synthetic and for the most part I want to change it every four to five thousand miles oh and I did my battery for it those AC Delco batteries are junk let me get it to my son at zero issues no problem and used a half a quart oil between 5000 mi oil changes and what alternator and I don't really understand why these are considered 5 major problems?

[@rockyesterline7942]

@@bryanyoung2963 none of those are major problems that is maintenance only so whoever says they are major problems they are crazy

[@bryanyoung2963]

@@rockyesterline7942 not that my opinion matters but I agree with you 100% had a mechanic tell me that the motor and transmission would probably still be running when the body and interior fell to the ground no rust issues but the interior she'd seen better days and you can imagine but three grandkids and two kids

[@bryanyoung2963]

@@rockyesterline7942 I agree totally but the way people today seem to find a fault with everything it's unbelievable. I Don't worry about cosmetics as much as I do dependability transmissions that don't work serving eviction notice to a rod oil pan becomes a exit I don't know how old you are but I can remember one of my cars a 73 Ford Torino had just a AM radio my Impala had a AM FM radio with eight-track CB radio those were considered luxury items and my may pop will pop tires always popped always

[@Albee213]

Oil pickup O-ring, $1,000 job on a 4x4 model and the ground wires. If that O-ring fails it will not deliver enough oil to the valvetrain and destroy your cam and lifters, ask me how I know LOL. Corrosion is also a problem. My truck brake lines disintegrated and left me driving a 6,000lbs+ truck 10 miles with no brakes. Yeah, my butt puckered up a few times! Other than that, it's an awesome truck.

[@richardfettig5974]

what about the banging in the motor when it's a cold start? then go's away

[@SnowMizt]

My beater 2004 just hit over 395,000 on the original motor but she does Leak oil