Install video of the Navitas 5KW AC conversion kit on a EZ-GO TXT golf cart.
Пікірлер: 85
@MattyRocco3 жыл бұрын
Thanks so much for this. Haven't seen a video of the motor being installed on a fully built cart, only on a bare frame. Super helpful.
@Amicodablack2 жыл бұрын
Always an informative cart video...not ta go off topic but you definelty look like the white ice cube...
@1kzrider3 жыл бұрын
Yea, would like to see total break down of cost. Of EZ cart-lift-rims\tires-new conversion kit.
@williamcheek89672 жыл бұрын
Great viid. Noticed at the 10:40 mark that you've got a 16 penny nail in your driver front tire... Hopefully you found it already without issue!
@beckyanddaveporter11222 жыл бұрын
Hey! Thx for the video! I am just starting out on building an electric golf cart. Any recommendations on where to start. I need just about everything except the batteries since I picked some up already.
@portlandlocalchurch81682 жыл бұрын
For an AC motor and controller conversion of my 80s 48v ezgo do you recommend the navitas controller and navitas AC motor or the plum quik Motor?
@TheDouglaswilfer Жыл бұрын
hello, do you have electrical schematic of Curtis 1515, I need to make a modification on my golf cart! tanks!!! lol
@allandenola59682 жыл бұрын
Great video loved it . What does the 5K kit have or do vs the 4 k kit? It’s only 100.00 more but I don’t see any difference in speeds . Should I just buy the 5K
@PlumQuickRacing2 жыл бұрын
5 kw has more torque
@bjbrunetti11 ай бұрын
Well it fit a non lifted g29?
@ipgdev9598 Жыл бұрын
I just bought the same system from Matt at Plum Quick. I have a 36v series and pulled everything out and converted to a 48v. How do I wire the dash Fwd/Rev switch? The wire harness I bought appears to connect the switch in the body behind the knee. I have the Sw180 Curtis Solenoid as well.
@PlumQuickRacing Жыл бұрын
Get with Matt on Monday and he'll direct you in the right direction.
@SinisterMD2 жыл бұрын
Thanks for the video. Curious about a comparison of the stock battery life/range and this. Clearly it's going to be worse but how much worse are we talking?
@PlumQuickRacing2 жыл бұрын
AC is actually less drain on your battery pack, it's more energy efficient.
@TheNicko7732 жыл бұрын
@@PlumQuickRacing I have the full Navitas A/C kit installed, 23" tires and everything else. The only time the A/C is more efficient is if you don't jam at full speed the whole time. If your going over 30+ and using fast acceleration the whole run, your batteries drain much faster. If your going only 20-25 mph you get better range than the D/C.
@lotusguy01 Жыл бұрын
Great video. I am doing a 32v conversion to 48v. I see you replaced the solenoid. Which one do you recommend for this controller?
@PlumQuickRacing Жыл бұрын
You can use any good 48 volt 400 amp solenoid.
@billyt44482 ай бұрын
Love the video used it for my hook up, but I can’t get my pedal to communicate with a programmer. I wonder if you can help me figure it out
@PlumQuickRacing2 ай бұрын
1-800-333-1194 Ext. 305 for tech support
@stuartwickersham857 Жыл бұрын
Do you have any more pictures of how the solenoid is wired with the remaining smaller wires thanks
@PlumQuickRacing Жыл бұрын
plumquick.com/maintenance/techtips/ look in this link and you'll find this info
@Paul-MavenАй бұрын
I'm just curious. In my 2019 cart I upgraded the batteries and charger where I put 4 x 12v LiFePo4 batteries instead of 6 x 8v lead gel batteries and I'm wondering how well this kit will work with those batteries. I think there shouldn't be any problems.
@PlumQuickRacingАй бұрын
No, problem if you run enough AH
@billingram74182 жыл бұрын
So if you go into the app and tell it you have different size tires than you do can you get even more speed out of it? Will it fool the controller and motor so you can go faster than the 35 mph?
@PlumQuickRacing2 жыл бұрын
You can only get so much energy out of a battery pack regardless of the settings, lithium will get you higher speeds.
@jsethl132 жыл бұрын
Since my 2008 EZGO TXT/PDS is currently 36v and I want to convert to 48v, will I need to purchase different batteries for it to work efficiently and not drain too quickly? Will it even function with the batteries I have now? TIA
@PlumQuickRacing2 жыл бұрын
You'll need to convert to 48 volts for the 5KW AC conversion kit
@CityGirl3311 ай бұрын
Do you have to be in the dealer settings to be able to change it from the priest at 25 mph up to the full potential of 35 because I saw another video that said you have to change your RPMs to 6500 and that part doesn’t allow me to make a manual change on the app
@PlumQuickRacing11 ай бұрын
The user app allows you to make these changes.
@dgvette1 Жыл бұрын
Will this work with Lithium batteries found on the new EZGo Liberty?
@PlumQuickRacing Жыл бұрын
Depends on controller
@agentmichael_scarn34742 жыл бұрын
How many miles will those Trojan batteries last on a full charge with this navitas kit? I want the navitas kit but don’t want to spend over 2,300$ for a LI battery.
@PlumQuickRacing2 жыл бұрын
Good quality battery pack should get around 20 miles
@agentmichael_scarn34742 жыл бұрын
@@PlumQuickRacing dang… that’s it huh?… is this estimate for a cart with no lift and stock tires?
@PlumQuickRacing2 жыл бұрын
@@agentmichael_scarn3474 This is estimate, every cart will vary depending on several factors.
@cameronlott2303Ай бұрын
You think if i did the 72v ac conversion, could i use 6 12v regular batteries, or do you have to do a 72v lithium?? Thanks!!
@PlumQuickRacingАй бұрын
You'll have to run deep cycle golf cart batteries
@cameronlott2303Ай бұрын
@@PlumQuickRacing so I wouldn't need lithium? I could use 12v deep cycles instead? And just get the 72v solenoid instead of the 48v? And also why doesn't everybody just get the 72v if you can just put 6 12v deep cycle lead acid batteries for like 40-50mph over doing the 48v which is 35mph? All the difference is, is the solenoid is 72v and u got 12v batteries, right? Or is there a downfall to having 72v on this system? Because I believe this same system you installed is good for 72v also.
@PlumQuickRacingАй бұрын
@@cameronlott2303 6-12 volt batteries are going to be hard to fit under the seat and you'll have a greater weight load
@cameronlott2303Ай бұрын
@@PlumQuickRacing also, with the 600a kit. Is deep cycle lead acid batteries ok? Or do they not put out enough amps for the controller. Because idk if that controller will put out 600a but for a second when you floor it maybe?
@rippinlip12 Жыл бұрын
Have you ever worked with the badboy buggie system
@PlumQuickRacing Жыл бұрын
Sorry, we don't offer anything for these.
@floggerman562 жыл бұрын
I am converting my cart to a 72 volt 6-12 lithium batteries with the Navitas 72 volt controller and 5 kw motor. What speeds can i expect?
@PlumQuickRacing2 жыл бұрын
40 to 50 mph
@floggerman562 жыл бұрын
@@PlumQuickRacing Thank you !
@stevenacosta8953 Жыл бұрын
Can you keep the original motor and still use the Navitas Controller with it?
@PlumQuickRacing Жыл бұрын
Yes, not AC but a DC controller.
@stevenacosta8953 Жыл бұрын
What will the speed increase to with the stock motor with the DC controller? Right now mine goes 12mph
@oscarluzio41894 ай бұрын
I have EXGO txt 2006 36 volt can i upgrade to 48 volt? I would like to know what do i need to do it ?
@PlumQuickRacing4 ай бұрын
email matt.steen@plumquick.com and he will give you your options, thanks
@dannyrogers23513 жыл бұрын
What was the price for the kit?
@finnkiper97512 жыл бұрын
1800
@djcdan55693 жыл бұрын
Did this decrease battery life
@gideonstibor25192 жыл бұрын
I'm wondering the same
@davekenyon95824 ай бұрын
No one can answer this. I have an ez go 2001 cart. I have an Alltrax controller and a lithium 52 volt battery. Also 24 inch wheels It runs 29 mph plum quick says if I install the demon motor I can run 40 mph. Is that possible before I spend 900 on the motor
@PlumQuickRacing4 ай бұрын
Demon motor listed as this..........New Custom Built Motor, Class H Motor Rating, High Performance Brushes, Torque/Speed EZ-GO 48 volt Series 19 spline 16.7 HP, Speed 28-30 mph (estimated) and added 50% more torque *must upgrade controller*, flat terrain and a good quality battery pack. With the lithium pack and taller tires you could see around 35 mph.
@SolarGuy-gc4ry21 күн бұрын
Can you set the speed faster than 35mph?
@PlumQuickRacing21 күн бұрын
yes, you can run 72 volts and or go with 8:1 gear set
@joaquinrodriguez39142 жыл бұрын
Is it possible to make this setup solar?
@bbllaakkee Жыл бұрын
no
@trevorjames9282 Жыл бұрын
How did you get the dealer app?
@PlumQuickRacing Жыл бұрын
navitas dashboard app
@mjpopp2 жыл бұрын
The problem is their customer support is horrible. Nobody is ever there to answer a phone. So if you have an issue during a install, good luck getting an answer in a decent time frame.
@PlumQuickRacing2 жыл бұрын
Covid has hit our shop hard with 6 positive results and one passing away over the past 45 days........sorry, doing the best we can.
@rogernascimento50062 жыл бұрын
How much did it cost for the motor and the controller and the cable let me know thanks
@PlumQuickRacing2 жыл бұрын
plumquick.com/ac-conversion-kits/
@MrbrentLa3 жыл бұрын
Could anyone actually read the GPS at the end?
@capt.lennymiller65242 жыл бұрын
Exactly, I was wondering the same thing. The other question is what effect the 23" tires had on the speed?
@dgvette1 Жыл бұрын
Hell no
@CristianZamora Жыл бұрын
hey guys. Anyone here know a guy that has one of the Danaher handsets that would be willing to shoot me the wiring diagram at the serial port plug at the base of the handset? My girls yanked my wires out...
@alanroberts37652 жыл бұрын
What about the rxv its already ac
@PlumQuickRacing2 жыл бұрын
All you need is a 600 amp controller, 2ga wires and a HD solenoid for up to 30 mph
@aronbjorkqvist6_620 Жыл бұрын
Where do I order everything
@PlumQuickRacing Жыл бұрын
Call 1-803-548-7205 ask for Matt or email matt.steen@plumquick.com and Matt can help you in ordering what you need to make this conversion. Thanks
@CityGirl3311 ай бұрын
How to change the RPM?
@PlumQuickRacing11 ай бұрын
you have to download the user app.
@djquick Жыл бұрын
Why do they call this an AC motor?? This is a brushless DC motor.
@donniecahill52432 ай бұрын
Because it is an ac motor, there are 3 phases on the brushless motor hence the 3 power cables. All brushless motors are 3 phase.
@james107392 ай бұрын
Damn $2000 tho
@Dave-co1cv2 жыл бұрын
You forgot to mention that your modification is illegal for use on a golf cart, and may only be used if the cart is being converted to a Low Speed Vehicle, which must then be weight certified, include headlamps, taillights, turn signals, horn, seat belts, DOT approved polycarbonate windshield and wiper, inspected by the DMV, issued a VIN & vehicle title, automobile insurance, and lastly, a registration plate. The operator must also have a valid driver's license. (25-year LEO - Florida State Trooper - retired)
@PlumQuickRacing2 жыл бұрын
Dave, golf cart regulations vary from state to state. This is why the kit comes with a on-the-fly programmer which the customer has to get the app to set up the speed and before it can be saved in the app the customer has to click the "customer accepts all liability" before it can be programmed for higher speeds. Just so you know in SC you ONLY need insurance and a $5.00 one time DMV sticker to drive the cart within 4 miles of your residence on 35 mph roads and you can cross over higher speed limit roads. Thank you for your service.
@zakkul6242 Жыл бұрын
You sound like you grew up in California 😂
@bbllaakkee Жыл бұрын
LOL
@rickyweymers920920 күн бұрын
What a freakin loser 10 year truck driver active 😂😂😂