Short video showing you how to test and repair a non functioning blower motor in your 2006 Chrysler Town and Country , Dodge Grand Caravan
Пікірлер: 403
@patspalace6 жыл бұрын
MY goodness, thank you so much,went and got the new resister last night,found the right wrench,flash light etc. down to the under ground parking, did exactly what you said and within minutes I had it done ,one broken thumb nail !!! Cost me $22, a wee bit stiff,do not bend so well anymore. I am an 80 year old Grandma. Once again thank you, God Bless.
@carlmoody19355 ай бұрын
God bless you grandma,your awesome,keep going😁
@underwaterlover114 жыл бұрын
I pulled down the glove box and hit the blower motor shazam it worked just fine. I had already replaced the resistor and the control panel It happened to be minus 32 here in Calgary Canada and the blower motor kicked in halaluia brother sometimes miracles do happen. Yeah if your having problems with motor. Just give it a wack with a pair of channel locks.
@honeybunnz123Ай бұрын
@underwaterlover11 Hi there, I have been trying this and it's worked like a charm for the last six months. But now my air won't come on at all even when ai hit the motor. Do you think the blower motor is finally gone or the resistor has failed? Or should I just replace both to be safe? Mechanic quoted me $1500 to fix and that's crazy. This seems too easy to replace.
@joelsiftv3267 Жыл бұрын
Was in my car getting ready to do a full repair. Saw you hit the bottom of the of the glovebox, gave it a try myself and no joke, my air kicked on. Absolutely unbelievable. You’re the bomb!
@thirty6pacАй бұрын
As a transmission rebuilder I understand a great deal about all vehicles. But you just saved me a bunch of time with this vid, Thank you. My wife will be happy and I can go fishing instead of spending my day working on the van. 👍
@wefive35016 жыл бұрын
My fan runs either High or Low. I learned how to use my test light probe that has been sitting in my tool box for 40 years and how the blower circuit works. I see right where the resistor pack is located before I start accessing and troubleshooting. You save me a lot of time and aggravation. Thanks!
@MatthewJeremiah-n2t4 ай бұрын
Just replaced my blower resistor without testing anything. That wasnt the problem. Thanks for putting in the wiring information so i can now go test and find if its the controls or blower motor. Great video
@DarrenMclarnon5 жыл бұрын
My heater kept knocking off and on but my car was way to new for the heater to be burnt out so I checked the pollen filter and surely enough it was completely clogged up and black I changed it and no problems at all! So easy to over look the basics thank god I didn't pay 100 for a new motor for the same thing to happen a few months down the line
@AlSteel993 жыл бұрын
Perfect how-to. Concise and easy to follow. Solved my ac fan issue in 5 mins for less than $20! Thank you!
@allsopgreg7 жыл бұрын
Very informative. After watching this I called my local Autozone, confirmed that they had the part, picked it it up and spent all of five minutes replacing it, using the 8mm socket driver that Eric indicated. All for $13.99! Oh yes, it's going to snow tomorrow! Thank you so much!
@michaellitscher94565 жыл бұрын
The resistor pack can get very hot, hot enough to melt the plastic on the electrical connectors, leaving you with burnt plastic on the copper contacts inside the connector. The layer of carbon left over from the burnt plastic provides even more resistance, and thus heat, to the connector. I went through three resistor packs in a year before I figured this out. The best way I found to get the connector back to bare copper is to use the small nail file from a nail clipper. Insert and remove the file a couple of times, turn it around and do it again, and you should be good. Also, spend the extra $2 and get the resistor pack with the lifetime warranty, and keep the receipt right in the glove box.
@michaellitscher9456 Жыл бұрын
@@MrDepodot7 I cannot disagree, if you can get a pig-tailed connector to replace it with, because the original can get pretty melted.
@jjromano42043 жыл бұрын
My blower just quit running. Wasn't sure if it was a switch, resistor or fan motor. Took a chance as this video made it easy to replace and was a cheap part at AA in stock. Took longer to pay for the part than to install! Thanks for the helpful video! Cost me $17 plus gas to repair.
@aaronrienas61285 жыл бұрын
Thank you! My wife's town and country's blower motor quit. I did your tests and determined the blower motor was getting proper voltage. Then I remembered you hit the motor, and it worked!!
@TheAmericanman592 жыл бұрын
Helpful guy who's good at electrical trouble shooting... you can tell. Understands wiring and diagrams. Made this job understandable and a breeze to do. Thanks!
@jaytees64203 жыл бұрын
Exactly what i needed. Thank you so much for the clear step by step process. I replaced the blower motor first but no luck and wasnt sure what to check next. Saved days of trying to figure this out!
@OGsmooth-o2v4 ай бұрын
I did what you said I whacked it a few times and it started blowing, thanks man saved me money and time.
@hatfez6 жыл бұрын
I gave my wife a rubber mallet to keep in the car when the motor stopped until the motor I ordered was delivered. I explained that the brushes were worn and that a total failure was just around the corner! Thanks for posting this video on the resistor unit.
@865P7 жыл бұрын
22 deg here in Ohio. Blower went out this morning. Searched for a fix and yours was the first to come up. 1 hour later and $15 and I now have heat again. Thank you !!!!!!
@l3luemang0 Жыл бұрын
Bro I had already checked fuses and relays then found your video. Just had to wack the underside of the glove box once and it fired up LoL. TY so much
@alalbatross65493 жыл бұрын
Thanks. You're the only one who eliminated the possibility of fan speed selector being bad.
@davemcddd5 жыл бұрын
Yet another one of your videos that helped me quickly diagnose a problem with my 2007 Town and Country minivan. This time the front fan blower stopped working, so based on watching your tutorial, I was able to prove the front fan blower relay and fuse were good. Plus the fan motor worked fine, and the fan speed switch worked fine. Replacing the fan speed resistor cured the problem. Thank you for posting these great videos!
@cloose8 ай бұрын
Thanks for explaining how to test it. I hate trying parts until it works.
@riemerclan7 жыл бұрын
You were right on with this video, thank you. Made the repair easy and inexpensive. I watched this video a few times, made notes on the wiring colors, and went at it. Again, thank you for your advise!
@SouthMainAuto7 жыл бұрын
Glad it worked out for ya :)
@willfrat8383 Жыл бұрын
all the way from McAllen Texas. Great big thanks for Eric in New York. Your help with these videos make all our lives easier to handle unpredictable car problems.
@alanmoffat46803 жыл бұрын
G'Day Eric from sunny warm Queensland Australia. Just bought a 2005 Chrysler Grand Voyager with, you guest it, no functional blower motor. Found your video and I did it too. Motor blower works well, now to get cold A/C out of it. probably just a re-gas after some 300000 Klms. your video and a $20 part fixed it.
@matumbomabeco50858 жыл бұрын
This video saved my life I removed the wires from the socket trying to fit the wrong resistor just to forget the order , so I order the right resistor and sorted the wires thanks alot
@larryreynolds6935 жыл бұрын
Had a friend come to me with no blower motor was going to replace it and ran across this blower motor vid thank SMA saved money time and no shop fee. Keep your vids going love them.
@geoffspear9 жыл бұрын
Thanks so much for this. Was able to diagnose bad resistor with your information and a multimeter, fixed for $16 part and about 30 seconds of labor installing it (not counting time verifying voltages correct on the wires...)
@SouthMainAuto9 жыл бұрын
Geoffrey Spear Cool glad it helped :)
@megaloogy9 жыл бұрын
Good video. I like it when commentary is clear and organized with good video. Keep up the good work!
@SouthMainAuto9 жыл бұрын
Thanks Don! Pretty new to the whole KZbin thing lol, just trying to get my name out there and gain a few subscribers while attempting to provide good information.
@rockyortiz16154 жыл бұрын
South Main Auto Repair LLC how much was the job?
@jeremyhelton9847 жыл бұрын
Eric O to the rescue again, 10 below zero today running service calls and the blower stopped working in my dodge caravan.I remembered the resistor video you posted stopped at Napa diagnosed in the parking lot with my multi meter power in the harness but fan no go ran into Napa installed it parking lot now my feet will be toasty warm during this cold stretch in northern Michigan.Thanks again Eric
@tlyonstlyons7 жыл бұрын
Excellent. $12 from Advance auto and maybe 20 minutes all told. A tip: there are blower motor resistors for one zone, two zone and auto temp controlled heaters. There are also resistors for the rear blower. Some differ depending on the exact setup.
@lasermanhollywood9 жыл бұрын
My blower motor works on high only. I have a manual and figured it is a resistor block problem but I had no clue where it is located. Now I know where! Thank you.
@kaliensmashingatoms5 жыл бұрын
Dude you're a rockstar. I've lived with intense anxiety and pain for nearly twenty years now and felt very unsure of my work.this video change everything in terms of solving a problem that I should have normally been able to solve like no big deal. Therefore you are my rockstar. Thank you very much
@jbaker97477 жыл бұрын
Thanks for the video! Made the repair easy after buying the $16 part. I also powered the blower motor to make sure it worked before going to get parts.
@richardsantacruz71295 жыл бұрын
I have the same car except the front AC /Heat works when the car is moving on a highway but very faintly. I believe it’s the blower motor that needs to be replaced or should I replace the blower motor resistor ? Not sure please any help would be great
@JavaRatusso4 жыл бұрын
Straight forward and detailed.. Just what I needed. I'll watch it again to jot down the wire colors. Thanks! Update.... Left blower on high and bumped the fan and voilà all working again.... Thanks for that tip. The fan has been making a slight groaning noise causing me think it's a fan going out.
@mingohernandez64753 жыл бұрын
Did not know u could test a resister cable like that thanks for the knowledge .
@andynewsom1272 жыл бұрын
We are blessing you by 10,000 blesses, watching other videos this morning watched you for 3 minutes had my wife knock on the deal underneath her dash and the heater started working again you sure are an amazing mechanic and if you were hearing Eugene Oregon I would be coming to you all the time God bless you God bless your business God bless your hands God bless your family God bless people around you people who know you God bless you God bless you God bless you God bless you!!!!!!!
@davejones10644 жыл бұрын
Lol I'm sitting here in 90 degree weather trying to figure out why mine quit work I seen you hit under the dash so I did the same thing and it started working again thanks for posting the video
@DesireeTX1212 жыл бұрын
This worked for my 05 town and country after my blower just would not turn on one morning $16 fix! Thanks a lot!!
@curtisscullop84392 жыл бұрын
Great job. Good explanation of what everything should be doing Should make my job of replacing my resistor easy. Thank You 😊
@eldenshore7445 жыл бұрын
Thanks for putting this video out, it helped me tremendously. I was able to replace mine and get the heater going in my van in -23c weather. THANK YOU!!
@monsonmania84102 жыл бұрын
I just replaced my resistor and noticed the AC coil was clogged. If not enough air passes over the resistor I think it's the first thing to go. I'm not sure how to clean my AC coil though. Good video it helped me find the root problem.
@UncleDannys5 жыл бұрын
Great Video, I had a newer style resistor that burnt up with corroded wires. I found a wire harness and an older style resistor at Pull-A-Part In Lafayette LA. Your video helped me with determining if i could replace with the old one. Thanks a bunch ;)
@stephenblake67546 жыл бұрын
Thank you, I watched so many videos, this one had the info I wanted explained how the system worked. I did not know it used the ground to finish the circuit.
@natearsenault88873 жыл бұрын
Ty very much. This video saved me labor fees. Unfortunately I'd already bought my blower motor (cuz my heat went) ...then I saw tbis video n was like shit ...it might not even be the motor! Sure enough it was the resister...under 20 bux I'm happy. Thanx again
@RJ-rd5wx5 жыл бұрын
Tapping on my blower motor worked perfectly on my 2012. Thank you for saving me hundreds at the shop.
@kirkb22864 жыл бұрын
Thanks so much for the video....that is exactly what was wrong with my 2006 town & country...awesome
@JonBoy4707 жыл бұрын
I love your exhaustive electrical troubleshooting.
@xiloeteknowledgiesllc19736 жыл бұрын
Great video! I just replaced the blower motor resistor pack in a 2001 Chrysler Voyager. I've got heat and air again! Thanks for the video. The part was
@garyjames24657 жыл бұрын
I can't thank you enough you do a lot of work on these kind of Vans I see and I just bought one so now I know what channel to go to really thank you so much
@williammarvel1745 жыл бұрын
I have two vehicles with different blower failures, and you were right on both counts. Thanks.
@nichellejones90488 жыл бұрын
THANK YOU for this video! I just replaced the resistor for my 2005 Caravan and the fan is now working. As easy as you made it look! Thank you
@wisamabazly2 жыл бұрын
Beat video ever. Would of never known what you showed me..thank you. Fixed it .heat blower works..lol
@dadannyboyo8 жыл бұрын
thanks a million..the first tip was my problem..I simply hit the motor and she started back again!!!!
@pedrodelasancha5165 жыл бұрын
Excellent video. Thanks a bunch for sharing the knowledge. I don't know if you'll see this comment but here's my questions. I tested the blower motor resistor inputs by probing the full time power wire like you did with your test light. And here's what I got. 2012 Focus with Manual AC Controls. Has 0-4 speed settings. When I set it to speed 1, I got ground on that wire. If I set it to speed 2, I get ground on the wire for speed 1 and 2. If I set it to speed 3, I get ground on the wires for 1, 2, and 3. If I set it to speed 4, I get ground on all the wires. What would cause that? I know you said it should only have power on each particular wire. What would you check from there? I tested my blower motor by providing power directly and it worked. I also tested my blower motor resistor for resistance and it checks out with the resistance specs. I also checked my relays and fuses and they are working properly. I don't know what else to do. Any help will be greatly appreciated.
@thegakfiend4 жыл бұрын
Thank you for your information, but my 1998 Town & Country has the resistor located under the hood instead. In case anybody was baffled like I was when I removed the glove box door and didn't see the same thing as I saw in this video. Now that I found it, it is dark out. I will resume this project another day. Again, thanks for the info. I didn't even know a blower motor resistor was even a thing. I was going to attack the motor itself first.
@michaelsam52057 жыл бұрын
THANK YOU VERY MUCH, I KICKED THE MOTOR AND IT WORKED. NO, I DID NEED A NEW RESISTOR, YOU SAVED ME TIME AND MONEY. THANKS AGAIN
@kevinkeithphoto8 жыл бұрын
Great video. Fixed my problem and only took 10 min and less than $20. Thanks!
@boomspawn3 жыл бұрын
Excellent video. great step by step presentation.
@metalwaves41545 жыл бұрын
00 Chrysler 300m but I had the same problem hot going to the ground on the blower ur video saved me alot of time thank you keep them coming
@billsmith60312 жыл бұрын
Good Job ! You obviously know your Caravans ! Thanks
@RJB00078 жыл бұрын
Great stuff, you saved me a lot of money. The price of the blower motor resistor was 20 bucks.
@Handynel12 жыл бұрын
Concise and easy to follow. Very well made video.
@TYMWLTL8 жыл бұрын
Thank you for the great video. Now I can attack my sometimes works for a while and then quits front heater motor problem. My dogs don't like it when the AC is not blowing hard from the front and back of the car. Much appreciated. Good luck.
@latakishiathornton38935 жыл бұрын
Eureka,I think I have found the solution to my problem! This video has been very helpful and informative. Thank you!
@andypuu84243 жыл бұрын
Waiting on parts to come I have this same problem, thanks for the video
@kevinohern68095 жыл бұрын
Great video, hit under dash with hand. Blower started working. Thanks!!
@bheras067 жыл бұрын
thanks alot man you help me saved couple of hundreds, I just had to spent 32 dls In a new blower resistor and it worked, keep posting videos man I appreciate it.
@diyty24308 жыл бұрын
A very informative video. Love it that you show how to check it out step by step. I'm surprise that you don't have more subscribers than you have now. Keep the videos coming.
@Jas4u23 жыл бұрын
Great video , I have a Ford F150 replaced the Resistoe pack , it lasted three days now I have to check the Blower motor amperage .
@treybeerbower85326 жыл бұрын
I literally just smacked my blower motor and now it’s working after going all day in a hot vehicle lol I feel so stupid now best video ever
@awachutka9 жыл бұрын
Thanks for the info. Now that frost has arrived, time to fix my blower. Should be easy with your help.
@SouthMainAuto9 жыл бұрын
+Al Wachutka Oh yeah the frost is setting in here too :)
@glennnile79186 жыл бұрын
Thanks man. That worked perfect. The new style resistor fit in up side down but fit and works perfect.
@bwiles126 жыл бұрын
Your a bright guy, great video. Well put and straight to the point of the title. Thankyou.
@nathanael-nancysommers30756 жыл бұрын
This was a VERY helpful video to watch! We have an '05 and had lost all fan speeds at once.
@smdavis4209 жыл бұрын
you just saved me soo much money. Third time in a year my heat was out. Well my dealership just changed policies and to even look at my car is 45 an hour!! I was so down thinking once again I bought a lemon!! I looked and my resister was unplugged!!
@SouthMainAuto9 жыл бұрын
:) Glad it helped!
@RaoulThomas0079 жыл бұрын
Shawntae Davis The resistor was unplugged! You should charge the dealership $45.00 an hour for finding it yourself! Wow!
@smdavis4209 жыл бұрын
***** I agree!!
@knikhusky Жыл бұрын
Wow, THANK YOU!! Worked with the first whack 👍😁
@brianthomas33574 жыл бұрын
This is a good video, I will be checking mine out tomorrow. Hopefully its that simple. Thanks for the great commentary and clear pictures.
@ctloyd6407 жыл бұрын
Great job! Followed the video knocked it out in about an hour.
@mkIIIsupras9 жыл бұрын
Good video! Just replaced the resistor on my uncles van and saved him some cash. Thanks a million!
@SouthMainAuto9 жыл бұрын
Nice glad it helped!
@amadohernandezrobbio69614 жыл бұрын
Thank you very much for this video. It help me to solve my problem. My blower is working already!!!
@realspacemodels9 жыл бұрын
Thanks for the video. My repair was identical to yours (except on a Town & Country) right down to the change in the resistor style. Ten minutes and we had air again. What a lifesaver! (Yeah, it's October in Florida & 87° today)
@SouthMainAuto9 жыл бұрын
+RealSpaceModels Haha nice, well I started the wood stove last nigh :) A little chilly in upstate NY.
@StevieTheScotsman9 жыл бұрын
Just about to tackle same symptom on my zx2..Video will prove helpful Thanks for taking the time and trouble to make the video Cheers Steve
@mattress23316 жыл бұрын
Good Lordy Easy Peasy Thanks for the video! First, I bought the Hvac unit control assembly., Luckily got it for 12 dollars Ebay. That didn't work. So tried this tested switch good to go- 14 dollars later replaced resistor Wahla! Like a Boss up and running!
@ChrisWilliams-hm1nx4 жыл бұрын
Most helpful video ever! Bang it, and it works. You are the man.
@nerfcommando1495 жыл бұрын
thank you. this was super helpful. i watch most of your vidos through my ps4 which dosent allow me to comment. my favorite video is of the girls changing a lower control arm(i think) followed by mrs o changing her tires. keep up the great videos.
@shaneprince40433 жыл бұрын
Thank you! Very clear explanation on troubleshooting.
@papaneilg66966 жыл бұрын
Thank you very much! Very helpful and clear! Got my van fixed!!!
@tylerm74037 жыл бұрын
this was very helpful thanks for showing us how to change it
@seccat5 жыл бұрын
Excellent camera work, Hannah.
@brandonwoodruff8943 жыл бұрын
Saved me tons of money, thanks man!
@KOLODNY957 жыл бұрын
Excellent and a very clear explanation. Thanks!
@debrah11828 жыл бұрын
thank you. changed it out tonight and ac works nice.
@davidshortt19793 жыл бұрын
Dude, God bless your heart ! I tried the first thing ¥OU did. H@! I put my fist to it a couple times and it worked ! ThanX.. it's starting to get colder.
@williammchaney17927 жыл бұрын
excellent video quality. very informative and thorough. this was very helpful considering I do not have electric defrost windshield super low base model no drivers door side slider even. crank windows and all without vents going from the dash to the door even.
@josejoubert43956 жыл бұрын
You sir should be a NASA tech - impressive
@jasonmitchell44695 жыл бұрын
Your video just saved me thanks Mr.O
@Jake-sv9fv4 жыл бұрын
good video, thank you it was very helpful, informative and easy to comprehend.
@chriskeim55756 жыл бұрын
You explained that to the T...good show man
@josesalazar7378 Жыл бұрын
Wow. Thnx so much.all it needed was a love tap 👍✌️
@seanshadow3 жыл бұрын
$20 and fixed, thank you!
@josealflores23726 жыл бұрын
Ur a bad ass, I’ve taken my van to like tow shops n they can’t find what’s wrong. Changed the controls and blower motor and still nothing. Going to try the resistor hopefully that fixes that. Only blowed in the 3 level or third gear.