Learn how to troubleshoot your way through the fifteen typical causes of pressure switch chatter. Learn more about Goulds Water Technology Tanks HydroPro Diaphragm Tanks: www.xylem.com/...
Пікірлер: 35
@blitzkrieg8172 Жыл бұрын
Here's what's driving me absolutely nuts right now... I use the water, pump turns on, then once at pressure it turns off. 30 -60 seconds later it turns back on, runs for a minute, then turns back off. Repeats this a few times then stops until I use the water again. Any suggestions on what could be causing this? Pump is only a few months old, changed the filter out, replaced all tap washers, but still stops and starts..
@ryangibson19006 ай бұрын
That's what mines doing what fixed your issue?
@mycats73214 жыл бұрын
By "chatter" do you mean when it makes a rapid clicking sound? My pump stopped working & when I went outside to check, I pulled up on the cable supplying power to the little box & it turned the pump on. Happened twice in the past few weeks. Then it went out again tonight. I got a flashlight and checked it. Did the same thing, pulling on the cable (which seems to reset it). Pump started running but as I was walking away I heard rapid clicking, then the motor running normally, then the rapid clicking, then it shut off again & wouldn't come back on. In the past this has been caused by a short from damaged wires (my wires get fried by power surges because my power company sucks).
@TRUMP_WAS_RIGHT_ABOUT_EVRYTHNG3 жыл бұрын
i just saw at home depot that they have whole house surge protectors, think it was under 100 bucks. guess youre not the only one with crap power company if they are sellling these now!
@mycats73213 жыл бұрын
@@TRUMP_WAS_RIGHT_ABOUT_EVRYTHNG Yeah, I got one but need to get it installed. Problem is I can't seem to figure out where the power for my pump is coming from and I think it's on a breaker that exists before the lines enter the house. And yeah, you're not alone.
@zakkeels3383 Жыл бұрын
Mines doing the same at first I thought it was the power wire I ended up changing the switch and it's still doing it! Honestly hope it isn't my electric that's messed up
@Sean-Aviation4 жыл бұрын
Im getting 148V on my new pressure switch. does it make sense? I would assume it should be either 230 or 115V, am I wrong?
@FlashConceptsInc3 жыл бұрын
I'm in FL, now the winter has dropped temps to 30-40 F and my pressure switch started clacking as if trying to start even though there's pressure above the switch on level of 30 psi. It goes, clack clack... Clack clack at if trying to start. Any idea? Thanks
@supremewunder19063 жыл бұрын
I'm having the same issues right now in TX
@TRUMP_WAS_RIGHT_ABOUT_EVRYTHNG3 жыл бұрын
weather can mess with the adjustable springs.
@qadirali9666 Жыл бұрын
One of the springs to the electrical connector of the pressure switch is broken.should I replace the entire switch ?
@madridserrano4 жыл бұрын
Any help please , have replaced the water pump since it did go out , and now it keeps turning off we replaced pressure switch 3 different ones , replaced the tank and the electric box I’m confused that’s everything ? It keeps shutting off I have to go and manually reset that pressure switch to make it start up again thanks
@carman81404 жыл бұрын
Hey! Im sure you've solved it or tapped by now, but i think the issue is you need to adjust the cut in and cut on PSI for your switches. And to that you need to know the cut in and cut on PSI for your pump. Mine 40 psi cut on and 60psi cut off. If you're looking st the switch from the top down, in the direction that the wires come in, the big nut on too of the spring is the "range" turn that clockwise to increase the cut on PSI. The smaller nut to the left is the "differential" turn that clockwise to increase cut on PSI. Reverse it on both to decrease. Make sure to look it up yourself because i could have range and differential swapped.
@JohnSmith-mv6bw2 жыл бұрын
Mo Mnmjn
@mrbrown64212 жыл бұрын
I noticed there is a 'snubber' on your pressure gauge, but you didn't do many details, and I learn more by just looking at the way things are constructed. That was not a real life installation, but it was a very nice collection of parts to allow visualization of the concept. Best to most everybody. Mr. Brown
@TheTinyValentine5 жыл бұрын
Hi my pump when turns on the switch keeps coming on and off on and off constantly
@senatorjosephmccarthy27205 жыл бұрын
The pump pressure switch needs to be adjusted. Did you watch the video? It's the subject of this video.
@rickgamboa3793 Жыл бұрын
You explained nothing!!
@dontbea7237 Жыл бұрын
Nope the only video I cannot find this on those stupid little f****** cotter pins nevermind the pressure switch and riser just blew off lol
@2d404 жыл бұрын
I have a high pitched sound coming from the switch
@JuanCoreas103 жыл бұрын
My pressure pump is good but stops the water returns to the well and the pump starts working again, and I don't know what parts needs to be changed.
@matthewlowe85413 жыл бұрын
Sounds like your check valve is not working, u can leave it where it is and install a new one between pressure switch and pressure tank
@JuanCoreas103 жыл бұрын
Thank you very much. Really appreciated.
@cherylshirley31144 жыл бұрын
what causes my points to stick we bought a new box and their still sticking
@herbdawson38244 жыл бұрын
Thanks so much for your time and help with your help and video i was able to fix my pump and have water again
@lukebogacik27932 жыл бұрын
You are awesome! ✌🏼
@blgamesrock6 жыл бұрын
I'm new to pumps, pump doesn't shut off and only 30 psi on guage half way to house,150 ft.
@diazjarquin39586 жыл бұрын
Do you have pump relay or pressure switch?
@senatorjosephmccarthy27205 жыл бұрын
Larry, there's a lot of resistance in such a long pipe. Is your pump big enough?
@manueltejada25894 жыл бұрын
M
@nayaklaxman63297 жыл бұрын
dat compresr video
@senatorjosephmccarthy27205 жыл бұрын
Thanks for the information. Needless to put your finger so close to the electrical contacts. Yes, the electricity is supposed to be off. And we never make mistakes. And it was supposed to be off today when I was shocked. And many times we're standing on a wet surface and the items around us are wet. So now I'm keeping rubber gloves in the pit as a reminder to wear them. So you needed me to tell you that?
@TRUMP_WAS_RIGHT_ABOUT_EVRYTHNG3 жыл бұрын
anything with a capacitor has the possibilty to shock your a$$ lol even when the power is off i only use one hand and an insulated tool. ive been shocked enough for one life :)
@brabble20065 жыл бұрын
I have replaced 2 pressure switches in the past 6 months. I keep losing all water pressure. New plastic water line installed to the switch. Any suggestions. Been using the same setup for years and no problems.
@christinesmith76255 жыл бұрын
me too the new switches are made in mexico I found a old new stock switch on e bay American made switch much better made works fine so far 9 months make sure the line going to bottom of switch is clear and in good shape if not replace it the switch I used was a square d 30/50 made in palatine illinois