Honda EU3000IS, Service a Non Running Generator

[@stephenpwesley]

Well done. Perfect, direct, efficient, complete information. Old guys rule.

[@ThrottleStopRacing]

I try to start the videos with a bang, get right into it. Thanks for the comment.

[@juangallegos256]

Watched another video 20 minutes ago on the same subject, 5 minutes in and Old timer has already gave me more knowledge than I could’ve dreamed of

[@ThrottleStopRacing]

I am happy that the video was good for you

[@RhinoRider2006]

Just serviced my EU about a month ago. Battery died about 15 years ago. My gen is in an aluminum enclosure on my car hauler race trailer. used the pull start as I was too lazy to pull the case apart. After sitting all winter it would not start. It took me 2 hours to take the compartment apart since the torks screws stripped. My buddy serviced it, runs great now. At the time I did not know the battery was so accessible.

[@hansschut7765]

Excellent video sir! Just bought a used one and needs some TLC. Learned a lot from this video very well done 👌

[@ThrottleStopRacing]

Thank you, did you get it running? Thanks for the comment.

[@hansschut7765]

@@ThrottleStopRacing | it was running when I bought it but surging when eco off. I have since done some maintenance had the carb apart and checked the spark arrestor, was not bad but had a torch to it. Surging less but still some maybe just fine.

[@ThrottleStopRacing]

@@hansschut7765 Mine runs even, even with the Eco mode shut off.

[@alkennedy1124]

I love the vlog,it’s like going back to skool , nice thanks BigAl merry honda days ahead, thanks.

[@ThrottleStopRacing]

Glad you enjoyed it

[@homevampire6455]

Just a beauty of video in all regards. It is very well filmed and narrated

[@ThrottleStopRacing]

Thank you very much, it is always nice to get these kind of comments.

[@user-or1xh1vc8n]

You're video is amazing! Simple and to the point. I'm wondering if you might know off the top of your head why a Honda eu2000i would start pouring fuel out of the air vent hose when it's turned on. Even without turning on, pulling the cord a few times gets fuel to come down that hose, through the little black T connector and then up the other hose to erupt from its end where it's attached to the little black bracket.

[@ThrottleStopRacing]

I would check the carb, and rebuild it.

[@user-or1xh1vc8n]

Yes I assumed it is to do with the carb, but was curious what mechanically was causing it. Maybe is the floater is normally meant to block this air vent when fuel filled the bowl? I have not learned the design yet but that's my first thought. Thank you for your advice and the very informative video

[@strafto04]

You do a great job with this video. I wish you had taken the carb out and given it a cleaning, I need the help and I trust your methods. Mine has sat for about 10 years with fuel in it without having been drained out during its last time running. I have slowly pecked away at the maintenance items you have done, but now I need to clean the carb and fuel lines before I start it up. Thank you for the video.

[@ThrottleStopRacing]

Sounds like quite a project. Good luck.

[@strafto04]

@@ThrottleStopRacing got it done, a lot of work, not a lot of money, it's running like a champ.

[@ThrottleStopRacing]

@@strafto04 Great!

[@t.hargrove3843]

​@@strafto04 Same situation with my EU3000is. Has sat for 1 year with gas in it and won't start, need to clean the carb. Can you give some instructions or tips on how you did yours? You should do a "how to" video on cleaning the carb. Thx.

[@t.hargrove3843]

Nicely detailed instructions on what you were doing. Really wish you would do another video on removing and cleaning the carb on the EU3000is. Any chance?

[@ThrottleStopRacing]

Sorry,no. We are concentrating on the 49

[@crisphol33]

You're the man!

[@ThrottleStopRacing]

Thanks for the comment.

[@thisisfilmatic]

Thank you! Can you add an Amazon store link in the description with all the items you ordered? Thank you again!

[@davidsilos7241]

Did you say use premium gas? Does that make a difference?

[@ThrottleStopRacing]

It most likely makes no difference but it mad me feel better.

[@papajo7316]

There is zero benefit from using premium fuel in these small engines. It would be better to go out and find a gas station that sells E-Zero fuel (No Ethanol) as E-Zero fuel last longer in storage.

[@ThrottleStopRacing]

@@papajo7316 The 93 octant is ethanol free

[@matthewnieber6387]

How did you get it on the table !!!!???

[@ThrottleStopRacing]

I used our engine host. Thanks for the question.

[@tundralou]

Weighs about 175 pounds-need a lift to get it on table

[@ThrottleStopRacing]

@@tundralou Yes sir that is correct. I used my engine host to get it on the bench.

[@hank3571]

it weighs about 148 lbs, How did you get it up onto your work bench?

[@ThrottleStopRacing]

I used my engine hoist. Thanks for the comment.

[@my3corvettes]

Can you add the part numbers or amazon items so people can order itand follow along please?

[@ibrahimkuttyali6330]

Thank you sir 👍

[@ThrottleStopRacing]

It was my pleasure. Thanks for the comment.

[@hilltopper600]

what brand of battery worked for you

[@ThrottleStopRacing]

This is what I used. www.amazon.com/gp/product/B071VW65RZ/ref=ppx_yo_dt_b_search_asin_title?ie=UTF8&psc=1

[@TruDu89]

If the main board of this generator was errored, can it be repaired?

[@ThrottleStopRacing]

I wish I could answer that question but it is beyond my knowledge.

[@tundralou]

Does it call for Premium or 87???

[@ThrottleStopRacing]

I'm sure it calls for 87, but iot sits a lot and it makes me feel better. Thanks for your comment.

[@Bluebird-farm]

Thank you!

[@owlmessenger]

That's an awful lot of Sta-Bil you bought there, you know it goes bad 2 years after you open it right?

[@ThrottleStopRacing]

That was the only size AutoZone had