Vauxhall Astra Convertible Roof Latches - FIXED

This video is about Astra Convertable Roof Latches and replacing the damage latch component.
Manually opening the roof
1. Lower the windows. This is important and easily forgotten. Failing to lower the windows can damage the roof mechanism and may even result in the windows breaking.
2. Open the roof latches using the supplied hex tool through the grommet in the centre of the front edge. It takes a lot of turns, so be patient, and the latches appear to stop moving a long time before the mechanism has fully opened - the side “flipper forks” move during this time to raise the front edge of the roof by about 10cm. When the latch is fully open, the mechanism should feel a little stiffer, but don’t force it as this will break the plastic blocks or damage the flexible drive shafts! Do NOT use a power tool to drive the mechanism - this will almost certainly break the latches.
3. Open the boot.
4. Push the release lever on the left-hand side of the boot fully forward and wedge it there.
5. Close the boot lid.
6. Raise the rear windscreen.
7. Open the tonneau cover and clip the Vauxhall/Opel supplied plastic clip onto the ram (or some other means) to keep it open.
8. Lower the rear windscreen.
9. With a helper, slowly move the front edge of the roof up and backward until the roof folds into the storage compartment.
10. Close the latches - again, this takes a lot of turns. Make sure the latches are pointing at each other since they will hit the tonneau cover and damage it if they are pointing upwards.
Full credit for these instructions goes to a third party.

[@Aussielachy324]

Hi mate . Just fitted new latch motor , everything working spot on . Crackin video and thanks again for headin me in the right direction. Much appreciated. Cheers.

[@killawattgarage]

Great outcome, enjoying drive it with the top down.

[@sandiedean6629]

I am soo stoked you put this up. Ive been looking for 4 years now. And ive only just come across your vid. 👍 soo stoked. X

[@killawattgarage]

Glad I could help!

[@pedecia]

Thank you very much for this video. I could finally take out the broken latch and it had exactly the same problem as yours. I ordered a new part from UK and hopefully will arrive soon. I will replace that plastic part on both sides as the car is 2002 and the other one may also break in the near future. Big help mate!! So appreciate your work here in posting this guide!! I will post again once the part has arrived if I will encounter any difficulties.

[@megamario77]

Whete can i order it....

[@LorenzoMelino-rq6hb]

My roof won't open the Alan key just keeps on turning

[@ElBJosh]

Great video. You do have the patience of a trout fisherman. I'll try and follow your guidance as I do mine.

[@killawattgarage]

El B. Josh cheers. Let me know how it goes. I have an PDF resource I can email you if you need more information.

[@louisebloom8950]

Great Video. My astra snapped the cables that open the cover for the softop and burst the hydraulic ram on the left . Too much work to fix but this video enabled me to close the roof. One of the plastic brackets shown in video snapped during the melee. I unscrewed the threaded shaft, took off the broken plastic , abraded it and superglued it together in situ. I then threaded the shaft back in and did a manual wind to lock the roof. Didnt have to unbolt the whole unit. Couldnt have done it without video. Kept the car on the road until it went to scrappers. Great.

[@killawattgarage]

Well Done. Glad it helped out.

[@Snuggylike]

Great video - helped me to replace my old and broken latches - thank you!

[@killawattgarage]

Glad it helped

[@Wirtbutterblume]

Thank you for the detailed description. Now I know how to do it when the spare part arrives.

[@killawattgarage]

Glad to help

[@royflynn3110]

Great video for a common problem on these cars. Now that the replacement parts are available online, you don't have to suffer the exorbitant prices for metal replacements from a certain repairer in Aussie. With regard to the very tight screws retaining the locking mechanism (Locktite has been used), I found by supporting the roof edge when folded down, and giving the screw heads a very FIRM smack with a hammer and brass drift, it allows the screws to be undone without stripping the head. I also replaced the screws with Allen head cap screws so the issue never reoccurs. With plastic blocks that are just cracked a little, I have used stainless steel cable ties to provide reinforcement and a fix. Two slipped under the plastic mechanism and crossed over do the trick. Getting them TIGHT is the issue and you may need a SS cable tie gun.

[@killawattgarage]

Cheers, thanks for the comment. Can’t wait for the day when we can all 3D print these types of parts.

[@andreaskuhmann2558]

Thanks from Germany Great video that's make it easy to repair the roof of my Astra G Cabrio 90 years Bertone Edtion

[@killawattgarage]

glad it was of help to you

[@TataAmina]

Thanks Killa. this video what I was looking for to fix my BMW E46 top. The latch is identical to my 325CI. You could help a lot more people if you edit the video title to (Vauxhall Astra & BMW E46 Convertible Roof Latches - FIXED). Thank you again!

[@joshualazaras6924]

100%

[@mickgraham3206]

Thank you for the effort that you have taken to make this video. I appreciate it. Kind Regards Mick.

[@killawattgarage]

No problems, if you have any questions I can try to help you out. Thanks for the comment.

[@mickgraham3206]

Sent you an email today to this address [e-mail] requesting PDF. Having the same problems as Trystan below. Hope you can help me out? Regards Mick

[@killawattgarage]

Email sent.

[@nunoaquiles81]

great video and description. Thanks from Portugal .

[@killawattgarage]

Nuno Neves thanks mate

[@joshualawton57]

Awesome video man, definitely gonna come back to this when my latches eventually shit themselves

[@johnnyp5258]

Best video out there for this repair! Thanks!!

[@rogera2877]

Hi. Great video but can you please explain how to remove the fabric lining to reveal the screws holding the cover in place. It looks like it's been done from inside itself!

[@maciejbak6803]

You are a star mate. Great informative video. Bravo

[@killawattgarage]

Just saw you comment now, sorry for the delay. Cheers.

[@emadfarid5082]

THANK YOU FOR THIS VIDEO IT HELPED ME ALOT !!!

[@carloconde3142]

Good video 📹 it's really helpful. Do you have the link and the description of the parts that you removed so I can buy one ? Thank you!

[@mochnanszkizsolt4639]

Do you have longer video,for the fixed? How to start satr the roof after the fixed?

[@davidvango4426]

Hi Can you do a video to show how to remove and replace the hydraulic hoses on a 2004 Astra convertible

[@dervhane]

This video is soooooo precise, same process for the BMW e46

[@killawattgarage]

I have heard that they are the same latches. glad it helped

[@laomedoon]

Hello Killa watt Garage . Thanks for the video. Now I know how to get it off. Do you have the OEM number of the part? Thank you

[@kfacampinfo9870]

Great vid KWG, really appreciate it. Have had hydraulic pipe come adrift and when manually operating roof broke the roof latches AND the flexible drives, even with a tiny allen key. Working on it though with your assistance. Two questions, 1 any ideas for flex drive replacements, and 2. Are there any vid resources about for how to replace the hydraulic hose/s that you are aware of? They are something I haven't done much work with. Cheers. Kinglake Col

[@killawattgarage]

Hi and thanks for the comment. I have replaced the hoses a couple of times. Each time I removed the leaking hose I took it to a local hydraulic hose maker. Cost about $60-$80 Australian but the quality was high. It's pretty straight forward to replace one hose at a time. Once done top up the fluid and operate the roof and it will self bleed. I use fluid like this. www.nulon.com.au/products/hydraulic-fluids/iso-32-hydraulic-fluid As for the broken flexible drives, I wouldn't want to suggest a suitable replacement, find some good second and ones. Plenty of these convertibles out there getting stripped for parts. Let me know how it goes happy to offer help.

[@JOHNSMITH-if9jr]

hi mate great job and great video can you tell me where you can get spare hoses and connectors from as mine has poped and and cant be put back on thanks john.

[@killawattgarage]

I get the hoses made up from a local hydraulic hose company, there are always heaps around. Much cheaper than from the dealers. Hope this helps.

[@marcosbustabadgarcia2401]

Thanks dude you made my day ;)

[@killawattgarage]

glad to help.

[@eteaminc3463]

Nice video, but how did you get to the screw that to the far right?

[@danielgregory8623]

Great video mate, just wondering if you have a way to get to the latches when the roof is locked closed, my passenger side has failed with the roof closed but drivers side is still working.

[@killawattgarage]

Unfortunately not. Usually you have to cut a hole in the plastic trim next to the latch to get access to manually open it. Plenty of new plastic trims in wrecker yards.

[@LorenzoMelino-rq6hb]

Hi, great video my roof top won't open Manuel iv tried with Alan key it just keeps turning

[@bandicoot2016]

Cracking vid, mate. Most useful bit of info I've found on repairing the latches on this car which I know I'll need some time in the future. At the moment I've got problems with the tonneau cover/ deck lid not locking into place in either the opening or closing sequence. The latching cables are broken, but I think there is a sensor not getting a signal that the deck lid is closed. Beeps madly, and the roof won't fully close, however it does fully open. Any help you can offer would be really appreciated. Thanks

[@killawattgarage]

Email me at [e-mail] and I have a really good resource I can email you.

[@paulbradford8240]

I got side tracked into watching this! My oil reservoir had almost emptied. I had never looked at it in 17 years of ownership. I topped it up with the correct grade oil and was looking for some time and a fine day to reset the roof. I went to work on it and found the reservoir completely empty. Obviously a leak somewhere. Researching the leak brought me here! I don't need to replace the latch mechanism at this time, but this is a great video should I need to. As an aside, we have the UK model of this car. Spares are not readily available in the UK, is that different in Australia?

[@sherileepattinson3310]

Can you please tell me where I can purchase these arms and exactly what they are called etc 🙏🤷‍♀️

[@scottscratch6710]

Great video! Probably off the exact topic a bit but mine has a problem with the motor that drives the latches. The plastic worm wheel that runs off the motor's worm gear has broken in half. I'm not having any luck at all chasing up the gear itself or the motor. Are you able to point me in the right direction?

[@ianwilkinson5549]

Top class video, Thanks

[@killawattgarage]

Thanks mate, hope it helps you out.

[@AHH-qy9qf]

Hello Please can you tell me why the roof hang on frim frint whule openning ,so i have to puch it by hand above to help it openning Thanks

[@jodiejones551]

Hi do you have a video on how to open the boot on a 2007 astra twin top...mine will open a couple of inches and that's all...

[@killawattgarage]

No Sorry, haven't done much with the Astra twin tops.

[@korewrekt1]

G'day...I'm hoping I can assistance:) I have no power it seems to power roof,anti theft and window switch next to roof button on mid console isn't working , if those brackets are broken , does the anyone theft still work(turning key in door lock to turn blinkers on) I checked fuse 15, fuse it fine.. totally at a loss?

[@vinkerai]

Fantastic video, what is the cable called that goes from the motor to the latches? where can i buy that from...i am in Sydney. Thanks in advance

[@killawattgarage]

I would call it the 'drive cable between the motor and latches' try some wreckers or gumtree.

[@vjaceslavskolosovs3585]

Great video! Do you have a part number of replaced item? Please advice... tanks!

[@killawattgarage]

No, sorry

[@connormorse9191]

Hey man when I turn the hex key the piece that turns seems to drop down and spin without anything happening, do you know if that's supposed to happen?

[@killawattgarage]

The hex key turns a cog, if you are feeling no resistance or connection through the cog I would assume that the cog is badly damaged. Thanks for the comment.

[@gabrielguzman2160]

Hey killa, do you live in queensland?. I have this Astra and I need to fix the roof of it. do you know somebody that can fix it?

[@killawattgarage]

message sent

[@Hydraulic.Online]

Nice Video Killa Watt, I will attach a link to your video in our Astra Convertible Blog. B.T.W we fix a lot of the hydraulic oil leaks related problems at the other end of the roof.

[@killawattgarage]

Sounds great! Feel free to put a link to you business in these comments.

[@peterwilliams4842]

What is the tool you used to undo the centre (screw) I used a torx screwdriver and turned it and turned it until it started to tighten up.

[@killawattgarage]

Yep, its a torx bit. I used them with a ratchet for extra ease when tightening or loosening.

[@8BitPasta]

I need help. In a bit of a financial pickle so can't pay to get repairs. So my girlfriends car is an Astra 2002 I think, she when to open the roof today a hose on the left side seems to have burst and oil is coming out. Right now the roof is in a closed position about 5-10cm from being completely shut. I just want to shut and lock the clamps for now but not having much luck. I don't want to push down the top for fear of more damage. What do I do?

[@killawattgarage]

At the 0:20 second point you can see me manually unlatch the roof. You essentially need to do the opposite. Don't push down on the roof just manually wind and the roof will lower and lock into position. It will take a fair few turns to fully close and lock the roof. Don't force it. You can them fix the hose whenever. I suggest getting a hydraulic hose company to make the hose after you have removed it yourself. You should get some coins in change from a $100. Let me know if you have any questions. cheers

[@davidkpakiwa2851]

Thank you very much where can i get the latches coz i have the same problem

[@killawattgarage]

Can always find them on eBay, just search 'Astra roof latches' lots of different sellers are there. You can also buy genuine but the price is very high and I have found the aftermarket ones to be of good quality.

[@rogera2877]

Great video, thanks, but can you please explain how to remove the fabric lining to the roof to reveal the screws holding the cover in place? It's all very tight and looks like it's been done from the inside of itself!

[@killawattgarage]

no problem

[@TheWalker0224]

hi what if you cant open the roof by Manually with the xkey haw do i open it as it just terns thanks

[@killawattgarage]

check this out. mikeellis.org.uk/photos_astraowners/Astra%20Convertible%20roof%20hints%20and%20tips.pdf

[@robertbrechin633]

Couple of years old. But great video. I think I may have damaged the motor.... Any clues on replacing that??

[@killawattgarage]

At 1:40 you can the the motor on the left of the screen that operates the latches, its held in place with a couple of bolts/nuts. Thanks for the question.

[@jeffnsuebrandenburg8181]

thanks for the info,mine was working fine,now it seems it won't drop down in the locking position ,sits on lip and doesen't connect,again thanks. jeff

[@killawattgarage]

JeffnSue Brandenburg email me at [e-mail] and I can send you a good resource that can help you out.

[@chrisheylbut841]

Hi, My Daughter has a 2003 astra and the latches failed. With the help of your video i bought the broken parts of ebay and replaced them. Now i can close the roof manually but if i try to open it the buzzer sounds and it won't open. Any idea what it could be?

[@killawattgarage]

chris Heylbut flick me an email at [e-mail] and I'll send you a full instruction manual of how the roof operates and what the fault could be.

[@gego6784]

The latch Vauxhall/Opel is the same of BMW 3 series e46 convertible ? 🤔

[@killawattgarage]

I believe they use the same latches

[@chelseaweston]

Hello 👋🏼 I know this was posted 2 years ago but hopefully you will see this. My roof will not open and it doesn’t make any noise like beeping I thought maybe no power ? Do you have any suggestions?

[@killawattgarage]

With no beeping at all I would be thinking a power issue. Start by checking fuses.

[@chelseaweston]

@@killawattgarage yeah that’s what I was thinking but it wasn’t a fuse

[@patgar1956]

G'day Killa. When you open the roof manually do you need to touch the lever at the back of the car L/H side.??? also when you finish the job can you close it in auto mode ?? or we need to close manually ?? Thanks. All the best to for 2018 . Cheers from Australia. Patrick

[@killawattgarage]

Winding the latches open unlocks the front section above the screen, then the lever in the boot needs to be used to unlock the rear roof. I manually closed the roof to the point that the latch motor begins and watched them operate and close. Be sure the have the latches at the same point when reassembling as only the left latch as the sensor which stops the latch motor.

[@patgar1956]

Thanks for your help well done. Cheers. Patrick

[@ahmednajim4251]

Hallo ... Plesse can you help me My opel astar same ur car Is not work roof its only beeping nothing moveing .. !!!!

[@killawattgarage]

check this out. mikeellis.org.uk/photos_astraowners/Astra%20Convertible%20roof%20hints%20and%20tips.pdf

[@chessguru900]

My Astra H Twintop MK5 roof stuck and won't open. There is a long allen key in the car but I can't seem to find anywhere that will go into. When I press the button the buzzer sound 3 times and nothing happens.

[@killawattgarage]

not too familiar with the twin tops, sorry

[@cecid70]

Hi, thank you so much for this. We managers to fix this. I now have a problem with the switch to open the roof. It keeps beeping and won’t open the roof. Did this happen to you?

[@killawattgarage]

A beep when operating the switch indicates a fault. Email me at [e-mail] and I will email a resource that I use.

[@ahmednajim4251]

cecid70 hallo plesse tell what is problem when you fix it i have same problem

[@nickter1969]

Thanks for the nice video..I have a diffirent problem..My roof wasn't opening correctly,needed help with my hands and stucks at the beginning of opening..I checked the hydraulik oil at the back,i saw it was under the minimum line and also i saw some liquid out..i put some new oil in the pump bewtween the minimum and maximum line but when i start the operation, it begins to throw out the oil from a part near to right back seat under the roof,,all the oil out...and of course the rood didnt work...do you know what kind of problem is this??

[@killawattgarage]

Yes, it sounds as if it has a leak in one of the high pressure hydraulic pipes. It is fairly common. If you are able to view into the compartment where the roof is stored when its fully open you will see a number of hydraulic lines and will be able to see the leaking one. I don't know which country you are in but the are lots of business that make hydraulic pipes and you can easily get a cheap replacement. Original ones are really expensive. Hope this helps. Thanks for the question.

[@nickter1969]

I thought it was somethink like that,thank you for your time i preciated it.!! .I am from Athens- Greece..

[@killawattgarage]

Wow Athens-Greece!! You got to fix that roof so you drive around with the roof down. I from Brisbane Queensland Australia.

[@nickter1969]

Yes..You are definitely right..:)i cant fix it by my self,i ll go to an opel engineer and i ll see what price he will tell me for this damage..I pray that he won't 'kill' me with the cost:)..i ve got cousins in Melbourn :)

[@vasilistzovas4396]

Im stuck...i cant open it manually. the right side its stuck.the left it realease a bit.any suggestions?

[@killawattgarage]

Sorry just saw your comment now.I hope you have it sorted.

[@MidnightPodcast]

My Astra's back hatch won't open for the roof to fold in :( Have had this problem for over a year. I thought it just needed hydraulic oil, nope, not the issue. Any help would be awesome and I would imagine save me a shitload of money!!!!!!!!!

[@killawattgarage]

Most times it's a failed hydraulic line. You will need to manually open the roof. 1. Lower the windows. This is important and easily forgotten. Failing to lower the windows can damage the roof mechanism and may even result in the windows breaking. 2. Open the roof latches using the supplied hex tool through the grommet in the centre of the front edge. It takes a lot of turns, so be patient, and the latches appear to stop moving a long time before the mechanism has fully opened - the side “flipper forks” move during this time to raise the front edge of the roof by about 10cm. When the latch is fully open, the mechanism should feel a little stiffer, but don’t force it as this will break the plastic blocks or damage the flexible drive shafts! Do NOT use a power tool to drive the mechanism - this will almost certainly break the latches. 3. Open the boot. 4. Push the release lever on the left-hand side of the boot fully forward and wedge it there. 5. Close the boot lid. 6. Raise the rear windscreen. 7. Push the release lever on the left-hand side of the boot fully forward and wedge it there, then close the boot lid. You should now be able to open the deck. Once in here have a good look around, hopefully you will see your problem. I have a good guide that I am happy to email you. Email me at [e-mail]

[@MidnightPodcast]

@@killawattgarage I've copied and saved your instructions. Thank you so much. And yes, I will email you right away. Dude, thank you!!!!!!!!!!

[@yonasduffy6747]

Could you tell me the name of the arm and where did you get

[@killawattgarage]

Search eBay for Astra G Convertible roof latches.

[@jorgefonseca190]

Hi I am George I have one BMW 2003 CONVERTIBLE E46 one latch is Jam , I don,t open these , I try Manually but not only one side is open do you know any possible trucki , for me thanks

[@killawattgarage]

Sometimes you have to cut the trim in front of the latches to pry them open. Then replace latches and the trim. In the Astras it is a plastic trim piece, can't remember what it looks like on the BMW. Sorry I don't have a better solution for you.

[@thiccness1501]

Great video, I'm in adelaide SA and find it hard to get anyone to look at my roof without charging UNBELIEVABLE prices, so I'm trying to educate myself as much as possible, your video saved me "thousands", thank you . I have a small hydraulic oil leak in roof, I've looked at my hydraulic oil bottle in the boot ( very low) can you assist with getting me started here? With my roof in the closed position, I went to open roof with button, stopped. Few centimetres tres from windscreen " beep beep" closed the roof immediately and then noticed that trickle of hydraulic oil running down the left hand side of my car ( rear from boot lid) Thank yo in advance

[@killawattgarage]

Brodi Harris in where the roof retracts is a number of pressure lines and hydraulic rams are located on each side in the roof. You will need to stop the operation mid way through to be able to see the mechanics of the system. Any good hose manufacturer can make up a pressure line and if you remove it they will charge around $50-100. If a hydraulic ram is leaking I generally replace with a good second hand unit. I will double check to fluid I use as the Holden fluid is at a crazy price. Email me at [e-mail] as I have and PDF resource I can send.

[@danielp9721]

hi would this stop it working as it wont open its making noise

[@killawattgarage]

Daniel phipps if it beeps when you try to open it there is a fault. The latches are a failing item and often the cause.

[@damianerwich8639]

Great video, the factory tool Does it have a hex head

[@killawattgarage]

Yes it is a hex head. Thanks for the question.

[@andrewbarbara8577]

Hi there, I have a 2005 ts astra convertible,the problem i have is when the roof starts to open it needs a little push, and then works fine. any ideas thanks.

[@killawattgarage]

The arms that run to the latch will need some adjustment.

[@andrewbarbara8577]

Thanks for your reply, I’ll give it a go,much appreciated.

[@Aussielachy324]

Hi mate. Just replaced hydraulic hose. Holden reset roof and fault codes. Worked a couple of times . Now nothing but the roof motor working. Cant even wind roof shut manually with hex tool , just spins and no movement on the latches. Would this be the little plastic blocks that could b cracked ?

[@killawattgarage]

GARY KELLY very much sounds like the plastic blocks are broken.

[@killawattgarage]

at 12:32 with the motor or hex key spinning you should see the movement of the cables transferred to the latches. If you are not seeing this your problem is the gears within the motor. They can be sourced 2nd quite cheaply. Using a power tool on the hex key is a common cause of breakage. Let me know how it goes.

[@Aussielachy324]

Killa Watt Garage thanks mate. Just picked one up. Is it any easy change over , anything i need to worry about.

[@killawattgarage]

GARY KELLY ensure that both latches and in the same position as they operate together and need to be doing the same thing at the same time. The passenger side has the switch that ensures the motor shuts off once it is fully latched. Take it slow the first time and just press the switch on and release it to move things slowly, checking ad you go. Ensure battery is fully charged or have the engine running.

[@Aussielachy324]

Killa Watt Garage cheers for the information. Will get on it as soon as rhe new one comes. Cheers

[@paulsmith8034]

Hi mate I have a code of B1306 roof works but when I open it, it beeps and I have to keep pressing it had new latch motor and ecu still the same any ideas please

[@killawattgarage]

paul smith if the motor and ecu have been changed and I am assuming it’s the first stage of the roof opening that lifts the roof from the windshield that is failing. The motor performs 2 tasks, undoing the latches and to lift the front of the roof with those arms that extend from the latches. Double check the latches aren’t cracked and those arms are moving. Another check will be the micro switch in the left latch, it may be mechanically OK but the switch isn’t working and the ECU sees an error. Will double check that code for you and reply again. But some suggestions to start.

[@paulsmith8034]

Killa Watt Garage hi I have replaced the cable in the left latch it has like two little black boxes, I have also looked the the plastic blocks and there is no cracking at all

[@killawattgarage]

flick me an email: [e-mail] and I will send you a detailed resource to help.

[@paulsmith8034]

Killa Watt Garage sent mate many thanks

[@pedecia]

Hi the two laches have arrived. Now the rods inside the latch is very hard to screw in. I need to use a tool to screw it in is it normal? Will the motor of the latch damage if it is too hard to move the rod? I don't know what else to do as it is just too hard to move it manually. The original one was very easy to turn but not this replacement.. Any advice please would be appreciated. Thanks

[@pedecia]

Looks like the items I received have the threads a little damaged... probably been used previously... Should I return them or can I used them like this? I had to wait 2 weeks from Uk to Australia to get them.

[@killawattgarage]

If the threads are damaged send a message to the seller, just to be sure. I would expect the threaded spindle to have more resistance than the old one but it should be binding.

[@pedecia]

He told me they are all like this and I should try to install it but it is hard and I can only screw the rod with pliers. Do you think it's ok for the small motor to have all this resistance in closing the latch? I may risk to burn the motor if it is too hard and I need to replace both latches as both cracked. I noticed your latch is gold in color like the original that was on my car and mine are silver. The thread it is hard but more and more I screw in and out it's getting just a little loose. Just my concern is the little motor. did you noticed if your latch had more resistance then the original one?

[@killawattgarage]

Lt. Nimitz if it’s really tight or could install one latch at a time and carefully watch and support the roof through the cycle (be careful) The gearing on the motor does make it quite powerful.

[@empress-iveemporium9255]

Hey buddy what is the mechanism that the Allen key goes in called? I just bought an astra 2md hand and went to shut the roof for the first time and it won't lower to the windscreen it just keeps clicking both ways.. Hilp plzzzz thx stacy

[@killawattgarage]

This should help you: mikeellis.org.uk/photos_astraowners/Astra%20Convertible%20roof%20hints%20and%20tips.pdf

[@empress-iveemporium9255]

Awww thx

[@stevenholland7610]

Hello my astra cabriolet the roof started to go down and then stopped working and just keeps bleeping do you have any idea what is the problem thank Stephen

[@killawattgarage]

Start with this.... mikeellis.org.uk/photos_astraowners/Astra%20Convertible%20roof%20hints%20and%20tips.pdf

[@stevenholland7610]

@@killawattgarage hello thanks for the reply I've pressed on the link but just keep getting a blank screen my email is [e-mail]

[@takissamantas7378]

Do you have an email to ask you something I don't know?

[@davidbauzon7630]

Great Vid, I bought a 2005 Holden Astra model and it beeps 6 times and won't open at all nothing happens. I took it to a mechanic and he couldn't fix it and now beeps 12 times with no action. Can you please help me? Any advice will be appreciated

[@killawattgarage]

check this out. mikeellis.org.uk/photos_astraowners/Astra%20Convertible%20roof%20hints%20and%20tips.pdf

[@davidbauzon7630]

@@killawattgarage Thanks for the link. I took my Astra to local Holden dealer (Geelong Victoria) where they ran diagnostics but there were a few faults that came up & they did not know where to start and said they couldn't help me. Do you have any contacts in Geelong or Melbourne that specialize in fixing these roofs that don't charge a fortune?

[@TJ-jm5yc]

Hey mate just an issue as i was opening the roof i heard a cracking or popping sound , but the roof opened. However as I was closing the roof it failed to lock. Why and what can i do as a temp measure to keep the car secure? Also my car did not have an allen key can i purchase one? Cheers

[@killawattgarage]

At a guess it sounds as if the latches broke, which means it won't lock closed. As a temporary measure your best hope is to tape it down. With a little more work you could pull off the internal plastic cover and manually make the damaged latches lock in place. This is what most people do until the next summer and then fix it properly. Hope it works out for you. Thanks for the question.

[@TJ-jm5yc]

@@killawattgarage Thanks mate. This morning followed your instructions and tried it manually the left sided latch locked however right is still loose. I had a look in the windscreen cavity and the left side had a black locking device whereas the right is missing is that normal?

[@killawattgarage]

@@TJ-jm5yc They should be the same. at least you have one side latched.

[@elizabethtate543]

Hay mate what size allen key do I need

[@killawattgarage]

Cant remember but you will need a range of hex bits and allen keys.

[@trystanauddino5263]

Hey mate so my roof is just beeping (12 beeps) whenever I start the car. A pipe burst and I've refilled the hydraulic pump reserviour. But the roof won't even try to open/close. I'm following some instructions that outline I have to reset the roof by: a: making sure the font edge is unlocked and 10cm above windscreen b: make sure the rear window is vertical (is this even possible when the front edge is 10cm from windscreen? I can only get a 30cm gap minimum) c: all four windows are down d: the tonneau cover is closed but not latched e: the release lever in the boot is not wedged (he must mean forward) "the roof is then reset simply by starting the engine and holding the roof closed button until the roof is fully closed" I've followed all the steps but it just beeps when I start the engine. Doesn't even try to seal itself shut.

[@killawattgarage]

I would try to fully shut or open the roof manually, then try. Makes sure the doors are closed and the handbrake is on.

[@trystanauddino5263]

@@killawattgarage Trying that now, it's just beeping. Won't even attempt to try. Do you happen to be in Sydney or Central coast nsw? 🤞

[@trystanauddino5263]

@@killawattgarage Here's a vid I uploaded, any help would be greaty appreciated❤️kzbin.info/www/bejne/naGnmWaEqq-XZrM

[@SpiderRS007]

@@trystanauddino5263 hi there .... do you have the solution ? Ive got the same f***** problem

[@Sup3rBeast]

Hi mate, My partner has just bought an 02 Bertone Astra, and the roof isn't operating. When the switch is pressed to open the roof, you can hear the mechanism try to do something but after a few seconds of no movement, we get a few beeps. Is the likely cause a broken latch? We've had a wrecker offer us a whole back cut of another astra with a working roof for $400 but would like to try all other avenues before we resort to that, seeing as we can't store half a car in our suburban lot. Thanks in advance!

[@killawattgarage]

Sup3rBeast yes it sounds like it's broken latches. Email me at [e-mail] and I can send you a comprehensive resource for repairing these roofs.

[@Sup3rBeast]

Thanks so much for the quick response, will do!

[@ocibbico]

Hello can you help me. Give me the B1302 error and the hood stops to close Many thanks

[@killawattgarage]

Hi the B1302 is referring to the Accessory Relay circuit. This circuit maintains power to the roof for a short amount of time after the key has been removed. Start with checking the relay.

[@ocibbico]

Killa Watt Garage could you please specify which relay I should check? Thanks

[@brianhatch626]

great detail..

[@killawattgarage]

Hope it helps. Thanks for the comment.

[@mitchellrose2040]

Hey man good stuff but I can’t find the bloody lever😂 all I see is the hydraulic oil on the right. Do I need to take all cover off in left hand side to find that lever

[@killawattgarage]

Mitchell Rose that lever is on the left hand side, but it’s hard to find. Don’t need to remove any panelling maybe just the wind deflector if that is still in your boot. The lever is accessed through a slot in the plastics.

[@mitchellrose2040]

Killa Watt Garage I’ll try to find it .. do you have wassap so I can talk better.

[@killawattgarage]

No, but Email me at [e-mail] and I can send you a comprehensive resource for repairing these roofs.

[@cosimociciriello3281]

Grazie, anche se non capisco l'inglese il video è talmente chiaro che sono riuscito lo stesso

[@alanhonan9632]

Great video

[@killawattgarage]

Alan Honan thanks hope it helped you out.

[@alanhonan9632]

Killa Watt Garage did u have a fault code stored iv got one and I think it's this sensor that's faulty

[@killawattgarage]

Alan Honan what code have you got?

[@alanhonan9632]

Killa Watt Garage b1302 hallsensor header close circuit open

[@killawattgarage]

The Hall Sensor is the small magnetic switch in the left-hand side latch. Either your latch is broken or the sensor is faulty, as the ECU is not recognising that the latch is closed while the roof is fully down. Best place to start would be to remove the plaster cover over the latches and look what's going on. I have further info that I can email you, just message me.

[@mochnanszkizsolt4639]

Hi. I have got a 2003 g astra cabrio and the roof isnt opening. The Opcom codes is b1300 b1301 and b1302 the all of codes is hall sensor's mistakes. the roof latches is broken the left and the right side too. i think if i repair the latches,the roof is will be working. sorry for my english,i learned ,but it was long time ago. do you have some idea for me? Thank you,and this video is king

[@killawattgarage]

The hall switch is a part of the latches and when the latches are broken the hall switch will not operate correctly causing these errors.

[@mochnanszkizsolt4639]

Thank you so much !!!!! :)

[@mochnanszkizsolt4639]

Hi. i replaced the broken latches,but the the roof dont work. :( do you think,if i deleted the fault codes it will be work? thank you the answer ;)

[@killawattgarage]

Mochnánszki Zsolt erase the fault codes and try again. Scan for codes again. Email me at [e-mail] and I can give you more information

[@mochnanszkizsolt4639]

thank you,now sleppeng winter dream my car,but i send it on the end of march ;) thanx the help again! have a nice day

[@huss4611]

Hey Where about are you located

[@killawattgarage]

Australia

[@R1CH130]

I've got a fault with my roof all of a sudden. It worked perfectly until the battery went flat (as I'd not driven the car for a while), I charged it up and refitted it. The roof just went mental the first time I tried to open it, relays clicking like mad and it stopped and beeped! I managed to get it all the way open and fully closed again, but now it work at all. When I unlock the door and open it, the roof alarm beeps. When I stop, I out the handbrake on, then the roof alarm beeps when I release the handbrake! The central locking now doesn't work on the boot either! Any suggestions? I'm thinking broken wires causing a short, rather than mechanical failure like in this video. Oh, and when I lock the car, the roof alarm beeps then too! Does the ECU think the roof is not fully shut maybe?

[@killawattgarage]

I agree it sounds as if the roof ECU sees the roof as still open. When you closed it manually did you fully wind in the latches?

[@R1CH130]

Killa Watt Garage Last time it closed, it did so electrically and it was totally fine. It stopped working then. The central locking on the boot lid was fine until late on today. I had been in the boot a few times, so maybe the split is in the loom to the boot lid.

[@killawattgarage]

I send you a private message

[@gghh6107]

Hi, this is my problem for me as well. Would you let me know that this problem resolved? Thank you very much for your help.

[@R1CH130]

Manny Maley I forget to ever update this. I fixed mine. It was the switch in the top of the windscreen at fault. The car thought that the roof wasn’t fully closed, due to the switch being faulty. I didn’t have to replace the switch, just cleaned up the contacts and it started working! The roof was totally fine after that!

[@markcross330]

What are the names of the parts?

[@killawattgarage]

They are just called Astra Roof Latches. I quick google search will see many suppliers. Thanks for the question

[@sandiedean6629]

Can you please send me the pdf to assist me. My roof doesnt work. Its a holden astra soft top 2004 model.seings thoe i am a girl. I know tech nothing bout cars. But my brother who is a mechanic of 30 yrs pluss has taught me all i need to know. Id love a guide into what u think i shouod do please. As ill be doing it myself. What parts do i need. Where do i get them. I noticed u said ebay. I did look them up. nice and cheap. But what parts i need is my question and if you could send me as much info to help guide me thrue. Ps wish i could hug u. Legend. X

[@killawattgarage]

Send a message to my instagram account with the details where to send the extra info.

[@MidnightPodcast]

👌❤️

[@killawattgarage]

Thanks for the comment

[@thiccness1501]

Oh I have an Astra g convertible 2003 auto bertone edition ( see last message enquiry)

[@brianhatch626]

bought my new parts from a company in spain for 60 usd.

[@megamario77]

Link please i have eccact this problem

[@killawattgarage]

try ebay

[@paulbradford8240]

I got side tracked into watching this! My oil reservoir had almost emptied. I had never looked at it in 17 years of ownership. I topped it up with the correct grade oil and was looking for some time and a fine day to reset the roof. I went to work on it and found the reservoir completely empty. Obviously a leak somewhere. Researching the leak brought me here! I don't need to replace the latch mechanism at this time, but this is a great video should I need to. As an aside, we have the UK model of this car. Spares are not readily available in the UK, is that different in Australia?