Zzp big wheel v3 turbocharger, chevy Cruze 1.4. Sounds and full throttle acceleration.

As im nearing the end of the tuning process with ZZP, I wanted to snap a video of the acceleration with the new zzp big wheel v3 turbocharger. This is on 93 octane pump gas. This little chevrolet rips now! if you have a sonic or cruze, you need this turbo!
Other mods include ZZP front mount intercooler, K&N intake, BNR downpipe, bosch 42# injectors, and NGK bkr8eix spark plugs. Car still has stock midpipe and stock exhaust.
Note: The lazy transmission shift was fixed in later revisions.

[@lsjionredlinesupercharged2049]

Sounds literally perfect and amazing.

[@coreyward5157]

Man that turbo sounds good can’t wait to order mine with the inter cooler

[@GTkyle]

You'll love it. It brought the car to life.

[@betabeta-tk7qv]

Which intercooler?

[@bbacna1]

@@betabeta-tk7qv ZZP makes a front-mount intercooler, but if you have an Eco like me, it won’t fit due to the electric flaps in the bumper

[@jesusfreakshow98]

I believe you can remove the shutters and have someone like BNR tune out the shutter code, but don’t quote me on that.

[@charlesammon3334]

I'm skipping out on the turbo due to mine being an ecotec. Going with an aftermarket exhaust, cold air intake, and performance chip. Should be able to get to about 211hp and 220 torque. Hopefully anyway.

[@hordebutcher2651]

That's a very healthy acceleration, especially the third gear pull. Stupid question but are you running a ported intake manifold?

[@GTkyle]

Nope! Actually after this video I had to replace it (PCV diaphragm failure) so I just replaced it with a Dorman unit, which has a little support pin that's supposed to keep that from happening again. The car mods are just enough to support this turbo. Nothing extra done to it. It runs great, and should have been like this from the factory

[@Jesus90mendoza]

awesome!...that turbo sounds sweeeet!...what all mods do you have and who tuned it?...also is this the V3 with "ported inlet/ported housing?...

[@GTkyle]

The car's other mods are zzp intercooler, bnr downpipe (the rest of the exhaust is stock), k&n intake, bosch 42#injectors, and ngk bkr8eix spark plugs. This is 93 octane pump gas. Zzp is who's tuning it. And this is just the standard non-ported housing.

[@Jesus90mendoza]

@@GTkyle ...alrighty im currently modding mine too...this week im adding ported intake manifold with V3 pcv fix kit, 42# injectors,...near future mods is bnr flex fuel kit, and ported zzp v3 turbo,...check my final tune video out on my page...😁

[@GTkyle]

@@Jesus90mendoza make sure you get a larger intercooler before you get the turbo, the stock one is terrible and heat soaks extremely quickly and will cost you a lot of horsepower. And ill head on over and check it out!

[@Jesus90mendoza]

@@GTkyle ...awesome will add that to my list...😎

[@GTkyle]

@@Jesus90mendoza as far as i know, zzp and cxracing are the only options we have. But its a crucial component!

[@ProjectCarTV]

Cute

[@CBosridesandreviews]

Looks fun. Especially city driving.

[@GTkyle]

Yeah it would definitely come off a light much harder than a stock turbo car. This car is mostly a highway driver. So it needed the top end power more than the punch. But it got both.

[@kettlebellcarnivore-vr5cw]

​@GTkyle I need some top end for passing trucks up here on the highway. Get few places to punch past.

[@robertgraff7666]

Is that a direct bolt on or does other stuff need done besides bigger intercooler new to turbo cars..

[@GTkyle]

Yep, directly bolts on just like the stock turbo. Completely plug and play. Make sure you buy new turbo mounting nuts and studs, as this turbo doesn't come with them. Also wouldn't hurt to replace the coolant lines and fittings at the turbo, as well as the oil feed and drain. The oil drain is plastic and will break upon removal. The absolute bare bones supporting mods you will need will be the Bosch 42 pound (green giant) injectors, cold air intake, intercooler, and downpipe. The car in this video has all of those mods but still has the stock cat back exhaust even, which probably costs us a couple horsepower but isn't super detrimental since we are least have the downpipe.

[@trushock2552]

Only thing that keeps me away is the 0-60

[@GTkyle]

You're basically at the threshold of 93 octane here. This is a massive improvement over stock. If you want better 0-60 you need to be looking at other cars than a Cruze.

[@frankrosenberger1151]

Awesome sound. Do you throw any codes with the downpipe?

[@williamevans-legette4063]

i think with the tune pcm it stops the car from throwing it

[@eyen8465]

Fireee

[@rathuanyatzi]

Just subbed lol

[@mannydelgado7819]

Did you need to upgrade the Inter cooler with stageing up to the v3

[@GTkyle]

Yes absolutely. The intercooler needs upgraded even with the stock turbo. This car has a zzp intercooler

[@joebone3151]

Will it fit on a 2015 buick encore running. Engine 1.4l luv turbo.

[@GTkyle]

This turbo is for both the LUJ and LUV engines. I would think it would work, just make sure you email or call ZZperformance to verify it will before you buy anything. Also make sure they can tune the Buick as well.

[@sukhjitsingh1513]

Do we need to tune for installing this big turbo?

[@GTkyle]

Yes it must be tuned. You need the zzp intercooler, a cold air intake, a high flow downpipe, 42 pound injectors, and tuning to run this turbo. You need 1 step colder spark plugs gapped to .028" and you need to run premium fuel as well. 91 or 93 octane, whatever is highest in your area

[@BoostedDirtyCruze]

Y does all your best videos cap out at 124 likes. KZbin stop count. I just liked the video, which gives it 125. I clicked on another video, which also had 124 likes. Im wondering if it's KZbin.

[@GTkyle]

Not sure, on my end it says this video has 370 likes

[@BoostedDirtyCruze]

@GTkyle oh ok. Awesome. Great videos, man. I noticed that when i went to like the videos. I guess that's the maximum number the viewers see on our end. I thought it was a glitch. Lol.

[@GTkyle]

@@BoostedDirtyCruze You're right, must be a glitch. Thanks for the kind words! I just document some of the car stuff I do! I just upload the videos to share. In this case, back when I installed this turbo, nobody really had video showing how it runs on pump gas in an automatic car. So I installed the turbo and made my own to share!

[@BoostedDirtyCruze]

@GTkyle cool stuff, dude. I subbed.

[@jaysonknouse846]

Could you send me a link to where you purchaced the turbo set up and intercooler please.

[@GTkyle]

www.zzperformance.com is where I bought everything including the remote tune session.

[@jaysonknouse846]

Thank you very much

[@prestonrodgers5394]

does this require a tune?

[@GTkyle]

Yes. Also requires larger fuel injectors, upgraded intercooler, downpipe, and cold air intake. This car is remote tuned by ZZP themselves.

[@Ohrank]

can barely hear it. the sound you hear is just a cold air intake

[@GTkyle]

It does make a good bit more compressor noise than the stock turbo but the air rushing noise is definitely prominent. it didn't pick up well on camera. Also this intake is a K&N. It's a hot air intake, stupid design. Car already had it though, prior to turbo install.

[@justinludwig4186]

Does anybody know what turbo charger I should put on my 2015 chevy cruze

[@betabeta-tk7qv]

Stock is fine, take off cats

[@cruzecollective]

The ZZP v3 Ported if you want a faster spool, or get the even stronger Z04 when it comes out for the Cruze. (They currently only have the Chevy Sonic version.) You're not gonna unlock any turbo's true potential without doing the cam/ported intake/42# injectors/CAI though, but you'll get about 70-80% of it without all that.

[@cruzecollective]

BNR also sells a turbo setup that supposedly gives you an extra 250 HP for around $1700. But Idk, I've never verified, but I can vouch for the v3 ported!

[@ferenckecseti8133]

Hello! What performance can be obtained from the 1.4 turbo Chevrolet Cruze?

[@GTkyle]

It all depends how much money you want to spend. The cars stock make around 110hp. This setup is somewhere around 200hp and it's all easy stuff. Turbo, intercooler, injectors, spark plugs, downpipe, tune. You can go up from there one step by doing camshafts/valve springs. Then another step up switching to e85, getting mid 200s. I've heard of guys with built engines getting into 300 territory with the properly sized turbo. But I don't know details. Check out zzperformance KZbin channel, They recently came out with a bolt on turbo that's bigger than this one and they've been doing a daily driver type build with it over the past several months

[@mikes.4811]

@@GTkyle Stock 1.4T makes 138HP. Gen2's make a little more at 153. 👍

[@GTkyle]

@@mikes.4811 I was referring to wheel horsepower. The gen 1 makes 110 wheel horsepower, and to my completely uncalibrated butt-dyno, I'm guessing 200 wheel horsepower where it stands currently. It's a substantial gain in horsepower for a couple grand. The car still isn't fast, but it will at least safely travel down an on-ramp now.

[@mikes.4811]

@@GTkyle Gotcha. Plan on getting the V3 turbo, ZZP intercooler and E85 (and everything it needs to run it). Already tuned with BNR, so thats covered.

[@GTkyle]

@@mikes.4811 have you seen the new Z04 turbo? I'd imagine it lags a bit more than the big wheel v3 but definitely would have more headroom. Assuming you plan to get into cams and valve springs and whatnot as well.

[@scottcooneymusic6736]

How long did that trans last?

[@GTkyle]

Still good, around 50,000 miles since the turbo and counting. The 1-2 shift was firmed up in later revisions of this tune so if that's what your worry was, it was handled after this video. Car has 184,000 on it currently.

[@eliwagner3190]

Transmission don’t sound happy😭

[@GTkyle]

Yeah this was before tuning was finished. The 1-2 shift had timing reduced and line pressure increased with the next 2 revisions, and shifts nice and firm now.

[@eliwagner3190]

@@GTkyle makes sense, how’s the reliability? Been debating one for the gas mileage but couldn’t stand it stock lol

[@GTkyle]

@@eliwagner3190 gas mileage is the same. Reliability is to be determined, since its only been a few thousand miles. They did fix the hotside issue that plauges the stock turbos and causes them to crack. You must do an intercooler, downpipe, and 42#injectors with this turbo. I highly recommend it thoigh. The car stock was embarrassingly slow. Now it gets out of its own way.

[@eliwagner3190]

@@GTkyle thanks so much for the info, you think I could get bnr to tune it? It’d be nice to switch back & forth to 87-93 Bc 93 3.50+ a gallon here lol if that’s even possible with the better turbo

[@GTkyle]

@@eliwagner3190 I'm sure BNR could handle it no problem. And dont bother spending all that money to set the car up and neuter it on 87 octane. Its only a couple extra dollars per tank. You honestly should be running 93 as it is, this is a turbocharged engine after all. The manufacturers only have to make them run on 87 to idiot-proof the engine, but power is sacrificed. I know all about the 93 octane life, the cruze is one of 5 vehicles owned between my wife and i, and they all are tuned and modded and only accept 93. Except for my focus ST which is currently running e30.

[@Rome-nr5cj]

what kind of bov you have

[@GTkyle]

Just the bypass valve that comes equipped on this turbo. And a k&n intake.

[@mohamedmelouk6446]

ممكن نغير محرك 1.8 ونركب محرك 1.6 كروز من فضلكم دلوني

[@InspireNThrive206]

how you get the coolant temp on the screen there?

[@GTkyle]

Using the "menu" buttom on the turn signal stalk, push it until you see "vehicle information menu". Then, use the arrows (the part near the end of the turn signal stalk that you can twist) to scroll through the list. You'll find coolant temp in that list.

[@lifeinmsl8650]

@@GTkyle yeah I knew that, but mine wont display that either even going through all the settings

[@GTkyle]

@@lifeinmsl8650 maybe its a year-to-year difference then. This is a 2012.

[@themrproamateur]

@@lifeinmsl8650 I drive a 2015 (LT2) and I don't have the option either. I'm jealous

[@DabMaster710X]

This work in 2019??

[@GTkyle]

No, this is for the 2011 to 2015 models

[@cruzecollective]

Unlock the FSCM and put it on E85... you'll like it even more. 😎 That's what I did to mine. It's a super fun car once you put some $ into it.

[@GTkyle]

If I owned the car, I probably would. It's my wife's daily driver, and the end goal was to make this thing actually have some passing power on the highway, which this definitely does now. Isn't a race car but also isn't a turd like it was stock.

[@cruzecollective]

@@GTkyle I can 100% understand that my friend. That was my original goal too as the Cruze originally was my wife's. These things are VERY unsafe stock, ZERO get up and go. So I get it. We got her a 22 Equinox instead, so the Cruze has become MY daily. Haha. If you ever decide to make it a toy, lmk. I've done everything ZZP on mine so I can answer questions. I even did the pistons, springs, and retainers. Your video is one of the ones I watched before buying the v3 though. 😆

[@GTkyle]

@@cruzecollective Just went through your acceleration videos, yours definitely rips! Any plans to take it to the track?

[@cruzecollective]

@@GTkyle I definitely wanna get it to the drag strip and run some 1/4 mile runs! I also plan to have it on the dyno soon too so I can pull some actual #s not just tuner estimations for out #s. I'm also going to convert this A6 to an M6. I'm gonna try to find a Malibu trans, but I may have to use the M5 from the Cruzes. Either way, the automatics in these are so slow. 🤣

[@GTkyle]

@@cruzecollective you know. That's one thing I don't have a complaint about, after this video I had Tim bump up the shift pressures/reduce shift time command and it's pretty crisp now. Downshifts are responsive and it does pretty well. Of course I prefer manual trans but I can't knock the 6 speed.

[@miantewinters9345]

Automatic?

[@GTkyle]

Yes. The tune wasn't done here, the 1-2 shift was firmed up in later revisions. Youll notice in the video it's kind of lazy here.

[@coreylivingston6168]

What’s the top speed

[@GTkyle]

Never actually tried on this car. It does run good now, though. Worth the money for these mods.

[@coreylivingston6168]

@@GTkyle what’s the fast u have gone is it over the 112 set

[@GTkyle]

@@coreylivingston6168 The car is my wife's car actually so I have never had it that fast, I usually don't drive it. However there's no doubt it can hit those speeds with the power it makes now.

[@Jon-ub2hr]

that thing pulls in third gear bro

[@GTkyle]

It's definitely a huge jump over stock. Worth every penny

[@Jon-ub2hr]

I actually want to mod my cruze but I don't want to blow the motor or cause a check engine light. I would also have to retune my cruze. I have a Trifecta Tune. any tips?@@GTkyle

[@GTkyle]

@@Jon-ub2hr I'd have to check my receipts but I think I put this turbo on around 130,000 miles and its got almost 180,000 now. It's all on how you drive it and maintain it. Drive it easy until it's fully up to operating temp, 5k oil changes with dexos oil, no low rpm lugging if it's a manual. Yes you will have to retune. You'll need the turbo, 42# injectors, a cold air intake, intercooler, and downpipe to make this all work. This car is running stock exhaust still which has been fine. I say do it. Just make sure you do it right. Buy all new coolant and oil lines for the turbo as well as the gasket and hardware kit (Dorman makes both of these as complete kits). Do a fresh oil change and put new coolant in while you do this work. It's definitely worth the couple grand in parts that it costs to do. That stock turbo is a joke, and all the stock ones crack inside the exhaust housing. That's what got the ball rolling on upgrading this one to the zzp

[@mikes.4811]

Nice. Seems to have made it a little faster. 🤣

[@GTkyle]

Yeah, it runs good now with this setup. Also just found the intake PCV check valve failed and was likely bad during the whole tuning process, so now the car builds another 2psi, flows another 1 lb/min airflow and spools a few hundred rpm faster.

[@srage9188]

Get a quarter mile time?! 😺

[@GTkyle]

It's my wife's car, i keep trying to talk her into going to the track with it. She's not very interested though. If i can talk her into it, I'll post a video and let you know.

[@DrDarkSight]

What year? Just got a 2011 Chevy Cruze LS 6Speed Manual

[@GTkyle]

This is a 2012 RS.

[@ajventura1756]

this works on a 11 cruze ls 6 speed

[@GTkyle]

@@ajventura1756 yes it will. Highly recommend it. You'll need intake, injectors, intercooler, and downpipe to go with it.

[@ajventura1756]

@@GTkyle yup going to order this soon, have all the needed upgrades as well just looking for info on the sonic forum about the 1.4 L racer x intake manifold, wondering if zzp can tune it with the turbo as well? I know I have to cut into PCV and brake booster line just wanted more info on that or a guide of some sort, hard to find!

[@GTkyle]

@@ajventura1756 oh sorry, i thought you were asking if it would fit. Ive yet to hear of the manifold, but it shouldnt make any difference to the tuning process.

[@racingdreamz8021]

Automatic?! Oh no 🙉

[@GTkyle]

Yeah, It's my wife's car.

[@factsforlife0O0]

Bro do manual shifting

[@GTkyle]

Why would I do that when the car has the best optimized shift points tuned into it?

[@factsforlife0O0]

Cuz you went into redline @@GTkyle

[@GTkyle]

@@factsforlife0O0 you don't understand, this turbo makes power into the 7,000 rpm range. These shift points are tailored to this turbo's power curve. It would be slower if I tried to shift it any other rpm

[@factsforlife0O0]

What about the stress on the engine aren't you afraid to blow the engine @@GTkyle

[@GTkyle]

@@factsforlife0O0 no, I had ZZP tune this car, they made the turbo and they know these engines. So they tuned it to maximum safe power limits. Car has been running this turbo for about 50,000 miles now.

[@saltycanadian6190]

Still so slow, why did you waste so much money? Should have bought an si and supercharged it. This is coming from the guy who thought it would be a good idea to have his Audi 2step around cops.

[@GTkyle]

Because this is my wife's car, it's paid for, and her only complaint with it was the lack of power. So she spent a couple grand in parts and I fixed that. It's fast enough she can pass people on the highway now. Not everything has to be a racecar.

[@mikes.4811]

Why not just buy a twin turbo Supra and be done with it. 🤣

[@mmhyesboykissies]

i can hear fast n furious in there c:

[@ProjectCarTV]

Cute