Kerry shows you how to properly fill your electric golf cart's batteries. golfcarsunlimit... Follow us: / golfcarsunlimitedinc
Пікірлер: 92
@jimmusgrave24884 жыл бұрын
Thanks for the video, I personally use a inexpensive garden pump sprayer and I cut just the spray tip off the end so the water flows out easily, this allows me to fill each cell and be able to see when it is at the correct level as the spray wand is only 5/16” and I can easily see around it to determine the correct fill level.
@JZ-od8bx4 жыл бұрын
First thing you do! Make sure battery is fully charged before adding any water! If not when you do charge they can overflow onto the floor the next time you charge them
@aaronwilliamson40452 жыл бұрын
Very good point JZ. Kerry failed to mention this.
@aaronwilliamson4045 Жыл бұрын
@@JT-jg8le Water on the floor is not such a great problem, that can be mopped up carefully because it is acidic. The point is if you fill before charging you will dilute the sulfuric acid, waste it, and weaken the battery.
@aaronwilliamson4045 Жыл бұрын
@@JT-jg8le Not necessary to add sulfuric acid. You need to take a brief read on the chemical reactions that take place during charging and discharging a lead acid battery.
@1985cjjeeper Жыл бұрын
@@JT-jg8le The water evaporates out but the acid doesn't. Therefore no need to add more acid.
@carriegriffin60692 жыл бұрын
Thank you! This is the best video that I've found for adding water to golf cart batteries!
@j3wsdid9113 жыл бұрын
Very nice. I followed these instructions and I'm happy. I put distilled water into an old water bottle and poured it in.
@crappiexpress56334 жыл бұрын
Covering the plates with 1/8 inch of water is sufficient. Over filling will cause lots of problems tons of corrosion on the golf cart and will destroy concrete. Focus on covering the plates not getting close to the tabs.
@crappiexpress56334 жыл бұрын
Yes he filled them too high. Do not go to the tabs I promise you that’s to much. 1/8 to 1/4 over the plates is perfect.
@crappiexpress56334 жыл бұрын
No it’s not that it dilutes the acid the battery will turn the water back into acid. It’s when the batteries charge they boil the water and it will comes out the caps. The top of the batteries get wet / collect dirt and the batteries will pull constant power/voltage across the top never letting the batteries stop working. This will ware them down faster. You want the top of those batteries clean and dry. That will stop corrosion in the cables and terminals and extend the battery life.
@richardrumplik70234 ай бұрын
Thanks for sharing this Information! It was hard to find anyone Showing and Explaining about hanging jewelry on your body or hands. I’m 71 years old and been involved with cars,boats, Mc, atv . But I wanted to know if anything has changed on the filling Height on my Daughters golf cart batteries. Awesome Job and Most vendors don’t know it’s all about. 👍👍
@annpettus17752 жыл бұрын
Thank you! I hadn't been told about the tab/gauge when being tutored on this.
@scdigger3 жыл бұрын
I've found using a turkey baster (like a big syringe) is helpful in putting the water in the batteries.
@meltyice843 жыл бұрын
This is exactly what I use as well. Much easier to control IMO.
@larrys2080 Жыл бұрын
Thank you this was so helpful. I thought I knew how to fill them, but there were several steps I did not realize and they were so helpful. Really appreciate it.!!
@rdr5553 жыл бұрын
Very helpful. Wasn't aware of the gauge. Thank you.
@judyfriday14223 жыл бұрын
How often should you check the water level on the batteries?
@here_to_watch21153 жыл бұрын
Monthly I was told by my battery guy
@greyghost88888888 Жыл бұрын
perfect video for the task
@welchsjuice444 жыл бұрын
Thank you very much for this very helpful and easy 👌🏼👌🏼
@zardiw4 жыл бұрын
What about a battery filler device/jug??????
@bonitabromeliads4 жыл бұрын
video starts at 1:19
@Gears.and.Gadgets6 жыл бұрын
Or one could use a battery filler available at Auto parts stores. They shut off automatically.
@treyhelms52822 жыл бұрын
ty so much for an easy to understand guide. I needed it.
@golfwipe3 жыл бұрын
Tell it goes in the equalization mode, they want at 1/8 to 1/4 inch below that indicator, And feel after charging.
@noahriding578010 ай бұрын
How much drop in voltage in a battery bank is just from having so many batteries together in a big long string? Wouldn't there be some voltage drop from this in charge decay? And how much is reasonable compared to something being a problem? Thanks.
@reboroadie4444 Жыл бұрын
There are a lot of helpful tips and information in the chat replies, a great video, and your viewers fill in the blanks.
@danielwalsh49614 жыл бұрын
What if you overfill?
@dadsvintagegarage75424 жыл бұрын
replacing batteries...have 3 12 volt batteries....can I go back with same or can i use 6 6 volt batteries????
@louannefournier70184 жыл бұрын
Thank you, very helpful my friend...
@jeffperkins8298 Жыл бұрын
Thanks I didn't know were the fill level was
@ItsJusHP Жыл бұрын
Thanks for the Playlist 🔥
@BlxzeSwxvy13 жыл бұрын
I have a 48 volt golf cart and it does not go like it doesn't have any power but I already put water in the batteries
@r.b.somers20524 жыл бұрын
Good stuff! Thanks!
@rodolfogrande30332 жыл бұрын
What happens if you fill them over the gauge, is there a way to fix that? Can you take water out?, and adding too much water affects the speed of the cart?
@uglybobhere2 жыл бұрын
Use a turkey baster to remove excess. Probably destroyed the baster so be careful 😉
@chuckchurch12372 жыл бұрын
A/c Condensate water can be used..
@marcmoore570211 ай бұрын
Is there a maintenance free battery we can use?
@bjbrunetti Жыл бұрын
Is it best to do it manually or use the water system
@latenttweet2 жыл бұрын
The batteries will shock you if you touch them in a series circuit ie 48 volts. Each battery only being 6-12v is not going to hurt. The movies where they connect jumper cables to your body it’s not going to do anything, 12 v will not hurt. AC or DC. 30 volts is where you start feeling stuff and 60 is going to hurt. It also depends on skin moisture and resistance and other factors.
@mrcool967210 ай бұрын
Agree. Jumper cable Clamp to Nips are more visually shocking than actual... 😏 🤭
@nickmurphy39352 жыл бұрын
What would cause the batteries to keep losing/using water? I’m adding every few weeks…
@4Eva_EnterTainMent3 жыл бұрын
Thank you
@hillbillybassfisherman81813 жыл бұрын
seems to me best way get most life is to put 32 cups epton salt in gallon water on stove low heat to turns clear that is how you make battery acid it just not charged yet to make the chemical what a battery guy said anyway.a battery is 65% water an 35% sulfate so if you put plain destilled water it will get the ratio out of whack
@donaldfranklin53914 жыл бұрын
Cool video 😎
@danmoore2053 Жыл бұрын
Get a battery filling container,no guessing or overfilling
@JustinMacri0076 жыл бұрын
When you said add the water or no water what did you mean?
@bahamutkaiser Жыл бұрын
How often do you fill?
@uptone121114 жыл бұрын
Seems like by now there would be an easier way
@rich182x6 жыл бұрын
Currently deployed, but I asked my neighbor to fill my batteries with distilled water and he overfilled them. The cart won't run! The battery meter is reading fully charged and the lights work; but when pressing the accelerator, nothing happens. Any clue why?
@nikogarcia50746 жыл бұрын
Richard Harrington maybe he accidentally hit the Tow switch?
@rich182x6 жыл бұрын
@@nikogarcia5074 exactly what I thought. Even though it wasn't we flipped it off to on and after 30 seconds all was fine!
@nikogarcia50746 жыл бұрын
Richard Harrington great to hear!
@ginagvlogs23863 жыл бұрын
@@nikogarcia5074 where’s the tow switch located?
@CB500Xoo73 жыл бұрын
@@ginagvlogs2386 under the seat off to the side. You’ll see there’s a switch. One side says run and the other tow. Depending on your cart etc
@ltsnipe2924 жыл бұрын
What about deionized water?
@craigbarrett73476 жыл бұрын
How much water does each battery take?
@JustinMacri0076 жыл бұрын
Craig Barrett over the color
@vtxdaryl4 жыл бұрын
Craig Barrett Take a battery out of the cart, turn it up side down to empty it into a bowl, pour the bowl of battery acid into a measuring cup and now you know the answer to your question.
@Raysea884 жыл бұрын
D Carlton Anyone that ask that question may really try this and emptying battery acid into a bowel would be dangerous. To answer the question correctly: it depends on how much water has been depleted by charging the batteries and you use the amount of water to cover the plates in the battery.
@vtxdaryl4 жыл бұрын
Charles Bianchi The question was “How much water does each battery take?” Your example doesn’t tell how much water/battery acid each battery holds. The only way to tell, is to fill the battery above the plates, turn the battery upside down, wearing gloves and protective glasses and a respirator of course, and measure the water that comes out of the battery. The simple and safe way would be to call and ask the manufacturer how much water is in the battery. It was really a weird question because who cares how much water the battery holds. Just keep the batteries filled above the plates.
@stevecolby61772 жыл бұрын
@@Raysea88 Especially if you add acid to your bowel
@j.c1874 жыл бұрын
What year and make is that cart
@j.w.grayson6937 Жыл бұрын
Well crap! You didn't show how you get the the fill holes that are under cover. It is really hard to reach them and see when it is full.
@dennisrobinson33166 жыл бұрын
Do you fill batteries after you have charged cart or before ?
@JustinMacri0076 жыл бұрын
Dennis Robinson I’m not sure
@nickcbass6 жыл бұрын
If they are low, fill with distilled water to at least cover the plates, run a charge cycle and then top up to mark. If they are almost full anyway, charge first then top up.
@brianreid30295 жыл бұрын
If level is covering plates always charge first then top water level off. Recommended by Trojan
@abdelrahmanabdelhamed39283 жыл бұрын
انا عاوز 3 بطريات جولف كار
@TheBenByers6 жыл бұрын
How often, on average, does this need to be done?
@JustinMacri0076 жыл бұрын
Ben Byers check every once a month or every 3 to four weeks
@whocares03164 жыл бұрын
@@JustinMacri007 I find it important to check my batteries much more often than monthly in hotter weather, or as the batteries age. My current batteries are 5 1/2 years old and Im checking them every 10 days and they always take a complete auto fill bottle of distilled water each time. I also live in a very hilly area which is very hard on golf carts . I am puzzled that this video didnt recommend and describe how to use an autofill bottle which is geared to golf carts and prevents overfilling.
@davidschlarp16062 жыл бұрын
This would of been good if you could of actually saw the guage
@wilmersegarra15743 жыл бұрын
There's no need to drain the entire battery and then, fill them? Always just top them off? HELP!!!
@PerryCS23 жыл бұрын
just top them up. it would be a nightmare to have to drain them and re-top them back up again. My gold cart, we just keep topping up for years...
@diegaogarcia3 жыл бұрын
@@PerryCS2 how many years do the batteries last?
@scroungyredneck9362 жыл бұрын
That’s what that blue rubber bag hanging in grammas shower is for it’s not for drinking out of . Gotta improvise guys
@nk_dalotazyt62215 жыл бұрын
Do u do that to all of them?
@rileymariah985 жыл бұрын
Just the red ones..
@g.flores5763 жыл бұрын
Golf cart battery filler
@rehemanzilani58166 жыл бұрын
I have spent months researching into fixing a car battery and discovered a fantastic website at Magic Mender Wizard (google it if you are interested)
@williamhodges16982 жыл бұрын
Bm,"
@josephlai97592 жыл бұрын
I am afraid I disagree with you saying touching batteries will not shock you. I certainly will not encourage anyone doing that at all - ever.