Hyundai Santa FE - AWD Not Working! Let's See What Failed

In this video I show a Hyundai Santa Fe with AWD failure, I show that part that has failed causing the problem (HYUNDAI SANTA FE 2012-2015 CUP-DIFFERENTIAL CASE)
If you have one of these vehicles be sure to check warranty from Hyundai in case you are still covered within their warranty range.
If I helped ya out and you would like to buy me a drink ko-fi.com/gerardburke
Thanks to everyone who watches my videos, Likes, Shares and or leaves a comment. I appreciate everyone of you.
Tool options that I recommend and use. www.amazon.co.uk/shop/gerardb...
➢ For business inquiries Email : [e-mail]
Disclaimer:
GerardBurke is a qualified motor technician who has completed modules & courses in manual handling and all aspects of workshop safety. These videos are not intended to be used by anyone who is not trained and or qualified to carry them out.
Due to factors beyond the control of GerardBurke, I cannot guarantee against improper use or unauthorized modifications of this information. GerardBurke assumes no liability for property damage or injury incurred as a result of any of the information contained in this video. Use this information at your own risk. GerardBurke recommends safe practices when working on vehicles and or with tools seen or implied in this video. Due to factors beyond the control of GerardBurke, no information contained in this video shall create any expressed or implied warranty or guarantee of any particular result. Any injury, damage, or loss that may result from improper use of these tools, equipment, or from the information contained in this video is the sole responsibility of the user and not GerardBurke.
HYUNDAI SANTA FE DM 2.2L D4HB DOHC 16v Turbo Diesel Direct Inj. 4cyl 145kW 6sp Auto 4dr Wagon AWD [01/12 - 12/18] All Wheel Drive
#Hyundai #SantaFe #AWD

[@GerardBurkeBurkesGarage]

If you do have this problem I recommend checking your warranty first before getting any work done, if you are still within the Hyundai time/mileage warranty this job should be done for free through the dealer. As always thanks for watching🙏🙏

[@sooty1410]

Hi, You say this can be an expensive repair. How much are we talking ?

[@crystalmakkinga8271]

Mine cost me $9.000 Canadian to get repaired. Had to replace the transmission, drive shaft and transfer case.

[@patkelly7999]

Good stuff Gerard, Thank You for the tip🙏👍🙂

[@GerardBurkeBurkesGarage]

Thanks Pat 🙏🙏🙌🙌🇮🇪

[@gemmanaughton3693]

Helpful video, thank you👍

[@GerardBurkeBurkesGarage]

❤️❤️🙌🙌🙏🙏

[@CraigPittman-bv4zo]

How hard is it to remove the transfer case just to check the splines for wear? I have this same issue.

[@MiracleMAX]

Interesting! Thanks for sharing 😁👍

[@GerardBurkeBurkesGarage]

Sure is, cheers mate 🙌🙌🙏🙏

[@UncleChopChop22]

Mine is a 2019 my20 version and i am gett ing the 4wd warning and loss to the rear. Was there any design changes for the later model by chance. Only 80k kms on it.

[@anthonywalker2904]

Do you have the part number or part name of the female end that goes inside the gearbox please? I have the same issue with my santa fe. The propshaft is not spinning when all 4 wheels off the ground so i want to build it with new parts so that there is less chance of it breaking again while i own the car. Thanks in advance.

[@Caleb-lbj]

I live in Sydney my 2015 ix35 did the same on SAND front wheels only so embarrassing

[@paulbucknall2435]

Kia Sorento had the same issue

[@imrulislam7301]

Thanks for sharing @gerard, life saver! My question is, if i dont use AWD, then can I continue to drive the car without getting this replaced? Thanks

[@karmdoon49]

Hi Imrul, I had the same question and I think Gerard does answer the question and we can still get around in 2WD OK. This video shows the same problem with the guy driving around without even knowing it was failed. kzbin.info/www/bejne/n3LXc5mNl62Sf5Y

[@jordanocepeda8433]

Does the car give any sound when that part is damaged and you activate the AWD?

[@seeul8rwaynekerr]

Yes. You get a loud graunching noise as where the splines were you now get slippage. I've got my old beater santa fe and I'm half tempted to weld this joint up to get round this issue.

[@samuesoeilyoriy6581]

always a bad sign of quality and poor engeening desgin when slpines shear

[@GerardBurkeBurkesGarage]

Agreed, this is badly made, no excuses for it to happen 🔧

[@aubreynoraqa3919]

Been driving like that for 5 years on Ix35 D4HA 2012.guess I don't need all weel drive. If I get lucky and find good splines, they'll fail anyway.