P178B, P177F, P0841, P189C, DSG 7 speed transmission faults. Gears not engaging.

[@johnmafura7641]

This DSGs have been a pain. Thank you for the headsup.

[@kimaniotieno5794]

This is the most straightforward video.

[@عبدالودود-طه]

Helpfull video have a problem on my golf mk7 gear is stucking in 2nd gear ????!!!

[@sebastianang9521]

This volkwagen not so good. My golf i changed transmission for few thousand and oil leaking three time within a month..... so what u think

[@Mcintechmobilemechanic]

Whats cost

[@lwazi_6r]

Mine did this left it alone then tried it after days and drive was engaging bt reverse still not do you have a video changing regulater, transmission oil and megatronic oil?

[@kevincortes2574]

Hello friend, I would like you to help me with a question.

[@aswanation]

Ask

[@lailasalman7243]

Thank you for the video... I have the same problem and I already sent the whole gearbox to fix it because someone said it was the gearbox but I'm still having the problem code P189C please help in showing or telling exactly which part is needed to be replaced or fixed it seems like mechanics are taking advantage since I'm a woman. I have researched alot and came across your video. Please assist 🙏

[@aswanation]

Hey, I have uploaded a video on how it is done kzbin.info/www/bejne/oYTVhoKOl9Bnmac

[@grim118]

Excellent, truly. What is the diagnostic unit called?

[@aswanation]

Launch X431

[@mthontando9334]

Hi i have a 2013 7 speed dsg it shows P173C,please advise.

[@tendaiphiri3942]

Excellent narration

[@timothygichuhi2618]

Hi there. I have a problem with my Gti golf. Gearbox DSG 7 - DQ200 Gears coming : 1 - 3 - 5 - 7 Gears not coming : reverse - 2 - 4 - 6

[@aswanation]

Clutch 2 responsible for even gears is worn out. You need a clutch pack replacement

[@ameerbardien7623]

Bro. First check solenoids blocked on broken on the even gears. First measure clutch before replacing.

[@MurugeMuruge-t4e]

Thanks

[@josephambani4546]

How can i reach you? My car cant engage the reverse gear. It has a 6 speed DSG Gearbox.

[@johnkaruga25]

Hello, thanks for the informative video my VW Golf MK6 has this problem. Where is your garage located?

[@aswanation]

At Donholm, opposite oyster village. Look for Automan garage, Nairobi on maps

[@bloodreighn]

@Aswanation Hey Bro, I have a dq200 that likes to jump out of 5th sometimes randomly from a cold start, however if i pull over and come to a stop then drive off again it is ok again, its not going into limp mode or showing any codes though, do you happen to know what might be happening??

[@aswanation]

Could a low fluid issue or still, a clutch problem

[@988oguzhan]

P073b is stuck in gear 6. Is the code I got. Anyone know how to fix this. Is it a gearbox replacement job?

[@pragasenponnen97]

I have a P177F Fault using ODB11 I did have a battery drain issue were the battery died and i had lots of Low Voltage Errors...cleared all errors and the P177F came back Prior to the battery drain i had no low voltage errors. And currently the car drives fine with gear changes. Just when the car is scanned you will find the P177F and the voltage gear train is at 14v

[@aswanation]

Change mechatrinic oil. The green fluid. One liter.

[@pragasenponnen97]

@@aswanation Hi i did change the oil

[@backshotdan]

What happened did it work

[@alexradu4991]

Same problem here with the low voltage battery… Have you fixed it by changing the oil? Please help !🙏🏻🙏🏻

[@ricardodavis9972]

No u have wire problem

[@jayswag2308]

Good vid! I have a jetta hybride and i have the same warning when i shift . The car drives normally but when i play a bit between 5th and 6th gear the fault begins to come and than it can only shift from 2 to 4 and 6. When i turn off the car and start it again it will just drive normal again till i dont know .. maybe you or someone knows a little more thanks !

[@alexradu4991]

Hello I have the same car with the same problem. Have you fixed it yours? Please help and share with me, if you got fixed it!🙏🏻🙏🏻🙏🏻

[@jayswag2308]

@@alexradu4991 i forgot to say that i also changed one clutch because our car has 2 clutches. That is why he couldn’t make the gears change but after that it did good for 2 weeks and than the problem came back and the second time the mechatronic was changed. And now i drive 3 months i think without a single problem.

[@mustafaaslan219]

Hii sir hope u ll hear me:)) i have the same problem with my 2.0tdi 180hp aut., it starts with no issue no voice from engine but it do not move no forward no reverse but after 5-10 min engine starting the p-n-d stops lighting and then i am able to mive wlth my car....some mechanics say that the mechatronic is dead ...what do u think brother? And here in turkey its very expensive..

[@aswanation]

Are you able to scan it and share the error codes? Could be as simple as low oil or bad sensor. Share the codes here

[@mustafaaslan219]

@@aswanation u are great my friend ...i have the errors allready but in turkish i ll translate it and send them to u by the way i noticed that when i start the car for a 5-10 min. I am able to move the car and the failure on the dash dissapears i mean the flashing gear selections like p,d,r stops and i am able to move it but i am afraid for going a long way ...i ll wait for ur answer thx give me only 1 day:)

[@cesiumion]

My 2013 VW Passat doesn't shift into any gear. When I put it into reverse, nothing happens. When I put it into drive, nothing happens. Then I can't put it back into Park without shutting off the vehicle first. It just started doing that today. It was working fine before that. Any help?

[@aswanation]

Have the gearbox scanned. The TCM may be faulty

[@omarelsenusi6486]

Hi thanks for your video was helpful I just wonder if you can advise me I have 2015 VW golf automatic petrol gear number one and two suck and then shift four and six I wonder what’s could be the problem if you can help I’ll be great thanks

[@secmourze3023]

Hey,did you maybe find a problem .. Mine ok going trow gears if I drive slowly, but 4 th gear is like hi getting confused..Idk if is electrical or fluid

[@JA-be7me]

I have p0841 and 17950 angle sensor throttle motor. Any idea what this means?

[@aswanation]

Basic settings or adaptations with VCDS

[@JA-be7me]

@@aswanation it says transmission oil pressure sensor on the report. And my car generally revs strangely. It’s dsg vw golf. Will it cause my gearbox to fk up?

[@VijayanRajarajan]

Can anyone tell that the following codes related to Mechatronic Fault? Also how much will cost to fix this codes? Thanks in advance 🤗 P0841:00/021 13:000 - Transmission Fluid Pressure Sensor/Switch A Range/Performance - Passive/Sporadic P17BF:00/060 79:000 - Hydraulic pump. Anti-play protection - Passive/Sporadic P17BF:01/060 79:001 - Hydraulic pump. Anti-play protection-Upper limit exceeded - Passive/Sporadic 79:002 P17BF:02/060 - Hydraulic pump. Anti-play protection-Lower limit not reached - Passive/Sporadic P189C:00/063 00:000 - Function restriction due to insufficient pressure build-up - Passive/Sporadic

[@bobbygicharu2628]

Most likely Accumulator blown/cracked so yes mechatronic issue

[@backshotdan]

Hi there sir I have a golf mk6 1.4 dsg 7 gears so on the dashboard it’s coming up gearbox overheating

[@aswanation]

Gearbox oil running low

[@backshotdan]

@@aswanation Am getting code coming up P0947

[@JA-be7me]

@@aswanation but the 7 speed dsg does not require a oil change cuz it’s sealed shut. Doesn’t transmission oil only apply to 6 speed dsg?

[@A.psychedelic.hood-rainbow]

Can somebody help me out, my 2009 VW Jetta is flashing all PRND at the same time even when I put it to drive or reverse it doesn’t move, sometimes it moves a little, only a little. How can I fix that ??

[@aswanation]

Scan it to get specific faults but generally, your gearbox is faulty

[@bobbondarul7448]

Really good explanation Stay safe

[@adamabushofa4120]

I have some time when it’s in parking mode didn’t move forwarder and reverse and suddenly jumped my car Tiguan 2013 7 speed

[@aswanation]

Low pressure. Low mechatronic oil or failing mechatronic unit

[@wongdewei9730]

I have this issue too,mk6 gti 2010 Sometime I put it in reserve .The error will pop out . I change to any gear still can’t move at all until I stop the engine and start back only will back to normal . Can you help me thank you.

[@aswanation]

Hey, here is what needs to be done, or how to replace the faulty components kzbin.info/www/bejne/oYTVhoKOl9Bnmac

[@wongdewei9730]

thank you

[@Maze250808]

Very helpful thanks

[@Chris-xc3xz]

How you drop the pressure in the accumulator before removing it?

[@aswanation]

Drain all the mechatronic oil before removing it

[@Chris-xc3xz]

@@aswanation does the gearbox have to up to temperature or can you drain it from cold

[@RG-bx1vd]

I’m having a jittering problem when pulling off it revs high in gear 2 I jolt forward and then everything is fine drive perfect after that, no fault code showing up someone help

[@aswanation]

Clutch 2 may be having excessive wear

[@terencekajese9921]

Hallo,thank you for the video,can anyone here help me 😢.. My transmission plug broke Into pieces and I can find anyone to help with how the wires are connected to the plug from the loom to the mechatronic.I can't figure out how the wires are connected to the new plug. VW POLO 2016 GTI 6C 1.8LITRE.PLEASE PLEASE HELP.

[@haseebkabir4541]

Hi I have a P177C fault any ideas ?

[@aswanation]

Mostly has to do with clutch tolerance limit. A gearbox reset, calibration or adaption is required.

[@alexzechariahtay319]

I have this issue as well. Is so troublesome and unreliable, plus have to get towing to VW Workshop. Thanks for sharing this n

[@fuzail3012]

My VW polo have problem. Gear stuck at parking and the LED next to the gear shifter is blinking. i use emergency shift release and shift the gear to drive, but the car wont move. i stopped at a traffic signal and when i try to move this happened. What could be the issue?

[@aswanation]

Your gearbox needs to be checked and serviced

[@mariachiwaula7140]

I have the same problem, how did u solve it?

[@AutoOtwieracz]

Hi, only P178B error. Do you have any idea?

[@aswanation]

The accumulator needs inspection. It may be loosing pressure

[@kasimtutundzic3466]

Do you fix? l have same fault😀

[@montaserfstk6986]

I have the same problem, did you solve the problem? How?

[@אוריסויסה]

🙏🏻🙏🏻👍👍

[@montaserfstk6986]

I have exactly the same problem fault code is P173B . I still can drive the car when I got the problem again I need to turn off the car and turn it on again then it’s good, so I’m not using the car to avoid bigger problems, do you have any idea what should I do here?

[@aswanation]

kzbin.info/www/bejne/oYTVhoKOl9Bnmac

[@montaserfstk6986]

@@aswanation I changed the whole mechatronic but still have the same problem!

[@wiggumo]

I have the mechatronic issue sad after 6 years ownership. Sad I have to sell mine

[@aswanation]

Why not repair it or replace the unit?

[@wiggumo]

@Aswanation car is worth 4k / 3.5k. Repair 1.5k for mechatronic. 95k miles n diesel 2011

[@TheJokersootrippy]

I have a mk6 gti 2010 dsg. My reverse gear does not select whenever I put it in reverse. I’m Not sure why, can you help me please ?

[@aswanation]

Reverse gear selector fork bearings

[@Matmassve]

How much is the hydraulic accumulator, mechatronic oil for VW Passat 1.4Tsi 2012?

[@aswanation]

2500 mechatronic oil and 25k for hydraulic pump

[@Mrchygozman]

​@Aswanation please, which currency is this

[@Geezy735]

Thank you so much mine engages the gears but vibrates of jercks when changing

[@aswanation]

Have you done transmission service yet?

[@aswanation]

It needs oil change.

[@Geezy735]

Yes i did , it just change the even gears ,2,4,6 and reverse gear the other gears dont change

[@jamaalbraithwaite3970]

@@Geezy735 Having the same problem. What is it you did?

[@kitakamusembi9054]

​@@Geezy735 did you sort it out?? Having a similar issue

[@dyndamarjory1811]

So common with thz golf

[@denisokoro7126]

Confirm

[@tayyibahkhan3867]

I have a polo wont crank, plugged into VCDS and getting no communication. Checked the fuse which seem fine. Any idea? Was driving completely fine now wont drive or show the gear on the screen. All i have is P/N on the screen- polo 2010

[@aswanation]

Hey, did you get help? Can you share more details of what the car is showing or doing?

[@tayyibahkhan3867]

@@aswanation My starter wire ended up snapping off which is why it wouldnt start. Car still wouldnt drive so i have sent my Mechatronics off for testing i haven’t got an answer as of yet

[@mariachiwaula7140]

What was the problem

[@tayyibahkhan3867]

@@mariachiwaula7140 it was the mechatronics