Peugeot 308 1.6 HDI FULL Service Oil & Filter Air Fuel Cabin Filters Service Light Reset How To DIY

  Рет қаралды 172,116

IAMASPANNER

IAMASPANNER

Күн бұрын

Here is the full service on the Peugeot 308 1.6 HDI diesel model years 2013, 2014, 2015, 2016, 2017, 2018, and 2019.
If this video helps then please support me by subscribing and liking the video, thank you!
Sump plug size is 21mm, torque requirement 34Nm
Oil filter housing 27mm, torque requirement 25Nm
Oil capacity 3.8 litres.
Air filter:
There are 3 T25 Torx screws along the front and a metal clip on the side that is easily done by hand. Make sure when fitting the new filter that the edges of the filter are definitely seated correctly.
Fuel Filter:
Remove the soundproof material on top of the engine. The fuel filter is located to the left hand side of the airbox/intake. Remove all the hoses and the electrical connector. There are 2x 8mm bolts at the rear and this will allow the top and filter to be removed from the car. Once you have removed the filter complete with the top if you lift the centre part by twisting this will allow the filter to be drained. Now remove the 3 T15 Torx screws. Now fit the top to the new filter making sure you replace the seal and fit completely square as the seal is easily dislodged. Push the centre down and replace the Torx screws. You can now refit to the car take care the bottom of the filter seats correctly, replace the hoses and electrical connector. Tighten the 8mm bolts. Cycle the ignition a few times as on a lot of cars this will allow the pre-delivery pump to fill the new filter. Now start the car and leave running for 5 minutes to make sure there's definitely no air.
Cabin Filter:
This is located in the drivers footwell on the right hand drive models just to the left of the clutch. Remove the kick panel insulation with Bojo Tip 3 then the side panel to the left of the clutch pedal. The filter is in 2 parts pull the tabs to remove. Refitting is the reversal of removal but make sure the new filters are pointing the correct way. They have a black arrow on and this should point to the rear of the car.
If you'd like to support my channel please visit my websites and follow my socials:
www.tolly.co.uk
www.cleverproducts.co.uk/bojo-...
/ tollyswift
/ tolly_swift
Thanks!

Пікірлер: 83
@johngalvin6010
@johngalvin6010 11 ай бұрын
I was initially looking to change the oil filter. I took it to a garage 6 months ago & they said that all this was done, oil, fuel and cabin filters. You just can't be certain that you're being told the truth so the best thing to do is to do it yourself if you can. Your video shows all the instructions required to do it. Thanks.
@IAMASPANNER
@IAMASPANNER 9 ай бұрын
Never chance it if you can DIY, use the best parts available and save on labour. At very least regular oil changes will keep your car running better for longer.
@barry5138
@barry5138 4 ай бұрын
Wouldn't trust any of them. Get it done yourself is the only option 💯
@brendanukveteran2360
@brendanukveteran2360 3 жыл бұрын
Much appreciated - no nonsense and very clearly demonstrated...even I could manage it now - thanks
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
That’s great, thanks Brendan!
@richardmackenzie7231
@richardmackenzie7231 3 жыл бұрын
Recently just got a 308 and this video helped a lot to show ease of servicing hardest part be that bloody undertray
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Working on the ground undertrays are the worst! It means you have to jack the car up way higher than if they just gave you a small access hole to the sump plug like they do on some cars!
@Asuka_kj
@Asuka_kj 3 жыл бұрын
hey buddy, its a very helpful video thanks
@Roosville1
@Roosville1 3 жыл бұрын
Best service for this car I have seen, many Thanks. I would only add that on the petrol filter it's worth pointing out if you don't rotate the centre you can break the centre rod if you then try to pull it apart. Again, really helpful video.
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Thank you for the feedback! When I’m in my friends workshop I don’t have anyone to record for me which makes it harder to show exactly what’s going on but I appreciate you mentioning it so other can see. I’m so glad the video helped!
@ChrisAngelov
@ChrisAngelov 3 жыл бұрын
I'm about to buy this moden 2015 and this video helps me a lot. I have a megane 2 2002 now and i can say that it would not be difficult me to do it :) as i do it on my megane 2. Many thanks for the video.
@paalston
@paalston Жыл бұрын
Thanks very much, seems the only one out there for the 1.6 hdi 92 t7
@alexandreleme7473
@alexandreleme7473 3 жыл бұрын
Thank you sir for your time and your expertise. Congrats
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
That’s very kind Alexandre, thanks for watching and the feedback!
@Sergioml700
@Sergioml700 2 жыл бұрын
That car comes from a Battle? 🤣. Nice vídeo, It helps me a lot. Thanks!!!!
@gf04rce76
@gf04rce76 3 жыл бұрын
Excellent walkthrough... thank you...... and one handed too .... very impressive..... 😂
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Thank you very much, and yes, can't believe how many jobs I have done one handed!
@aname5695
@aname5695 3 жыл бұрын
thanks bro from Belarus
@adnaneboukerboub9930
@adnaneboukerboub9930 Жыл бұрын
Well presented thanks for sharing
@vodonnell1
@vodonnell1 Жыл бұрын
Very helpful thank you.
@IAMASPANNER
@IAMASPANNER Жыл бұрын
Very glad to help!
@kaloyanski85
@kaloyanski85 Жыл бұрын
Many thanks for uploading the video! It is very helpful for DIY! I see you are having good practice to replace screws and washers. Do you have the screws and washer sizes and norms?
@IAMASPANNER
@IAMASPANNER Жыл бұрын
Glad to help! I don't have the sizes, you'd just need to order a sump plug for your car. If you give an auto factors your registration number they'll be able to find you one.
@sawomirpienkosz6131
@sawomirpienkosz6131 Жыл бұрын
Thanks
@demon23ro
@demon23ro 3 жыл бұрын
Hello there. Thanks for the video. Very useful. Are there any frequent known defects with these engines ? I am looking at buying one and i was wondering if it is safe to buy one that already has 200 000km on bord. Any feedback would be much appeciated. Thanks !
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
This engine is in a lot of cars and I’ve seen plenty with over 200k miles on the clock. Just make sure the belts have been done if you’re buying at that mileage. They have quite a high service interval for the belts and if they fail there’s a lot of work to fix them or it may even destroy the engine.
@faze_karel
@faze_karel 3 жыл бұрын
Je vous remercie beaucoup
@mykola_iegorov
@mykola_iegorov Жыл бұрын
thanks!
@arkadiuszkubiak566
@arkadiuszkubiak566 2 жыл бұрын
THX FOR HELP ;-)
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
You’re very welcome!
@ufs910
@ufs910 2 жыл бұрын
Vielen Dank, jetzt kann ich meinem Onkel etwas helfen.
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
Ich helfe sehr gerne!
@hamzadjaafri9839
@hamzadjaafri9839 2 жыл бұрын
Thanks for the video . How many horse in this engine ?
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
You’re welcome Hamza, 92bhp according to a quick car check.
@driverc6602
@driverc6602 3 жыл бұрын
In the lubricant advisor it says oil capacity is 3.75 (with oil filter) i guess? . Can you please tell me is 3 litre enough to get minimum oil on the dipstick, or 3.25l maybe?
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
It probably would be, there’s usually between 0.5 and 1 litre difference between minimum and maximum.
@michaelspafford5936
@michaelspafford5936 3 жыл бұрын
Hi. I've been doing this by myself for a while. But i cannot change the air filter. My box has a mass airflow sensor on it(i think its called). I snapped it once. I know you twist it and pull it but there is no room to remove it to get the lid off. Any advice? Thanks
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Hi Michael, the MAF sensor is the bit you can see around 4:16 with the part orange connector. Is there a sensor in your air box cover or something?
@thecontrolpanel1
@thecontrolpanel1 3 жыл бұрын
Whats the clicking sound when the engine is running? I have the same car and it sometimes makes the same sound. Is this common on these models?
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Most engines do it, it’s usually just the injectors or something electrical
@abderazakhaji8276
@abderazakhaji8276 Жыл бұрын
Merci beaucoup
@IAMASPANNER
@IAMASPANNER Жыл бұрын
Vous êtes les bienvenus 👍
@cleggy2009
@cleggy2009 3 жыл бұрын
Did you fill the new filter with diesel pal? I do where I can think helps purge the air out cheers 🍻
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
No I didn’t, yes I would suggest that where possible but many cars this isn’t possible
@pequlatv4814
@pequlatv4814 3 жыл бұрын
These new cars have electric diesel pumps, just crank it few times and it will pull the same moment
@okiesib
@okiesib Жыл бұрын
how often should a DIYer do this to their car?
@whoiam2878
@whoiam2878 2 жыл бұрын
Thx!) When will be 1.5 BlueHdi 130 HP?
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
Whenever I get chance to do one 🤞
@coldwatertap8424
@coldwatertap8424 3 жыл бұрын
Is there any chance you could link the filters and everything you need in the description?
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
I don’t have the paperwork anymore and I’m surprised I do usually put part numbers in the description. If you check who your local motor factors are you could try calling them or even get a quote from Halfords then shop around. Euro car parts website would also show you the part numbers just by typing your reg in.
@AjaySingh-mk7ig
@AjaySingh-mk7ig 3 жыл бұрын
Hi after how many miles do you do these filter changes on your Peugeot
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Hi, they vary but approximately off the top of my head, oil every 12k, air every 24k and cabin/fuel every 40k
@mullahosk585
@mullahosk585 3 жыл бұрын
Which grade oil is best for the 16 valve 1 6 hdi engines? I hear they are notoriously delicate
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
Hi Mullah, I haven’t heard this, unless it’s an oddly specific engine generally we use GM Dexos 2 which covers most cars including Mercedes long life and even VW PD.
@magdalenawereda8753
@magdalenawereda8753 2 жыл бұрын
5w30 c2
@spartan5397
@spartan5397 3 жыл бұрын
undercarrige bolts are M10 x XXmm? or Mxx X 10mm?
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
10mm heads so M6 bolts
@mutzeglatze1434
@mutzeglatze1434 3 жыл бұрын
When you screw of the oil-filter then a lot of old oil will come out. So i would close the screw at the bottom after oil-filter change.
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
I agree however the amount of residual oil inside the engine means you’ll never really get everything. As long as the car is maintained regularly it shouldn’t make any difference.
@mullahosk585
@mullahosk585 3 жыл бұрын
@@IAMASPANNER What about the old oil that never comes out due to the ingressed sump plug? Won't it contribute to the gradual accumulation of dirt that will inevitably block that turbo filter mesh?
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
If this is an issue then follow service intervals or change oil more often and before changing the oil maybe add an additive that helps flush the oil.
@sky4kino943
@sky4kino943 2 жыл бұрын
You wouldn't know by any chance where is the power steering wheel fluid reservoir is located on this model? I just can't find it to check the fluid level. Thank you
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
I don’t know off the top of my head but I’ve tried to Google images. It looks like it’s a black cap with a red steering wheel on but the pipe looks short so it may be pretty close to the steering rack and lower down in the engine bay. From what I can see briefly looking the power steering is the electric type.
@user-mn6jt1xv9f
@user-mn6jt1xv9f 2 жыл бұрын
Электрический
@justpassingthrough1461
@justpassingthrough1461 Жыл бұрын
To confirm, it's electric so you won't find a pump/reservoir
@snotdweiler
@snotdweiler 4 жыл бұрын
👍
@carlitosf1
@carlitosf1 3 жыл бұрын
Whats is the year of this car? And motor Code? Exist different types of fuel filter and Air filter that It depends of the year of manufacture.
@IAMASPANNER
@IAMASPANNER 3 жыл бұрын
2014 but unfortunately I don’t have a record of the engine code.
@TheChampionChimp
@TheChampionChimp Жыл бұрын
SUGGESTION! Remove the oil filter first before draining the sump as it allows any impurities from the oil filter to drain into the sump before the oil is removed.
@IAMASPANNER
@IAMASPANNER Жыл бұрын
I usually leave the oil draining while the sump plug and oil filter are both removed but you are correct it is good practice to remove the oil filter first.
@murattaskin4874
@murattaskin4874 2 жыл бұрын
hi mate, 4 liters enough for it?
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
Yes the capacity is 3.8 litres.
@murattaskin4874
@murattaskin4874 2 жыл бұрын
@@IAMASPANNER thank you
@johnowen8321
@johnowen8321 2 жыл бұрын
That's a pretty useful video... Hate the look of that cabin filter I bet there was no sound to hide the swear words.
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
Cabin filters are the worst and yes, there’s a lot of swearing involved on most jobs!
@arkadiuszkubiak566
@arkadiuszkubiak566 2 жыл бұрын
oil 0w30 ? 5W30 ?
@IAMASPANNER
@IAMASPANNER 2 жыл бұрын
I don’t know what the manufacturer recommends but I used 5w30.
@user-mn6jt1xv9f
@user-mn6jt1xv9f 2 жыл бұрын
Под капотом наклейка на видио видно,рекомендуемого масла пооизводителем пежо -тотал 0w30.5w30 тоже идёт. Лайк и подписка..... УКРАИНА.
@lopezben3023
@lopezben3023 4 жыл бұрын
- - NOT, NOT, NOT ... Peuge-NOT. - -
@haakonchristensen2880
@haakonchristensen2880 2 жыл бұрын
👍
🥳 Peugeot 308 II: does this car give you a lot of headaches? Subtitles!
21:27
АвтоСтронг-М
Рет қаралды 155 М.
MEU IRMÃO FICOU FAMOSO
00:52
Matheus Kriwat
Рет қаралды 15 МЛН
Hot Ball ASMR #asmr #asmrsounds #satisfying #relaxing #satisfyingvideo
00:19
Oddly Satisfying
Рет қаралды 51 МЛН
Faire la Vidange et changer les filtres sur Peugeot 308
17:48
How To Change The Oil, Air & Fuel Filters In A Peugeot 3008  - DIY
11:49
Peugeot 308 T9 replace cabin filter
4:13
Adrian Dragan
Рет қаралды 52 М.
Peugeot 308 1.6 hdi (T9) Diesel fuel filter change
6:59
Peugeot ON
Рет қаралды 7 М.
Cambio de aceite y filtros del Peugeot 308
38:42
George Aventure
Рет қаралды 65 М.
How To Unblock A Blocked DPF(diy)
2:45
DIY Alam
Рет қаралды 122 М.
Filtri clima Peugeot 308
8:17
il piccolo meccanico
Рет қаралды 6 М.
PEUGEOT 308 1.6 BLUE HDI TEST DRIVE
25:36
VmaxViking
Рет қаралды 43 М.
Peugeot 308 1.6 hdi (T9) motor oil change
8:06
Tamás Pózer
Рет қаралды 20 М.
СКОЛЬКО стоит содержание BMW X7? #авто #bmw #обслуживаниеавто
0:50
Виталий Нефедов | American Auto
Рет қаралды 5 МЛН
pitstops practice in Perth #supercars #pitstop #racecars
0:10
Brandan Trudinger
Рет қаралды 17 МЛН
ВЫШИБАЛЫ - Булкин, Слово пацана, САН-ТАН, Magic Man
1:0:54
Жекич Дубровский
Рет қаралды 2,5 МЛН