Tell whoever was recording that she’s the real MVP I was really confused what the WD40 was for
@riosautotransportllc9 ай бұрын
Thank you! 😊
@CassandraHancock-n2u8 ай бұрын
I'm still trying to figure out why the WD40 was used on the bolts? Makes it sound like it was sprayed on the bolts after they were out. Why not use an anti-sieze?
@daniellittle504Ай бұрын
The video was very helpful, except for the fact, he neglected to mention that there is a def injector gasket that you need to replace once in a while so that three minute job for me, turned into a two day job because I had a bolt that broke and I had to drill it out and I had to replace the def injector gasket and I had to replace the injector gasket which was heat welded to the injector and the mounting. However, I would suggest using never seize or anti-seize on the bolts instead of WD-40.
@petermandel25528 ай бұрын
Also clean this if def usage goes up. The white crystals mess with the spray pattern which makes it less efficient.
@riosautotransportllc8 ай бұрын
Thank you!
@pmtips4482 Жыл бұрын
You could try Blue DEF Platinum, I run it exclusively and my injector is staying clean.
@riosautotransportllc Жыл бұрын
I agree. I switched to Blue Def Platinum and no longer use Biodiesel fuel.
@joenissan10 ай бұрын
Try using blue def platinum. You shouldn’t have to clean it anymore. It contains an additive to help stop caking up.
@riosautotransportllc10 ай бұрын
Yes I switched to blue Def (I buy it at Costco for $13,99 each). I don’t need to clean it often anymore.
@carl259110 ай бұрын
@@riosautotransportllc have you used truck stop DEF or what were you using.. one question.. is this not HOT when you pull over?? seem like this is exhaust system and should be hot as hell..
@riosautotransportllc9 ай бұрын
No i was buying def at Home Depot or auto zone but it wasn’t the blue Def. Each time I clean it truck is cold, I’m usually home.
@iancameron1989 ай бұрын
Have you replaced the water hose for turbo cooling system??? If so did you make a vid. @@riosautotransportllc
@riosautotransportllc9 ай бұрын
No I haven't replaced it yet. @@iancameron198
@rickstills6716 Жыл бұрын
I just removed and cleaned mine at 52k miles. It was ready to be cleaned. I also replaced the old rusty 10mm bolts with new stainless steel bolts.
@Willfistergash211 Жыл бұрын
Stainless bolts,good call.
@riosautotransportllc Жыл бұрын
I need to replace mine with stainless steel bolts, I have the original.
@garymatusavige4023 ай бұрын
Mf my bolts were rusted so bad I thought it was 8 mm then ended up welding 3/8 nut with 9/16 wrench snapped off after about 2 move the other side I sanded im not sure if have to get pipe or can tack weld it my truck was parked to much and rusty I did see a lot white so now I’ll try hot water and maybe see if my brother can fix the bolts
@tenzinnamdhak Жыл бұрын
When the message popped up says - Exhaust System Service Required See Dealer. What does it mean? Is it the same issue as yours?
@riosautotransportllc Жыл бұрын
My message said Service Def see dealer on my 2016 Dodge 5500. It didn’t mention exhaust.
@jamesbinfl2 ай бұрын
where did you get your replacement DEF injector? Thanks
@riosautotransportllcАй бұрын
I bought it directly From the dealership.
@jeffarthur3224 ай бұрын
So no gasket replacement required? 3:12 3:12
@riosautotransportllc4 ай бұрын
No
@jeffarthur3224 ай бұрын
I’m concerned I’m going to snap off the bolts. I’ve been soaking with PB blaster for several days now. It would be nice to know the bolt size. Some have replaced with ss bolts. If I do ever get them out I’m going to treat them with some hi temp anti seez 😊
@kirkjellum9 ай бұрын
Great vid, Thxs!
@riosautotransportllc9 ай бұрын
You’re welcome, thank you for watching!
@imbatman6624 күн бұрын
I use blue def platinum and get def warning every 5000 miles
@riosautotransportllc24 күн бұрын
Do you use diesel #2 or Bio? I had the same issue using Bio.
@VictormarceloAguileraver-yq7ls6 ай бұрын
Hello, I am new to the channel, excellent tips to learn, I have a ram 2500 diesel heavy duty year 2022, the innova 5210 scanner, what model is it because there are many, which one is correct, what do you recommend, greetings from Texas
@riosautotransportllc6 ай бұрын
Just don’t purchase the cheap ones, I purchased mine at Costco. You want one that isn’t complicated to read.
@AndrewRoeder-g8u7 ай бұрын
Did you ever look down into the scr for build up of def? That is common on trucks that idle a lot or that are used heavy towing, there is or was a campaign for this issue by installing a def umbrella, I have 80k on my 3500 never had that issue, but I also work on dpf and scr issue everyday as a mechanic
@riosautotransportllc7 ай бұрын
I changed to blue Def and no longer use BioDiesel fuel. I haven’t had Def issues in months.
@levaughnhardie77273 ай бұрын
I have been using the Def from Pilot J. Do they sell cheap def?
@riosautotransportllc3 ай бұрын
I’m not sure, I use blue def. I buy it at Costco but they sell it at other locations.
@BLHomestead8 ай бұрын
The regen is supposed to take care of this. How often does your truck do the regen? I'm starting to think I don't run mine enough to get it to regen correctly.
@riosautotransportllc8 ай бұрын
It was building up and causing my engine light to turn on. I switched to Blue Def (I buy at Costco) and I no longer use biodiesel, I haven't had this issue in a few months.
@billwhipple7862 Жыл бұрын
How do you get warm water on the road ? Pee in a cup
@riosautotransportllc Жыл бұрын
😂
@flat4314Ай бұрын
Does that work asking for a friend
@jkendrick1006 Жыл бұрын
What code does it set?
@riosautotransportllc Жыл бұрын
I didn’t check the code but the dash said Service Def see dealer
@scotthelgerson533 Жыл бұрын
Can you tell me more about the code reader? Do you like it? Was it affordable? Where did you get it? It’s for a Cummins 6.7 , Correct? THANKS FOR SO THE GREAT VIDEOS!!!
@riosautotransportllc Жыл бұрын
I bought mine at Costco. Yes it’s affordable, under $100. It works for my 6.7 Cummins to read to codes.
@scotthelgerson533 Жыл бұрын
Do you know the brand name?
@riosautotransportllc Жыл бұрын
@@scotthelgerson533 Mine is a Innova 5210 it’s three years old.
@glennc71794 ай бұрын
That code is not for the def injector
@riosautotransportllc4 ай бұрын
Cleaning it cleared code.
@Knuckledragnation11 ай бұрын
So I’m curious if my 3500 is as simple to get to as your 5500? I’m curious as to why it needs to be cleaned every 3 weeks? Because the engine light comes on? I’m new to owning a diesel so any help is much appreciated! ✌🏽
@riosautotransportllc11 ай бұрын
Yes my engine light would turn on and service Def light too. I was using bio diesel and cheap Def. I now use regular diesel and blue Def (Costco sells it for $13.99) I haven’t cleaned it in over 2 months.
@victornunez826711 ай бұрын
If possible I'd keep another one In truck for quick swap and cleannother later after delivery. Cause time is money. Be back on road. Gotta be ready for any situation cause on road never know atleast there's a back up
@riosautotransportllc11 ай бұрын
Thank you, good idea!
@lesmcgann6 ай бұрын
What if i have a large resistance across the two pins? 270 k ohms?
@riosautotransportllc5 ай бұрын
I’m not sure, I haven’t had that.
@wanderingquestions75017 ай бұрын
Every month!? I used blue def for 92,000 in 7 years no problems, but I am switching to Platinum
@riosautotransportllc6 ай бұрын
Yes I use to but I haven’t in multiple months, I no longer have that issue now that I’m using blue def and no Bio- diesel.
@kikikeyless7 ай бұрын
you might be uding cheap DEF, every month is crazy
@riosautotransportllc7 ай бұрын
I haven’t cleaned it it months, no more issues.
@rogerjohnson3783 ай бұрын
You have a P2471 clean your egr cooler / valve its clogged.
@riosautotransportllc2 ай бұрын
Try cleaning the injector, if code doesn’t clear you may need to clear it yourself.
@goducgo Жыл бұрын
Wow haven’t cleaned mine yet.
@riosautotransportllc Жыл бұрын
You’re truck will let you know once it’s dirty.
@925HOTSHOTRUSH Жыл бұрын
Can you show how you operate your lift on your trailer... I just bought the exact trailer...need a few pointers 👍thanks
@riosautotransportllc Жыл бұрын
Yes, thank you for the suggestion. I’ll upload it early next week.
@LenTexDIY6 ай бұрын
You’re not doing that on the road unless it’s been sitting long enough to cool down
@riosautotransportllc6 ай бұрын
Yes you’re right.
@julioespino71125 ай бұрын
This work i clean mine with boiling water and toothbrush
@riosautotransportllc5 ай бұрын
Yes it does.
@petermandel25528 ай бұрын
There is a gasket on the injector. Keep one in the glove box.
@riosautotransportllc8 ай бұрын
No había you!
@RobertP-zk8vh5 ай бұрын
going to try this
@riosautotransportllc5 ай бұрын
It worked for me, I now use Blue def and never Bio Diesel. I haven’t cleaned mine in over 6 months.
@RobertP-zk8vh5 ай бұрын
@@riosautotransportllc my bolts for the def jnjector are rusted and crunchy i cant the bolts off
@RobertP-zk8vh3 ай бұрын
@darrylvaillancourt6144 i got the injector off it cost me 600 bucks but the injector is cracked so i have to buy a new injector, rock auto has the part for about 180
@Chad-wk2pm Жыл бұрын
Ad blue def might help it stay cleaner
@riosautotransportllc Жыл бұрын
Yes the blue Def works well, I use it. when I was using biodiesel I cleaned it more often. Now on regular diesel I can’t remember last time.
@AussieDazza10 ай бұрын
Dodge ? 🤣🤣🤣🤣
@riosautotransportllc10 ай бұрын
No issues now that I changed to better quality Def.