Tundra heater climate control defrost vent Finally Fixed

[@simplerickbar2602]

That was the most hank hill "dang it" I've ever heard. Thanks for the video

[@JohnCalebWarren]

I didn't think anyone would've ever caught that I snuck that one in there 😅

[@xammy3954]

I came straight to comments to make sure someone else noticed that!

[@M.D.Jones87]

😂 😂

[@mikel5992]

Great video especially the commentary from your daughter and the screwdriver trick to stop the annoying noise. Thanks for posting this

[@rsanchez5676]

Excellent video! Your daughter is precious!

[@orasioramon2651]

Bro, this video is amazing!!! Thank you so much. I just can't get the stupid thing to line up to get back on.

[@cuemyers376]

Thanks for sharing this info. Mine needs fixed and this will help out a lot!

[@TheGbowhntr]

THANK YOU! having the same issue.. Dealer wants 3k parts and labor. I can do this now after watching our video. Thx.

[@aerosmith59983]

Thank you John, your video was great and very helpful.

[@deezerdeezer]

Thanks for the video. Helped me get the job done!

[@elgatogordo9523]

Thanks for this informative video 👍 My buddy’s truck is having the same problem. We’ll give a whirl 😁

[@rsanchez5676]

Omg “she’s done with the video”. So cute

[@CharlieAtkins]

Damn dude, you showed everything but the most important part... I wanted to see the alignment of the damper door lever pins to the gear slots... I blink and the damn thing is already installed...🤕

[@rexcaron9847]

at the end of the video when you turned the knob to defrost it didnt sound smooth. kinda sounds like two plastic gears jumping. i just wondered bc im about to do this exact project

[@forsakenriceboyyang7807]

I noticed the gears jumping too, hopefully won’t cause a premature wear.

[@advancedmillworkinstallati5994]

awesome video man thank you

[@ianj4474]

My issue is that only cold air blows in the front, it'll switch between all the different modes like feet, face, defrost but no heat . The rear passenger heat does work just fine through vents. Would replacing this assembly make the heat come through front vents? Thanks!

[@lang5264]

Did your air sometimes hesitate to even turn on? Mine does and I'm only getting air through the defrost. I can turn mine on and start driving and sometimes it may take it a few minutes to come on.

[@JohnCalebWarren]

I've heard that problem is actually the control unit with the knobs it has a faulty circuit board in it. Ours does that too but I'm too cheap to fix it. I just bear through a minute of no air before it kicks on

[@maximumdeflection2113]

Hi John Is the lower servo motor to control the driver side temperature? Im having issues with my 11 Sequoia where the temp control for the driver side isn’t working properly. I can hear the passenger side motor working when the temperature is changed but not for the driver side Thanks for any help.

[@forsakenriceboyyang7807]

Those gears supposed to bind a little and pop when spinning?!? How’s those plastic gears holding up so far now?

[@K3nny24]

Os there computer reset for the mode doors they work except when connect like it’s still lost

[@jose72arvizu94]

I replaced mines this past Feb. And now it's messing up again???

[@jaymeswhiddon8307]

Where did you get the replacement gears

[@JohnCalebWarren]

Bought the whole unit off ebay for 20 or 30 bucks. Gear w/ motor

[@qlmotorsport]

Hey JCW - is this issue the same as this one (www.tundrasolutions.com/threads/climate-control-system-delay-after-startup.192498/#post-1989068)? Were you getting delays in the climate control turning on? Also wondering if this part just replaces all of that so I don't need to mess with the gears: toyotaparts.mcgeorgetoyota.com/oem-parts/toyota-damper-871060c140

[@deezerdeezer]

Yes, this is the correct part to replace all of the gears and motors on the servo side for Tundra 07-20 & Sequoia 08-20 Damper - Toyota (87106-0C140)

[@Cruz0604]

Where did you buy it, Any links?

[@JohnCalebWarren]

eBay dot com

[@jose72arvizu94]

SO Y ARE THEY GOING BAD??