If you cap the ends of the pump before you remove it you can let it tip back easier to get the float arm out without spilling so much gasoline inside the vehicle.
@PistonShack3 жыл бұрын
Thanks Jon! I That's great tip! I will pin your comment up make sure other viewers can see it. Cheers!
@coolbluelights4 жыл бұрын
Watching so I know what i'm in for. my fuel pump is leaking. Just ordered a new one. Thanks for this and awesome music!
@PistonShack4 жыл бұрын
You're very welcome coolbluelights! I love 90th Disco Hits). Cheers.
@Vrakkes4 жыл бұрын
Thank you very much for this video. Unfortunately I didn't pay complete attention to this video so my fuel gauge is no showing 75% fuel when I am at 100%. Thankfully, I have now learned at (2:38) that the pump should be aligned in a certain way and will now pick apart my Volvo again. Keep up the good work buddy!
@PistonShack4 жыл бұрын
Glad it helped) You are very welcome brotha!
@johnsbuilds54153 жыл бұрын
Did readjusting it fix it?
@emmanuela.imediegwu4949 Жыл бұрын
Very salient point here. Now I know why my guage has been erratic since working on that pump
@williamwilcox45392 жыл бұрын
Dear pistonshack. I have a 2004 Volvo S80 2.5 turbo all-wheel drive. I'm having two fueling issues. First one is I will fill my tank up in the needle reads full but once it gets past halfway it sticks and it doesn't move until the car runs completely out of gas this has happened to me twice while driving down the road. Second issue is that while feeling the fuel spews back at me unless I pump the fuel extremely slowly. Where it should take me just a 5 minutes or less to fill my tank it takes me almost 20 to 30 minutes to fill. What are your suggestions on fixing these issues. Thank you for your video and I hope to hear from you soon have a blessed day evening afternoon whatever time it is in your area.
@HannesKirsman2 жыл бұрын
Great video! Mechanics replaced my pump dash showed 50% when it was full. They tried to fix it but still same. Then they put old and new pump together. It's kind of ok but doesnt show it correctly when tank is getting empty. It shows like 10% full, 250km to go but then you are on the road..
@HannesKirsman2 жыл бұрын
You think it's the alignment?
@PistonShack2 жыл бұрын
Hi Hannes. Most likely fuel sender unit inside the tank got bent or damaged during the installation process, especially when you pull out extension fuel line inside the tank. It's so easy to messed up the float and potensiometer. Let me know if you have any questions.
@HannesKirsman2 жыл бұрын
@@PistonShack I thought I might try and open it up so much that I can see if the arrow is pointing correctly. You never know. I guess if it is then you're theory is probably right, sadly. Thanks for help!
@kokanelane2842 жыл бұрын
I have a 2008 xc70 and it will say 75 miles till empty then jump back up to 95 miles till empty. Any suggestions? Great video BTW!
@PistonShack2 жыл бұрын
Looks like fuel sender unit float sticking a bit.
@sjbock3 жыл бұрын
Wow, I'm glad this job is much easier on my 94 850.
@PistonShack3 жыл бұрын
It wasn't that bad. At least no need to drop a fuel tank.
@cleven2693 жыл бұрын
Nice video, I’m in the middle of doing mine now and I’m now looking for rope to tie to the end of the line to ease re routing !
@PistonShack3 жыл бұрын
Glad I could help Cleven!
@michaelmccrorie30115 жыл бұрын
I have no clue about cars really. I watched this as I thought my fuel pump had gone. I also checked the fuse for the fuel pump which was ok. But thanks to this video which showed how to test the fuel pump from the battery I done this and pump was ok. I then realised the connector had no power. I eventually found out that the fuel pump relay was located above the drivers footwell behind the steering wheel. So hard to find. So changed relay and all was fine. But glad I seen this video about testing the pump otherwise I would have thrown it away and bought a new one. Thank you for a great video.
@PistonShack5 жыл бұрын
That's awesome, I'm so glad this simple video helped you to get the car back on a road and save the money.You did right, test the relay and fuse first then checked wiring to the pump for voltage and ground! Cheers.
@rullekorn Жыл бұрын
Hej! Great video and I used your guides before. The problem is that my tank is 60% full. Any advice how to remove fuel from the tank before you open the plastic rings?
@mrnurse4479 Жыл бұрын
Thx for the video, did u had problems with the correct level? Either it shows too much or too little?
@PistonShack Жыл бұрын
Hi Mrnurse! Yes, I had problem after I assembled everything for the first time. My fuel gauge was dropping down to empty if I had 1/4 tank of fuel. After reinstalling sender unit again (more carefully) it has been working correctly.
@mrnurse4479 Жыл бұрын
Thx for answering, how did u installing it second time? I mean did u turn it more to one side?
@eddygiron65982 жыл бұрын
Hello! Great video👍 What volvo you fixing in video, is a xc70 2.5t ?? I have one 2007 and no turn on engine, Just make start but no turn on,,, meaby i think posible is the fuel pump gas... Thanks👍
@PistonShack2 жыл бұрын
Hey Eddy! I worked on 2001 Volvo V70XC with 2.4 gasoline engine. Have you tested your starter circuit yet? Check if you have power on starter command wire (Key Crank Position) first. I have video how to test starter itself.
@eddygiron65982 жыл бұрын
@@PistonShack Okay! i try and i let you know,,, thanks!
@jeffdavis2562 жыл бұрын
Thanks for the great video! Is it required/recommended to replace both the sending unit along with the fuel pump?
@PistonShack2 жыл бұрын
Hi Jeff! Well, you don't have too but if you have fuel pump assembly why not to put a new one.
@tommyaleks1004 жыл бұрын
Hello Sir. Great video it was very helpfull. People say you need to use a wire at the end but no need. I did the exactly as you did and it worked 100% and it was fast to do also. No string needed :) Thank you for making this video.
@PistonShack4 жыл бұрын
Glad it helped, Wolf Boy! Let me know if you have any questions. Cheers brotha!
@SELKCOMM2 жыл бұрын
You got lucky. The wire helps.
@JR-ly6bx5 жыл бұрын
thank you!! i have to do the same job.... perfect video!!! i feel more confident now
@PistonShack5 жыл бұрын
You are welcome!
@johnsbuilds54153 жыл бұрын
Hi. Amazing video. I have a 2000 Volvo s80 and I noticed that when I fill it up it only says 3/4 full. Do you think that the fuel level sending unit is bad or could it just be misaligned?
@PistonShack3 жыл бұрын
Thank you John! I installed 35$ used pump module. Yeah, fuel sender unit only shown 7/8 full.
@squidben57805 жыл бұрын
Excellent video, not a small job .... will get one for spare and practice and put on the side this summer
@PistonShack5 жыл бұрын
Thanks, brotha. You are welcome. Let me know if you have any questions. Cheers!
@giedriusbrogys Жыл бұрын
Hi, hope all well. I have Volvo XC90 2010, then fuel gauge less then half, car stops. Fuel pump working ok. Looks something wrong between two fuel tanks. One tank is empty, another is full, but fuel not going to prime tank. Thanks
@sherizazzetti18242 ай бұрын
My flow has power but not not the other side ,won't turn on everything good with the fuses, will that happen if a mice would of possibly chewed a wire maybe
@shanellewilson23473 жыл бұрын
Hey i have a volvo XC90 08 3.2 same problem when trying to start with a code p2227 is that the same thing changing the gasolina pump..I gotten the airflow map sensor changed spark plugs nit sure why i wouldn't start any ideas would be great thank u and like the video
@PistonShack3 жыл бұрын
Hey Shanelle! Sounds like you have crank no start issue. 1. Unplug MAF sensor, engine should start & run in default mode. 2. Check fuel pressure @ the fuel rail. 3. Check injector pulse, so easy to do (check KZbin); 4. Do you have engine light On and tachometer signal while cranking. 5. Do you have any other codes present? 6. How did this issue started? 7. Make sure your battery is fully charged. 8. Do you have any security / immobilizer problems related? Try different key. Let me know how is your Volvo. Cheers!
@kossmonaut3 жыл бұрын
great vid, thx for the diagrams
@PistonShack3 жыл бұрын
Any time!
@tadcraig31624 жыл бұрын
Question. I have a 2009 Xc70 needing a new fuel pump. Can I get access to fuel tank through cabin or do I have to drop tank??? Thank you so much
@PistonShack4 жыл бұрын
Hi Tad, I'm not quite sure. Take rear bottom sit cushion and check for the fuel pump lids. Let me know if you have any questions.
@sijovarghese46054 жыл бұрын
Remove the tank
@bigbluechopper245 жыл бұрын
Great video, thank you from the UK!
@PistonShack4 жыл бұрын
Happy Winter Holidays to You BigBlueChopper and you family! Cheers)
@luckyc9705 жыл бұрын
I got confused at 8:13 to 8:30. Looks like you tape the sensing line to the bottom of the seat. Why? Thanks for this video!
@PistonShack5 жыл бұрын
Yeah, I did because fuel lines and wiring pulled back into the tank few times when I was working on the passenger side. Thanks for your comment!
@michaelmccrorie30115 жыл бұрын
Can I ask a question? I could route the wiring as instructed just couldn't get it to feed through. So i used a metal coat hanger. Fed the wire hanger through till it came up then the other end of the hanger I attached to the cabling and just dragged it through. I assume it doesn't matter if I done this or not. The car is running but does it matter if the cable has been just dragged across the middle of the fuel tank as I have done??? Advice appreciated
@PistonShack5 жыл бұрын
Hi, Michael. I won't worry much about it if your fuel gauge works properly and pump works.
@KapriKorn0304 жыл бұрын
Great vid, 2 questions what year and model is car on vid, also I have a xc60 2015.5 T5 2.5L awd and the fuel level sensor is malfunctioning, I top it of and the dash will only show half a tank then later a full then as soon as I start driving (about 20 miles) it’ll drop like a 1/4 tank, can I get to it in the same way (removing back seat) or do I have to drop the tank? TIA
@PistonShack4 жыл бұрын
Hi Jose, On video Volvo V70XC 2.4 B4244T3 engine. You don't need to drop the fuel tank. Probably fuel level sender unit, wiring or arm have issue. Fuel sender is on left side. Just remove back seat to get access inside the tank. Let me know if you have any questions. Cheers)
@kiarapessoa89063 жыл бұрын
@@PistonShack what yearrrrr
@joemayet57475 жыл бұрын
my pump seems to b e working fine. car starts on one turn of the key. loss of power and engine management service light on (red). have been advised to remove fine filter gauze from under the pump housing and to replace pump as is. does this make sense?
@PistonShack5 жыл бұрын
Well, it's hard to tell based on information you provided. It shouldn't be gauze sump issue. Depends from the fuel quality. I never had problem with gauze filter itself. Pull it out and check it out. Lack of power could be a vacuum leak, low fuel pressure, ect.
@joemayet57475 жыл бұрын
@@PistonShack my apologies. i did not indicate that the vehicle is in limp mode most of the time. the turbo does not kick in all the time. on a straight road i have enough power. as soon as i get to an incline the vehicle loses power and i have to drop gears to maintain momentum.
@PistonShack5 жыл бұрын
Do you have any DTC? Seems like you have issue with westgate or might be turbine itself on a way out.
@joemayet57475 жыл бұрын
@@PistonShack hi. i have the following DTC codes... engine system service required. engine system service urgent. airbag service urgent.
@PistonShack5 жыл бұрын
Okay. Those are general warning messages. I would suggest you to scan the vehicle with Volvo Vida Dice Tool or OBD2 code reader.
@dimitricornelissen18454 жыл бұрын
i did replace the fuel pump same as decripted here but there is not coming fuel in the front of the car its a v70 2.4 diesel the pressside of the pump only delivers a very small amount of fuel (sorry for my bad english ) that hose goes to the fuel filter no ? At the fuel filter i mention also 2 electric wires what is the purpose of those 2 connectors ? I cant get it to run the car because of the small amount of fuel coming out of the pump in the tank
@PistonShack4 жыл бұрын
Hi Dimitri! I need to look a wiring diagram. We don't have diesel Volvo in Canada at all. Did you check new pump prior the installation? Do you have good pressure straight from the pump outlet? Some after market pumps are defective from the factory. I will get back to you later.
@Usmanthemecano4 жыл бұрын
Only thing I'd do differently is to tie a rope at the end of the wiring harness when extracting in order to reinstall it easily
@PistonShack4 жыл бұрын
Hi Sakeenah. Thanks for sharing your experience. That's good point. Happy Holidays to you and your family.
@davidjimenez69163 жыл бұрын
@@PistonShack q q
@Desire_of_Ages2 ай бұрын
What year is this Volvo? And what model?
@Sbflacko3 жыл бұрын
I was trying to feed my fuel pump lines into the sending unit and I couldn’t even get it to show up on the other side. Idk how you made it look so easy 😂
@PistonShack3 жыл бұрын
Hey Leonardo! Have you made it? You can use metal wire to help lines to go out.
@Sbflacko3 жыл бұрын
@@PistonShack yeah I’ve got it figured out thanks
@Joppe5273 жыл бұрын
Nice video! Do you know where the temp sensor on the fuel pump is located?
@PistonShack3 жыл бұрын
Hey John, Are you talking about gasoline or diesel Volvo? I don't think gasoline Volvo has fuel temperature sensor at all. In my Volvo only pump and fuel sender unit in a tank.
@chriskolar5 жыл бұрын
You the boss, great detail video
@PistonShack5 жыл бұрын
Thanks! You are very welcome. I was looking for complete Volvo fuel pump video - couldn't find. Then filmed own one)
@o_o30403 жыл бұрын
Nice video. What were the results from computer scan before? I have some issues at engine start and i think they are related with the fuel pump. It started to happens lately and often that when i push hard the car ( hard start in trafic) it gives me starts engine with problems, not normally as usual engine starts. Sometimes ( at mornings after the car stayed all night and cold engine) it doesnt start for the first and second time. It cranks, and it takes long to start engine, after that during day it starts but i can feel that the engine start has something wrong, not normal as before. Can you give me an idea. Thanks a lot 👋🏻 2.5t xc90
@PistonShack3 жыл бұрын
Hi, After I OBD2 scanning, I got nothing what can cause crank no start issue. I would recommend to check prime, idle and 2000 rpm fuel pressure. Check for any vacuum and turbocharger leaks as well. Do you have any data from your Vida Dice scan? Let me know, I will try to get back to you soon as I can. Cheers.
@o_o30403 жыл бұрын
@@PistonShack I made an OBD2 scan since vida vice is on the way...it shows misfire for 4 and 5. I changed sparks, coils (all of 5 both) and still that misfire. Anyway ill wait for vida to see if it catches more info. Checked battery, alternator, all electrical i ok. No vacuum leaks, fuel pump presion not checked ( this week will) and the injector, maybe number 4 and 5 are letting down. Many thanks for the feed back. I’ll write if it is something new.
@PistonShack3 жыл бұрын
Oh, okay. I will start with basics: Check wiring down to spark plug coils, very often it could get jammed or damaged while screwing down plastic cover. Check injectors pulse and resistance and compare 3 and 5 with 1-2-and 3. Take spark plug out check for any oil leaks inside plug well. Check spark plug for gap, deposits and wear. Check spark jump with test light - should be min 1'' spark jump from coil to the ground. Check wet and dry engine compression on 4-5 and 1-2-3. I have a video when I did compression test on VW Golf MK4 (check red Golf MK4 playlist) I don't want blame ECU right now but it could be one of the driver failure but it's too early to say. Let me know how everything is going. Cheers Brotha.
@andreasronnback61003 жыл бұрын
Oooh my god… Volvo is a great brand. But when the engineer come up with this construction he must have been high on gas….. Unbelievable
@PistonShack3 жыл бұрын
Well, no so bad Andreas! At-least we have access to the pump from inside, not like on some Fords and VAGs. Cheers!
@gretakilinskaite12127 ай бұрын
Does it work on 2005 volvo v50 2.0 dies too?
@jaimeparadise5 жыл бұрын
I have the same issue with no fuel. How do you check the fuel pump relay. I cant find it in any of the fuse boxes. Mine is a 2003 S60. Please help !!
@PistonShack5 жыл бұрын
Hello. Fuel pump relay located near the CEM deep under the steering column. Look for CMI 12 relay - fuel pump. To get that relay out use bend long needle nose pliers. If you have any questions, let me know.
@jaimeparadise5 жыл бұрын
@@PistonShack Thank you.. I already diagnosed a bad pump. Power goes in but it does not work. Getting a new one at ebay for $47. Thank you .
@PistonShack5 жыл бұрын
Sounds good. I will better install OEM pump or quality aftermarket. Cheap part do not last long but you might be lucky.
@TheWizechatmgr3 жыл бұрын
Wish it were this easy in the P80 AWD's =P Going to be cutting the floor in the near future as I don't want to drop the tank.
@PistonShack3 жыл бұрын
Oh, S80 doesn't have access under the seat, I didn't know!
@javieralarcon53363 жыл бұрын
Thnks man wow
@PistonShack3 жыл бұрын
Happy to help Javier!
@circlepilot Жыл бұрын
Is the "canister" in the pump shroud the fuel filter? We have a 2009 C70 and cannot find the location of the filter.
@PistonShack Жыл бұрын
Hey Norman! I am not sure about 2009 C70 set up. On my Volvo fuel filer mounted outside on front of the tank.
@JCDUDECANTU3 жыл бұрын
What size of tools do you need for this job?
@PistonShack3 жыл бұрын
Hi Jord. You need basic socket set, so far I remember, you need: 10, 14, 17 or 19 mm sockets. Thanks for watching)
@lairdvlaming5 жыл бұрын
Thank you for the comprehensive video! One question about replacing the pump with a new one. I purchased a Bosch 30761742 (Website said it was compatible with my 2002 v70 xc AWD) and the new pump has an electrical plug on the top and only one connection to the sender while the old pump had two. Is this a problem as my car has no means to plug into the top of the pump?
@PistonShack5 жыл бұрын
You are very welcome, Laird. Yeah, I experienced the same issue replacing my fuel pump. Thing is 2003 and newer models have different wiring to the fuel pump. My advise will be, just find the pump with a same wiring (2001-2002 models). Other wise it won't work.
@xanderbasson2185 жыл бұрын
Hey its Xander, Is the pump located in the same place for a Volvo s40 t5?
@PistonShack5 жыл бұрын
The fuel pump placed inside the fuel tank. I am not sure if you can reach from inside the vehicle just only removing the back seat or drop a fuel tank. I never did it on S40
@xanderbasson2185 жыл бұрын
@@PistonShack Thank you very much for the information💪
@PistonShack5 жыл бұрын
You're very welcome!
@mashamaitewidson51343 жыл бұрын
Which trusted web site I can purchase for my 2005 s40?
@PistonShack3 жыл бұрын
Well, I like to buy from Rockauto
@timmorodgers42715 жыл бұрын
I''m in the middle of doing this job, I've stopped for a cuppa. I used a pair of large screwdrivers, crossed over to undo the tank sealing ring, using a chisel can snap the fins off. I've taken the pump apart to clean it out and can't remember how to put it back together! ha ha!
@PistonShack5 жыл бұрын
Hi, Timmo What exactly you forgot how to assemble back together? I have used pump saved. I can take a look and help you with that. Cheers!
@timmorodgers42715 жыл бұрын
@@PistonShack Hi! I have managed to put the pump back together by pausing your video at a certain point and looking where the various pipes went. I disassembled the pump and housing as the fuel had been contaminated with grit and had blocked the fuel pump strainer meaning my V70 kept going into limp mode and cutting out. With the tank and pump cleaned and reinstalled my V70 drives great. Thankyou!
@DavidVillalobos14 жыл бұрын
Why is it that you put the same fuel pump back into the Volvo. Just for demonstration purposes, or were you just testing if it worked?
@PistonShack4 жыл бұрын
Hey David, I put used one OEM pump from local junk yard. It looks dusty on outside, might sounds like I put the same one back. Nope) 55K later pump has been working like a new!
@mishaivankov22495 жыл бұрын
You've made a nice video, but i'm concerned how the fuel pumping system works, because I've replaced mine, pump is working, but I get no fuel to the passenger side from the driver side and car stalls.
@PistonShack5 жыл бұрын
Hi, Misha. That's common issue if you didn't route side fuel sender line. Follow fuel line diagram, otherwise pump won't be able to get fuel from both sides. Let me know if you have any questions. Cheers.
@mishaivankov22495 жыл бұрын
@PistonShack Well, you made me concerned now... I have the suction type thingy in the right place, I used rope to manage my routing during the installation. I'm now thinking that my fuel pump element is faulty, because it sometimes seems to work sometimes it isn't... Btw I've installed the used unit. I'm going to remanufacture it myself by replacing the pump itself... If then the issue continues.........
@engineeringcanada4 жыл бұрын
Complete guide. Merci!
@PistonShack4 жыл бұрын
You are very welcome!
@aleksandrzhila88654 жыл бұрын
спасибо мужик!
@PistonShack4 жыл бұрын
Благодарю за просмотр! Александр всех благ вам и вашей семье.
@akillideli66975 жыл бұрын
perfect video :-)
@PistonShack5 жыл бұрын
I glad it helped more than just me)
@zsomborcsuja19644 жыл бұрын
Nice and lovely... But I can't find this type of fuel pump, just the other one everywhere, which has an electric socket on the right side unit between pipes. BIG SUCK!!! The pump works well, but some "professional mechanic" broke one of plastic pipes off and all the returning diesel flows out. Tried 4 types of glue, but can't fix it that way...
@PistonShack4 жыл бұрын
Hi Zsombor. Sorry to hear that! That's why I do all my repair by myself) It took me quiet some time to find pump for my 2001 V70XC. Only one of 15 Volvo at the yard had right type of pump. Bzw, how is your repair status?
@zsomborcsuja19644 жыл бұрын
@@PistonShack still no success yet. I bought the car with glued pipe. I was in 3 different services with diesel leaking, because had no time for repair myself, but all 3 said there is no service panel on right side... Then I bought a complete tank to change, but it's wirh different type pump. Now I try to find a lathe workshop to make a special common screw. Maybe...
@helicopters10872 жыл бұрын
🥳 Great video
@PistonShack2 жыл бұрын
Thanks for the visit!
@The_blue_skeleton3 жыл бұрын
Can you tell me what tools were used in this
@PistonShack3 жыл бұрын
Sorry, I don't remember. Next time I should ad tools I used down under the video. Thanks for watching.
@tess49664 жыл бұрын
Where can I find the fuel pump in my Volvo 2008 s40 2.4i
@PistonShack4 жыл бұрын
Hi Tess, Check under the back seat coshing.
@smartcardnine7 ай бұрын
Thanks 🫣✌🏽
@PistonShack7 ай бұрын
No problem 👍
@PulsarTECH5 жыл бұрын
Great video and nice music!
@PistonShack5 жыл бұрын
Thanks!
@abisismael13434 жыл бұрын
Thank you boss
@PistonShack4 жыл бұрын
Appreciated your feedback and time watching the video. Let me know if you have any questions. Thanks for subscribing. Cheers!
@michaelna31194 жыл бұрын
2001 V70XC, now iI know where it is and how to get to it, Q is..... what is the name and artist of the music please
@PistonShack4 жыл бұрын
There are few artists, which minute of the video?
@cleven2693 жыл бұрын
I hate the P2 fuel pump design just because you gotta remove both units😞. On my old 850 it was a quick 15-20 minute job
@PistonShack3 жыл бұрын
That's good to know) Normally, older models are much easier to fix. Let me know how is your repair so far.
@Iseeyoumane5 жыл бұрын
Where can I find the emotions code to match right fuel pump
@PistonShack5 жыл бұрын
Hi, Trone. What you mean by "emotion code"? The easiest way to find a right fuel pump is to compare visually electrical connectors and fuel lines location and shapes on pumps. Also you can pull Volvo part number form VIDA or ask your local Volvo dealer . Cheers!
@mustapha29134 жыл бұрын
Tooooop ✔️🛎️
@PistonShack4 жыл бұрын
Thanks!
@livingtoexpedite17304 жыл бұрын
New here ! Great Videos !!!
@PistonShack4 жыл бұрын
Thanks for watching the vid. I checked your channel yesterday. I would like to support you guys by subscribing. Stay safe and take care!
@АлексейПетров-р3и5ъ3 жыл бұрын
Вот чтоб зубилом гайку не портить можно из фановой пластиковой трубы "ключ" сделать.
@PistonShack3 жыл бұрын
Благодарю за совет, Алексей. Сам думал, но в тот момент не оказалось ничего под рукой) но идея отличная.
@georgesherwood27185 жыл бұрын
How do i get to the fuel pump
@PistonShack5 жыл бұрын
Well, you need to work it out from the tank. It might be difficult but you will get it.
@sara781302 жыл бұрын
Hi v50. There same
@PistonShack2 жыл бұрын
Cheers Alan! Thanks for letting me know.
@MrJasonfromcanada6 жыл бұрын
How many steps on the fit bit 😃
@PistonShack6 жыл бұрын
Steps, haha!) Walking around Volvo for few hours, probably 2000+ LOL!)
@MrJasonfromcanada6 жыл бұрын
VolvoFilms if you’re ever in my area again stop by for a beer (or coffee cream) lol
@PistonShack6 жыл бұрын
You bet, man! See ya one day at winter time)
@lorangajapp80865 ай бұрын
Mine dies with a quarter of a tank left🤔
@장사운드장인수5 ай бұрын
@Pezzonovante916 Жыл бұрын
Verbal explanation, instead of useless background music, could have made this video much more helpful.
@PistonShack Жыл бұрын
Sorry for that, life and learn how to do YT better. Thanks!
@Pezzonovante916 Жыл бұрын
@@PistonShack We all live and learn. Thanks for the reply!
@vulcano9115 жыл бұрын
Please help me. I am owner of a Volvo s40 year 2007. A few weeks ago the engine broke. I don't have money to repair it. My objective is to drain fuel tank due to it is full of gasoline. Please give me a hint. I don't want to loss that 50 lts. of premium gasoline. Thanks a lot.
@PistonShack5 жыл бұрын
Morning. Well, I will remove the fuel pump cover to get access into the tank and them syphoned gasoline with a syphone hand pump. Cheers.
@markoverton5858 Жыл бұрын
There is no hatch on my s40 2.0d 2008 model 😡
@PistonShack Жыл бұрын
Hey Mark! We don't have 2.0L Volvo diesels in Canada, unfortunately! I would like to have one!
@MonzaRacer4 жыл бұрын
Ah I see you never videoed dealing with the fuel line routing and attaching the left side sender to the fuel pick up line. .just have kicked your butt real good. If it's not properly installed car will only pull fuel from right side of tank.
@PistonShack4 жыл бұрын
So true MonzaRacer! Good point. When my fuel pump will fail again I probably should record only that part - How to do fuel line routing and attaching the left side sender to the fuel pick up line! Cheers, thank you for watching!
@AndyL9404 жыл бұрын
Thanks brother.. Helped me out alot.. What a stupid design.. Lol typical Volvo over engineered
@PistonShack4 жыл бұрын
I'm so glad to hear that) Cheers brotha! Let me know if you have any questions about your Volvo.
@gamekonto5262 жыл бұрын
I'm not going to get these hoses in the right place
@PistonShack2 жыл бұрын
How is your repair?
@avenqer4 жыл бұрын
Before you make your car smell like a gas tank, if you have a fuel pump control module located underneath the car attached on the side of the car or on top of the gas tank. disconnect and bypass to see if you can start the car before even thinking of replacing the fuel pump. If it fires up when you bypass, its the unit. Why am I saying this? Because $400 for a fuel pump and then $400 for the fuel pump control module adds up quickly. I recommend watching this video as well... kzbin.info/www/bejne/eqmZp3-Id914qNk
@PistonShack4 жыл бұрын
Thanks a lot for sharing info. I will definitely take your advice. Appreciated your time for watching my video. Stay safe!