Dodge Caravan Chrysler Town and Country Transmission filter change

Рет қаралды 19,779

10 ай бұрын

Dodge Caravan Chrysler Town and Country Transmission filter change
This is a simple change that can save you big money if it works.
Changing the filter out can restore the fluid flow in the transmission that may be the problem you are having. I will show you how easy it is to replace the transmission filter by watching the Vid.
Dodge caravan and the Chrysler town and country have the same engine for the most part.
Good luck.

Пікірлер: 76

@klwthe3rd Ай бұрын

This was a great tutorial. The only thing i would add is that when you first start the vehicle up after the fluid has been added, you should run the transmission selector in the car through all the gears slowly, stopping at each gear for acouple seconds. You need to give the new fluid time to fill all the appropriate chambers/selinoids before backing it off the ramps. That's why you had that hissing sounds that eventually went away.

@paulporter7490 6 ай бұрын

Purchased a 2012 T/C with 25K mi. in 2013. Dealer said tranny fluid change at 120K and I said YOU GOT TO BE KIDDING! It is a documented topic, but at 75K I had dealer replace filter and fluid. It was done at 36K as well and I plan on doing it every 50K in line with my goal of taking excellent care of our vehicles. This is our 3rd Chrysler van with having 306K on the previous Dodge GrandCaravan before a wreck took it out. The 3.6 is an excellent motor, but all things need excellent maintenance. Nice video.

@fireyourrocketts Ай бұрын

Every mechanic shop are no longer about the customer but about how they can rip you off some way, some how. This is why they lose customers by the minute, they still have enough poor souls out there who got no choice but to trust them, like women or elderly or the guy who does not know anything mechanical or do not want to get his hands dirty, so thanks to tutorials like this one there is hope. I am in the start part of process of rebuilding our 2015 Town and Country after my daughter hydro locked engine in a local storm last summer, Mopar lifetime warranty and progressive insurance full cover denied coverage after dealer quote the repair close to 12K, that engine was actually replaced already once when the car had 59000 miles due to a spun bearing, costed me $100.00 at the time, now this time around they just wont cover it, my daughter did not drove intentionally through water, she was caught in a flood so they all told me to total the car, I smiled and replied "sure" that is how I am taking it apart and doing it myself, not my first rodeo rebuilding an engine, my second one so why not? When you say " you can fix that" that is absolutely right!

@danbriese2559 7 ай бұрын

THANK YOU!!! I called a few shops, they said I needed a rebuild for $4400. Found your video that described my issues so decided to give it a shot. Van is now back to normal. Your video made me feel confident to do the repair (I've only ever myself done brakes and oil changes). YOU'RE A LIFESAVER!

@Jeff_Seely 2 ай бұрын

Thank Bud! I used to work at Daimler-Chrysler ITP4 plant that was the largest manufacturing facility of your 62TE transmission. This tranny is by far the largest transmission project Chrysler has ever produced. It is a good transmission but only if it is routinely serviced exactly the way you are doing it. There are two things that will kill the 62TE. Heat and contamination,so keep them cool and clean. Use Mopar full synth fluid (don't mess around with these other fluids. put Mopar in...). Reset the TCM each time. If you don't have a scan tool, take the battery leads off and touch them together for 5 minutes and that will do it. These things and just drive cool and don't race the hell out of them. If you live in Az or Tx keep that cooler nice and clean and you can get 400,000 miles out of it like I got in my minivan. It had 416,000 when I sold it and it still ran great!.

@klwthe3rd Ай бұрын

Is the Mopar Full Synth Fluid the same as the ATF+4?? If i go to the Chrysler parts counter, what do i ask the guy for? Mopar Full Synth transmission fluid??

@seatime674 Ай бұрын

Why do you have to Reset the TCM???

@Jeff_Seely Ай бұрын

I have found it to be good practice after performing any service to a transmission. Over time, the TCM's adaptive learning functions can become corrupted, which can lead to poor shifting, transmission slippage, and other issues. If the tranny feels like it may be slipping after this fluid service, you have eliminated the possibility of it being linked to any learned behaviors. It is my advice and I think it is good to ask 'why' but it is certainly not anything that has to be done.

@klwthe3rd Ай бұрын

@@Jeff_Seely I would have to agree with your statements. It's very good practice to do a TCM reset. And i like how you explained that if you don't have a electronic tool to reset the unit, you can do it the "old fashion" way of just touching the cables together. Your advice is very sound and much appreciated. Especially since you built these transmissions when they were new.

@Jeff_Seely Ай бұрын

@@klwthe3rd Thanks!!! And wanna help if I can.

@bobmccurdy8881 Ай бұрын

My mother as had one's from 84, 87, 91, 04,06 and 10 she had Grand Caravans and a couple of Town and county's and I got my first 06 Grand Caravan and we loved them all.

@Albee213 5 ай бұрын

You can also get a pan with a drain plug, makes future changes much easier.

@wyattberthold8334 4 ай бұрын

Beautiful video. 5 stars

@rajgandhi6163 2 ай бұрын

Great information ❤

@dancingspirit_ 2 күн бұрын

What a great video ty

@jeffreybanks0519 10 ай бұрын

This vehicle should have a magnet in its pan. Between the lack of a magnet and the silicon gasket, it looks like someome replaced this already. Magnet is important to collect the tiny metallic shavings over time..

@icanfixthat-ep4jk 9 ай бұрын

You are spot on -- we never found a magnet.

@rajgandhi6163 2 ай бұрын

Round magnet most important thing for transmission

@seatime674 Ай бұрын

Put 4 magnets in, 1 in each corner

@RamblerReb Ай бұрын

I don't know why there was no magnet, but 62TEs come from the factory with silicon gaskets. I just did mine today and it was silicon and had never been serviced.

@vinceleto 10 ай бұрын

I added 5 quarts to start and checked the fluid over a few days. I used the oil dipstick and basically you dont want to be higher than the letter a in safe from the dipstick. Measure with car on and warm. Ended up adding close to 6 quarts total

@icanfixthat-ep4jk 10 ай бұрын

Good to know ----thanks

@EM-828 8 ай бұрын

Thanks for sharing and helping others from getting scammed. Good quality video and good job sir! Just FYI, the factory uses rtv for the pan installation and the factory service manual states to use rtv when servicing. Doesn't really matter as a gasket works fine as you've shown. I've done the service twice now on our 2016 t&c with now near 150k, not a single issue with of the transmission. Service is key to keeping any car alive.

@icanfixthat-ep4jk 8 ай бұрын

Thanks for the feedback

@piratanet123 Ай бұрын

Thank you for the Video brother, I will try this on my 2013 Chrysler Town and Country. it has a leak that seems to be in the same area, the seals look pretty bad on,

@madcol1313 21 күн бұрын

Careful! You might want to research "oil filter housing". Those are at the top of the v on the engine. It is very common for those to leak and drip down the side of the tranny. It looks like a tranny leak but its coming from that part.

@serhiitiazhelnikov6486 6 ай бұрын

You don't have a magnet in your tray. This is an additional “filter” against metal particles and a wear indicator.

@paulgolmon1207 3 ай бұрын

My 2018 leaked with gasket after bolts were torqued 12 ft pounds. Drained and cleaned everything and used Mopar RTV. No leak now

@seatime674 Ай бұрын

You over torqued them that's why it leaked, 7ft lbs only

@oscaralarcon6695 8 ай бұрын

Hi that's a good video but you missing the magnet transmission pan

@rwill10282 10 ай бұрын

Hard to believe you didn't mess up your drive with that drain pan

@orlandoarmenguer9985 7 ай бұрын

nice

@herbilanidrik9184 6 ай бұрын

Thanks guys I’m going to change mine

@icanfixthat-ep4jk 6 ай бұрын

Great --- I hope it solves your problem. I did my Town and Country 2+ years ago and it is still working.

@shadetree359 4 ай бұрын

looks like your magnet is missing this is a sign someone else was there before you.

@orionthestars1459 21 күн бұрын

Great job! The only concern I have is there is no magnet in the bottom of that pan. Most Dodge/Chrysler transmissions that are in those Caravans have a circular magnet in the lower side of the pan by the little dimple. I'm wondering if the previous owner changed the filter and took that magnet out and didn't put it back. I'm not entirely sure its needed, just curious not seeing one in there.

@harryhagerty1177 20 күн бұрын

You are totally correct I noticed when doing the job there was no magnet --- I should have mention it.

@EricTireguy 5 ай бұрын

How is the transmission going on both yours and your friend's? Interested in knowing. I only use the recommended mopar atf +4 but was wondering about the other brands and how they do. Appreciate any info. Good video

@icanfixthat-ep4jk 5 ай бұрын

Mine is still working --- over 2 years.

@chair8540 8 ай бұрын

did you know there is just as much fluid in the torque converter that is left still in?

@papabits5721 6 ай бұрын

The factory uses silicone on the trans and the oil pan.

@sly2392 6 ай бұрын

i have a 2009 chrysler town and country with the 3.8 litre V-6 with the 62TE transmission. a couple of weeks ago it went into limp mode and the check engine light came on and it would not shift anymore into the higher gears. i think its stuck in 2 or 3rd gear. i do not believe it has ever had the fluid changed or the filter. the engine has over 200.000 miles on it. when i disconnect the negative terminal that will take it out of limp mode but for just a few miles then the engine lite comes back on and it is stuck in the lower gears again. i am going to change the trans fluid and filter and hope that works. what do you think ? will it help ? when its out of limp mode it shifts just fine.

@robpaananen5449 4 ай бұрын

I have the same issue DID IT WORK?

@seatime674 Ай бұрын

How did it work???

@JAKCQWIK 25 күн бұрын

@Stew-rl9qk 5 ай бұрын

60k if you tow or use "commercially", 120k if you just drive light duty.

@jesseamburgey7919 7 ай бұрын

Where is the magnet that goes into the pan.

@charlessanders1342 5 ай бұрын

I had took a car to a trans shop said oh u need a rebuild so took it to another shop they wanted to do more diagnosis they wasn't condemning trans so I decided to put a new battery in car as the car had original bad battery causing trans issues after replacing battery no more issues drove Impala another 29k.Alot of places wanna do a flush when you only want a filter and pan fluid change to get more $$ out of you.

@swisschocolatecake4547 Ай бұрын

Mechanics are full of 💩

@brianv5031 8 ай бұрын

Does the cap on the transmission fill screw in or push in?

@sly2392 6 ай бұрын

screw in.

@704azul704 3 ай бұрын

Did your check engine light come on and if so did you get any codes like p1745?

@seatime674 Ай бұрын

Why would he get an engine code?

@user-rb6lz1se3x 9 ай бұрын

Did'nt change the seal for the new filter, and did'nt see a magnet.....

@jimkirk989 3 ай бұрын

Will This Solve My P0731 code on my 2015 Chrysler Town & Country Touring 3.6 v6 flex fuel with 193,800 miles?

@CHICAGOFIREWORKS Ай бұрын

Did it fix your car? I have same code on 2019 dodge grand caravan

@topfloorstudio2684 2 ай бұрын

Did you just reinstall that new gasket dry? Is that how this is supposed to be done? Thanks

@vortextricking6849 2 ай бұрын

Good Call --- Yes a new gasket --- alway use a new gasket if you can.

@topfloorstudio2684 2 ай бұрын

@vortextricking6849 I wanted to know if you put anything on it before install? Like some new ATF or RTV or (even AXLE GREASE IF YOU CAN BELIEVE ONE GUY SAID)... lol. It looked like you installed it "dry". Thanks for what you do!