Thank you, from another technician. You waste no time and get right to the point in this video. If only everyone's videos were done like this.
@FichaelMranklin11 ай бұрын
Video is 12 years old a one of the best DIY’s I’ve ever seen
@Jeremya746 ай бұрын
How is this the best when it does tell you the model or the year?..I seen 30 of there that don't tell you the year..WHY NOT??
@jackMcRyder5 ай бұрын
Exactly. Love it how this older video is so good. Even has a drain/pan diagram
@daniel.gilliss60305 ай бұрын
Outstanding piece of instruction. VW wants $500 to do this to my wife's car. Thanks for the video
@scubaluigi110 жыл бұрын
I did the drain and replace the exact amount through the filter using the funnel with the hose on my 2006 Jetta TDI and it work perfect save me $170.00 from the dealer. Thank you guys very well explained you ROCK!
@mencken84 жыл бұрын
When we owned the Passat (before it got Dieselgated), I did this once, at 40K, rather than pay the absurd amount to have it done. This method works very well, and I did it in the garage, with ramps, did not consider leveling at all- no need to when it’s just drain / measure / refill. Drove it for another 35K before selling it back to VW. The only bitchy part was getting the battery tray out. Without that step, it would be a piece of cake.
@matthewethier19772 жыл бұрын
Did you refill from the top after you measured?
@mencken82 жыл бұрын
@@matthewethier1977 Yep, just filled it through the hole in the center of the filter housing. There’s a funnel called a “Flo-Tool” that fits it perfectly. And I ran the kitchen sink full of hot water and preheated the transmission oil bottles in it, made the fill very fast.
@swingmanic8 жыл бұрын
Great video..Although I own a Skoda Yeti 2.0 litre tdi with 6 speed DSG, I presume the principle is the same..I'll probably fill from the top with around 4.6 litres, (A little slow I believe) run the engine until gearbox is the required temperature, run through the gears and then remove the drain plug and capture the excess fluid from above the plastic snorkel, replace the drain plug and voila, all is done! (I hope:)
@nathanbradley6119 Жыл бұрын
You clearly know what you’re doing 👏👏👏. It’s not as simple as just draining, filling and changing filters then.
@dfu16852 ай бұрын
Thank you so much for those tips! That appears to make the job much more doable. Thanks again.
@fastyz4008 жыл бұрын
Great video. I didn't have vcds so, I used the water temperature as a gauge of my transmission fluid temp. i waited till the water temps raised above 100 deg. F. Then removed the hose for the final leveling drain. 35C equates to 95 deg F.
@senseeh4908 жыл бұрын
+fastyz400 Americans and their F word...
@tonyd32666 жыл бұрын
or just wait until august in Florida and it's room temp at 3pm...
@toddschmieder6086 жыл бұрын
@ Two types of countries. Those that use the metric system and those that have put a man on the moon. And have consecutive world war wins.
@theodoremarakas98994 жыл бұрын
It is not accurate at all. The coolant temp and the trans temp which is measured at 90 can vary depending on how long the car run for and the trans fluid takes much longer to warm up relative to the water temp. Maybe an infra red thermometer will give you a better base line but this method is certainly not recommended for accuracy
@noventay4 Жыл бұрын
@@toddschmieder608 you mean Russia? Because they're were the first ones in space and the ones that defeated Hitler
@jerryreding73698 жыл бұрын
So, I don't understand...if the capacity is 4.5 litres, why can't you just put that amount in, run through the gears, and call it good? Do I HAVE to drain some excess once it reaches operating temp?
@tkrogs35359 жыл бұрын
If you can change this cars oil you can change the DSG fluid as well. It is easy! You can do this faster by putting the fluid by a heater or in the sun. Drains into the top fill hole faster (if you go that route). I measured mine including the filter part and put back 4.6L. That was at 33,000 miles now at 38,000. No issues. Dealer quoted me $500 I laughed. Shop were I got my tune quoted me $300. Did it for $140.
@Typhoon06277 жыл бұрын
hahaha just had the dealer quote me $500 too... and I said "oh wow, that's it? How much extra would it be to have you guys replace the muffler bearings? I think they're starting to go out" which drew a death stare from the service advisor. Lousy pricks wouldn't even reset the service interval because I refused their $850 75k service. I love my A3 TDI, but I'm gladly giving it back and taking my settlement money to buy something where the dealer doesn't try to rape me for $500+ every 10k miles, when all it really needs is an oil change.
@AbranMarquezGarcia7 жыл бұрын
What is the diameter of the tube I should squeeze into the filter plug?
@tonyd32666 жыл бұрын
changing the oil myself yesterday I found a dealer didnt tighten the 13mm oil canister drain correctly and it was dripping onto a wiring harness. Thank the Lord I decided to change at 3K myself this time instead of waiting 10K. Like someone in the Audi world said - how to get 300K out of your audi-- never return to the dealer.
@tonyd32666 жыл бұрын
I also tried to buy a DRL bulb for my car at the audi dealer 3 years ago - their expert parts guy brought out one incorrect bulb after another until I said -- can I see the bulb rack? every bulb had been put into the wrong tray for the drawer. And nobody there knew the difference. note to self: they are never touching my car again...
@salyzproperties5 жыл бұрын
@@tonyd3266 agree. Last time I visited audi delrship at 45K, now at 216K and going.. Love my A3
@caesarcruz64278 жыл бұрын
I was pretty confident... until the filling up part :/
@theodoremarakas98994 жыл бұрын
One other way this can be done is take two identical buckets and weigh them. Weigh the fluid taken out and the filter together. Now you know the exact amount that you need to put back in. On the next bucket weigh the filter and put the matching weight of fluid. Use a small manual pump from ECS tuning to put the fluid back it. Done !!!! No need for VCDS and accurate to the last drop.
@Gotta_Ketchup_All11 жыл бұрын
How would filling through the filter be done? I'm assuming that it's pretty straight forward and just pour fluid in. But I noticed how you had to suck fluid out, so is there some sort of separation in there?
@MM20094 жыл бұрын
Factory overflows these boxes by 160ml. This instruction for 6speed, 7speed has two drain caps and a filter on the engine side.. Drain oil first, then start with the oil filter. Remove mechatronix metal cap and drain remaining 1.3-1.5l of oil. This is the correct way to remove almost all 6l of oil. You've done 100's of these right???
@Righteouness4 жыл бұрын
Yeah.. there seems to be an inconsistent measure throughout this video which can be very misleading.
@jasonsmith767110 жыл бұрын
You guys make it so complicated and make me happy to pay someone else to do the job
@أحمدالمحروقي-ج8ظ5 жыл бұрын
Jason Smith what your expecting
@noventay4 Жыл бұрын
Nothing wrong with paying someone else to do this as long as they know what they're doing.
@VENUEATHENS6 жыл бұрын
Hi there! Thank you for this informative video!!! I have a 2004 Audi A4 1.8t with CVT Multi-tronic transmission.. It's a similar procedure, regarding filling fluid with slight differences in plugs, type of ATF fluid filter setup etc.. However the principles are the same proper fill temps between 35 - 45c, gravity fed pump, and drip fluid level check.. although there are two plugs on my particular transmission, one to drain and the other to fill.. I filled the same amount that came out 6quarts, while the care in the air, I then Attempted to cycle through the gears 2 second intervals on each PRNDS.. Unfortunately I got an abs light go on along with traction control light signifying brakes have failed.. There was resistance to the brake pedal as though it were pushing back against my foot, not sure if the trans is some how in sync with the brakes system (I have not touched the brake system at all), not sure whether I've done something wrong during the fill process to cause the brakes to react this way.. I have not put the car back on the ground to test whether this was a result of the wheels dangling off the ground freely.. I used a bug spray type pump with an adapter screwing onto the fill port to pump the Atf fluid in trans.. The pump builds pressure, 10 to 15 psi to pump fluid in trans.. not sure if pumping fluid in with this type pressure may have caused an issue V.S the gravity fed syle funnel.. Any feedback or suggestions will be great help and very much appreciated!!! Best regards Tony
@andrzejdziuba7 жыл бұрын
thanks guys will do my s-tronic oil change tomorrow, save me a lot $$$
@KerstenElizabeth9 жыл бұрын
So if I measure the fluid drained, I don't have to warm up the transmission at the end? I just fill it and remove the vas6262 then plug up the transmissions?
@mandataruu86853 жыл бұрын
start engine, put in neutral or idle and add oil in filter directly..its new oil get job done in 5 minutes
@tonyd32666 жыл бұрын
I think the overfill method is healthier for trans, as it washes away and flushes away more residue. its like doing an oil change and pouring a clean quart in with the drain plug out -- kinda flushes out a little more gunk and leaves clean residual oil instead of dirty. Never seen a car-change video doing the extra quart method on engine oil - but it makes sense with the price of these motors, smaller and closer tolerance bearings, and having 4 and 5 valves with over 50 hp per cylinder cylinder these days. think about the advanced additives VW has in oil -- spec 507 ! its not a complete waste of oils I hope.
@GaryMarkowski3 жыл бұрын
Based on your comment, I have the impression the fluid levels are not correct in many cars then. I prefer to take the time to fill the transmission, start the car, put the transmission through all the gears, put it into park, what for the temp to get to 100 F, remove the drain plug keeping the car running, and closing the plug once you have reached about 105 F. This likely will result in a more accurate amount of fluid.
@paulwary2 жыл бұрын
So you're definitely meant to keep the car running after the correct temp is reached, when you remove drain plug again? It doesn't splash the oil around and release too much?
@GaryMarkowski2 жыл бұрын
@@paulwary When the engine is running, the pump in the transmission is pushing the fluid up, and there is less fluid in the bottom of the pan. Yes, it is important that the engine is running when you remove the plug and when you reinsert the plug. Once the plug is back in place you can then turn off the engine. If you remove the plug when the engine is off, then too much fluid will come out and you will need to refill and retest.
@paulwary2 жыл бұрын
@@GaryMarkowski Thanks. So it's the exact opposite of what I imagined!
@tcpatfehr9 жыл бұрын
I pried off the cap on the trans vent and put a A/C vacuum pump to the vent and poured the fluid the oil filter cavity, goes in almost as fast as you can pour it through a trans funnel
@mitchelllarson86807 ай бұрын
Can you leave the 8mm drain plug in while gravity does its job refilling the transmission reducing the amount of waste?
@weskarp7643 Жыл бұрын
This seems a lot more complicated than I was thinking. Especially the special tool used to drain the excess oil. Having to have the oil at the right temps at certain times. Also a computer needed if u want it done right. ALOT could go wrong. I would recommend to the average mechanic for a professional to do this procedure. It'll be worth the extra $300, knowing that the 2nd most important part of your car was done right.
@kevinosgood2526 Жыл бұрын
I hope you can help I am working on a 2013 Jetta Hybrid. I'm trying to find how to top off fluid or change the filter in the transmission being that it has no reverse. Cannot find any videos on hybrid Transmissions mine is a code PMY
@dankcorey242412 жыл бұрын
Can you fill the transmission at the filter rather than though the drain plug?
@n9wox4 жыл бұрын
Yes, but very, very slow to put fluid back in that way. You have to measure the drained fluid and only add that much back in.
@ninjadesonepiece71783 жыл бұрын
I get some one to do it thanks for the video it will take 200e from me and the problem solved 😉👌
@BMACVAGS10 жыл бұрын
I like watching your videos
@nagyba10 жыл бұрын
God...so much plastic in an engine bay...:(
@VWGTI20139 жыл бұрын
Wish u would show how to remove the air intake
@roachwrc16206 жыл бұрын
Great video. Thanks! I'm going to change the oil now.
@hddm313 жыл бұрын
thanks so much. glad someone made this. helped me abunch
@hayzeproductions70934 жыл бұрын
So far this video was a great how too video and exactly the same car as mine. But my concern is if im able to just fill the transmission back up from inside the filter area before installing the new filter. Hoping the video publisher or soneone can give me some insight if this is possible or not because i really dont have an air compressor to do what he did to fill it back up.
@yiranjack5 жыл бұрын
I am wondering, if i just put back the same amount that I drained. Can I put the oil back from the filter whole?
@Naeromusic4 жыл бұрын
I am sure you figured it out but anyone else wondering, always put the equivalent to what you got out
@pipgt11 жыл бұрын
A really well made tutorial well explained thanks.
@bbbmw12 жыл бұрын
there is a different model of dsg, in europe, for different engines with dry clutches. its a 7 speed i believe. i dont remember if its for higher or lower power engines.
@Dadlifefitness_846 ай бұрын
Has anyone tried putting the 4.5L in the oil filer housing? after draining all the old oil out first, obviously.
@chrisantoskow136012 жыл бұрын
I was towing my ATV loaded down from Atlanta to NC about 800-1000 LBS. up the mountains... I shifted manually as needed... All was fine until I got back and drove the car.... Then 2nd & 3rd gear will chatter when you get it the fuel hard.. If I drove soft all is fine.. If I shift manually, and you give it the fuel hard it is all works fine... Someone told me that the fluid must have gotten hot and needs changing... It has been 78,000 miles since the last change... What do you think...?
@anuruddhadissanayake48812 жыл бұрын
Wow amazing video! Very informative
@gigeldehohentoler96298 жыл бұрын
Where does that oil come from? the one that pours when you remove the plug, before the plastic pipe? If at the previous oil change you do the oil level it is supposed to be below the tip of the plastic pipe and is not supposed to pour anything.
@fraymond38 жыл бұрын
It's residual oil that's in the stove pipe.
@henryng4392 жыл бұрын
Is it okay to leave an slight excess of new transmission fluid inside the DSG? Or, is it a must to drain the excess using the snorkel method?
@halohms7 жыл бұрын
2005 Beetle TDI with DSG transmission - took out 4.4L of old oil, Filled using the bottom method using 5 Litres and measuring oil temp with the software but when I removed the hose, there was no 0.5L coming out of the overfill tube. Car was made level by leveling the centre of the front to back wheels and using ramps and lowering the tire pressure. Why didn't I get any fluid come out? Is there a problem or should I just drain 0.5L out manually. Does it hurt to have 0.5L more than the 4.5L?
@romanprophotographer11 жыл бұрын
Hi. My VW touareg v8 leaked transmission fluid from condenser and doesn't have dip stick to check fluid level. How to check fluid level or add fluid since mine leaked out over time? Thanks...
@davidbarthel99762 жыл бұрын
Can you add fluid through the filter area?
@drewnashty Жыл бұрын
Why not leave VAG6262 on but drain the hose of the excess fluid into a container, and wait for it to stop dripping? Then simply unscrew the tool when you're only going to spill a few drops instead of it pouring all over. It amazes me how much people waste towels on to clean up things not necessarily made in the first place.
@bennyngphotography110 жыл бұрын
Hello, where do you refill the fluid? from the photo, it looks like you refill it from the filter? am I right? Thanks!
@bennyngphotography110 жыл бұрын
Sorry, I think I got it. You refill the oil from the drain hole itself and push it with air compressor machine. Am I right?
@m-hadiassi274210 жыл бұрын
Benny Ng I made it today and its not refilled from the filter, but from the drain hole...
@chrisyork37144 жыл бұрын
Has anyone tried to fill up the trans through the filter housing before you install the filter ?
@Softballcrazy9 жыл бұрын
Is thus the process for a 2012 Jetta Sportwagen TDI?
@domingogonzalez40879 жыл бұрын
hello.please could you tell me what king of oil do you use for this kind of transmission. i have a Passat V6 4motion 2006 with a DSG 6 speed gearbox and the dealer tell me that i have to use VW G 052 145 A2. it is correct? thx
@bobl788 жыл бұрын
VW is great... they invented the most stupid way to fill a Transmission... we´re happy it does not require to put the car upside down.... how easy would a simple Overflow hole / screw be... but of course then you can not sell those Handy Dandy Special fill adapters
@senseeh4908 жыл бұрын
+bobl78 Top fill with one of those funnels with the screw valve and hose. That's it bro...
@danielfl.93475 жыл бұрын
You dont refill the DSG transmission as you change the oil at 60.000km
@danjackson63885 жыл бұрын
A lot of companies are doing similar things. Cars are getting harder to work on, more expensive, and poorly made, more and more every year. The aim is to make cars a throw away item after maybe ten years.
@waifuracer65165 жыл бұрын
You do realise that a lot of new transmissions are filled up this way? Even older torque converter ones...
@LoveLikeaHurricane11 жыл бұрын
I just read your article, and I have questions regarding the measure refill method. You said to install the plastic snorkel into the dsg oil pan, and then put the drain plug over it. Then you pour new fluid into the filter section. Once done reinstall the filter and everything else. Do you leave the plastic snorkel in? Also you didn't mention if you should shift into each gear for 3 sec with this method.
@dunti2112 жыл бұрын
wow at low volume you sound like Microsoft Sam :-)
@AMGTOM10 жыл бұрын
That's not me !!!!!!!! LOOOOOOOOOOL Great video by the way.
@vipstash9 жыл бұрын
Would this be the same procedure for a 2013 passat tdi?
@maherdaibes93443 жыл бұрын
Hi is the same for jetta 2010???
@myturbodieseld0tcom12 жыл бұрын
Read the linked article in the description for the long answer. Yes.
@tonyd32666 жыл бұрын
is it just 40K miles or is there a Year-Age limit as well? Got a super low mile buyback DSG-TDI that sat for 2 years...
@makhan10110 жыл бұрын
hi is this same procedure to change a vw golf dsg oil or just audi?
@twinturbotaj7 жыл бұрын
I bought another drain plug and made my own fill tool today.. then watched this and realized you can just fill the new fluid (maybe slowly) into where the filter goes on top while it is removed, then install the new filter after you put 4.5L of new fluid in. ... I hate this 'german engineering'
@markkay81174 жыл бұрын
Exactly, another thing why whey didn't add another re-fill plug on top of the gearbox, just like normal manual gearbox has. This "engineering" is getting worse and worse.....
@mencken84 жыл бұрын
Taj Jacobs Yes , I did the top fill drain / measure / remove method. So much easier!
@nuskox3 жыл бұрын
@@mencken8 And then just start the car and thats it? You can drive?
@mencken83 жыл бұрын
@@nuskox Look up “DIY VW DSG fluid drain and change service.” That should clear things up. He covers both methods in the article. Yes, not only can I drive, but I’ve used this method and it works.
@nuskox3 жыл бұрын
@@mencken8 thank you so much brother.
@Jeremya746 ай бұрын
GOD FORBID YOU PUT THE YEAR
@buffplums4 жыл бұрын
This is brilliant thank you
@redouaneboumegouas13118 жыл бұрын
Pleas is it a same with S-Tronic Transmission in AUDI A1?
@harryeaton71937 жыл бұрын
Good tutorial but skips the removal of the air filter box which is the most tricky part of all.
@davekana83888 жыл бұрын
Is this auto any better than the ones behind the AHL?
@korykeller68568 жыл бұрын
Thanks for the video. What should I do with my 1989 Dodge Caravan trans? Every day there is about 0.5-1 L of transmission fluid underneath the car which I am getting tired of having to top off. This has gotten expensive, so I've been gathering as much from the ground as I can and putting it back into the transmission. Also, gears two and three do NOT work (loud noises? can try spelling how they sound if this helps) and the car smokes when I'm in fifth, but with less noise. Please help.
@videovideo51245 жыл бұрын
Are you serious? First you buy a complete piece of shit vehicle, then you scrape contaminated fluid from the ground and put it back in? You're a moron and shouldn't be allowed on the road at all but if you must- get yourself a bicycle.
@georgemorgan948 жыл бұрын
Is the filter in the same spot for all DSG transmissions? I have a Mk 6 2.5 litre
@lloyd_36566 жыл бұрын
George Morgan 2.5 does not have DSG. It has 6spd auto.
@showcasinskillzrecordsskyy57679 жыл бұрын
where can i buy the kit
@BangOConner9 жыл бұрын
Is it a Golf your changing on? I have inspekted my Passat 2010 and i cant find any drainedge och refilling and when i call VW they just say that it´s nothing you can do your self, and the whant like 250-300 dollers for a fluid change.. and why ive been checking is because ive got this popcorn like sound in my gearbox. but only in P and N. Not when i put it in R, D och S. Any Ideá what it could be!? Sorry for my bad spelling..
@jaureguixp9 жыл бұрын
That's your Flywheel. Change it as soonest you can.
@Samolsen769 жыл бұрын
Bengt Bang Actually, dealer will tell you the same thing regardless what car you drive. i got myself a vw...i know nothing about germany cars but engine principles works the same all car brand. One of my coil broke, i simply just bought one coil. i let the engine run while i disconnect one coil plug at a time. i found which coil was faulty. replaced it myself 18.00 dollars. dealer wanted 260. just 10 mins of your time. wanted to charge me 300 for labor only to change cv axles. i did it myself easy. just disconnect ball joint, lower. there are so many things that dealer wont tell you, and charging you recklessly!!! This video is amazing. thanks!
@senseeh4908 жыл бұрын
+Sam Olsen The only thing I HAVE to buy from a dealer is wiper blades. $55...I bet they'd charge $269 to install them.
@Trond2374 жыл бұрын
not needed to remove plastic, just remove bolts and push it to the left
@aaron___6014 Жыл бұрын
Drain it, refill with the same measured volume through the filter housing hole. New filter. Reassemble and you're done til you hit another 40k miles.
@ningnyco1782 Жыл бұрын
No, you dont add same amount fluid that came out, you must follow overflow pipe. Read 02e repair manual page 140
@danjennings506810 жыл бұрын
Is that a 300ZX that you are starting at the beginning of the video?
@myturbodieseld0tcom10 жыл бұрын
OMG...how could you tell? TT with SpecialtyZ H exhaust.
@danjennings50689 жыл бұрын
Haha, that ding is very distinct, and so is the starter sound. Also owning/driving/working on Z32s for 10 years kind of gets one familiar.
@jackpontiac5212 жыл бұрын
How much is the DSG Fluid and Filter to buy? Who makes the best fluid?
@tonyd32666 жыл бұрын
get dealer DSG. viscosity tests show HUGE differences in aftermarket DCG brands and some lead to premature wear. DSG is really like a wet motorcyle clutch manual shift with a robot shifting the gears. very efficient cuts on gears and handles mega torque well.
@igorjcgaspar2 жыл бұрын
Gambiarra de primeira
@lmogden112 жыл бұрын
great video
@jackpontiac5212 жыл бұрын
You should be able to Guesstimate 35-45 Celsius. Human Body temp is around 36c or 98.6f I'll get a Registered Nurse to help me do a DSG Fluid Change LOL!
@paguliukas6 жыл бұрын
Nice job and good video Will have to give to the pros to do it :D lol
@MrLooperg Жыл бұрын
You forgot to drain the Tiptronics.
@rebb516411 жыл бұрын
I get the OEM VW DSG fluid & filter kit to do this service myself from idparts.com. I do it myself (Easy!) and save big over what the dealership quoted. $144.95 for the idparts.com kit vs. $400.00 at VW. My labor is cheaper. LOL!
@mencken811 жыл бұрын
How in the world can VW claim to be so environmentally responsible when their DSG refill method wastes so much fluid?
@chrisantoskow136012 жыл бұрын
Fanatic Video ! Do you have to have the vas software ? If so where and how much ?
@n9wox4 жыл бұрын
You can use OBDeleven to get DSG fluid temperature, which is less expensive than VagCom.
@Brunoxtr12 жыл бұрын
You should leave the filter cap open while draining the oil.
@67mustang351w10 жыл бұрын
where i can buy the transmission fluid for 03 jetta, automatic transmission, and what type of transmission fluid use
@hdudic10 жыл бұрын
buy at the dealer
@progmanmike7 жыл бұрын
67stang Amazon, ecs, shopdap, autohaus, idparts, etc.
@Joelkswagen10 жыл бұрын
If you are looking to change your DSG fluid with the "Measure Fill" method see my channel for a full tutorial!
@clarkinthedark113 жыл бұрын
What a terrific vid, but what a pain! How often does this have to be done? I might stick with a stick shift. :)
@joeintern3 жыл бұрын
In my Jetta Sportwagen TDI it is at 40K. You can check here: maintenance.vw.com/
@davidtoth40026 жыл бұрын
Is that original vw oil? Does somebody knows what brand is the original (what vw use)?
@n9wox4 жыл бұрын
Pentosin FFL-2
@davidtoth40024 жыл бұрын
@@n9wox thanks very much
@myturbodieseld0tcom12 жыл бұрын
@lizlupeliz I accept donations through the companion article linked below :) :) My site is free but I put a lot of work into the content.
@n9wox4 жыл бұрын
@@dropthegun21 Very, very slow process.
@krawcuk-rawcu33635 жыл бұрын
Dsg 6 czy 7 biegów?
@JohnDoe-gm5qr7 жыл бұрын
I wonder how many people just yank upward on the engine cover and have it come loose suddenly and they fall backwards hehehe.
@ScottBurel11 жыл бұрын
3:20 for the win!!!
@KimTyroneAgapito12 жыл бұрын
I want this video on my t800 phone.
@aquabono7 жыл бұрын
00:20 do you recommend leaving the cover off to get a tiny bit more cooling effect?
@AbduulG5 жыл бұрын
Lol. The engine doesnt get THAT hot.
@pospc24 жыл бұрын
If it was a TSI i would and have left mine off to help keep the coils cooler. However this doesn't apply on a TDI.
@grnfsh10 жыл бұрын
Question: At 4:15 you say to add 4.5Liters but at 6:20 you say 5.5 Liters. Which is correct?
@drdwgmd1410 жыл бұрын
I had same q, i DONT get it...its like the extra 1L dripped out the bottom...
@jelneutron310 жыл бұрын
Dr Dwg yes
@2011kimura11 жыл бұрын
where do you purchase the VAS software ?
@n9wox4 жыл бұрын
Use OBDeleven. Bought mine from ECS Tuning.
@nofaithjusthope87147 жыл бұрын
You explained that VW tech whom has done 100 DSG fluid changes used 4.5L of fluid (with diagram and whatnot) and then you go on and say to add 5.5L? So which is it 4.5 or 5.5L? Do I buy 5L or 6L? Also, forcing fluid into transmission using compressed air? there must be a pressure relief valve on the transmission I assume or else you might blow seals couldn't you compromise the pressure relief valve if you use too much air pressure? You also talked about measuring the drained fluid and replacing with same amount, what about the fluid in the old filter how do you measure that not to mention the spilled fluid?
@RobinGWakker5 жыл бұрын
I agree with what you described. The video has it wrong, its confusing to say 4.5 and then 5.5. The VW Workshop manual on the DSG 02e mentions to fill 5 liters and then drain after the gear box has reached 35 to 45 celcius, of course having cycled each gear. Im actually to do this job myself first time this week, so hopefully it works well.
@stuarth435 жыл бұрын
they are all hex head screws not bolts, pains me, however good vid
@amgtim46364 жыл бұрын
First drain oil second oil filter.
@Dubrovnik8211 жыл бұрын
And u have to fill 5.5l oil if u read elsa,reason is not to buy extra oil. In gearbox u have mechatronic and higher oil level washes gearbox inside and when you draining rest of oil that oil cleaned that surfaces.Big nut u have to tiht to 4.5kg and every time change seal
@edberger46799 жыл бұрын
I have a new 2015 tiguan, so when should the first oil change be done ???
@19SiD829 жыл бұрын
+Ed Berger read the owners manual located in the glovebox
@Themattoutside12 жыл бұрын
every 40K miles.... it almost puts me off the idea of having DSG completely.
@n9wox4 жыл бұрын
Dealer DSG service can be expensive, but if you DIY, it's not that bad. DSG transmission doesn't have torque converter like other auto transmissions and is more efficient.