Raptor Supercharged V6 Hilux - N70 1GR-FE

[@cliveblair2435]

Did this to a 100 Series but went a lot further with custom forged decompressed pistons', blue printed engine, tuned ceramic coated extractors etc. Unbelievable fun to drive but the 25 litres per hundred of 98 was not so enjoyable. Was blistering fast for a Land Cruiser . Amazing on and off road. It could be economical if you could control you right foot. Never managed that for any length of time. You no doubt know all of these quirks by now. Enjoy.

[@HaydnKamp]

That would have been mental! Yeah it’s not easy to drive economically that’s for sure, the right foot has other ideas 😅

[@bikedirt4wd154]

To tell you the truth, Tim from Raptor is my Dad. It is cool to see that a KZbinr has one of my Dad's superchargers.

[@HaydnKamp]

It’s a great kit, been a dream of mine to do this for waaay to long and his kit made it all possible 🤘🏻

[@bikedirt4wd154]

Nice 👌👍, hope have lots of fun with it.

[@hookednhunted]

Shame he didn’t mention raptor or Tim, he’s a legend

[@TasmanianDevil3]

​@@hookednhuntedIt's literally right there in the title.

[@miniwhatt]

The exhaust note in the final limmie bash clip- hell yes. So sick. Standard tradie’s lux.. next minute babababa !!

[@HaydnKamp]

Gets me excited every time I drive it 😍

[@procheckautomotivemechanic4551]

Should have told me you were doing a vlog on it. We could have done a before run on the dyno and some videos on the dyno after.

[@HaydnKamp]

Was really torn wether to actually go ahead and make the video to be honest. New to this KZbin thing 😅 Would have been great to get some footage of it on the dyno and like you said compare what it had as a baseline before the kit.

[@racingescort1970]

Put it back on the dyno and video it, be good to see it

[@saxon7034]

That’s awesome man! Very decent increase in power and torque. Nice all round hilux.

[@HaydnKamp]

Thanks man, super drivable and alot of fun

[@antoniosaab5319]

My dad had an FJ Cruiser and I remember it having the 1GR as well but it came supercharged from the factory, and if I’m not mistaken the TRD N70s came with the same engine too. From the factory the cruiser would absolutely rip though, could only imagine what it’d be like with an aftermarket one.

[@HaydnKamp]

It’s a lot of fun 🤘🏻

[@Tanner731]

trd superchargers are a dealer add on not factory.

[@stuartdevenish5761]

Awesome post mate, there's surprisingly little content available for those wanting to S/C Hilux's so big props for making the effort to share. I've been on that journey myself over the last 2 years, I have a 2016 N80 1GR-FE (one of the very last) with a Magnusson S/C kit (the TRD one) and it was the best addition I ever made (though it was an expensive exercise). Similar exhaust and snorkel and the same airbox. That PSICO airbox made a massive improvement to performance, should have got one years ago. Going back for another ECU remap in the next month or so.. it never ends.. :-)

[@HaydnKamp]

Been scratching my head for years due to the lack of content out there so thought I’d have a crack. I’d absolutely love to have that setup in a N80, would be unreal!! Wished they kept making them with the 1GR!

[@m-funkshun]

Beautiful work and great vid! Those of us with Hilux fantasies back here in the States can only look on and drool...

[@HaydnKamp]

Thanks man, I’ve only been over there once and the stuff you guys can get on the road puts us to shame 😅

[@m-funkshun]

@@HaydnKamp Our Rams and Chevys, HDs and so forth have some ridiculous numbers in terms of torque and HP... and yes, these trucks are designed for work and get used for that purpose, plus some fun on the weekends. And we're seeing an increasing trend of 2 and 3-liter turbos V6 engines generating some interesting numbers. But nearly gone are the manual transmissions and in terms of hell-and-back reliability, war fighting capability, and just general mojo... nothing can touch a Hilux and your Hilux sir... is a BEAST! Much respect from the U.S.A.!

[@Hz1ww]

Nice setup dude with bigger fuel injector also upgrade the fuel pump its smart move don’t forget to bigger the throttle body it’s mandatory with supercharge use Toyota v8 5.7 its can fitted with minimum work on 1gr good luck 🤞

[@TasmanianDevil3]

They don't need a bigger throttle body.

[@jezzalinkco9214]

I've had my 05 1gr hilux for 3 years now and this is the dream 😍, its got 220k on the clock tho which is holding me back. Awesome video mate!

[@HaydnKamp]

220k’s is barely run in 😅 go for it man. My Ute had clicked over 350,000 when I installed this kit

[@croweater6814]

I can't be the only person that thinks this model Hilux dumped to the floor with a tray delete and a super or turbo charged engine would make an excellent drift and/or rally car.

[@HaydnKamp]

Had a 2wd single cab V6 with an ally tray and auto for work and the thing hooned! Was super light and silly quick for a work Ute. Would be a handful with some boost and a locker 🤤

[@ryansmith9283]

so sick must be stoked

[@HaydnKamp]

Proper stoked! A long time coming

[@typicalmx6215]

Have you noticed much fuel consumption increase since adding the supercharger, I own a v6 4.0 and they chew so can only imagine how it is with a supercharger.

[@HaydnKamp]

Haven’t had a chance to drive normally yet if I’ll be honest. I might do another video in the future with that included

[@Heef101]

Would also like to see this

[@antoniogutierrez4496]

Its actually better on fuel if you drive it normal / but then its power at your fingertips so ….

[@kenoath6846]

That came up sick 👌🏻 I got a stock 4.0 single cab n love it 🇦🇺🇦🇺🇦🇺

[@HaydnKamp]

Cheers man, used to have a singe cab work Ute. Super light with 1GR power, sick combo 🤘🏻

[@on1ytheb3st]

Very weird; the Tacomas and 4runners in the states with the 1GR-FE output much higher at the crank. Tacomas were about 240bhp while the 4runners are 270bhp. You might of mixed up kW and hp, cheers!

[@HaydnKamp]

Yeah you’re right man. I sure did mix it up

[@Perspari]

Sick vid, love it

[@HaydnKamp]

That’s mate!

[@Hunter-yy4es]

Nice power increase, why do Queenslanders use Hp an not Kw at the wheels ? l noticed that when l moved up here had to get on google to convert the numbers haha

[@HaydnKamp]

Honestly no idea, maybe we think it sounds cooler 😂

[@hillcountrytruck]

No doubt! it's so much fun ...

[@PJDJ1986]

Sick build, looks awesome 😎👍

[@HaydnKamp]

Cheers man, loving the turn out

[@anels9]

Awesome video and hilux Hayden

[@luisugueto5025]

where can I buy that supercharger kit?

[@HaydnKamp]

Raptor Superchargers Australia

[@STGaming297]

Love the truck

[@HaydnKamp]

Thanks! It's been a great ute that keeps getting better

[@Alidilman]

You said the autos arnt the strongest Is there anything that can be done to them to change that ??? As I'm looking at a 2012 Prado same engine ECT.

[@KevinHernandez-vh9dl]

Would the extra horsepower affect the head gasket since its an open deck block.

[@HaydnKamp]

I’d assume if you got it hot enough it’ll cause issues. The kit I’m running is pretty mild at 7.5psi ish. There’s an updated kit that now allows 18psi of boost. Would be interesting to see how they hold up against that.

[@Alidilman]

Did U go petrol lux for reliability reasons ????? Over the desiel?

[@HaydnKamp]

Reliably and the cost to purchase and maintain. Plus the petrols are a lot more exciting to drive

[@Alidilman]

@@HaydnKamp no doubt 👍

[@vlat]

Love it mate, just made my decision a bit easier about buying a 1GR Lux!

[@HaydnKamp]

Not many stock motors out there in a 4wd that’s as reliable and powerful as the 1GR-FE. Even better when they’ve got boost 🤘🏻

[@zainebickerstaff8324]

Is the 1grfe not 249hp stock ?

[@HaydnKamp]

The supercharged TRD kit gave them around 250hp stock. N/A was around 170hp

[@pottypete5593]

I though about 175kw not hp standard at the engine.

[@antoniogutierrez4496]

175 kw stock at the flywheel hilux 1 gr-fe

[@nickryan9833]

Pretty sick whip bro I’d be happy with it 👌…

[@HaydnKamp]

I’m stoked with it

[@cheeseontoastbrah]

Any clearance issues with the body lift and the supercharger setup?

[@HaydnKamp]

None at all, no clearance issues

[@cheeseontoastbrah]

@@HaydnKamp thanks for the info mate

[@cheersmate.]

Hey Haydn. Did you use the Beaudesert Headers?

[@HaydnKamp]

Yeah I sure did

[@cheersmate.]

@@HaydnKamp Thanks for the reply mate.

[@ashkellybarr8980]

why no install and tune video?

[@altuspotgieter5497]

Did you also change out injectors? If so how many cc's?

[@takaianicholas7581]

I have the same kit and it was the best purchase I’ve done on the lux and the worst because now I get speeding fines 😂

[@HaydnKamp]

It’s hard to drive normally 😅

[@Sillyboy9572]

With having have super charger, there’s no lag, like what you’d get with a turbo

[@HaydnKamp]

Linear power from idle to rev limiter 👌🏼

[@esoterical7920]

Hey mate where did you get your scrub/sliders from?

[@HaydnKamp]

Sliders are from dominate 4x4 and the brush bars where made by a local fabricator

[@the_nothing]

A couple supercharger options up here in the states, but no kit as thorough as that! very nice.

[@HaydnKamp]

Had everything I needed

[@the_nothing]

@@HaydnKamp any head gasket fears at this point?

[@mrshinybald2739]

I was seriously looking at that Beaudesert exhaust.... sounds sick.. also bro, 175kw at the crank not HP

[@HaydnKamp]

Yeah seems to be doing it’s thing so far. Had a few sets of pacemaker headers let me down. True! Lucky someone knows what their talking about 😜

[@mrshinybald2739]

@@HaydnKamp ahh most of the world is HP so I get it... I believe 225hp but yeah... you've essentially achieved every v6 owners dream haha

[@giggygiggy1393]

Nice work !!! i priced one thru Harrop at $13k installed for an FJ cruiser...........what did your kit cost ?

[@HaydnKamp]

Less then half that man for the kit

[@giggygiggy1393]

And not a full exhaust? Kept stock headers ?

[@arrex700]

Very nice! Only thing my hilux workmate is missing is a supercharger or a turbo (2.7 2TR-FE)

[@HaydnKamp]

One of my mates had one that was turbo'd, thing was quick!

[@stevenmoloney6917]

Sick m8. Currently rebuilding my V6 but the supercharger is on the list. Curious if the raptor kit is better than the TRD factory supercharger?

[@HaydnKamp]

Have a chat to Tim from raptor, he can give you a good comparison

[@simonbarber3936]

Epic Man

[@HaydnKamp]

It was worth the wait, cheers

[@jcautec]

I need this for my hilux!

[@HaydnKamp]

It made the Ute so much fun to drive 🤘🏻

[@r2garage]

hi, that's a great Hilux! What is the maximum boost pressure for a supercharger?

[@HaydnKamp]

Cheers! At the moment it’s setup for just 6psi. I know the next kit up from mine is around 12psi

[@r2garage]

@@HaydnKamp thank you for answering. 12psi is great! I'm looking forward to the next kit up. My car is a Land Cruiser, same engine as your Hilux but with a Magnuson supercharger. Let's enjoy each other!

[@williswombat6995]

now that u got a 1 piece flywheel watch your transfer case and Diff seals go leaky. that extra little vibration u get with 1 piece often does this unfortunately.

[@HaydnKamp]

Stock flywheel is one piece. New one is just larger and heavier to suit the larger clutch. I assume two piece flywheels are just for those rattely 4 cylinder diesel motors 😂

[@stellanmccarthy9039]

How many ks were on the engine

[@HaydnKamp]

350,000km’s

[@stellanmccarthy9039]

@@HaydnKamp lot of ks to be putting boost on

[@johnstatziano8733]

Sounds bad ass!!

[@cohendecatania-ogden1747]

That’s awesome, I’m doing the same thing with my prado. What injectors are you using?

[@HaydnKamp]

I’m not sure on specs to be honest, they came in the kit alongside the fuel pump

[@chrismarr3326]

How is the exhaust system? And how was their service? Im looking at getting one of their systems on my hilux.

[@HaydnKamp]

Yeah no dramas, all straight forward. It’s got a nice enough note for an ally block V6

[@Nico-vt4il]

Better than common rail diesel i.e. the greatest joke on consumers of all time.

[@alexrychkoff7603]

Which year car?

[@HaydnKamp]

It’s a 2005

[@tylerglover959]

What’s it like on fuel after much worst?

[@HaydnKamp]

Honestly about the same if I drive normally but it’s incredibly difficult to do so. So it’s been worse after I Supercharged it 😅

[@tylerglover959]

Yeah I get ya there no point having the power and not using it

[@HaydnKamp]

Couldn’t be more accurate 😍

[@dspry7851]

What stage kits is it. What size injectors and pump?

[@HaydnKamp]

Stage 2, not sure about injector size or pump rating. It all came in the kit

[@simoncolles8961]

I have this kit car flies it’s a tuning nightmare car hasnt idled or run right since I fitted the charger after 3 tunes and and fixing intercooler leeks etc owes me over 10k

[@HaydnKamp]

Talk to Tim from raptor. I got my car localy tuned and it had a few issues that I put up with for way too long. Talked to Tim about it recently and he suggested I send him my Ecu to get reflased and now the car runs better then it ever has. Really wish I did it sooner…

[@reesy22]

Wait so was this a turbo not a supercharger?

[@illynoizzz]

This is not turbo, coz it goes not from exhaust but from crank shaft. It's just "centrifugal" type of boost, not "twin screw", which you usually may see installed on engines.

[@HaydnKamp]

What he said ^ The compressor side is driven by a belt off the harmonic balancer not by the exhaust gas. The Supercharger unit does looks like the cold side of a turbo

[@reesy22]

@@HaydnKamp never seen one like that. That’s awesome

[@TLE1977A]

Might want some locktite!

[@claudetorki1860]

Can you supercharge my V6 Camry ? I’m in the Gold Coast let me know

[@HaydnKamp]

Sleeper Camry would be fun 😅 I only work on my own cars sorry

[@colchronic]

Thats hot, i want to put a supercharger on my IS350 (2gr-fse)

[@totobyafrica847]

If you did a dual fuel conversion this would actually be quite cost effective to run

[@chasp_0784]

Bleh keep the gas for taxis

[@fint3810]

Gross

[@totobyafrica847]

@@chasp_0784 95c/L should be for everyone

[@nolesy34]

​@@chasp_0784 gas is for everyone! from fellas to females to fitness freaks doing jumping jacks flashdancers and gas gas gaaaas

[@Aussieadventurefam]

Hey mate how has this kit been ? Reliable ?

[@HaydnKamp]

It’s been good so far, just got it retuned and it’s making more power again and running smoother. Very happy with it👌🏼

[@Aussieadventurefam]

Nice man ! Who did the latest tune ? Just autos ? Bigger pulley ?

[@alexmanning652]

bought a beudesert for my hdj79 with the fte in it and after 5 yrs the thing is rusted to bits. ppd way better

[@HaydnKamp]

Hopefully after 5 years they stepped it up 😅

[@coolkatz9012]

Same poke as the fg xt barra

[@dwaynecarroll2969]

Awsome

[@Nathan-fv8rt]

how has it effected ya fuel usage?

[@HaydnKamp]

Haven’t had a chance to drive ‘normal’ yet so will have to wait for that one 😅

[@Nathan-fv8rt]

@@HaydnKamp haha all good mate, wish i had the money to put one on the missus prado !

[@HaydnKamp]

Would be an absolute weapon!

[@nitishk9]

A 4.0 litre supercharged V6 petrol engine has a lot more potential yet to be explored, just look at what a 3.8 litre twin-turbo V6 does in a Nissan GTR, of course the 1GR isn't built the same way as the VQ38 for a different application altogether. I guess you need cams and headers aswell, and see how much more you may gain.

[@HaydnKamp]

There’s is a Japanese bloke who runs one in formula drift. It makes huuuuge hp

[@iRoPoT011]

No driving footage 🥲

[@HaydnKamp]

Not yet anyway 😜

[@troybrymer5013]

I've noticed that all V6 N70 owners always want to supercharge their car

[@HaydnKamp]

I think it’s because the motors been proven to work well with the factory TRD supercharger kit. And I mean it’s kinda lame if you don’t want an easy and reliable 300rwhp 😅

[@jarrod1687]

Nice mate. Deisel is dead, long live petty

[@HaydnKamp]

Diesels are for tractors and generators 😅

[@MussaKZN]

We all know why you didn’t give the cost. You told ya misses you found it on the nature strip in hard rubbish and you couldn’t believe someone could throw this away and it fits my Ute,

[@HaydnKamp]

I know right! Hard story to believe but it’s true 😅

[@PerthSnaps]

Looks like I’m doing the 120

[@HaydnKamp]

Won’t regret it 😅

[@theviolator2.030]

My Toyota has a turbo. But it’s a diesel 😐

[@HaydnKamp]

Spewin!

[@tyzon00800]

U can put lipstick on a pig 🤣

[@HaydnKamp]

Only if it wants it

[@jaybajan]

i did not know a hilux has a v6, wtf

[@HaydnKamp]

Yeah even the little 2wd hiluxs came out with the same 4L v6 motor. They hoon!!!

[@tareskisloki8579]

They had them right up to the start of 2018. But they were never advertised or used in media fleets, so you only ever heard about the diesels.

[@Lloydy225]

Lol 175 "hp"

[@AkhmedEvil]

Hi, can i contact you in messenger (like telegram, WhatsApp and etc) ? I have 1gr-fe, want to supercharge it too and have some questions.

[@HaydnKamp]

You can send me a message on Instagram if you want. I don’t have any of those apps @haydos_luxys