Spark Plug Install (DIY) How to on VW 2.5L 5 Cylinder Engine

Looking to replace the spark plugs on your VW 2.5 engine? The spark plugs should be replaced every 40K miles on most VW engines.
This video will show you how to remove then engine cover, the ignition coil packs, and finally remove and replace the spark plugs on your VW 2.5 engine.
The 2.5 engine has 2 different spark plugs depending on the engine. If you are not sure which plugs are the correct ones for your vehicle, you should contact us with your VIN number.
Here are the 2 OEM VW plugs available. Please note OEM VW plugs come pre gapped.
Spark Plug for 07 and Later 2.5L Engines (Bosch)
www.shopdap.com/2-5-vw-bosch-...
Spark Plug for 07 and Later 2.5L Engines (Genuine VW/Audi)
www.shopdap.com/101-905-601-f...
Spark Plugs for Early 06 + 07 2.5L Engines
www.shopdap.com/spark-plugs-f...
Spark Plug Socket
www.shopdap.com/vw-audi-spark...
This part would fit on the following models
VW - Beetle - 2006-2010 - 2.5 Engine
VW - Beetle - 2012-Present - 2.5 Engine
VW - Beetle Convertible - 2003-2005 - 2.5 Engine
VW - Beetle Convertible - 2006-2010 - 2.5 Engine
VW - Golf - MK6 2010-2014 - 2.5 Engine
VW - Jetta - MK5 2005.5-2010 - 2.5 Engine
VW - Jetta - MK6 2011-Present - 2.5 Engine
VW - Passat - B7 2012-Present - 2.5 Engine
VW - Rabbit - 2006-2009 MK5 - 2.5 Engine
VW - Sportwagen - 2009 - 2.5 Engine
VW - Sportwagen - 2010-Current - 2.5 Engine
Disclaimer: Please note all DIY are intended for basic information. Deutsche Auto Parts is not liable for any damage incurred during any attempt to follow the information shown in the video above.
Shop for VW and Audi Parts Here
shopdap.com
----------------------------------------------------
VW AUDI Specialty Repair Cornelius NC
www.daprepair.com/vw-repair-c...
VW AUDI Specialty Repair Kent Ohio
www.daprepair.com/vw-repair-a...
----------------------------------------------------
More info on DAP Reward Credit
shopdap.com/store/rewardpoint...
We are your number one place for VW and Audi Performance Software (ECU Tuning) as well as Parts and Accessories in the Charlotte area.

[@Beslan_Myths_And_Facts]

Thank you for saving me $200 on labor. Taking the engine cover off was actually the most difficult part for me.

[@j.a.s7571]

Same here

[@hubster4477]

Just finished the spark plug change. I wouldn't have tried it with out this video. Thanks!

[@Deutscheautoparts]

+Hubster Glad we could help. Thank you so much for the support. Your purchase allows us to continue to make videos just like this one.

[@rajkarki3242]

Thanks so much for a wonderfully descriptive video. Just finish changing spark plugs on my 2009 VW Jetta that would never have been possible without this video.

[@dustinrobertson3188]

I just purchased a 2005 Jetta and it is in need of spark plugs... I would not have even tried attempting it had I not watched this first. Thank you for the straightforward and detailed info! Great camera positioning as well made it easy to see what you were doing and in what process. Thanks!

[@dohc1067]

I know I am a little to the party, but a year ago my wife purchased a 2010 beetle 2.5 automatic. This video been a game changer for maintaining the car's performance. Thank you sir.

[@paulbunch8388]

This was a nice and simple video. I changed my plugs yesterday (80k) and it went well. Thank you.

[@Deutscheautoparts]

Great so glad we could help

[@michaelbattle7477]

Very nice job of demonstrating the procedure. I will be changing plugs on my 13 beetle. Thank you!

[@NCOV089]

Another helpful tip after viewing this, upon not having a long strong flat head. My man who is not handy whatsoever, handed me a small hammer. I used the nail remover ever so gently while resting against the opposing coil pack and they lifted up sooooo easily.

[@padawanseventyone]

Very helpful video, it saved me about $250. Instead of paying to have it done, I was able to do it myself in about a half an hour. Many thanks!

[@Deutscheautoparts]

padawanseventyone Awesome so glad we were able to help. Please consider us next time you are in need of VW parts. I'm sure you'll find our pricing to be agreeable as well.

[@padawanseventyone]

Deutsche Auto Parts Will do, thanks!

[@richhenry6626]

Very helpful and informative. Thanks !! Now out to change the spark plugs on my 2009 VW Rabbit with 2.5 engine

[@kevinballard5737]

This was incredibly helpful as i did this to my 07 beetle yesterday!! She is running perfectly now. My procedure was almost identical to this video, except i didnt have to remove any air intake pieces, and the fit is a little tighter for your wrench. I had to take my extension off and work the wrench extension pieces on seperately for cylinders 3, 4, and 5.

[@acaesar2009]

Thank you very much for the step by step tutorial! Great Video.

[@WhowereEpsteinsclients]

Straight and to the point great video thanks

[@fezziwig47]

Just went to the dealer this AM and he wanted $199 for 5 plugs and labor at $120/hr. job said to take 1.3 hours. I may be slow, but I think, after watching your great video, that I can do this. I've changed plugs in MGs, Jaguar and Triumph and my 98 civic. Probably will check the gap and put some anti-seize on the threads.

[@Deutscheautoparts]

Purchase them from us and do it yourself. It will save you plenty ; ) shopdap.com/store/2-5-vw-bosch-spark-plug-kit-101905601f.html

[@Oliver.Money.]

Great video man great angles showing what your doing too! Thank you for your help man saved me a couple hundred dollars

[@gotminegettingyours]

Further up in the comments it says any quality plug, other than Autolite. Someone used NGK and is happy with them.

[@Deutscheautoparts]

- We appreciate your Support and Purchases! Spark Plug for 07 and Later 2.5L Engines (Bosch) www.shopdap.com/2-5-vw-bosch-spark-plug-101905601f.html Spark Plug for 07 and Later 2.5L Engines (Genuine VW/Audi) www.shopdap.com/101-905-601-f.html Spark Plugs for Early 06 + 07 2.5L Engines www.shopdap.com/spark-plugs-for-2-5l-5-cylinder-set-of-5-101998600cgrp.html Spark Plug Socket www.shopdap.com/vw-audi-spark-plug-socket-magnetic.html

[@nacholibre1962]

3:32 One trick worth doing at this point is tosit the plug on the hole/top of the thread and rotate it gently counter-clockwise with your fingers on the shaft of the ratchet extension until you feel the slight 'click' of the two thread engaging (the plug thread and the thread in the cylinder head). That way you will avoid any risk of cross-threading which would be a nighmare! Also, I was always taught to put a dab of lithium grease on the top of the plug before applying the connector (in this case the coil) as it gives a better electrical connection and keeps away any moisture.

[@DouglasHavens]

Thanks. This made it easy on my 2008 Jetta.

[@Deutscheautoparts]

Awesome! Glad we could help

[@rev.georgegrogan9396]

I don't remember you telling them about the gap of the spark plug I'm old school I used to rebuild my own motors and stuff back in the 70s and 80s but I assume you still have to Gap the spark plug not trying to be a smart or anything like that I just didn't know thank you for your KZbin channel it did help me a lot trying to figure out these newer model cars I'm 60 years old and they ain't built like they used to be

[@smr92]

Great video, thanks!

[@Biomedman82]

Fantastic video. Keep me coming. Quick question, what is the gap requirements for a 2006 Jetta 2.5L? Also, do you know of a good gapping tool to decrease the risk of cracking the iridium on spark plugs?

[@jeffwilson369]

Thanks fellas, really straight forward and nice video. I'm changing the spark plugs on my 2013 Passat, any recommendations on what brand of spark plugs? Or are the all pretty much the same? Thanks.

[@whome2485]

When replacing the engine cover, a trick I learned is add a little personal lubricant (ky, astro glide etc.) on the rubber grommets, makes it easy to pop it back into place. The reason for personal lubricant is it won't damage the rubber.

[@Verbalism]

That isn't necessarily true with regards to your statement about the lubricant not damaging the rubber. Your lubricant needs to be water based in order to avoid damage to rubbers. The products you mentioned fall within that scope, but I wanted to clarify this for people who will connect their own dots and use other products.

[@13crazydaisies]

Cool tip, thanks!

[@SoulDaddy33]

Silicone grease also works well unless you just like to mix business with pleasure.

[@dieseldabz7104]

VASELINE! Same shit you use on orings folks...

[@gregpezan9631]

@@SoulDaddy33 great response! Lol

[@Jokero_YT]

Subscribing from the vwvortex :)

[@elenacerasela]

Thank you. I will do this.

[@billmotor1441]

I would like to see a video on replacing a thermostat on a 2.5L Jetta. MK5

[@aprilholecek]

Intake removal Volkswagen Jetta 2006 intake removal

[@Bwebb38804]

Great video!! Will you make a video showing how to install a new thermostat on this same car?

[@DaTobester]

What tool were you using when u pulled out the spar plugs?

[@Orrsmen]

Its crazy to think thats a 2.5 hour job right there

[@hughmclovin5376]

At first it might be but it dont take that long after. I do mine usually in an hour

[@FGCscrub24]

Don’t worry I got the joke @orrsmen 😂😂😂

[@deepblue153]

😂 on god

[@joem4069]

They are quoted me newr 1k to replace 2 spark plugs! It's this avg price, or are they ripping me off?

[@joem4069]

Is it a 2.3hr job was this video speed up or edited?

[@isaacshively6705]

So I recently replaced my spark plugs and it ran great but a week later I installed a AFE cold air intake and now it kind of acts like I have a misfire though there is no code so I'm inclined to think it doesn't like the gap because of the intake so do you recommend closing or opening the gaps and what gap should I try?

[@MrDevilcross]

Hey bro. when you removed the coil packs, was the a sticky reddish stuff on the tube between the tube the the housing? I'm wondering if it's just antiseize.

[@bleeatch]

Hey, my 2009 Rabbit is revving at idle. The idle is also rough. It will increase up and down but only by 75-100rpm. Could spark plugs be the cause? There is no CEL so I'm having a very hard time figuring this out. Mechanic said there are no vacuum leaks.

[@aly8848]

should we disconnect the battery by removing negative leads from battery first?

[@SocketDaddy]

SO much easier than most cars!

[@atcodoe1568]

I have a 2007 2.5 vw beetle, what type of wires and plugs would I need for a tune up?

[@colubrinedeucecreative]

I just randomly watched this video, nice one here. Is there a video you have made about what to look out for if one was wanting to purchase one of these "new beetle"s 1997-2011 will probably be looking for a mechanics special type car. Thanks.

[@longhornjay]

Great video guys, I just subscribed and will search your other videos as well, but thought I'd ask here also. I had a check engine light advise me that one of my ignition coils was bad (specifically #3) is this something that I can just replace the faulty one or should I replace all five? It seems most places want to sell you a kit with 5 new plugs and ignition coils, but I just wanted to check and see if that's really necessary, I know it is for the plugs...thanks and keep up the great work!

[@geneh9014]

Hello all I have a 2006 Jetta 2.5 that the back tires chirp/spin sometimes. I replaced all the plugs, coils and fuel filters. it seems like the RPMs are steady and there is a stall to the back tires, you can hear/tell when the hard shift is coming. Any advice would be great

[@johnmilner7603]

I like applying dielectric grease to the rubber seals on the plug boot and coils.

[@dieseldabz7104]

Exactly what I do as well and he should have also.

[@budbudpoop]

Thank you very much 🙏

[@msand951]

Great video thanks. subscribed. Can you tell me the spark plug gap for a 2013 passat 2.5 eng. and torque spec in pounds Please. Thankyou.

[@anthonym5050]

Have a slight rough idle my 2.5 Rabbit 08, any suggestions of where to start. Thanks

[@mjq21xb]

Would a misfiring spark plugs cause a check engine. Sometimes when I accelerate (merge on the highway for example) I feel my car sort of "buck" at my if I accelerate too fast. Recently got a check engine light (all after a mechanic charged me $400 to replace one spark plug and change my oil and filter (even though I had replaced it ~3k miles before w full synthetic.) After that the car seemed to misfire and drive worse than before.

[@dii36000]

do you have to use anti seize? on original vw spark plugs

[@JoeyAdes]

Thank you. I have a 2009 VW Jetta 2.5. Which brand spark plugs is best? should I get? Bosch? E3?

[@rodaraguz]

To do this, should you disconnect the battery? I saw no mention of the battery..

[@erickasanchez2967]

Hi, my 2008 GTI is showing the codes P0300, P0301, P0303. I switched ignition coils and scanned again and the same codes came up. I'm thinking I need to replace spark plugs since it doesn't look like it's limited to the original #1 and #3 coils. I'm just going to replace ig coils and spark plugs, which ones should I get from your store? My vin is WVWHV71KX8W083961

[@GQplayboi]

What should the gap setting be for a 2013 VW Passat SE?

[@martinezlozano2453]

Hi I have a Passat Jetta 2010.what spark plugs the Passat Jetta should have?and what's the gap number of the sparkplugs?

[@toniocastro5426]

Thank you so much for the video on spark plug replacement on a Jetta, 2.5 L. My is 2011 but same thing. Thank you again.

[@Deutscheautoparts]

+Tonio Castro No problem glad to help

[@granddisney5461]

Hey whats the gap on the spark plugs for the jetta 2008 2.5l 5.5 model?

[@faridfaab6709]

Hi please can you show on how to clean or replace the mass air flow sensor on the 2013 passat se 2.5. also how to flush transmission fluid on that car. thank you

[@luisenriquez5211]

farad sarrad ur a big boy figure it out

[@AyItsEZ]

You should make a video how to install a turbo on a 2.5L 2010 Jetta

[@jeffreymcvane8953]

Did you use anti - seize , why didn’t you torque the plugs to 18 ftlbs per factory specifications?

[@johny1127]

THANK YOU FOR THIS VIDEO!!! Would you happen to know what spark plugs are needed on a 2013 Golf 2.5L?

[@dieseldabz7104]

Same

[@elgallopeleador5672]

Hi Deutsche..whats the gap for the Volkswagen jetta 2.5 2010 sparkplugs?

[@king_g684]

I have 2011 Volkswagen Jetta 2.5 SE which spark plugs is better for my car....

[@ghoulbusters6805]

This method would work with a 2008 bug then?

[@uium]

Hi, i did the same but the car sound weird + the temperature gauge off ! Why?

[@lukaskiknadze804]

Hello I need help and please answer.I own volkswagen jetta 2006 2.5 Decided to change spark plugs and bought original bosch 101-905-601.than I found out that spark plugs is for 2.5 but 2008- models.please tell me is there any problem if I use it for my car? My car spark plug number is 101-905-600

[@MarioDallaRiva]

Thanks for the great tips. ?: what was the rattle sound I heard on the engine cover removal and reinstallation?

[@WelterWeiqht]

Probably dirt from the air filter

[@tonyfoster1991]

Thank you! The dealership was going to rob me.

[@jameswood1560]

Replacing the spark plugs in my wife's beetle and on the last plug (last plug on the right facing the engine) appears to be off center. Can't get a ratchet to seat on the plug. Any ideas?

[@dieseldabz7104]

Ya you cross threaded it guy! Time for a heli-coil. GOOD LUCK😂

[@gregeikenberry6176]

how do you remove the air intake ducts?

[@Heidenryk]

Spark plug gap for 2007 vw beetle? .040 or .025

[@AcetuningTVPerformance]

hello, would it be beneficial for me to install ngk or Bosch iridium spark plugs instead of platinum on my 2013 2.5L Jetta?

[@Deutscheautoparts]

I would advise using the correct plugs. Here are the ones for your vehicle shopdap.com/store/2-5-vw-bosch-spark-plug-kit-101905601f.html

[@JeffreyWillis800]

I didn't see anything about greasing the threads or putting any for the coil pack connector, I guess we don't need to?

[@cebastienlarochelle8182]

I thought it would be worse than that. Dont even need a special tool. Nice!

[@joseph-ow1hf]

Is it a good idea to use anti-seize on the plug threads? Also, what about dielectric grease for the plug to coil pack connection? Thanks.

[@spaace9414]

no anti sieze and no dielectric grease. if u hear about extra things on car diys it's most likely not needed if it's not common knowledge it's not nessary worry about gap size and brand

[@iwander2561]

What do I do when I find oil in the spark plug tubes?

[@shawnmcmahon143]

Great vid. How about dielectric grease? Should I put that on the coils?

[@dieseldabz7104]

Yup

[@KevinsChili]

Deutsche Auto Parts With that aftermarket intake installed, why isn't there a tube connecting to the engine cover like on the stock lay out? What does that tube do, i've often wondered.

[@WelterWeiqht]

With aftermarket intake, you do not even need the engine cover its just for looks at that point. The tube used to be for the original air filter to pull air from outside the engine

[@KnuckleSangwhich]

Is the mk6-2011 the same as the 2011 Jetta 2.5 SEL? Also, is there a video for the installation of that after market intake? I am assuming that is the Carbino. The problem I see with installing one is the power steering reservoir is in the way. Thanks!

[@Deutscheautoparts]

Phillip Grigsby Yes this would be the same for most 2.5 engines. Im sorry as far as the intake we do not have a DIY like this.

[@suadabecirovic6829]

Please answer my questions please I just changed spark plug and coils jetta 2,5 se 2011 Chang all 5 still says missfier number 3 what can be?? Thank you

[@dieseldabz7104]

BAD COIL PACK OR YOU DAMAGED THE WIRES GOING FROM HARNESS TO PACKS.

[@maup1n]

When should someone need to change the spark plugs?

[@chrisrodriguez8305]

How long of an extension do you recommend to use to be able to get to the spark plug? Also, what size socket did you use to take them out? Thanks in advance.

[@ethandelgado2799]

Chris Rodriguez 5/8

[@dieseldabz7104]

4" 3/8 extension and 5/8 spark plug socket

[@horrezplater228]

Do the coils have to be put in in order

[@scottyboy2400]

Thanks, awesome video! I just purchased a 2010 w/88k miles, with no service records to refer to. The car is running great, but the manual says the plugs should have already been changed. So my question is, since i have no idea if the plugs have been changed yet, should i go ahead and change them or assume they have already been changed since the engine runs great ? Thanks!

[@Deutscheautoparts]

You should not just assumed they have been changed. You could inspect them to see if it is obvious they have not been changed. If what is not the case then changing them to be sure your have good plugs is not a bad idea.

[@scottyboy2400]

Deutsche Auto Parts Gotcha! I went ahead and changed them. They had been changed probably at 40k, because it had Autolites in it. Do you think the NGK's that are recommended by VW, will give me better mpg and performance? Or not enough to mention?

[@Deutscheautoparts]

Any high quality spark plug should be what you're looking for. Autolite plugs generally don't do well in VW and Audi models.

[@scottyboy2400]

Deutsche Auto Parts thanks!

[@Tomicide36]

Vin# 3vwdp7aj5cm100932 what spark plugs do i need? I bought ngk pzfr5q-116737, are these correct?

[@TylerKlose21]

I am having an issue taking off the coil harness. It seems like the tab on the 5th coil was busted and now i can't slide it off. Any advice on how I might be able to get around this?

[@Verbalism]

If the tab is broken, you should be able to just wiggle it out. The tab is what's keeping it in place.

[@Ms126st]

hi i have a jetta wagon 2.5 and after i took it for tuneup service it started to shack and some times turn of wen i make a stop does this sound familiar to you???

[@cocob7789]

I had to change my VW jetta fuel pump, this exact same thing happened to me. Shake, then turn off.

[@kieranimal]

3VWLX7AJ3CM380619 - what spark plugs do I need? Thanks!

[@maidenlover1]

ive a 2012 passat 2.5 auto 73000 mls. its a super car but ive never changed the plugs. How often should I change them

[@Deutscheautoparts]

+maidenlover1 you should check you manual but it should be 60k

[@heatherfrench3095]

The rubber boot from inside the coil deteriorated and fell off around the spark plug so I can not my socket around it. Any suggestions on how to remove it?

[@Deutscheautoparts]

+Heather French You will need a long pick or long needle nose to remove this. We would also recommend replacing the coil if the sheathing has torn off.

[@danielsotoosornio3972]

whats the spark plug gap on a jetta 2013 se 2.5

[@DuanC30]

Do you need to disconnect the battery when replacing spark plugs and ignition coils?

[@dieseldabz7104]

NO

[@ChrisDan94_]

The plugs are gapped to 0.032 correct?

[@norvellewells4093]

Y did not let us know what size tools socket was use

[@romanblandino7087]

I am sure you have probably already answered this, but is this essentially the same for all 2.5l engines? I have a 2012 Passat 2.5l SE that needs to have the plugs replaced and I want to make sure that this is how it is done for my car.

[@Deutscheautoparts]

+roman blandino Yes pretty much all 2.5 engines are the same with only slight variations.

[@Snipergoblin]

I have issues with my jetta when I drive to long. Especially on hot days where my car starts bucking when I accelerate and I have to pull off the road for a bit to grt it to stop lokg rnough to get home. Could this be a spark plug issue? Sorry I dont knoe anything about cars and ik worried it will crop out of me and leave me without a car.

[@loverboi93]

I’ve been having the same problem. On really hot days it sometimes dies. I’ve replace both o2 sensors because that’s the code it gave me but it still bucks and shuts off. The only thing left I can’t think of would be the plugs or maybe a ignition coil not making enough contact.

[@felipemendoza8465]

I have a 2007 vw rabbit , engine and epc light came on. What are the most common issues?

[@Deutscheautoparts]

Felipe diagnosing a car is a very complicated process, which requires diagnosis. You should consider bringing your vehicle to a shop to have them diagnose it.

[@galic79]

What's the difference between Bosch 101-905-601-F and the Bosch 101-998-601-F spark plugs? Thanks!

[@Deutscheautoparts]

+Erick Crespo the first number is the single genuine vw one. The second is the Set of 5

[@themachine8009]

Does that Jetta have interference engine?

[@Stan_Ipkiss_SS]

if they are using after market intake, is there any point on keeping that cover on the engine?

[@Deutscheautoparts]

Nope only for looks

[@angelolaboy4472]

about the 2002 1.8T new bettle,spark plug position is different

[@ggabixx99]

yeah, it's not the same engine

[@danielgalarza5580]

Hello, thank you for making such a complete informative video. Are spark plugs - ZFR6FGP correct for - 3VW2W1AJ9DM310748 ?

[@TSMEP64]

How about NGK Spark Plugs would this be an ideal spark plug brand to use?

[@Deutscheautoparts]

TSMEP64 NGK is a quality brand. Just make sure you are getting the correct ones.

[@kevinaln1]

I noticed you didn't throw on any anti-seize or disconnect the battery. Usually those are both recommended when doing the plugs DIY. Are they required?

[@Verbalism]

Anti seize isn't required but is a good idea. Disconnecting the battery also isn't required as I personally never do it because of the headaches I face afterwards with my model car, but it is generally better to be safe then sorry.

[@LokiusMaximus]

I had a misfire on #4. 37,000 miles on my Jetta. I just replaced all five of the stupid things probably 5,000-10,000 miles ago. I have not changed the spark plugs ever, so I bought those as well. This time, instead of replacing all five which appears to have been a waste of money now, I will replace only number four but keep a couple spares around. My question is, which one is number four? I assume fourth from the left/second from the right as that would make the most logical sense. Is that the case? I should note that the worker told me nine times out of 10 it is the ignition coil and not the spark plug. Is it not uncommon for an ignition coil to go out after 5,000 to 10,000 miles? Also, the light only came on once, flashed for maybe five to 10 seconds, and has not come on again. Though, I've only driven it about 10 miles since.

[@oscara5041]

I know im 2 yeara late but if you still need any help i can

[@kaylaleave]

LokiusMaximus what year Jetta

[@maidenlover1]

Wow thanx bruh. Could I do this myself???

[@maidenlover1]

Plus what size socket are you using?