Trane XL 15i installation start to finish

[@wholeNwon]

I'm in the mid-Atlantic area and my central air conditioners are 49 years old and function well. There has been no "maintenance" done, just kept the units clean and yard debris away from them. I did replace one relay and a contactor was corroded, so I replaced that ($10.59 and 20 min. work for me).

[@marvingarcia8982]

I think the installer did a great job. enjoy your air conditioning

[@jefffinn8817]

There is a trap it runs under the house down through the chase and back up at a lower point than the air handler. double trapping can cause drainage issues. And I personally like flex ducts very convenient easy to install, pre insulated, time saving. thank you .

[@BotvacProductions469]

its really cool how you got a startup shutdown!

[@amberlynn6914]

RIP WeatherKing 2001-2011. May you find a good new home.

[@EminHVAC]

They did a very nice job installing the units. Looks great.

[@theimaginator16]

Wow, your contractor did a really great job! Hope you gave them a good rating on Angies list or something lol!

[@charliegiddens9608]

Nice Video, Upgraded the Unit.

[@Andrew_Bdish]

I love all that new stuff you got

[@j.rcoker9051]

Last 8 years!!!...That is a load of crap. I have the same exact unit that was installed in 1995 and still going strong.......THOSE ARE TANKS!!!

[@aircooledtx]

Nice system, all new, I would have added better filtration with all zone returns. 4" pleat at air handler. It could be added with some modification to platform.

[@wholeNwon]

(addendum)...and I wish that the 49 year old cases on my Carriers looked as good as the case on yours! Oh, and, if that's your dryer vent, lint escaping the filter can contribute to condenser coil clogging. Just a thought.

[@wholeNwon]

My Carriers lasted 49 years and were actually still working when I replaced them. Some parts were getting very hard for me to find. Total cost of replacing both complete systems by a reputable company with 10 year parts and labor warranty, upgraded filters, etc. $7300.

[@leanorlando]

They did a wonderful job!

[@ike2167]

The switch on the drain line it shuts down your system preventing more water so it does not flood your house

[@PatentRob]

good work, thanks. i am in the market for a new heat pump/air handler and air conditioner. this was very helpful. i like the returns in every room and widen vents.

[@latrobenut66]

sometimes hanging flex duct will get you in trouble with sweating. would be nice to keep it on the floor of the attic close to the condtiotioned space. insulated or not, flex will sweat internally

[@ricardot5366]

trane its good. have to understand very good pressures and what type of metering device. here in phoenix az trane and american standard. las weekend 122 F no problem for trane....

[@wholeNwon]

Don't see dampers in your flex-ducts but maybe you wouldn't be able to get to them anyhow. Smart to have set the new diffuser to direct air away from that thermostat. How long did they pump down the system before charging? How deep was the vacuum and did it hold when the pump was isolated from the line set? Did they braze under N2? Did you educate yourself before hiring a contractor? Were you having repair or function problems with your old system?

[@localhvacrepairman]

installed many of these XL models these are good running units

[@AutistiVision]

localhvacrepairman It has been an awesome unit. The coil went on it right off the bat, but the tech actually said that all the coils leak right off the bat, and the replacement will last a long time. Which is exactly what we are finding to be true.

[@xDulux]

localhvacrepairman

[@xDulux]

localhvacrepairman

[@PHope-sl4nj]

Very Good Unit.

[@lynnmaoran7856]

We have a 3 1/2 Ton TRANE heat pump and nothing but problems since installation. So bad that we have to make monthly installments on the repairs each month to the local dealer in Smithfield, Va. Replaced fan on compressor 1 day out, then thermo expansion valve within 1 year and 3-4 trouble call so far 2014 and its down again! The lemon of all lemons!!!

[@1515alaro]

Top of the line install guys!!!!

[@RatTailKid15]

They replaced the lineset, AH, condenser, and all the ductwork in a tight attic. Could be done in 1 day but they'd be there until midnight.

[@AutistiVision]

@DJCalimovement Actually, I have the invoice, and I can't tell you an exact price either, LOL. We had the inside & outside units replaced, all of our ducts, vents & returns were replaced, and we have the extended warranty. The package price was $7,905. The warranty cost $550. So, the remaining $7,355 covered the units, ducts, other supplies and labor. I'm guessing the system cost was around $5,000, but that's just a guess. I hope this helps!

[@AutistiVision]

@84randomdude Are you seeing the old unit in the vid? It's about to rust through. Maybe the compressor would last a bit longer, but not before the case it's in collapses.

[@JamesPettinato]

A couple things I don't like about this unit, the air discharges horizontily out of the condenser, one side hits a wall, I would think the heat would get sucked into the air intake, negateing 25% of the unit. I would like to see a smoke test. The company uses cheaper to produce spine fins instead of standard aluminum fins,dirt gets in them and when you try to wash it out the fins close up.The last thing is the condenser has louvers covering it,preventing rain from washing most of the dirt out.

[@Viper21654561564894]

Your installer did a great job. I'm trying to get new ducts installed in a 1,500 sq ft ranch since my ducts are too small for the system. To replace flex return duct and 9 flex supply ducts to 7" I was quoted $3,000. I asked for returns in each bedroom, $300 each. How did you get that deal

[@kevingavigan7883]

I know I may be a bit late in commenting, but a couple things I noticed. First off, the old Weather King unit looks similar a Rheem or a Ruud. Also, the Trane units seem to have evolved, when Trane first started making their outside units with those "weather guards", all models had the louvered fan grille (both the ones *with* the "weather guards" and the ones *without* the "weather guards") apparently the only newer models that still have the louvered fan grilles are those *without* the the so-called "weather guards", maybe they did that to improve airflow or something. Moreover, I've never seen a Trane with a 2-blade fan up until watching this video. One thing is for certain, "It's hard to stop a Trane."

[@AutistiVision]

Yes, Rheem, Ruud, Wheather King, all exactly the same with different name plates. And indeed, hard to stop a Trane. We actually sold this house and the air conditioner was still going strong!

[@PHope-sl4nj]

It Is A Straight Cool Unit.

[@thesmoothjazzguy2012]

Big flaw! The air handler and condensing unit are at practically the same height, but I noticed something. The lines arch above the units, and come back down. That unwanted lift in the lines will restrict refrigerant flow, and cause problems.

[@billybassman21]

So how many filters do you have to replace? Did you get a UV light or an air cleaning system. My issue with all of those returns is the ducts are going to get dirty over time and will need to be cleaned. Its more maintenance. I would rather have a couple of returns and have the filters right at them to keep the return ducts clean. Nice setup never the less.

[@zeframcochrane1183]

Bar Type Returns

[@AVTreasures]

This is a great video. You did an awesome job documenting your install. I am impressed by your contractors attention to detail. Very neat install. Does the new Trane control the humidity better in your house? I would guess that your house is much more comfortable now than before.

[@nobaddog1]

Thats a nice install. I dont understand all the return ducts. Do you know why they put so many? Hows the unit been working? No drafts or hot spots?

[@LadariusCapersOfficial]

They added return vents for perfect air circulation

[@gunnarbondank3893]

What happened to the old air-conditioning unit that was out there?

[@brandonbomba8821]

Looks like they did a clean job , I noticed they did not build a radius on your supply plenum for the best performance of your ductwork. Also why did they not run your drain out of the right side where it is coming out of the air handler, that could cause problems down the line . Its not good practice to run your drain across the air handler like they did, even if you do have a filter back. Hope you enjoy your new system.

[@AutistiVision]

I don't know :) but thanks for the extra info!

[@sissymurphy9620]

looking at going to trane xl18i and indoor unit hyperion xl tam 7 cost quoted would be 7304.99 installed and wondering how happy you are with yours .I looked at carrier also .i live in VA plus i get a rebate back from my utility company of 500 dollars

[@AutistiVision]

So far, the only issue we've had was an evaporator coil that needed to be replaced 2 years after installation, but that was covered under warranty. Our power bills are much improved since we replaced the old Weather King, and the Trane seems to be able to keep up with the Florida heat :)

[@sissymurphy9620]

how quite is inside unit and out side unit .Great video by the way

[@AutistiVision]

Not silent, but a lot quieter than our neighbors' units :) Thanks for watching!!!

[@Caterday1234]

+AutistiVision goooodman! Lol enjoy the system

[@Ubmd1]

I once had a trane XL 14 witch is vary powerful

[@FEDERALSIGNALTECH]

NICE TRANE XL 1500I UHE weathertron

[@TXcodeDesigner]

Thanks for sharing the overall experience of your A/C overhaul. My current "updated" heatpump (Goodman) gave out after 11 years and my air handler is over 31 years old (still works)... But, I guess I got more than my money's worth. Now I'm debating on what brand (Acroaire, Lennox, Trane) to go with. How do you like your new Trane system? Any problems/issues?

[@frtguy80]

Did they really install a supply duct that close to your Thermostat? I know the return can be close but not the damn supply

[@zeframcochrane1183]

10 years ago

[@AutistiVision]

@FEDERALSIGNALTECH But even with the camera so close?

[@patsyjohnson4313]

Where is the reset button on this XL15i unit?

[@farstarfilm]

dude what did u pay for the whole thing?

[@harrycrafter18]

it looks like my 2000 Rheem Classic air conditioner. is it a Rheem

[@AutistiVision]

@84randomdude I see. I guess you're in a dryer climate. This is Florida and it appears as though the Weatherking's casing just rusts. And oh yea, I've heard of some A/C units lasting real long. But you really want a lower SEER rating. My power bill has dropped by 2/3rds with the new unit.

[@FEDERALSIGNALTECH]

LOUD COMPRESSOR!

[@billybassman21]

How is your Trane holding up? I just got a whole new Trane two stage system installed. You can see a quick video of it on my channel. Very impressed with their quality.

[@AutistiVision]

Still running strong! No problems.

[@js0009]

Strait cool or heatpump?

[@easyjohnny4320]

Very clean install. Who's the company? I also had the Trane but no new ducts. They used my old ducts and vents. And only one huge return. I'm not a HVAC guy but I think having return vents on each room is appropriate. Did you request for the ducts and return vents to be replaced for extra or it's part of the agreement?

[@AutistiVision]

The company name is Del-Air, and they're great. Yes, replacing the actual duct work was extra.

[@FEDERALSIGNALTECH]

I had a great 10 seer system that has been replaced with 13 seer due to the freeon phase out.

[@PHope-sl4nj]

Weather King Was Made By Rheem.

[@Bajaheat]

What did a job like this cost all together?

[@AutistiVision]

We had the inside & outside units replaced, all of our ducts, vents & returns were replaced, and we have the extended warranty. The package price was $7,905. The warranty cost $550. So, the remaining $7,355 covered the units, ducts, other supplies and labor. I'm guessing the system cost was around $5,000, but that's just a guess. I hope this helps! Thanks for watching!!!

[@Bajaheat]

That's a great deal for such nice work! My father paid 6 for his without new ductwork..needless to say I won't be recomending them

[@erickl3329]

+AutistiVision that's a good deal. I just got the 14 ser installed for 5k.

[@bradmironik6137]

Doesn't look bad but I don't agree with the setup of the condensate drain, where's the trap? Not to mentioned it runs in front of the air filter access panel. I didn't see any other filter grille in the video. Lastly I hate using flex duct. That is for guys who don't know how to install sheet metal.

[@hotniaoniao]

Keep the sprinklers off of the A/C units!

[@FEDERALSIGNALTECH]

You don't have the new Air handler that has the blower in bottom.

[@blissJesus1]

pretty good deal

[@arcticarrowhvacr]

Would you recommend Trane?

[@AutistiVision]

Yes! We made this video in Feb 2011 and it's now almost 2018. 7 years with no problems. The installers tell me that Carrier is better though. Maybe just a little better than Trane.

[@arcticarrowhvacr]

AutistiVision thanks! Do you know what series or model of carrier is best?

[@AutistiVision]

No I'm sorry, the technicians only said Carrier.

[@zeframcochrane1183]

How A Heat Pump Works

[@Wigmaster1527]

Nice install. Most of your efficiency increase is the new ductwork which is the most difficult part of the job. I wish you had gotten the aluminum A coil instead of the copper one tho...

[@zeframcochrane1183]

TRANE XL15i

[@zeframcochrane1183]

10 year anniversary

[@AutistiVision]

Yep. And still running good!

[@mwgowin]

@AutistiVision Good lord they make a killing. I purchased and installed my own unit making a 2 zone from a one zone and it only cost me $2000. Wow.

[@jerrellstrawn6409]

Not quite a 'start to finish' install video. "Day 2' starts with the indoor and outdoor unit already installed and plumbed.

[@timsouttahere]

I hope that those weren't asbestos ducts

[@timsouttahere]

After I typed that I see that they say fiberglass 😅😅

[@jay11j]

Your unit seems pretty loud when it started, where in the start of your video, that unit is what it should be.

[@zeframcochrane1183]

XB90

[@Mooseguy15]

Those are commercial units not residential.

[@LayJD_]

8:52

[@Z71Ranger]

I would NOT want a unit like that with all the returns in each room... The return ducts like that will be filled with dust, hair and skin in no time... My return is 30 inches x 30 inches with a filter right in that vent... I also have a filter in the air handler unit its metal and can be washed out with cleaner and water... We also have the... Trane electronic whole-house air filtration system...

[@EagleKeeper86]

If you keep all the bedroom doors closed that’s actually the better way to do it. Door undercuts aren’t sufficient to allow air back to the handler to be conditioned.

[@amberlynn6914]

higher SEER Rating.

[@amberlynn6914]

you mean higher SEER rating.......

[@875billiondude2]

10 years is poor quality. And 10 SEER.

[@zeframcochrane1183]

Gas Furnace

[@brentaudi9354]

Did you not notice in your video that all of your vents were closed? Every vent you showed in your video was closed. No wonder why your Utilities were so high. You were not getting any air movement at all.

[@AutistiVision]

Very observant of you to notice, but the vents were open when the system was in use, LOL! I'm guessing the technicians closed them before removing the old duct-work to reduce the amount of falling debris :)

[@brentaudi9354]

AutistiVision That is good to hear. I sure do like your Trane! Did yours come with a lifetime warranty? Some of the Trane dealers in the Atlanta area offer this. I did not know if it came from Trane or from the dealer.

[@somerandomdude82]

Don't buy a Trane! They break down after just a few years! More freon leaks and compressor failures than you could imagine! I know this because I have 3 Trane units.

[@madinmia1]

this is the dumbest most misleading video. You didn't know anything or explain anything.

[@FEDERALSIGNALTECH]

Does your boy have autism spectrum disorder?

[@AutistiVision]

+MIKE CHIESA Yep. Loves air conditioners too!

[@FEDERALSIGNALTECH]

+AutistiVision I love HVAC ,sirens and computers.

[@FEDERALSIGNALTECH]

+AutistiVision I'm a high functioning autistic person.

[@AutistiVision]

MIKE CHIESA Nice to meet you. My boy is high functioning as well. We are thankful.

[@LadariusCapersOfficial]

@@AutistiVision I love ❤HVAC To it’s the reason why we go on with our daily lives in comfort 😊

[@vincentsargenti9574]

This video is about 10-12 minutes too long.

[@bkrplusa]

2 day chang out ? hahaha lazy installers

[@zeframcochrane1183]

10 years ago