CHEVY K30 FUEL TANK CLEAN AND SEAL | And Replace Fuel Sender

I was having a problem with my fuel level gauge reading incorrectly on my 1984 Chevrolet K30. I even ran out of gas a couple of times and had to stop IN THE MIDDLE OF THE ROAD! I was alone and this truck is WAY to heavy to push by myself. So I ordered a new fuel sending unit and went about installing it. At the same time I figured I would buy a kit off of Amazon to clean and seal the gas tank. I figured the gas tank might be rusty and crusty in there. Turns out the inside of the tank was not bad, but I went ahead and cleaned it inside and out, and poured in the sealer. I even had time to apply some fresh paint! It's an easy process you can tackle in a weekend. The most difficult part is removing and installing the gas tank. ENJOY!

[@chevybeaglenox2402]

I love the bike tube for the insulator, great idea.

[@ok8990]

Replacing left side gas tank 1983 Chevy K30

[@critterray6742]

Have an 82 with an aluminum flatbed. Thanks fer the vids.

[@ratroddiesels1981]

i like your truck , i opt for 3 on the tree . the music was real good.

[@hermyherm365]

Dude I always enjoy your vids bud !! I clicked on this vid so fast !!! How bout a update on the ol red and white truck pal ???love the content brother ! Much love

[@doodar21]

Thanks for posting.

[@stevehughes6203]

Great job!! Wish you could help me with my old project. Got a 74 k10. But I've had health problems where I have a dropped foot and no balance on left leg. Keep sending vids. On what you do to your truck.

[@leogetsome]

Cool video

[@aladwanit]

Good 👍 job

[@FABRIC8TIONUNLIMITE1]

@ 10:34 The bolt for some ground, WILL eventually SCRUB a hole in that PLASTIC fuel filter, inevitably causing a fuel leak. And I'm not guessing.

[@gumboot65]

Nice job ! I wonder how the gas model differs from the diesel on my 83 K20 ?

[@doughboy1966]

You planning on putting in another new tank on the other side? I sure like that truck but it would be brutal to drive in the Texas summers here without AC.

[@racerguy008]

I have to do this on my 83 square, DREADING it.

[@xandercharlie3525]

pro trick: watch movies on Flixzone. Been using it for watching a lot of movies recently.

[@mrwilson4909]

i have 87 r20 with dual 16 gallon tanks. do you think the straps could support 20 gallon tanks?

[@molo9256]

Help what fuel pump is that one becouse my Ebay one is to loud.

[@molo9256]

Bnb dose it have a regulator and return line?

[@ramirogarcia1045]

Stupid music ruins the video